Relocate the unit if necessary. 9. Keep children away from the unit while it is being repaired. Fig. 1-3 No Kids Nearby! 10. Be sure to clean the unit and its surround- ing area. Fig. 1-4 Clean the Unit Samsung Electronics...
˚C Run capacitor µF x VAC 4µF x 450VAC 4µF x 450VAC Coil AL-FIN / Copper tube AL-FIN / Copper tube Rows x Steps 2 x 24 2 x 24 Heat Exch. Fin pitch Face area 0.5376 0.5376 Samsung Electronics...
Page 9
2.5µF x 450VAC 3.0µF x 450VAC Coil AL-FIN / Copper tube AL-FIN / Copper tube AL-FIN / Copper tube Rows x Steps 2 x 24 2 x 24 2 x 24 Heat Exch. Fin pitch Face area 0.5376 0.504 0.504 Samsung Electronics...
Page 10
17AM037A5 17AM037A5 135±5˚C 135±5˚C 135±5˚C 2.5µF x 450VAC 2.5µF x 450VAC 2.5µF x 450VAC AL-FIN / Copper tube AL-FIN / Copper tube AL-FIN / Copper tube 2 x 24 2 x 24 2 x 28 0.504 0.504 0.534 Samsung Electronics...
Page 11
˚C Run capacitor µF x VAC 4µF x 450VAC 2.5µF x 450VAC Coil AL-FIN / Copper tube AL-FIN / Copper tube Rows x Steps 2 x 28 2 x 28 Heat Exch. Fin pitch Face area 0.543 0.504 Samsung Electronics...
Page 12
2-3 Dimensions 2-3-1 Indoor Unit (Remote control) (Front view) 1080 (Rear view) The feature is subject to be varied as a model. 2-3-2 Outdoor Unit 2-3-2(a) 24K BTU (Front view) (Rear view) Samsung Electronics...
To select the 5 way function with the remote control, press the 5 way button one or more times until the desired mode is selected. Each time you press the 5 way button Each 5 way indicator on the indoor unit comes on in order. Samsung Electronics...
Page 17
De-ice end by sensing of the processing 7. FAN SPEED : Manual (3 step), Auto (4 step) time by de-ice Condition. Fan speed automatically varies depending on both the difference between setting and the room temperature. Samsung Electronics...
Page 18
"beep". 10. 24-Hour ON/OFF Real Setting Timer. : The air conditioner is turned ON at a specified time using Samsung Electronics...
It is harmful to the air conditioner if it is used in the following environments: greasy areas (including areas near machines), salty areas such as coast areas, areas where sulfuric gas is present such as hot spring areas. Contact your dealer for advice. Samsung Electronics...
7) Pull the upper left, right and Center of discharge softly for the outside cover to be pulled out. 8) Pull softly the lower part of discharge and push it up. Caution; Assemble the front panel and fix the hooks of left, right and Center. Samsung Electronics...
Page 21
4) Separate the bush body at the upper side and holder at the rearside. 5) Loosen the two fixing screws of left side. 6) Lifting the heat exchanger up a little to push the up side for separation from the indoor unit. Samsung Electronics...
Page 22
2) Loosen the fixing three screws and separate the motor holder. 3) Loosen the fixing screw of fan motor. (By use of M3 wrench) 4) Separate the fan motor from the fan. 5) Separate the fan from the left holder bearing. Samsung Electronics...
Fan Motor 1) Do Procedure 1 above. & 2) Remove the nut flange. Propeller Fan (Turn to the right to remove as it is a left turned screw) 3) Disassemble the propeller fan. Samsung Electronics...
Indoor unit heat exchanger temperature sensor Error (open or short) Indoor fan malfunctioning (for speed is Below 450rpm) NATURE LED blinking (1Hz) STD, NATURE and TIMER LED blinking(1HZ) EEPROM Error AII LED blinking (1Hz) Option Error (Option wasn’t setup or option data error) Samsung Electronics...
Check PCB pattern. Refer to Replace ICO2 10ms Replace nidule PCB. Is voltage output terminal of D101~D105(IN4007) normal? Are voltage at #18 and #19 of the micom normal? Replace resonator (X501) 100ms Replace IN4007 Is operation normal? Replace micom Samsung Electronics...
Page 26
Test rod location Normal voltage PCB CN73 Condition Fan operate = AC 180V Pin 3, Pin 5 MF-C is out of order Replace MFC Fan motor Fan motor should be replaced. is out of order. Samsung Electronics...
Page 27
Is the rating voltage ±10% range applied relay between out of order replaced. CN78 ! and # . Outdoor unit is out of order. Is the room sensor normal register? (25°C 10KΩ) 10°C 20°C 30°C 17.96k Ω 12.09kΩ 8.3kΩ Samsung Electronics...
Page 28
Is the voltage between CN71 #5 and CN78 #1 the rating voltage ±10% range? Abnormal RY73 Abnormal 4way valve of Outdoor Unit. or connecting Cable Refer to replace PCB module 4 way valve should be replaced or connecting Cable Check. Samsung Electronics...
Page 29
Voltage at PIN #30 of Remocon Micom change? Voltage at collecter of Q601 or Q602 change? Q601(C4375Y) or Q602(C1623Y) is faulty. IR LED(CL-1L5EU) is faulty. Voltage at pin #26 of micom (IC04) change (INDOOR UNIT)? Receiver module is faulty. Micom (IC04) is faulty. Samsung Electronics...
5-3 Replace PCB module 5-3-1 Replace PCB module Remove power cord Replace the PCB module Check the connection and plug in Replace another PCB module Does all display lamp blink or STD lamp blink? Refer to set up the Model option(5-3-2) Samsung Electronics...
$ When pressing the button appear on the display, select one of them. % When pressing the button appear on the display, select one of them. ^ When pressing the button appear on the display, select one of them. Samsung Electronics...
Page 32
If all lamps of indoor unit are flickering, Plug out and plug in again and pressing ON/OFF key to retry. If the unit is not working properly or all lamps are continuously flickering after setting the option code, see if the correct option code is set up for it’s model. Samsung Electronics...
5-4-2 Procedure The parts should be replaced in the following procedure. Check for any faulty part. Detach the faulty part. Replace it with a new part. Check the operation of the new part. The repair is completed. Samsung Electronics 5-11...
1. check voltage of IC06 IC06 is faulty (pin#13, pin#8) Compressor Operating check : relay on 0.7[v] -Set the TURBO mode : relay off 12[v] 2. Voltage at terminal block RY71 is faulty ((N1) -1) rating voltage 5-12 Samsung Electronics...
6. Exploded Views and Parts List 6-1 Indoor Unit 18L or 18R 17L or 17R 10-1 You can search for the updated part code number through the ITSELF. URL : http://itself.sec.samsung.co.kr Samsung Electronics...
Page 37
ASSY THERMISTER ASSY DB61-10163A CASE-CONTROL ABS(V0) DB94-20037H ASSY BACK BODY ASSY DRAIN: LEFT SIDE DB94-00107A ASSY BACK BODY ASSY DRAIN: RIGHT SIDE DB90-00163A HOLER PIPE DRAIN: LEFT SIDE DB90-00434A HOLER PIPE DRAIN: RIGHT SIDE DB70-10663A PLATE HANGER SGCC-M Samsung Electronics...
Page 38
ASSY THERMISTER ASSY DB61-10163A CASE-CONTROL ABS(V0) DB94-20037H ASSY BACK BODY ASSY DRAIN: LEFT SIDE DB94-00107A ASSY BACK BODY ASSY DRAIN: RIGHT SIDE DB90-00163A HOLER PIPE DRAIN: LEFT SIDE DB90-00434A HOLER PIPE DRAIN: RIGHT SIDE DB70-10663A PLATE HANGER SGCC-M Samsung Electronics...
Page 54
TERMINAL BLOCK SOLENOID COIL CRANK CASE HEATER CAPACITOR FAN MOTOR FUSE(2A, 250V~) SPARK KILLER UQ18A(B)9(0)RE, SH18ZA(B)9X UQ18A(B)9(0)RED, SH18ZA(B)0DX, UQ18A(B)9(0)RBD MARK NAME MARK NAME POWER-RELAY TB 1, 2 TERMINAL BLOCK SOLENOID COIL FAN MOTOR CAPACITOR SPARK KILLER FUSE(2A, 250V~) Samsung Electronics...
Page 55
Wiring Diagrams UQ24A(B)5(6)RBD MARK NAME MARK NAME MAGNETIC CONTACTOR TB 1, 2 TERMINAL BLOCK SOLENOID COIL FAN MOTOR CAPACITOR SPARK KILLER FUSE(2A, 250V~) INTERNAL TYPE Samsung Electronics...