Page 1
OPERATORS’ GUIDE REL-TP SERIES HYDRAULIC TRASH PUMPS REL-TP SERIES Trash Pumps are a light weight, efficient way to move large quantities of liquids FAST. REL-TP4 REL-TP3 NOTICE Sizes, weights and specifi cations listed in this manual are subject to change without notice.
A digital copy of this manual is available on line at www.Reliable-Equip.com THIS SYMBOL INDICATES ITEMS OF EXTREME IMPORTANCE. Obey all safety messages that follow this symbol to avoid possible injury or death.
Length ....14 in. (35.5 cm) 301 Ivyland Road • Wa r m i n s t e r, PA 18974 Width ..... 16 in. (41 cm) Phone: 800-966-3530 • Fax: 215-357-9193 Weight ....30 lbs (13.6 kg) Visit us on the web at www.Reliable-Equip.com...
Length ....19 in. (48.3 cm) 301 Ivyland Road • Wa r m i n s t e r, PA 18974 Width ..... 15 in. (38.1 cm) Phone: 800-966-3530 • Fax: 215-357-9193 Weight ....59 lbs (26.8 kg) Visit us on the web at www.Reliable-Equip.com...
Backpressure should be measured at the tool before being used. Excessive backpressure will damage shaft seal. REL-TP4 4” TRASH PUMP Consult your supervisor, safety personnel, or RELIABLE EQUIPMENT with any questions regarding the safe operation of this tool.
BEFORE USING THIS TOOL, READ THE WARNINGS and the recommended practices described in this manual. Failure by the operator to read and fully understand these warnings will leave this person unqualified to use and operate this tool. Property damage, severe personal injury, WARNING and/or death could result by not following these warnings.
Page 8
SAFE OPERATION & CARE USE THIS TOOL FOR ITS INTENDED PURPOSE ONLY Any other use can result in injury or property damage. INSPECT TOOL BEFORE USE. Replace any worn, damaged WARNING or missing parts. A damaged or improperly assembled tool may malfunction, injuring operator and/or nearby personnel.
Page 9
Never disconnect tool, hoses, or fi ttings while the hydraulic power source is running or if the hydraulic fl uid is hot. IF YOU HAVE ANY QUESTIONS REGARDING THE SAFE USE AND/OR OPERATION OF THIS TOOL, CONSULT YOUR AREA SUPERVISOR, OR CONTACT RELIABLE EQUIPMENT AT 800-966-3530...
Page 10
ELECTRICAL SHOCK HAZARD Always wear and use the necessary clothing, equipment and safety practices to protect against electrical shock. Failure to follow these rules can result in serious personal injury or death. WARNING GENERAL SAFETY USE ALL APPROPRIATE AND APPLICABLE PERSONAL SAFETY EQUIPMENT as required by the operating company.
OPERATION PRE-OPERATION Do not use this tool under unsafe working conditions or locations. Use this pump only for it’s intended purpose. This pump is not designed for operation with a suction pipe inlet. Read entire manual prior to operation of this tool. (Refer to all safety recommendations and warnings) Observe all safety precautions &...
DAILY MAINTENANCE IMPORTANT: The greatest cause of hydraulic system failure is dirt. Prevent the introduction of foreign matter into the pump via hydraulic fl uid, dirty connections or accumulation of sediment in the hydraulic system. The life, reliability, and safety of the tool is dependent on proper maintenance. Maintenance must be performed by authorized and trained personnel ONLY.
Increasing Flow May Remove Excess Solids, but may result in wear or damage to the pump. IF THE ISSUE OR THE PROPER SOLUTION IS NOT FOUND ABOVE CONTACT YOUR RELIABLE SERVICE REPRESENTATIVE WARNING: ALL tool repair and service must be performed by authorized and trained personnel ONLY.
Page 15
REL-TP3 HYDRAULIC SUBMERSIBLE TRASH PUMP REL-TP3 PARTS LIST Description TP305 Urethane Volute TP307 Base TP306 Urethane Impeller TP321 Gasket TP317 Motor Mount Plate TP304 Motor FF-370 FF Coupler Set TP319 Carry Handles TP301 Wing Nut 10 TP318 Cam Loc 3” Male 11 TP315 Motor Mounting Nuts 12 TP303...
OPERATION RECORDS Date Hours Liquid Type Solid Type & Concentration Flow Head...
Page 18
RELIABLE EQUIPMENT Protective Foot Wear at the address, phone or fax numbers shown below. Electrical Shock 301 Ivyland Road • Warminster, PA 18974 Hot Surfaces Phone: 800-966-3530 • Fax: 215-357-9193 Visit us on the web at www.Reliable-Equip.com Hydraulic Injection...