Table of Contents
Advertisement
OWNER MANUAL / SAFETY MANUAL
FULL SIZE / CREW CAB UTILITY VEHICLES
GAS POWERED AND ELECTRIC POWERED MODELS
THE LATEST VERSIONS OF THE ILLUSTRATED PARTS
LISTS ARE ONLINE AT AMERICANLANDMASTER.COM
This manual applies to the following Full Size / Crew Cab Utility Vehicle brands:
16599 rev. B pub. 11/07/2017
Advertisement
Table of Contents
Troubleshooting
Subscribe to Our Youtube Channel
Related Manuals for American Landmaster LandStar LS670
Summary of Contents for American Landmaster LandStar LS670
- Page 1 OWNER MANUAL / SAFETY MANUAL FULL SIZE / CREW CAB UTILITY VEHICLES GAS POWERED AND ELECTRIC POWERED MODELS THE LATEST VERSIONS OF THE ILLUSTRATED PARTS LISTS ARE ONLINE AT AMERICANLANDMASTER.COM This manual applies to the following Full Size / Crew Cab Utility Vehicle brands: 16599 rev.
-
Page 2: Table Of Contents
Table of Contents Section 1 Introduction / Features . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . pages 2-3 Your vehicle’s model, VIN and serial number . -
Page 3: Introduction / Features
We hope you will have a fun, safe experience with for a variety of cargo carrying functions. A standard 2” receiver hitch makes our products and thank you again for choosing an American LandMaster Utility towing convenient and easy. -
Page 4: Section 1 Introduction / Features
NOTE: Fully equipped Dash shown. Actual features may vary based on model. American LandMaster wants you to be satisfied with your new vehicle. If you do not understand any part of this manual or you’re not satisfied with the service... -
Page 5: Safety
section 2 safety section 2 safety IMPORTANT SAFETY INFORMATION The following section has been prepared to instruct you in the safe and responsible operation of your utility vehicle. Read and abide by all safety alert information about this vehicle. If you do not understand any part of this section, contact your local dealer for additional information and clarification. As the operator of this piece of equipment, you are in complete control. -
Page 6: Safety Labels And Locations
section 2 safety SAFETY LABEL LOCATIONS IT IS VERY IMPORTANT TO READ, UNDERSTAND, AND FOLLOW ALL INSTRUCTIONS AND WARNINGS LOCATED ON THE DECALS ON YOUR UTILITY VEHICLE. 11 12 7 8 9 14 SEE FOLLOWING PAGES FOR SAFETY LABEL DETAIL 16599 rev. - Page 7 section 2 safety IT IS VERY IMPORTANT TO READ, UNDERSTAND, AND FOLLOW ALL INSTRUCTIONS AND WARNINGS LOCATED ON THE DECALS ON YOUR UTILITY VEHICLE. Label illustrations may not be actual size WARNING CAUTION PRECAUCION OBSERVE THE FOLLOWING INSTRUCTIONS SHUT OFF FUEL VALVE Failure to understand and follow Warnings and Instructions for the safe use Always shut off fuel valve before transporting this vehicle.
- Page 8 section 2 safety WARNING ADVERTENCIA ALWAYS WEAR SEATBELT SIEMPRE USE CINTURON DE SEGURIDAD Seatbelt must be properly fastened and adjusted for each El cinturón de seguridad debe ser apropiadamente atado y occupant prior to operating the vehicle; See Operator's ajustado para cada ocupante antes de la operación del Safety Manual.
-
Page 9: Warnings: Operation
section 2 safety SAFE OPERATING PROCEDURES WARNING OPERATION Your Utility Vehicle has been designed with many built-in safety features. However, no one should operate this vehicle before carefully reading this Operator’s Manual. Also read all instructions noted on the safety decals. •... - Page 10 section 2 safety WARNING WARNING OPERATION OPERATION • Use extreme caution when descending hills or running on loose a . Hot engine, muffler, or drive components can burn on contact . UNDER UNDER slippery surfaces . Towing, braking, and traction are greatly diminished . •...
-
Page 11: Warnings: Maintenance
section 2 safety WARNING WARNING MAINTENANCE MAINTENANCE • NEVER place hands, feet, or any body parts or clothing near the engine, • Never modify any parts on the vehicle without authorization . wheels, chain, and other rotating parts of the vehicle while riding or Unauthorized modifications will void warranty to all parts directly and running the engine . -
Page 12: Warnings: Fuel, Tires, Vehicle Care, Batteries
section 2 safety WARNING WARNING FUEL BATTERIES • Battery fumes are explosive . A spark will ignite battery fumes . Wear a • Vehicle must be stored where gasoline fumes will not reach an open face shield when charging or jumping a battery . Follow all battery safety flame, spark, or other source of ignition . -
Page 13: Warnings: 48 Volt
section 2 safety 48 VOLT UTILITY VEHICLE SPECIFIC WARNINGS & CAUTIONS - BEFORE INITIAL USE WARNING CAUTION 48 VOLT MODELS 48 VOLT MODELS BATTERY PROLONGED STORAGE • Do NOT let metal objects fall from the seat onto the top of your UNDER UNDER batteries . -
Page 14: Responsible Operation And Rider Safety
section 2 safety ARE YOU READY TO RIDE? SOME WORDS ABOUT RESPONSIBLE OPERATION AND RIDER SAFETY The following pages present important information and recommendations to help you operate your vehicle responsibly and safely . Forming good habits and developing driving skills is an ongoing process . - Page 15 section 2 safety CONSUMER RESPONSIBILITY FOR SAFE USE AND MAINTENANCE OF A UTV (cont .) Persons with the following conditions shall not ride in or operate a UTV: a . Those with heart conditions b . Pregnant women c . Persons with head, back, or neck ailments, or prior surgeries to those areas of the body . d .
-
Page 16: Operation
section 3 operation section 3 operation See back cover for a pre-ride checklist WARNING - BEFORE YOU DRIVE Always perform a pre-ride inspection of the vehicle using the checklist provided on the back cover of this manual. Check tire pressure before each use. a . -
Page 17: Section 3 Operation
section 3 operation WARNING - WHILE OPERATING THIS VEHICLE OPERATION NEVER place hands, feet, hair or any body parts or clothing near the engine, wheels, and other rotating parts of the UNDER vehicle while riding or running the engine. a . Use caution in performing required maintenance on or near operating engine . b . -
Page 18: General Operation: Gas Models
4 times . If after 4 times, Braking is accomplished by simply releasing the throttle pedal and depressing the the engine does not start, contact American LandMaster brake pedal that is located on the floorboard left of the accelerator . A lever action Customer Service . -
Page 19: General Operation: Electric Models
section 3 operation General Operation - All Gas Models (continued) 4WD Operation CAUTION Four wheel drive models are equipped with an electronically activated “On Demand” 4WD system . To engage the 4WD system, simply flip the dash mounted switch to 4WD . Engagement of the system should always be done with the vehicle Engine should be at idle before selecting 4WD mode. -
Page 20: Driving Recommendations
section 3 operation DRIVING RECOMMENDATIONS OPERATION DRIVING WITH A PASSENGER(S) DRIVING ACROSS A HILLSIDE UNDER • Passengers must be tall enough to comfortably and safely sit in a • Avoid driving across hillside slopes whenever possible . Slow down passenger seat with the seat belt secured, and with the ability to grasp and exercise extreme caution . -
Page 21: Driving Recommendations
. • Avoid crossing over large obstacles whenever possible . If • Your American Landmaster UTV is capable of operating in water to unavoidable, use extreme caution and slow down . Damage to your a maximum depth equal to the ground clearance of the floorboards vehicle may occur if the obstacle is larger than the ground clearance of of your vehicle . -
Page 22: Maintenance
. Take this manual and all supplements to the dealer when ordering parts in person . If replacement parts are not available from a dealer, they may be ordered directly from American LandMaster by contacting Customer Service at 1-800-643-7332 or online at www .americanlandmaster .com . -
Page 23: Maintenance: Engine
Your vehicle has been supplied with an engine manufacturers manual . Follow all guidelines and recommended mainentance procedures . If for some reason you did not receive an engine manufacturers manual, please contact American Landmaster at 800-643-7332 . Manuals are also available for free download at americanlandmaster .com . -
Page 24: Engine Oil Change
section 4 maintenance ENGINE MAINTENANCE CONT . Engine Oil Change NOTICE - HIGH ALTITUDE USE Warm oil drains quickly and completely . Therefore, drain used engine oil while engine is still warm as follows: CARBURETED MODELS ONLY 1 . Park vehicle on a level surface, set park brake, turn off ignition switch, and remove key . -
Page 25: Maintenance: Drivetrain
section 4 maintenance DRIVETRAIN MAINTENANCE CONT . TRANSAXLE OIL NOTE ALL MODELS LOW TRANSAXLE OIL: Running vehicle low on transaxle oil can damage transaxle and void warranty . Transaxle Oil Type, Fill, and Drain (Refer to figures 4 .6 and 4 .7) SAE 30W oil is used in the transaxle. -
Page 26: Important Notice
4 . Remove the oil fill plug using a 5/16” hex key wrench . Identifies a step where there exists a risk of part deterioration or component 5 . Add 150 ml . (5 oz .) of Mobil fluid 424 American LandMaster part # 2-20848 malfunction . - Page 27 section 4 maintenance DRIVETRAIN MAINTENANCE CONT . Exploded view of the pulley 0600 (ALM part number 2-20662) Ref Description Fixed Flange Sliding Flange Washer Spring Seat Spring Washer Spring Cover Snap Ring Block Assembly Flat Washer Block Weight Pulley removal from the vehicle Not to unbalance the pulley, it is best to note the location of the centrifugal blocks in order to place them in the same location during reassembly .
- Page 28 section 4 maintenance DRIVETRAIN MAINTENANCE CONT . Cleaning the cap - cont . Cleaning the flanges 1 . Clean the flanges with compressed air . 2 . Clean to remove any dust or dirt that can remain on the flanges . 3 .
- Page 29 section 4 maintenance DRIVETRAIN MAINTENANCE CONT . Assembling the cap and block centrifugal Put the blocks in their respective location previously noted during disassembly in the sliding flange . Make sure that the tabs are positioned upside up as shown in the figure below . tab positoning on sliding flange reassembled pulley Reassembly of the pulley on the vehicle...
-
Page 30: Maintenance: Chassis, Steering & Suspension
section 4 maintenance CHASSIS, STEERING, SUSPENSION MAINTENANCE Pedals CABLES The pedals on your vehicle require inspection before each use . Pedals should depress and return freely . Pedals may need lubricated with a lithium grease at the Several cables are used on your vehicle and should be inspected and maintained locations shown in figure 4 .13 . -
Page 31: Maintenance: Brakes & Tires
section 4 maintenance WHEEL ALIGNMENT SHOCK ADJUSTMENT Front Wheel Alignment (Refer to figure 4 .15) Adjustment of Front and Rear Shocks (Ref figure 4 .16) The front wheels should be set with a “toe-in” from 1/4” to 3/8” . At the centerline There are five adjustable positions on each shock . -
Page 32: Maintenance: Vehicle Care
section 4 maintenance BRAKES, TIRES MAINTENANCE CONT . Hydraulic Brakes - 4WD (refer to figure 4 .18) Hydraulic Brakes use fluid pressure to transfer the braking force to the wheels . Before driving the vehicle each day, check the fluid level in the reservoir . The reservoir is located under the hood behind the front differential gear box . -
Page 33: Maintenance: Transportation & Storage
Engine Fuel Valves (Ref to figures 4 .20, 4 .21 & 4 .22) American Landmaster recommends closing the fuel valve whenever the unit is trailered to avoid fuel flooding . On single cylinder models the engine has a fuel valve that opens and closes the passage between the fuel tank and carburetor . -
Page 34: Maintenance: Battery & Electrical
section 4 maintenance BATTERY & ELECTRICAL Battery Charging - Gas Models DRIVER SIDE OF Use a trickle charger to maintain battery voltage as needed . BENCH SEAT Battery Charging - 48V Models (Refer to Figure 4 .23) • A charging port is located on the seat surround below the driver side of the bench seat . - Page 35 section 4 maintenance BATTERY & ELECTRICAL CONT . figure 4 .24 (battery charger) figure 4 .25 (25 amp fuse) NOTE ALL MODELS FUSES: • In addition to the main fuse, there are three smaller fuses to protect the 12 volt and 48 volt circuits . These fuses are shown in figures 4 .25 &...
-
Page 36: Troubleshooting
section 5 troubleshooting section 5 troubleshooting SYMPTOMS PROBABLE CAUSES SUGGESTED REMEDIES Key switch left on Turn key off, recharge battery DEAD BATTERY Bad battery Replace battery Shorted starter solenoid Replace starter solenoid Loose or corroded battery connection Clean and tighten connections Defective voltage regulator Contact local service center Turn key on and pull rope to start engine (if equipped). -
Page 37: Section 5 Troubleshooting
2 . Turn and hold the key to start . – cycle the shift lever in and out of gear several times . If the starter engages, release the key and call American LandMaster Customer service to order a neutral switch shim kit . -
Page 38: Wiring Diagrams
section 6 wiring diagrams 16599 rev. B pub. 11/07/2017... -
Page 39: Kohler 429Cc
section 6 wiring diagrams 16599 rev. B pub. 11/07/2017... -
Page 40: Vanguard 479Cc
section 6 wiring diagrams 16599 rev. B pub. 11/07/2017... -
Page 41: Kohler 674Cc
section 6 wiring diagrams 16599 rev. B pub. 11/07/2017... -
Page 42: Volt
section 6 wiring diagrams yellow from A/H post terminal block 16599 rev. B pub. 11/07/2017... - Page 43 section 6 wiring diagrams 16599 rev. B pub. 11/07/2017...
-
Page 44: Specifications
section 7 specifications 16599 rev. B pub. 11/07/2017... -
Page 45: Section 7 Specifications
section 7 specifications 16599 rev. B pub. 11/07/2017... -
Page 46: Warranty
Utility Vehicle / Light Utility Vehicle Limited Warranty: American LandMaster (hereinafter referred to as “ALM”), hereby warrants to the original purchaser, that your new ALM UTV/LUTV will be free from defects in material and workmanship for a period of one (1) year from date of purchase, except as provided below. -
Page 47: Service And Warranty Contact Information
Should your American LandMaster product require warranty repair, service or if you have any questions concerning assembly, replacement parts or how to care for your product please contact your local American LandMaster dealer or American LandMaster directly . American LandMaster Dealers: To locate the authorized dealer nearest you please call American LandMaster customer service at 1-800-643-7332, visit our website at www .americanlandmaster .com or contact your place of purchase . -
Page 48: Utv Setup And Pre-Delivery Checklist
WARRANTY EXPLAINED FULLY I have visually inspected unit and found no defects * American LandMaster Low Speed Vehicle (LSV) models are street legal where allowed when properly licensed and plated. No ALM RECEIVED OWNERS MANUAL I understand this vehicle product is not designed for racing vehicles are designed for, nor allowed on highways. -
Page 49: Pre Drive Inspection Checklist
PRE DRIVE INSPECTION CHECKLIST ITEM INSPECTION PROCEDURE ACTION Engine Oil Level Add oil if required. Refer to operator's or engine manual. Check for leaks. Tighten filler cap securely. Fuel Level Add fuel if necessary. Refer to operator's or engine manual. DO NOT overfill.
Need help?
Do you have a question about the LandStar LS670 and is the answer not in the manual?
Questions and answers
Can you tell me the rim bolt pattern on a Ls550eps landstar by american landmaster. I would like to put other rims on it but don't know what will fit. Thant you!