Page 1
3 7 63 1515 0 For U.S.A & Canada model SERVICE MANUAL DVM-1805 MODEL DVD VIDEO AUTO CHANGER L 13942296513 Some illustrations using in this service manual are slightly different from the actual set. u163 16-11, YUSHIMA 3-CHOME, BUNKYOU-KU, TOKYO 113-0034 JAPAN...
http://www.xiaoyu163.com LASER BEAM SAFETY PRECAUTIONS 3 7 63 1515 0 This DVD player uses a pickup that emits a laser beam. Do not look directly at the laser beam coming from the pickup or allow it to strike against your skin. The laser beam is emitted from the location shown in the figure.
http://www.xiaoyu163.com IMPORTANT SAFETY PRECAUTIONS 3 7 63 1515 0 Product Safety Notice I. Also check areas surrounding repaired locations. J. Be careful that foreign objects (screws, solder Some electrical and mechanical parts have special droplets, etc.) do not remain inside the set. safety-related characteristics which are often not evi- K.
Page 6
http://www.xiaoyu163.com Safety Check after Servicing 3 7 63 1515 0 Examine the area surrounding the repaired location for damage or deterioration. Observe that screws, parts, and wires have been returned to their original posi- Chassis or Secondary Conductor tions. Afterwards, do the following tests and confirm the specified values to verify compliance with safety Primary Circuit Terminals standards.
http://www.xiaoyu163.com STANDARD NOTES FOR SERVICING 3 7 63 1515 0 Circuit Board Indications How to Remove / Install Flat Pack-IC 1. Removal a. The output pin of the 3 pin Regulator ICs is indi- cated as shown. With Hot-Air Flat Pack-IC Desoldering Machine:. (1) Prepare the hot-air flat pack-IC desoldering Top View Bottom View...
Page 8
http://www.xiaoyu163.com With Soldering Iron: (4) Bottom of the flat pack-IC is fixed with glue to the 3 7 63 1515 0 CBA; when removing entire flat pack-IC, first apply (1) Using desoldering braid, remove the solder from all soldering iron to center of the flat pack-IC and heat pins of the flat pack-IC.
Page 9
http://www.xiaoyu163.com Instructions for Handling 2. Installation 3 7 63 1515 0 Semi-conductors (1) Using desoldering braid, remove the solder from the foil of each pin of the flat pack-IC on the CBA Electrostatic breakdown of the semi-conductors may so you can install a replacement flat pack-IC more occur due to a potential difference caused by electro- easily.
http://www.xiaoyu163.com CABINET DISASSEMBLY INSTRUCTIONS 3 7 63 1515 0 1. Disassembly Flowchart REMOVAL REMOVE/*UNHOOK/ LOC. PART Fig. This flowchart indicates the disassembly steps to gain UNLOCK/RELEASE/ Note access to item(s) to be serviced. When reassembling, UNPLUG/DESOLDER follow the steps in reverse order. Bend, route, and 2(S-4), CN5002, [7] Relay CBA dress the cables as they were originally.
Page 11
http://www.xiaoyu163.com *=Unhook, Unlock, Release, Unplug, or Desolder 3 7 63 1515 0 e.g. 2(S-2) = two Screws (S-2), (S-2) (L-1) 2(L-2) = two Locking Tabs (L-2) (5): Refer to “Reference Notes.” Reference Notes (L-1) CAUTION 1: Locking Tabs (L-1) are fragile. Be careful not to break them.
Page 12
http://www.xiaoyu163.com 3 7 63 1515 0 Drive Mecha CN5101 Assembly CN5002 Short the three short lands by soldering [8] Sensor CBA (S-5) CN5005 [7] Relay (S-4) Fig. D6 [10] TrayGuide (L) (S-7) View for A (S-7) (S-8) L 13942296513 (S-8) Short the three short lands by soldering Slide...
http://www.xiaoyu163.com TROUBLESHOOTING 3 7 63 1515 0 FLOW CHART NO.1 The power cannot be turned on.(1) See FLOW CHART No.3 <The fuse blows out.> Is the fuse normal? Is normal state restored when once unplugged Check if there is any leak or shor-circuit on the power cord is plugged again after several seconds? primary circuit component? (Q1001, Q1003,T1001, D1001, D1002, D1004,...
Page 15
http://www.xiaoyu163.com 3 7 63 1515 0 FLOW CHART NO.4 When the output voltage fluctuates. Does the photo coupler circuit on the secondary Check the circuit and replace the parts. side operate normally? (IC1001, IC1006, D1048, D1015) Does the photo coupler circuit on the primary side Check the circuit and replace the parts.
Page 16
http://www.xiaoyu163.com FLOW CHART NO.8 3 7 63 1515 0 No operation is possible from the remote control unit. Operation is possible from the DVD, but no operation is possible from the remote control unit. Is no operation possible if replacing the remote Original remote control unit is poor.
Page 17
http://www.xiaoyu163.com 3 7 63 1515 0 FLOW CHART NO.13 PON 1.8V is not outputted. Check D1013, C1014 and the periphery circuit. Is 2.5V voltage supplied at pin(1) of IC1002? Check PWRCON line. Is the "H" pulse inputted into pin(4) of IC1002? Replace IC1002.
Page 18
http://www.xiaoyu163.com 3 7 63 1515 0 FLOW CHART NO.17 [No Disc] is indicated. (When the focus servo is not functioning.) Replace the DVD Main CBA Unit. No improvement can be found. The malfunction of the original DVD Main CBA Unit. Replace the DVD Mecha.
Page 19
http://www.xiaoyu163.com 3 7 63 1515 0 FLOW CHART NO.20 Picture does not appear normally in interlace mode. Set the disc on the disc tray and playback. Replace the DVD Main CBA Unit or DVD Mecha . Are the video signals outputted to each pin of CN1601 on the the Changer CBA? CN1601 7PIN CVBS...
Page 20
http://www.xiaoyu163.com 3 7 63 1515 0 FLOW CHART NO.21 Component video signals are not outputted normally in progressive mode. Set the disc on the disc tray and playback. Are the video signals outputted to each pins of Check the line between each pin of CN1602 and CN1602 on the Changer CBA? each pin of JK1403 on the Changer CBA, and their periphery.
Page 21
http://www.xiaoyu163.com 3 7 63 1515 0 FLOW CHART NO.22 Audio is not outputted. Set the disc on the disc tray and playback. Replace the DVD Main CBA Unit or DVD Mecha. Are the analog audio signals outputted to each pin of CN1601 on the Changer CBA? CN1601 13PIN AUDIO-L CN1601 15PIN AUDIO-R...
http://www.xiaoyu163.com BLOCK DIAGRAMS DVD System Control Block Diagram 3 7 6 3 1 5 1 5 0 IC301 IC601 (FRONT END PROCESSOR) (DVD HOST PROCESSOR) TFWD TREV TFWD TFWD TOUT TREV TREV TOUT IC605 TOUT +3.3V STDIO RESET RESET FROM/TO STDIO RF SIGNAL PROCESS...
Page 23
http://www.xiaoyu163.com Changer System Control Block Diagram 3 7 6 3 1 5 1 5 0 FOCUS SERVO SIGNAL TRACKING SERVO SIGNAL PICK-UP UNIT CHANGER CBA CN5004 CN5005 LOADING C 10 MOTOR CN3003 DETECTOR 1 LM(+) 2 LM(-) CD/DVD 21 CD/DVD CN3001 CN5004 CN5005...
Page 24
http://www.xiaoyu163.com RF Signal Process/Servo Block Diagram 3 7 6 3 1 5 1 5 0 DATA(VIDEO/AUDIO) SIGNAL FOCUS SERVO SIGNAL TRACKING SERVO SIGNAL SLIDE SERVO SIGNAL DISK SERVO SIGNAL IC101 (RF SIGNAL PROCESS) DVD MAIN CBA UNIT HOLD TESTSG CN101 FROM/TO DVD SIGNAL PROCESS BLOCK DIAGRAM...
Page 25
http://www.xiaoyu163.com DVD Signal Process Block Diagram 3 7 6 3 1 5 1 5 0 DATA(VIDEO/AUDIO) SIGNAL DVD MAIN CBA UNIT IC201 (DVD SIGNAL PROCESS) PARA0 PARA1 PARA2 DATA VIDEO/AUDIO PARA3 SLICER PARA0-PARA7 TO VIDEO DEMODULATOR FROM/TO RF SIGNAL INTERFACE NARF PARA4 BLOCK DIAGRAM...
Page 26
http://www.xiaoyu163.com Video Block Diagram 3 7 6 3 1 5 1 5 0 DATA(VIDEO) SIGNAL DATA(AUDIO) SIGNAL VIDEO SIGNAL DATA(VIDEO/AUDIO) SIGNAL IC601 (DVD HOST PROCESSOR) CACHE FROM DVD PARA0 SUBSYSTEM SIGNAL PROCESS PARA0-PARA7 BLOCK DIAGRAM PARA7 CENTRAL FRONT-END PCM-BCK COMMAND &...
Page 27
http://www.xiaoyu163.com Progressive Block Diagram 3 7 6 3 1 5 1 5 0 DATA(VIDEO) SIGNAL VIDEO SIGNAL IC1801 (DE-INTERLACER) IC1803 (PROGRESSIVE ENCODER) CN1801 TEST PATT.GENE. 3-10 YC(0-7) FORMATTER DE-INTERLACER FORMATTER /DELAY /GAMMA CORRECTOR FROM/TO VIDEO BLOCK CLK27MHz PLL/CLOCK GENE DIAGRAM CN702 H SYNC 4:2:2 4:2:2...
Page 28
http://www.xiaoyu163.com Audio Block Diagram 3 7 6 3 1 5 1 5 0 DATA(AUDIO) SIGNAL AUDIO SIGNAL IC1204 FIBER OPTIC TRANS MODULE WF 6 JK1201 CN701 CN1601 Q1351 SPDIF DIGITAL AUDIO OUT IC801 (AUDIO DAC) IC1201 (AMP) W F4 SPDIF CN701 CN1601 4X/8X...
Page 29
http://www.xiaoyu163.com Power Supply Block Diagram 3 7 6 3 1 5 1 5 0 CAUTION ! CAUTION Switching power supply circuit is used in this unit. FOR CONTINUED PROTECTION AGAINST FIRE HAZARD, NOTE : If Main Fuse (F1001) is blown, check to see that all components in the REPLACE ONLY WITH THE SAME TYPE FUSE.
http://www.xiaoyu163.com SCHEMATIC DIAGRAMS / CBA’S AND TEST POINTS 3 7 63 1515 0 Standard Notes Notes: WARNING 1. Do not use the part number shown on these draw- ings for ordering. The correct part number is Many electrical and mechanical parts in this chassis shown in the parts list, and may be slightly different have special characteristics.
Page 31
http://www.xiaoyu163.com LIST OF CAUTION, NOTES, AND SYMBOLS USED IN THE SCHEMATIC DIAGRAMS ON THE FOLLOWING 3 7 63 1515 0 PAGES: 1. CAUTION: FOR CONTINUED PROTECTION AGAINST FIRE HAZARD, REPLACE ONLY WITH THE SAME TYPE FUSE. ATTENTION: POUR UNE PROTECTION CONTINUE LES RISQES D'INCELE N'UTILISER QUE DES FUSIBLE DE MEMO TYPE.
http://www.xiaoyu163.com FIRMWARE RENEWAL MODE 3 7 63 1515 0 1. Turn the power on and remove the disc on the tray. 2. To put the DVD player into version up mode, press [9], [8], [7], [6], and [SEARCH MODE] buttons on the remote control unit in that order.
Page 35
http://www.xiaoyu163.com 3 7 63 1515 0 8. Disconnect and connect the AC Plug to the AC Outlet again during opening the Tray. 9. The Tray closes when the POWER Button (*1) is pressed to turn on the Power of the unit. (*1: The operation differs depending on models.) After the above, a series of the Back-End F/W updating procedures completes.
http://www.xiaoyu163.com LEAD IDENTIFICATIONS 3 7 63 1515 0 2SK3374 2SC2785 (H) 2SC2120-Y(TPE2) KTC3199 (GR) KTC3203(Y) KRA110M 2SC2236-Y-TPE6,C KRC110M-AT KTC3205 (Y) BA1L3Z-T BN1L3Z (P) 2SA1015-Y (TPE2) KTA1266 (Y) DTC114ESA TP G D S E C B E C B PT204-6B-12 PT6315-S PT6315-S(-TP) 2SA1359-Y KIA431-AT...
Page 37
http://www.xiaoyu163.com Progressive Schematic Diagram 3 7 6 3 1 5 1 5 0 1 3 9 4 2 2 9 6 5 1 3 w w w u 1 6 3 - 37 - http://www.xiaoyu163.com...
Page 38
http://www.xiaoyu163.com DVD Main 1/4 Schematic Diagram 3 7 6 3 1 5 1 5 0 1 3 9 4 2 2 9 6 5 1 3 w w w u 1 6 3 - 38 - http://www.xiaoyu163.com...
Page 39
http://www.xiaoyu163.com DVD Main 2/4 Schematic Diagram 3 7 6 3 1 5 1 5 0 1 3 9 4 2 2 9 6 5 1 3 w w w u 1 6 3 - 39 - http://www.xiaoyu163.com...
Page 40
http://www.xiaoyu163.com DVD Main 3/4 Schematic Diagram 3 7 6 3 1 5 1 5 0 1 3 9 4 2 2 9 6 5 1 3 w w w u 1 6 3 - 40 - http://www.xiaoyu163.com...
Page 41
http://www.xiaoyu163.com DVD Main 4/4 Schematic Diagram 3 7 6 3 1 5 1 5 0 1 3 9 4 2 2 9 6 5 1 3 w w w u 1 6 3 - 41 - http://www.xiaoyu163.com...
Page 42
http://www.xiaoyu163.com Power Supply Schematic Diagram 3 7 6 3 1 5 1 5 0 CAUTION ! CAUTION Fixed voltage power supply circuit is used in this unit. FOR CONTINUED PROTECTION AGAINST FIRE HAZARD, NOTE : If Main Fuse (F1001) is blown, check to see that all components in the REPLACE ONLY WITH THE SAME TYPE FUSE.
Page 43
http://www.xiaoyu163.com Changer 1/3 Schematic Diagram 3 7 6 3 1 5 1 5 0 1 3 9 4 2 2 9 6 5 1 3 w w w u 1 6 3 - 43 - http://www.xiaoyu163.com...
Page 44
http://www.xiaoyu163.com Changer 2/3 Schematic Diagram 3 7 6 3 1 5 1 5 0 1 3 9 4 2 2 9 6 5 1 3 w w w u 1 6 3 - 44 - http://www.xiaoyu163.com...
Page 45
http://www.xiaoyu163.com Changer 3/3 Schematic Diagram 3 7 6 3 1 5 1 5 0 FL2001 MATRIX CHART STANDBY TITLE CHP. TRK. REPEAT DVD VIDEO CD 1 3 9 4 2 2 9 6 5 1 3 w w w u 1 6 3 - 45 - http://www.xiaoyu163.com...
Page 46
http://www.xiaoyu163.com Relay Schematic Diagram 3 7 6 3 1 5 1 5 0 1 3 9 4 2 2 9 6 5 1 3 w w w u 1 6 3 - 46 - http://www.xiaoyu163.com...
http://www.xiaoyu163.com EXPLODED VIEWS 3 7 63 1515 0 Cabinet View 1 See Electrical Parts List 2L021 for parts with this mark. 2L021 Some Ref. Numbers are not in sequence. 2L021 2L021 2L021 2L021 2L041 2L061 2L061 Relay CBA W1801 2B13 Progressive W5002 W1802...
http://www.xiaoyu163.com 3 7 63 1515 0 PARTS LIST PRODUCT SAFETY NOTE: Products marked with a # NOTE: have special characteristics important to safety. Before Parts that are not assigned part numbers (---------) are replacing any of these components, read carefully the not available.
Page 51
http://www.xiaoyu163.com 3 7 63 1515 0 Ref. No. Mark Description Parts No. (DE) Part No. Q'ty I/B BAG 0DM400757 9H2 6000 319 AV CORD LP-970124 WPZ0102LG008 9H2 6000 225 AV CORD TSCKA-Y/RW100 WPZ0102TM015 9H2 6000 226 AV CORD RCA(M*2)TO RCA(M*2) WPZ0102LTE01 9H2 6000 243 X10!
Need help?
Do you have a question about the DVM-1805 and is the answer not in the manual?
Questions and answers