Page 1
CD72/92 Service Manual Issue 1.0 DiVA CD72, CD92 Compact Disc Player (Text) ARCAM ARCAM...
Page 2
Contents List Contents list Circuit description Upgrade procedure Service guide Circuit diagrams Component overlays Circuit board parts list General assembly parts list...
Page 3
92DAC upgrade connections omitted (L933AY). Remote control data is received from the IREye on the display PCB DiVA CD72 (text) - With the standard set of and buffered by TR300 and TR301. The Programmable Interrupt components fitted (L899AY).
The remote control data contains a ‘Customer Code’ that identifies this as an Arcam product. The diode network D100 to D106 configures the micro to accept this code. Remote Bus Carrier Filter & Demodulator Remote control commands can be delivered over wire to SK500 for multi-room applications.
Page 6
Upgrading a CD72 to CD92 1. Disconnect the mains supply from the DiVA CD player. 2. Remove the top cover by taking out the 2 screws from the top edge of the rear panel (marked 1) and on each side (marked 2). 3.
Page 7
Upgrading a CD72 ( TEXT ) to CD92 ( TEXT ) 1. Disconnect the mains supply from the DiVA CD player. 2. Remove the top cover by taking out the 2 screws from the top edge of the rear panel (marked 1) and on each side (marked 2). 3.
Page 8
10. Push the module down firmly on to the support pillars. 11. Fit the supplied screws with integral washers to the 3 points marked 4 on the drawing overleaf to secure the module in place. The 2 slightly shorter screws and the shake proof washers should be fitted to the 2 points marked 6.
CD72 / CD92 (Text) Service Guide Fault diagnostics Fault Action No power Check mains fuse Check power supply rails No Audio output Check for digital output, if ok then check power supply voltages Check DAC chip Intermittent noise on output Check Dac chip Fails to respond to commands Check supply to remote circuit...
Page 10
POWER SUPPLIES MECH INTERCONNECTS DAC AND OSCILLATOR DISPLAY AND MICROCONTROLLER L899C2_2 L899C3_2 L899C4_2 L899C7_2 L899C2_2.1.sch L899C3_2.1.sch L899C4_2.1.sch L899C7_2.1.sch FILA FILA BCLK DEEM RESET FILB FILB ADATA LRCK 17MHZ RC5 IP LRCK ADATA 17MHZ DIGOP BCLK RESET EMPHASIS DISPLAY PCB RC5 INPUT AND DIG OUTPUTS LK600 L899C1_2 L899C5_2...
Page 23
VP18 IC302C R309 CLK17M_5V_DAC 100R SM 74VHC125 SM +5VCLK C325 NOT FITTED L300 22P SM 33UH SM IC303B +5VCLK 74VHC125 SM R308 CLKLAT C309 L303 CLK17M_3V_LATCH IC301 100N SM 100R SM 7F004 FLT300 78L05 P5VCLK 7G002 R305 C324 NOT FITTED Vout 22P SM 100R SM...
Page 24
IC403B +3V3 +3V3 +3V3 74VHC74MX SM IC401C L400 IC402C L402 IC403C L403 74VHC74MX SM 74VHC74MX SM 74VHC74MX SM 7F004 7F004 7F004 IC402B C407 C410 C409 C412 C413 C414 100N SM 100N SM 100N SM 100N SM 100N SM 100N SM CLK17M_3V_LATCH IC402A 74VHC74MX SM...
Page 28
Reference Description Part CD72 (text) Main Board L899_2.1 number C505 CERD 100N 63V 20% RA 2A410 C506 ELST 22U 20V OSCON 2P622 Reference Description Part C507 CERD 100N 63V 20% RA 2A410 number C508 PPRO 680P 5% 63V RA 2D168 BR200 Bridge rectifier DF01M 1A 100V 3BDF01M...
Page 29
Reference Description Part Reference Description Part number number PL300 3WAY MOLEX VERT MALE 8K2103 R425 RES MF W4 1% 1M0 1H510 CONNECTOR R426 RES MF W4 1% 33K 1H333 PL400-402 2WAY MOLEX VERT MALE 8K6201 R427 RES MF W4 1% 33K 1H333 CONNECTOR R428...
Page 30
Reference Description Part CD92 (text) Main Board L934_2.1 number FS201 FUSEHOLDER 20mm PCB 8S004 Reference Description Part FS201 INS COVER PCB FUSEHOLDER F022 number FS201 FUSE 20mm 160mA T C11166 BR200 Bridge rectifier DF01M 1A 100V 3BDF01M S504160mA BR201 Bridge rectifier DF01M 1A 100V 3BDF01M HS200 HEATSINK TO220 8.6 DEGC/W...
Page 31
Reference Description Part number R221 RES MF W4 1% 820R 1H182 R222 RES MF W4 1% 470K 1H447 R223 RES MF W4 1% 10K 1H310 R224 RES MF W4 1% 10K 1H310 R225 RES MF W4 1% 2K2 1H222 R226 RES MF W4 1% 10K 1H310 R227...
Page 32
C76-C84 MLC 10N 50V X7R 10% 0805 2J310 CD92 DAC Board L912_2.0 PPRO 4N7 63V 5% RA 2D247N CD92 MLC 10N 50V X7R 10% 0805 2J310 after serial number C92P02150 MLC 10N 50V X7R 10% 0805 2J310 CD23 after serial number F23C02425 MLC 100N 50V X7R 10% SM 2C410 ELST 100U 25V ZA...
Page 34
R47-R49 RES SM W4 2% 15K 1A315 R305- RES SM W4 1% 100R 1206 1A110 R309 RES SM W4 2% 15K 1A315 R314 RES SM W4 2% 4M7 1A547 RES SM W4 2% 15K 1A315 R315 RES SM W4 1% 100R 1206 1A110 RES SM W4 1% 47R 1206 1A047...
Page 35
CD72 (TEXT) General Assembly Parts List ITEM 230V 115V 100V SILVER BLACK DESCRIPTION WHERE USED L815RC REMOTE CONTROL E050AY E050AYB CD72 FRONT PANEL E828CP E827CP COVER PLATE E991AY E992AY CD DRAWER FRONT HA4V06S HAV406B M/C TORX M4X6 LID TO CHASSIS B2012 SONY MECH C11166...
Page 36
CD92 (TEXT) General Assembly Parts List ITEM 230V 115V 100V SILVER BLACK DESCRIPTION WHERE USED L815RC REMOTE CONTROL E050AY E050AYB CDTEXT FRONT PANEL E828CP E827CP COVER PLATE E995AY E996AY CD DRAWER FRONT HA4V06S HAV406B M/C TORX M4X6 LID TO CHASSIS B2012 SONY MECH C11166...
Page 37
CD92 (TEXT) General Assembly Parts List ITEM 230V 115V 100V SILVER BLACK DESCRIPTION WHERE USED K5408 LIGHT PIPE SLEEVING (6mm) L806CA CABLE ASS MOTORDRVE L806CA ISS2 CD MECH. LEAD L811CA3 23-WAY FLEX-FOIL CD MECH. LEAD L860CA CD 72/92 DISPLAY TO MAIN FCC CABLE DISPLAY LEAD L866TX L866TX...