freightliner S2 Operator's Manual page 95

Procedure Performed
(check off)
Drain manually drained air reservoirs (that are not equipped with automatic drain
_______
valves)
Check _______ windshield washer reservoir fluid
Inspect _______ wheel seal and hub cap (for leakage)
Check _______ surge tank coolant level
Inspect _______ radiator and charge air cooler
Check _______ engine for fuel, oil, or coolant leaks
Inspect _______ engine and chassis wiring
Inspect _______ air intake system
Check _______ intake-air restriction indicator mounted on air intake
Check _______ engine oil level
Check _______ power steering fluid level
Inspect _______ fuel tank(s), fuel lines, and connections
Check _______ fuel level
Check _______ fuel/water separator
Inspect _______ front and rear suspension components
Inspect _______ headlights, mirrors, and window glass, and windshield wipers
Check _______ doors (open without difficulty and close securely)
_______ Adjust driver's seat, then align rearview and downview mirrors
Check _______ dash-mounted intake-air restriction indicator
Check _______ oil- and air-pressure warning systems
Check _______ ICU fault codes
Check _______ horn, windshield wipers, and windshield washer
Check _______ heater, defroster, and optional mirror heat controls
Check _______ backup alarm
Check _______ panel lights and interior lights
Check _______ exterior lights and reflectors
Check _______ tire pressure
Inspect _______ tire condition
Inspect _______ rims and wheels
Check _______ automatic transmission fluid level
Inspect _______ air brake chambers and pushrods
Inspect _______ air brake lines
Inspect _______ slack adjusters
Check _______ air brake system operation
Check _______ Bendix® Hydro-Max Power Booster
Inspect _______ frame rails (missing bolts), crossmembers (bent or loose)
mud flaps (aren't damaged, at least 10 inches above the ground, and brackets
Check _______
are secure)
exhaust system (mounted securely, connected tightly, no signs of leaks such as
Check _______
soot trails)
_______ Remove chocks and test service brakes
Inspector___________________________________________________ Date ________________
Daily Pretrip Inspections/Checks
Table 14.1, Daily Pretrip Inspection and Maintenance Checklist
Pre- and Post-Trip Checklists
Procedure
Reference
D1
D2
—
D3
D4
—
D5
D6
D6
D7
—
D8
D9
D10
D11
D12
—
—
D6
D13
D14
D15
D16
—
D17
D18
D19
D20
D21
—
D22
D23
D24
D25
D26
—
—
—
D27
14.2