GSM TELEPHONE SGH-E100 Manual SERVICE GSM TELEPHONE CONTENTS Specification Circuit Description Exploded Views and Parts List Electrical Parts List Block Diagrams PCB Diagrams Flow Chart of Troubleshooting...
Page 2
ELECTRONICS ⓒ Samsung Electronics Co.,Ltd. August. 2003 This Service Manual is a property of Samsung Electronics Co.,Ltd. Any unauthorized use of Manual can be punished under applicable Printed in Korea. International and/or domestic law. Code No.: GH68-04388A BASIC.
- 1 0 0 d B m TDM A M u x C el l Ra d iu s 3 5 Km 3 5 Km 2 Km SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization...
Page 4
6 ± 4 dBm 9 ± 3dBm 7 ± 3 dBm 4 ± 4 dBm 5 ± 3 dBm 2 ± 5 dBm 0 ± 5 dBm SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization...
The Mixer output is amplified with an analog programmable gain amplifier(PGA), which is controlled by AGAIN. The quadrature IF signal is digitized with high resolution A/D converts (ADC). SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization...
Page 6
The Backlight Brightness Modulator (BBM) contains a programmable Pulse-width modulator (PWM) and FET to modulate the intensity of a series of LED’s or to control a DC/DC converter that drives LCD backlight. This phone (SGH-E100) works by PWM. SAMSUNG Proprietary-Contents may change without notice...
Page 7
7. Battery Charge Management A complete constant-current/constant-voltage linear charger for single cell lithium-ion batteries. If TA connected to phone, "V_EXT_CHARGE" enable charger IC and supply current to battery. SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization...
Page 8
Signals in the OM6357 enable two memories. They use only one volt supply voltage, VDD3 in the PCF50601. This system uses Samsung's memory, KBB06A300M-T402. It is consisted of 128M bits flash NOR memory and 128M bits flash NAND memory and 32M bits UtRAM. It...
Page 9
This system uses the 26MHz TCXO, TCO-9141G, Toyocom. AFC control signal from OM6357 controls frequency from 26MHz X-tal. The clock output frequency of UAA3536HN is 13MHz. This clock is connected to OM6357, YMU762. SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization...
Page 10
3. SGH-E100 Exploded View and its Parts list 1. Cellular phone Exploded View-1 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization...
Page 11
MAIN PBA GH92-01455A VOLKEY FPCB GH59-00678A IF COVER GH73-01844A GH30-00006A VOLUME KEY GH75-02846A ANTENNA GH42-00300A REAR COVER GH75-02843A RF COVER GH73-01843A SCREW 6001-001478 BATTERY GH43-00940A SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization...
Page 12
3. Test Jig (GH80-01909A) 3-1. RF Test Cable 3-2. Test Cable 3-3. Serial Cable (GH39-00140A) (GH39-00217A) 3-4. Power Supply Cable 3-6. TA 3-5. DATA CABLE (GH44-00184A) (GH39-00143B) SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization...
0801-002237 U403 2007-000142 R128 0801-002540 U452 2007-000147 R212 0801-002540 U453 2007-000148 R113 0801-002540 U508 2007-000148 R208 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization This Document can not be used without Samsung's authorization...
Page 14
R121 2007-000162 R598 2007-001308 R114 2007-000162 R600 2007-001313 R400 2007-000162 R650 2007-001325 R403 2007-000164 R416 2007-002965 R112 2007-000167 R417 2007-007001 R358 2007-000171 R126 2007-007008 R202 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization...
Page 15
C502 2007-008117 R419 2203-000438 C503 2007-008312 R513 2203-000438 C520 2203-000233 C132 2203-000440 C127 2203-000233 C214 2203-000550 C140 2203-000233 C215 2203-000585 C115 2203-000233 C216 2203-000585 C116 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization...
Page 16
2203-000854 C529 2203-005061 C368 2203-000885 C411 2203-005061 C369 2203-000995 C104 2203-005061 C370 2203-001153 C141 2203-005061 C371 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization This Document can not be used without Samsung's authorization...
Page 17
2703-001747 L202 2203-005482 C125 2703-001748 L109 2203-005482 C135 2703-002198 L203 2203-005482 C138 2703-002203 L100 2203-005482 C312 2703-002208 L106 2203-005482 C540 2703-002208 L107 2203-005496 C126 2801-003747 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization...
Page 18
F453 2901-001258 F451 2901-001258 F452 2904-001390 F100 2904-001403 F102 2909-001204 MODULE1 3301-001105 L300 3705-001273 CON201 3709-001250 CN301 3710-001816 3711-005078 CN100 3722-001715 EAR500 4302-001119 BAT100 GH41-00382A SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization...
VDD1 (1.35V min 2.95V max , 150mA ) VDD2 (1.35V min 3.45V max , 150mA ) VDD3 (1.35V min 3.45V max , 100mA ) VDD4 (1.35V min 3.45V max , 150mA ) SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization...
Page 20
SRAM (32M bit) RAMP VDD2 FLASH VDD3 (256M bit) VDD_VIB MIC_BIAS Li-Ion Battery (Slim,Standard) VDD_KEY KEY_BOARD VDD_AMP AVDD Charging RTC_CLOCK SIM CARD Circuit (32.768KHz) AVDD_TEMP SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization...
6. SGH-E100 PCB Diagrams 1. Main PCB Top Diagram SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization...
Page 22
SGH-E100 PCB Diagrams 2. Main PCB Bottom Diagram SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization...
Check the VDD2,VDD3 circuit = 2.8V? Check the clock generation circuit Check for the clock at C132 = 26MHz (related to U101) Check the initial operation SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization...
Page 24
SGH-E100 Flow Chart of Troubleshooting Power On SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization...
Page 25
Check the circuit related to reset R576 (RSTON) ="H"? Is U508 pin 4,6 Check the U508 (memory CE) OK? Check the circuit around LCD & U402 (Short or not solder) SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization...
Page 26
SGH-E100 Flow Chart of Troubleshooting Initial SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization...
Page 27
U406 pin 5 (CHG_ON) = "L"? CHG_ON signal Check the U405 pin 7 Resolder U405 = "H"? U405 pin 1,15,16 Resolder or replace U405 ≒ 4.2V? SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization...
Page 28
SGH-E100 Flow Chart of Troubleshooting Charging SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization...
Page 29
Check the 32k OSC CN301 pin3 in a few second After SIM card insert, Replace PBA CN301 pin 2 = "H(SIM_RST)"? Check the SIM Card SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization...
Page 30
SGH-E100 Flow Chart of Troubleshooting SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization...
Page 31
Resolder MIC from MIC Check the circuit Resolder the C508, C515, R502, R504, R507 from U504 to MIC and R509 Check the MIC Replace the MIC SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization...
Page 32
SGH-E100 Flow Chart of Troubleshooting Microphone 7-10 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization...
Page 33
U402 pin 17,18 ≒ 1.8V? Resolder U402 (When U301 operate) CN100 pin 20,21 Check the circuit related to ≒ 1.8V? "SPK_P/SPK_N" signal Is Speaker working? Change the Speaker 7-11 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization...
Page 34
SGH-E100 Flow Chart of Troubleshooting Speaker HPOUT-L/MONO IOVDD HPOUT-R SPVDD SPVSS 7-12 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization...
Page 35
Check the Dome sheet & Key Pad pushed, is it displayed on LCD? When one of the keys is Replace the PBA pushed, KBIO signal is OK? 7-13 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization...
Page 36
Replace CN100 CN100 pin 20,21 = 1.5V? Check the soldering of the Modify the speaker wire soldering speaker wire Replace the Receiver Is Receiver working? 7-14 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization...
Page 37
Menu? Resolder U509 CN100 pin 23 = 2.8V? Replace the PBA CN100 pin 15 = 3.05V? Replace the LCD Module 7-15 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization...
Page 38
Key Backlight does not work Check the PMU related to "VDD_KEY" U518 pin 5 = "H"? Resolder or replace U518 U518 pin 2,3 = "H"? 7-16 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization...
Page 39
>= -70dBm Check & Resolder U100 pin6, 7, 8, 9 U100 >= 1V RF26MHz, RF PSU Part R123, R125, R127, R128 >= 1V Check U504 7-17 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization...
Page 40
Check & Resolder RFLO U100 pin6, 7, 8, 9 signal, RF26MHz, >= 500mV RF PSU Part Check U504 Check U100 pin 10, 22,23>=2.7V Resolder U100 7-18 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization...
Page 41
>= -70dBm Check & Resolder U100 pin6, 7, 8, 9 U100 >= 1V RF26MHz, RF PSU Part R123, R125, R127, R128 >= 1V Check U504 7-19 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization...
Page 42
Check & Resolder RFLO U101 pin6, 7, 8, 9 signal, RF26MHz, >= 500mV RF PSU Part Check U504 Check U100 pin 10, 22,23>=2.7V Resolder U100 7-20 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization...
Page 43
SGH-E100 Flow Chart of Troubleshooting Transmitter 7-21 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization...
Page 44
SGH-E100 Flow Chart of Troubleshooting Transmitter 7-22 SAMSUNG Proprietary-Contents may change without notice This Document can not be used without Samsung's authorization...