Table of Contents
Advertisement
Here are just a few:
ProMar1 Series - Recreational Grade Waterproof Marine Battery Chargers
ProSport Series - Heavy Duty Recreational Grade Marine Battery Chargers
ProTournament Series - Professional Grade Tournament Grade Marine Battery Chargers
ProNauticP Series - Sailing and Cruising Marine Battery Chargers
ProIsoCharge Series - Digitally Controlled Zero Loss Charging Isolators
Digital Mobile Charge In-Transit Chargers
ProSport 1.5 Amp Multi-Use Battery Maintainer
AC Plug Holders
Battery Isolators
Galvanic Isolators and Monitored Systems
Corrosion Control Products
Waterproof Marine Binoculars
A Complete Line of Hand Held Test Meters
Online Technical Support and Service Support
5005649
TruePower Series
PLUS
Heavy Duty Marine, Mobile and Industrial Grade Inverters
ProMar
Digital
Performance Technology Inside
Owner's Manual and Installation
Model
Part No. Wattage
DC Input
TruePower Plus 1200MS 06120
1200 W
12 VDC Input
TruePower Plus 1500MS 06150
1500 W
12 VDC Input
TruePower Plus 2000MS 06200
2000 W
12 VDC Input
TruePower Plus 1000PS
07100
1000 W
12 VDC Input
TruePower Plus 2000PS
07200
2000 W
12 VDC Input
IMPORTANT NOTICE - SAVE THESE INSTRUCTIONS
Please save and read all safety, operating and installation instructions before installing or applying DC or AC
power to your TruePower Plus Inverter.
Your Satisfaction is Important to Us!
Do not return this product to a retailer or dealer for any service or warranty requirements.
PLEASE RECORD YOUR:
Model Number:
Serial Number:
Marine/Mobile/Industrial
Built-in AC Transfer Switch
2 Year Warranty
AC Input
AC Transfer AC Waveform
115 VAC
30 Amps
Modified Sine Wave
115 VAC
30 Amps
Modified Sine Wave
115 VAC
30 Amps
Modified Sine Wave
115 VAC
30 Amps
Pure Sine Wave
115 VAC
30 Amps
Pure Sine Wave
Date of Purchase:
Advertisement
Table of Contents
Summary of Contents for On Board TruePower Plus 1200MS
- Page 1 A Complete Line of Hand Held Test Meters Model Part No. Wattage DC Input AC Input AC Transfer AC Waveform Online Technical Support and Service Support TruePower Plus 1200MS 06120 1200 W 12 VDC Input 115 VAC 30 Amps Modified Sine Wave TruePower Plus 1500MS 06150...
-
Page 2: Table Of Contents
TABLE OF CONTENTS Important Notice: Introduction... Please read this manual and all warnings including those provide by the battery manufacturer. This Safety Instructions... manual is written to assist in the safe installation of the TruePower Plus Inverter. Installation must comply to the applicable electrical codes and when installed on a boat the American Boat and Yacht General Overview... -
Page 3: Introduction
TruePower Plus Inverters are available in both Modified Sine Wave (MS) 1200, 1500 and 2000 watts Thank you from all of us at On Board Solutions and congratulations on your recent purchase of a and Pure Sine Wave (PS) models in 1000 and 2000 watt models. -
Page 4: Safety Instructions
WEAR - Complete eye protection and protective clothing. Avoid touching eyes while working near battery(s). Use of attachments not recommended or sold by On Board Solutions will void warranty and NEVER - Smoke or allow a spark or flame within the vicinity of the battery work area. -
Page 5: General Overview
GENERAL OVERVIEW GENERAL OVERVIEW TruePower Plus Overview TruePower Plus Overview The above picture outlines the front of the TruePower Plus Inverter. The above picture outlines the back of the TruePower Plus Inverter. Please Reference Table below for features: The table below references the above numbered features of the back panel 1. - Page 6 GENERAL OVERVIEW GENERAL OVERVIEW TruePower Plus Inverter Modes TruePower Plus Display Overview The TruePower Plus Inverter has 3 distinct modes which allow you to tailor the inverter behavior to your specific needs: DC to AC Output Input Power DC Input Level Pass-through Mode (LCD display is off): Pass-through mode is indicated by only being lit on the display panel.
- Page 7 GENERAL OVERVIEW GENERAL OVERVIEW System Status Fault Modes USB Charge Port All faults conditions are accompanied by a 2 second on / off tone. The USB port on the front panel provides power (5 VDC, 2.1 ADC ) to USB connected devices. The port can provide power when the inverter is running from DC power or AC shore power.
-
Page 8: Preparing For Installation
WARNING: Electrical shock and fire hazards - Mounting hardware On Board Solutions recommends all wiring be done by qualified personnel. Disconnect all AC and DC Inverter Unit Location power sources to prevent accidental shock. Disable and secure all AC and DC disconnect devices and automatic generator starting devices. - Page 9 INSTALLATION INSTALLATION AC Wiring Options Installation Diagrams WARNING - AC Installations have the potential to cause serious injury or death. Installations should be performed by an ABYC Certified Electrical Technician to ensure a safe and trouble free installation. Depending on the appliances and loads that are intended to be powered by the TruePower Plus Inverter, there are essentially 2 installation options: 1) TRANSFER TO ALL LOADS –...
-
Page 10: Installation
(Example: DC += 2 AWG, Earth = 4 AWG) Case Ground/Earth 12 Volt DC Battery Source- On Board Solutions minimum recommended battery or battery bank Dedicated is 200 Ahr. Batteries can be a single battery or multiple batteries in parallel. Batteries connected... -
Page 11: Operation
If the motor startup current is acceptable under ABYC E-11 AC & DC Electrical Systems on Board Boats (types such as too high, the inverter will turn itself off. -
Page 12: Maintenance
MAINTENANCE TROUBLESHOOTING Maintenance Troubleshooting Battery Maintenance WARNING ELECTRICAL SHOCK HAZARD Periodically, check the batteries to make sure they are good condition. Check the terminals for Do not disassemble the TruePower inverter. It does not contain any serviceable parts and corrosion and clean them with a wire brush if necessary. If the batteries are flooded lead-acid, attempting to service the unit could result in an electrical shock or burn. -
Page 13: Specifications
7 lbs 11 lbs 11lbs normal use for two full years from the date of purchase. On Board Solutions at its discretion will repair DC Input or replace free of charge any defects in material or workmanship. Operational Voltage Range 11.0 - 15.0 VDC...
Need help?
Do you have a question about the TruePower Plus 1200MS and is the answer not in the manual?
Questions and answers