Advertisement
17. Rear block installation: Install the new lift blocks, taller end toward the rear bumper, between
springs and original blocks (new block will be installed on top of the original block).On 8" kits,
install the provided rear brake lines using the instructions enclosed.
18. Using the floor jack, raise the axle up to rear springs. Be sure the spring tie bolts and block pins
all align in proper holes and are completely seated. Install and torque new u-bolts to 100-110 ft.
lbs.
19. Install rear sway bar endlinks (supplied only in 8" kit or ordered optionally w/ 4" & 6" kits). Install
new shocks and tires, then lower vehicle to ground.
NOTES:
•
If vehicle is equipped with rear sway bars, you need to order the following extended sway
bar end links:
•
According to Ford manuals there is a 3/4" tolerance on side to side height differences
from factory. If you are having this problem after installation, please call for further
options.
•
On models equipped with a rear carrier bearing, if a driveline vibration occurs, it may be required
to lower carrier bearing after installation of this lift.
4-6" Lifts use Skyjacker Part # CBL3401
•
Be sure to have front end alignment checked periodically by a professional for your safety and
longer tire life.
•
Check drive shafts for proper length and clearance. Check brake line length; it may be necessary
to re-route original lines or replace with new longer stainless steel lines available from SKYJACKER
•
It may be necessary to recenter the steering wheel by adjusting the turn buckle on the drag link
assembly.
NOTICE: Retorque ALL nuts, bolts and especially the u-bolts after the first 100 miles,
again after another 100 miles, and then check periodically thereafter.
Torque Specifications:
7
⁄
" Bolts ............55 - 58 ft.lbs.
1 6
1
⁄
" Bolts ..............85 - 90 ft.lbs.
2
9
⁄
" Bolts ............115 - 125 ft.lbs.
1 6
9
⁄
" Front U-Bolts .........85 - 90 ft.lbs.
1 6
5
⁄
" Rear U-Bolts ..........100-110 ft. lbs
8
12mm Bolts ...........73-77 ft.lbs.
ACCESSORIES:
• Triple Front Shock Kit (Shown at right)
• HD OEM Replacement Steering Stabilizer
• Single Steering Stabilizer (Shown below) #7199
• Dual Steering Stabilizer
The SOFTRIDE
®
rear springs are also available separately.
#SBE404 for 4" lifts
#SBE405 for 6" lifts
8" Lifts use Skyjacker Part # CBL214
#TS950
#7099
#7299
7199
®
.
TS950
4
Advertisement
