Page 1
KS-FX901/KS-FX801 3 7 63 1515 0 SERVICE MANUAL CASSETTE RECEIVER KS-FX901/KS-FX801 KS-FX901 Area Suffix LOUD LOUD Multi DISP DISP Music Scan Other areas SCAN SCAN RM-RK31 L 13942296513 KS-FX801 LOUD LOUD Multi DISP DISP Music Scan SCAN SCAN RM-RK31...
KS-FX901/KS-FX801 3 7 63 1515 0 Safety precaution Burrs formed during molding may be left over on some parts of the chassis. Therefore, pay attention to such burrs in the case of preforming repair of this system. L 13942296513 u163 http://www.xiaoyu163.com...
KS-FX901/KS-FX801 3 7 63 1515 0 Disassembly method Removing the front chassis (See Fig.1~2) Remove the two screws A attaching the front chassis. Insert a screwdriver to the two joints a on the side of the front chassis, two joints b on the right side and one joint c from upside, then detach the front chassis toward the front side.
KS-FX901/KS-FX801 3 7 63 1515 0 Removing the bottom cover (See Fig.4) Turn the body upside down. Bottom cover Insert a screwdriver to the two joints d and two joints e on both sides of the body and the joint f on the back of the body, then detach the bottom cover from the body.
Page 5
KS-FX901/KS-FX801 3 7 63 1515 0 Removing the Cassette mechanism Cassette mechanism assembly assembly (See Fig.7) Remove the front chassis. Remove the bottom cover. Remove the main amplifier board assembly. Remove the fore screws F attaching the cassette mechanism assembly from the top cover.
Page 6
KS-FX901/KS-FX801 3 7 63 1515 0 Cassette mechanism ass’y <Removal of the cassette mechanism> Removing the head amplifier board. Head relay (See Fig.1 and 2) board For the 6pin wire extending from connector CN402 on the head amplifier board, disconnect it from the head relay board.
Page 7
KS-FX901/KS-FX801 3 7 63 1515 0 Head relay board Removing the head relay board (See Fig.4) Unsolder the soldering b on the head relay board. Remove the screw C attaching the head relay board. Remove the head relay board in the direction of the...
Page 8
KS-FX901/KS-FX801 3 7 63 1515 0 Cassette holder and holder arm Joint h Shaft Joint h Shaft Removing the play head (See Fig.9) Prior to performing the following procedure, remove the head relay board and the sub chassis. Fig.8 Remove the two screws F attaching the play head Pinch roller ass’y...
KS-FX901/KS-FX801 3 7 63 1515 0 Removing the flywheel Cassette mechanism ass’y Reel disc board (See Fig.10 and 12) Soldering j Prior to performing the following procedure, remove the head relay board, the load arm, the sub chassis, the cassette holder, the holder arm and the reel disc Tab k board.
Page 10
KS-FX901/KS-FX801 3 7 63 1515 0 Push aside the gear and reattach the reel disc Ass’y( ). Removing the reel disc ass’y( ) (See Fig.12 to 15) ATTENTION: Prior to performing the following procedure, remove the reel disc ( ).
KS-FX901/KS-FX801 3 7 63 1515 0 Adjustment method Test instruments required for adjustment Standard volume position 1. Digital oscilloscope(100MHz) Balance and Bass,Treble volume .Fader 2. Frequency Counter meter :Center(Indication"0") 3. Electric voltmeter Loudness,Dolby NR,Sound,Cruise:Off 4. Wow & flutter meter Volume position is about 2V at speaker output with 5.
Page 12
KS-FX901/KS-FX801 3 7 63 1515 0 Arrangement of adjusting & test points Cassette mechanism (Surface) Motor assembly Tape speed adjust Azimuth screw A (Forward) Playback head Azimuth screw B (Reverse) Head section view L 13942296513 Azimuth screw B Azimuth screw A...
Page 13
KS-FX901/KS-FX801 3 7 63 1515 0 Information f or using a car audio service jig 1. We're advancing efforts to make our extension cords common for all car audio products. Please use this type of extension cord as follows.
Page 14
KS-FX901/KS-FX801 3 7 63 1515 0 Mechanism adjustment section Item Adjusting & Confirmation Methods Adjust Std. Value 1. Tape running a) At Forward playmode, using mirror tape, make adjustment Azimuth adjustment with Azimuth screw A and Azimuth screw B, without curl of 4 screw A parts of head tape guide.
KS-FX901/KS-FX801 3 7 63 1515 0 Description of major ICs AN80T05 (IC901) : Regulator 1.Terminal layout & Block diagram Reference Voltage ASO & Peak Current Protection Thermal Protection Drive Drive Drive Drive Drive L 13942296513 MODE2 MODE1 5.6V 8.7V 8.7V...
Page 16
KS-FX901/KS-FX801 3 7 63 1515 0 LA4743K (IC301) : Power amp. 1.Block diagram 2200 F 0.022 F Vcc 1/2 Vcc 3/4 IN 1 OUT 1+ 0.22 F OUT 1- PWR GND1 Protective circuit OUT 2+ IN 2 OUT 2- 0.22 F...
Page 17
KS-FX901/KS-FX801 3 7 63 1515 0 2.Terminal layout 3.Pin function LA4743B Pin No. Symbol Function Header of IC Power GND OUTRR- Outpur(-) for front Rch Stand by input STBY Output (+) for front Rch OUTRR+ VCC1/2 Power input OUTRF-...
Page 18
KS-FX901/KS-FX801 3 7 63 1515 0 LC72366-9987 (IC701) : System CPU 1. Pin layout 2. Pin function Pin No. Symbol Function Crystal oscillator input port Connect to GND Data input for J-BUS information J-BUS SI Data output for J-BUS information...
Page 19
KS-FX901/KS-FX801 3 7 63 1515 0 LC72366-9987(2/2) Pin No. Port Name Function Main motor output, H:Transport L: Stop MOTOR Sub-motor output(+), Loading direction to transport output SUBMO+ Sub-motor output(-), Eject direction to transport output SUBMO- Non connection BEEP Switch for detecting to input cassette, L: Cassette in...
Page 20
KS-FX901/KS-FX801 3 7 63 1515 0 CXA2560Q (IC401) : Dolby B type noise reduction system with play back equalizer amp. 1.Pin layout & Block diagram 7k/12k PBFB2 MSMODE 100k OFF/B PBRIN2 DRSW 300k MS MODE BIAS PBGND TAPESW MUTE...
Page 21
KS-FX901/KS-FX801 3 7 63 1515 0 HD74HC126P (IC801) : Changer control 1.Pin arrangement 2. Pin function Input Output ( TOP VIEW ) 3. Block diagram L 13942296513 u163 1-21 http://www.xiaoyu163.com...
Page 25
KS-FX901/KS-FX801 3 7 63 1515 0 TEA6320T-X (IC161) : E.volume 1.Pin layout 2.Block diagram VOLUME 2 MUTE 0 to 55 dB FUNCTION BALANCE OUTRR OUTLR ZERO CROSS FENDER REAR POWER DETECTOR OUTRF OUTLF SUPPLY VOLUME 1 BASS TREBLE +20 to -31 dB...
Page 26
KS-FX901/KS-FX801 3 7 63 1515 0 L 13942296513 u163 VICTOR COMPANY OF JAPAN, LIMITED MOBILE ELECTRONICS DIVISION PERSONAL & MOBILE NETWORK BUSINESS UNIT. 10-1,1Chome,Ohwatari-machi,Maebashi-city,Japan 200102 (No.49627) http://www.xiaoyu163.com...
KS-FX901/KS-FX801 3 7 6 3 1 5 1 5 0 Block diagram REAR LEFT (-) FRONT LCH FM/AM REAR LEFT (+) TUNER FRONT LEFT (-) FRONT RCH IC161 IC301 FRONT LEFT (+) E.VOLUME REAR LCH POWER AMP FRONT RIGHT (-)
KS-FX901/KS-FX801 3 7 63 1515 0 PARTS LIST [ KS-FX901 ] [ KS-FX801 ] * All printed circuit boards and its assemblies are not available as service parts. Areas suffix U --------------------- Other Areas L 13942296513 - Contents -...
Page 34
KS-FX901/KS-FX801 3 7 63 1515 0 Exploded view of general assembly and parts list Block No. L 13942296513 u163 http://www.xiaoyu163.com...
Page 35
MINI SCREW 1 LOCK LEVER(O.L.) FSKW4013-002 T.SPRING 1 FOR OPEN LEVER FSJC3014-001 CASS LID VKW4947-002 DOOR SPRING GE10005-002A FRONT PANEL 1 KS-FX901 GE10005-001A FRONT PANEL 1 KS-FX801 GE30113-003A FINDER ASSY 1 KS-FX801 GE30113-002A FINDER ASSY 1 KS-FX901 FSJK4009-001 REMOTE LENS...
Page 38
KS-FX901/KS-FX801 3 7 63 1515 0 Parts list (Cassette mechanism) Block No. M2MM Item Parts number Parts name Q'ty Description Area X-0801-1003S MAIN CHASSIS AS X-0801-1002S SLIDE CHASSIS A X-0801-1008S SIDE BKT ASS'Y X-0801-1010S EJECT CAM LIMIT X-0801-1013S CASSETTE HANGER...
Page 39
KS-FX901/KS-FX801 3 7 63 1515 0 Parts list (Cassette mechanism) Block No. M2MM Item Parts number Parts name Q'ty Description Area 1-0801-4008S REEL DRIVER SPG 1-0801-4009S LOAD ARM SPG 1-0801-4011S HOLDER STAB SPG 1-0801-5001S BELT 1-0801-5002S FELT 7.5*18.5*1.0 1-0801-5003S...
Page 41
KS-FX901/KS-FX801 3 7 63 1515 0 Grease point 2/2 L 13942296513 u163 http://www.xiaoyu163.com...
Page 42
KS-FX901/KS-FX801 3 7 63 1515 0 Electrical parts list (Main board) Block No. 01 Item Parts number Parts name Remarks Area Item Parts number Parts name Remarks Area QERF1CM-106Z E CAPACITOR 10MF 20% 16V C 342 QERF1HM-225Z E CAPACITOR 2.2MF 20% 50V...
Page 43
KS-FX901/KS-FX801 3 7 63 1515 0 Electrical parts list (Main board) Block No. 01 Item Parts number Parts name Remarks Area Item Parts number Parts name Remarks Area D 753 SLR-56MC3F PILOT LAMP R 35 QRE141J-152Y C RESISTOR 1.5K 5% 1/4W...
Page 44
KS-FX901/KS-FX801 3 7 63 1515 0 Electrical parts list (Main board) Block No. 01 Item Remarks Item Parts number Parts name Remarks Area Parts number Parts name Area R 719 QRE141J-472Y C RESISTOR 4.7K 5% 1/4W R 979 QRE141J-473Y...
Page 45
KS-FX901/KS-FX801 3 7 63 1515 0 Electrical parts list (Front board) Block No. 03 Item Remarks Item Parts number Parts name Remarks Area Parts number Parts name Area C 601 NBE20JM-475X TS E CAPACITOR R 611 NRSA63J-122X MG RESISTOR...
Page 46
KS-FX901/KS-FX801 3 7 63 1515 0 Packing materials and accessories parts list Block No. Block No. L 13942296513 A1,A2 A8, A9 KIT : A3~A7 u163 3-14 http://www.xiaoyu163.com...
Page 47
QPC03004315P POLY BAG 1 SET QPA01003003 POLY BAG 1 HARD CASE FSYH4036-068 SHEET GE30123-035A CARTON 1 KS-FX801 GE30123-012A CARTON 1 KS-FX901 GE10008-001A ESP CUSHION Parts list (Accessories) Block No. M4MM Item Parts number Parts name Q'ty Description Area GET0016-001A INSTRUCTIONS...