Page 1
Service Manual ViewSonic G90f/B-3 Model No. VS23283 19” Digital Controlled Color Monitor (G90f/B-3_SM_944 Rev. 1a – Jan. 2005) ViewSonic 381 Brea Canyon Road, Walnut, California 91789 USA - (800) 888-8583...
Page 2
Further, ViewSonic reserves the right to revise this publication and to make changes from time to time in the contents hereof without obligation of ViewSonic to notify any person of such revision or changes.
(as shown in Fig.1). Use an AC voltmeter with 1000 ohm/volt or more sensitivity and measure the AC voltage across the combination 1500 ohm resistor and 0.15uF capacitor. Confidential - Do Not Copy ViewSonic Corporation G90f/B-3...
Page 5
X-RADIATION, shock, fire, or other hazards. Do not modify the original design or this will void the original parts and labor guarantee. Confidential - Do Not Copy ViewSonic Corporation G90f/B-3...
B RETURN 2.2.6 SIGNAL MEMORY MODES 13 PRESET MODES 2.2.7 PLUG & PLAY VESA DDC1 / 2B SCANNING FREQUENCY 2.3.1 HORIZONTAL 30 KHZ TO 96KHZ 2.3.2 VERTICAL 50 HZ TO 180 HZ Confidential - Do Not Copy ViewSonic Corporation G90f/B-3...
Page 7
R E C A L L E X I T : 1 S E L E C T : 2 LED INDICATION STATUS NORMAL GREEN POWER ON POWER SAVING AMBER OVER RANGE FREQUENCY AMBER POWER OFF Confidential - Do Not Copy ViewSonic Corporation G90f/B-3...
Page 8
POWER SAVING AMBER 10 SEC < 4W POWER SAVING AMBER 10 SEC < 29 KHZ OR < 49 HZ OR < 4W FREQUENCY OVER 10 SEC AMBER > 96KHZ >181 HZ RANGE Confidential - Do Not Copy ViewSonic Corporation G90f/B-3...
Page 10
- y AT 25.75 FL < 0.005 AND: x AT CONTRAST 25.75 FL - x AT 10 FL < 0.009 Y AT CONTRAST 25.75 FL - Y AT 10 FL < 0.009 Confidential - Do Not Copy ViewSonic Corporation G90f/B-3...
Page 11
BLACK W HITE PICTURE PICTURE BEZEL BEZEL 4.14.2 DYNAMIC REGULATION PICTURE GROWTH SHALL BE LESS THAN 1 mm WHEN PICTURE IS EXCHANGED FROM < 1 mm 100mm BLACK 100mm W HITE 370mm Confidential - Do Not Copy ViewSonic Corporation G90f/B-3...
Page 12
- 5/+15 DEGREES SWIVEL ± 90 DEGREES PACKAGING 6.3.1 CARTON DIMENSION HEIGHT 498 mm WIDTH 557 mm DEPTH 577 mm 6.3.2 SHIPPING WEIGHT 22.4 KG 6.3.3 CONTAINER LOADING 320 UNITS WITH PALLET Confidential - Do Not Copy ViewSonic Corporation G90f/B-3...
Page 13
2.40V MIN. 3.5V NOM. 5.5V MAX. TIMING OF INPUT SIGNALS H-TOTAL TIME V-TOTAL TIME H-SYNC PULSE WIDTH V-SYNC PULSE WIDTH H-BACK PORCH V-BACK PROCH H-DISPLAY TIME V-DISPLAY TIME H-FRONT PORCH V-FRONT PORCH Confidential - Do Not Copy ViewSonic Corporation G90f/B-3...
Push the increased ‘△’ or decrease ‘▽’ button for the desired adjustment﹐all adjustment are memorized automatically immediately﹒ a. Power switch b. Power-On indication c. Adjustment control buttons e. Auto sizing d. Function select buttons Confidential - Do Not Copy ViewSonic Corporation G90f/B-3...
Page 18
V. size / Position. Pincushion / Balance. Trapezoid / Parallel. Top/Bottom Hook. ZOOM Tilt . Main menu, Part 2. Degauss H/V Moire. OSD Position. Input Level. View match color. Language. View meter. Memory Recall. Confidential - Do Not Copy ViewSonic Corporation G90f/B-3...
Page 19
PARALLEL (parallelogram) slants vertical edges of the screen to the left or right. slants vertical edges to left, slants vertical edges to right. Confidential - Do Not Copy ViewSonic Corporation G90f/B-3...
Page 20
▽ move OSD to left side, △ move OSD to right side ﹒ OSD V-Position control Press the ▽ , △ button. △ move OSD to up, ▽ move OSD to down. INPUT LEVEL displays the voltage level of the video signal. Confidential - Do Not Copy ViewSonic Corporation G90f/B-3...
Page 21
Display Time : 25 seconds Pull-in range Back ground : Blue H . V F R E QU E NC Y Characters : White O V E R R A NG E Confidential - Do Not Copy ViewSonic Corporation G90f/B-3...
12V and 6.3V﹒ Degauss When the powers is on and when press manual degauss﹐IC301 pin20 output high level voltage to turn on Q201﹐RL101 and activate Degauss﹒ Confidential - Do Not Copy ViewSonic Corporation G90f/B-3...
Page 23
As IC401 pin25 ≅8V﹐IC401 X-RAY protection circuit immediately active﹐H-driver, B-driver and V-out no output﹒The X-RAY radiation protection circuit used in this monitor is a latching type the monitor will shown down and continue until turn-off the monitor with power switch﹒ Confidential - Do Not Copy ViewSonic Corporation G90f/B-3...
Page 24
Horizontal blanking pulse are fed to IC601 pin28 and let video O/P amp cut off during the period of horizontal retrace. Mute. While mode change﹐IC301 pin16 will pull high to turn off﹒The G1 voltage will down to –180V then CRT will cut off the video output ﹒ Confidential - Do Not Copy ViewSonic Corporation G90f/B-3...
Page 25
Key Control﹕IC301 pin26~pin29 function as DAC switch input to control OSD display function﹒ Pin40: ﹒ Pin38:▽﹒ Pin37:△﹒ Pin39: ﹒ C Bus IC301 have two groups I C bus to control E PROM﹐IC401 deflection IC﹐Auto alignment﹐IC601 pre-AMP﹒ Confidential - Do Not Copy ViewSonic Corporation G90f/B-3...
Page 26
Waveform Confidential - Do Not Copy ViewSonic Corporation G90f/B-3...
Page 27
(10) (11) (12) Confidential - Do Not Copy ViewSonic Corporation G90f/B-3...
Page 28
(13) (14) (14) (16) (17) (18) Confidential - Do Not Copy ViewSonic Corporation G90f/B-3...
Page 29
(19) (20) (20) (22) (23) (24) Confidential - Do Not Copy ViewSonic Corporation G90f/B-3...
Page 30
(25) (26) (26) (28) (29) (30) Confidential - Do Not Copy ViewSonic Corporation G90f/B-3...
Page 31
(30) (32) (33) (34) (34) (36) Confidential - Do Not Copy ViewSonic Corporation G90f/B-3...
Page 32
(37) (38) (39) (40) (40) (42) Confidential - Do Not Copy ViewSonic Corporation G90f/B-3...
Page 33
(43) (44) (45) (46) (46) (48) Confidential - Do Not Copy ViewSonic Corporation G90f/B-3...
Page 34
(49) (50) (51) (52) (53) (54) Confidential - Do Not Copy ViewSonic Corporation G90f/B-3...
Page 35
(55) (56) Confidential - Do Not Copy ViewSonic Corporation G90f/B-3...
Discharge of CRT anode should be done only to CRT ground strap﹒ Geometric measurements assumed to be made along a straight surface with a flat rule or template﹒ Confidential - Do Not Copy ViewSonic Corporation G90f/B-3...
Page 37
264mm Picture Centering﹒ Input mode 1~13 adjust V-position﹐ Picture Bezel H-position such that the picture is centered with the screen﹒ lA – Bl < 4mm lC – Dl < 4mm Picture Bezel Confidential - Do Not Copy ViewSonic Corporation G90f/B-3...
Page 39
” and power switch on﹐the picture should restore to that of factory mode﹒ Focus Adjustment﹒ Apply signal ALL “ME” pattern at 1280*1024 94KHz mode﹒ Set Brightness 50%﹐Contrast 100%﹒ Set focus control for best focus﹒ Confidential - Do Not Copy ViewSonic Corporation G90f/B-3...
Page 40
C﹒ PCB defined﹒ Main board﹒ Confidential - Do Not Copy ViewSonic Corporation G90f/B-3...
Page 41
:Save color 6500K adjustment data Save color to 5000 :Save color 5000K adjustment data Save geometry :Save geometry adjustment data 2.10 Save all preset mode :Save adjustment data to E PROM 2.11 Reset :Monitor Reset Confidential - Do Not Copy ViewSonic Corporation G90f/B-3...
Page 42
Get mode data Pull adjust ( 255 ~ 0) Change other mode Save color to 9300K Save color to 6500K Save color to 5000K Save geometry All mode adjust finish? Save all preset mode Confidential - Do Not Copy ViewSonic Corporation G90f/B-3...
Page 43
& Power on key : Into OSD service mode. Press & & Power on key : Clear burn in flag. Press & & Power on key : Set burn in flag. Press & Power on key : All mode recall. Confidential - Do Not Copy ViewSonic Corporation G90f/B-3...
Page 44
GT F S A V E G T F R C U T G C U T B C U T R D R V G D R V B D R V Confidential - Do Not Copy ViewSonic Corporation G90f/B-3...
Is the LED normal R112 normal R111, R112 Check horizontal Check video circuit and vertical circuit Are TP201~TP205 voltage normal Check D201, D203, D205, D206, Q203, Q208 Is the T101 normal Replace T101 Confidential - Do Not Copy ViewSonic Corporation G90f/B-3...
Page 46
Is the waveform of Q402 64Vp-p Q402, T402 "collector" normal? Horizontal out is Is the waveform of Q401 defective Q401, FBT "BASE" normal? 0.8Vp-p Is the horizontal output DY is defective circuit normal? CRT is defective Confidential - Do Not Copy ViewSonic Corporation G90f/B-3...
Page 47
CRT glow red? defective normal? Heater voltage approx. 6.3V Turn the FBT screen clockwise Q420, Q419, IC301 Does the entire screen Mute control are light up? defective FBT is defective Confidential - Do Not Copy ViewSonic Corporation G90f/B-3...
Page 48
IC501 normal? Pin5 =-11V? Is the waveform of IC401 Check the deflection Yoke pin21, pin23 normal? R502, R503 are defective R502, R503 are normal? Check power supply +12V, -12V IC401 is defective Confidential - Do Not Copy ViewSonic Corporation G90f/B-3...
Page 49
CRT drive circuit is defective Are the voltage on heater, power supply circuit heater, G1,G2 of CRT D206, G1, G2, FBT socket normal? and its drive circuit. Heater: G1: -38V G2: 660V The CRT is defective. Confidential - Do Not Copy ViewSonic Corporation G90f/B-3...
7. Recommended Spare Parts List RECOMMENDED SPARE PARTS LIST (G90f-3) ViewSonic Model Number: VCDTS23283-3 Rev: 1a Item Description ECR/ECN ViewSonic P/N Ref. P/N Location Universal number# Q'ty Accessories: AC POWER CORD L=1800 (Beige) A-PC-0106-0132 3090107700 PC Board Assembly: MAIN BD ASSY K996 SAR 01A...
Page 51
CD-ROM G90F-3 K996 SAR 01A CB-00001233 3649110700 CRT GROUNDING WIRE K996 #N/A 4090001000 SOLDER WIRE 50/50 1.6mm #N/A 5011088201 MANUAL VIEWSONIC CRT ALL MODEL B-00001210 5600010632 MAIN BD ASSY K996 SAR 01A E-R-0405-5879 0013100000 RES CF 1/4W 10 J J106 RD1/4WJ 10R T52...
Page 56
Item ViewSonic P/N Ref. P/N Description Location Universal # E-C-0404-3640 1120018800 CAP CD 100V 33P J C0G TP5 C306 CHA4330JG1H E-C-0404-3640 1120018800 CAP CD 100V 33P J C0G TP5 C307 CHA4330JG1H E-C-0404-3640 1120018800 CAP CD 100V 33P J C0G TP5...
Page 57
Item ViewSonic P/N Ref. P/N Description Location Universal # #N/A 1421022112 CAP AL 10V 220U M 6.3*12 TP5 C314 0110010227VM5 #N/A 1421022118 CAP AL 10V 220U M 6.3*11 TP5 C314 TVR1A221MA06110TC3 #N/A 1421210112 CAP AL 16V 100U M 6*12 TP5...
Page 58
Item ViewSonic P/N Ref. P/N Description Location Universal # E-C-0404-4943 1421647812 CAP AL 50V 4.7U M 5*12 TP5 C303 0110050475VM5 #N/A 1421647815 CAP AL 50V 4.7U M 5*11 TP5 C301 TVR1H4R7MA05110TC1 #N/A 1421647815 CAP AL 50V 4.7U M 5*11 TP5...
Page 59
Item ViewSonic P/N Ref. P/N Description Location Universal # E-C-0404-3691 1950106126 CAP MY DP I 50V .01U J TP5 C454 PEI103J1HT E-C-0404-3694 1950108101 CAP MY DP I 50V .022U J TP5 C110 PEI-223J0050DT2058 E-C-0404-3694 1950108104 CAP MY DP I 50V .022U J TP5...
Page 73
Item ViewSonic P/N Ref. P/N Description Location Universal # E-C-0404-4482 1111358800 CAP CD 50V .1U Z Y5V TP5 C640 FYU6104ZG1H E-C-0404-4482 1111358800 CAP CD 50V .1U Z Y5V TP5 C403 DCS104Z30Y5VF6FJ5A E-C-0404-4482 1111358800 CAP CD 50V .1U Z Y5V TP5...
Page 74
Item ViewSonic P/N Ref. P/N Description Location Universal # E-C-0404-3729 1142938800 CAP CD 1KV 220P K Y5P TP5 C220 DCH221K22Y5PN6FJ5A E-C-0404-3656 1142945800 CAP CD 1KV 1KP K Y5P TP5 C412 BM6102KG1H E-C-0404-3656 1142945800 CAP CD 1KV 1KP K Y5P TP5...
Page 75
Item ViewSonic P/N Ref. P/N Description Location Universal # #N/A 1421622015 CAP AL 50V 22U M 5*11 TP5 C114 TVR1H220MA05110TC1 #N/A 1421622015 CAP AL 50V 22U M 5*11 TP5 C432 TVR1H220MA05110TC1 E-C-0404-4942 1421622812 CAP AL 50V 2.2U M 5*12 TP5...
Page 76
Item ViewSonic P/N Ref. P/N Description Location Universal # E-C-0404-3690 1950104126 CAP MY DP I 50V 6.8KP J TP5 C514 PEI682J1HT E-C-0404-3691 1950106101 CAP MY DP I 50V .01U J TP5 C430 PEI-103J0050DT2058 E-C-0404-3691 1950106101 CAP MY DP I 50V .01U J TP5...
Page 77
Item ViewSonic P/N Ref. P/N Description Location Universal # #N/A 2033225706 DIO ZEN 0.5W 8.61-8.99V DO-35 ZD402 RD9.1E-T4-AZ(B2) #N/A 2033225802 DIO ZEN 0.5W 8.9-9.3V DO-35 ZD303 HZ9C1 TA-E #N/A 2033226106 DIO ZEN 0.5W 11.9-12.4V DO-35 ZD201 HZ12A2 TA-E #N/A 2033226703 DIO ZEN 0.5W 17.5-18.3V DO-35...
Page 83
Item ViewSonic P/N Ref. P/N Description Location Universal # 1012 M-SCW-0824-0411 3109010300 SCREW T M3*0.5*10 BIND C S18C ZN YEL 1013 M-SCW-0824-0413 3109011400 SCREW T M3*0.5*6 BIND C S18C ZN YEL 1014 M-SCW-0824-0617 3109017300 SCREW T M3*0.5*8 PAN C S S18C ZN SCREW T ? p4*1.6*10 PAN C S18C ZN YEL...
We would appreciate your completion of the Assessment Matrix below, for return to ViewSonic Corporation Assessment A.What do you think about the content after reading G90f/B-3 Service Manual? t i n e l l Precautions And Safety Notices 2.