Related Manuals for Bakers Pride Y600
Summary of Contents for Bakers Pride Y600
- Page 1 OPERATION MANUAL SUPERDECK SERIES GAS DECK OVENS SERIES: Y600 & Y800 B U I LT BY C R A F T S M E N . T E S T E D BY T I M E ®...
- Page 2 Read the installation, operating and maintenance instructions thoroughly before installing or servicing this Bakers Pride Oven Company, LLC is a wholly owned equipment. subsidiary of Standex International Corporation. All gas operated Bakers Pride deck ovens are intended ®...
-
Page 3: Table Of Contents
FLOOR MODEL GAS DECK OVEN OPERATION MANUAL TABLE OF CONTENTS INSTALLATION INSTRUCTIONS OPERATING INSTRUCTIONS RECEIVING LIGHTING PROCEDURE CLEARANCES BREAKING IN ASSEMBLING THE STAND BAKING INSTALLATION WITH CASTERS RECOMMENDED OPERATING PROCEDURE PIZZA DECKS HELPFUL HINTS (A) THREE DECK INSTALLATION CLEANING AND MAINTENANCE OVEN EXTERIOR (B) FIVE DECK INSTALLATION CONTROL PANEL... -
Page 4: Installation Instructions
FLOOR MODEL GAS DECK OVEN OPERATION MANUAL INSTALLATION INSTRUCTIONS Receiving: Clearances: Read the notice on the outside carton regarding damage Combustible Non-Combustible in transit. Damage discovered after opening crate(s)/ Construction Construction carton(s) is ‘CONCEALED DAMAGE’ and the carrier Minimum Clearance from: Left 3”... -
Page 5: Assembling The Stand
FLOOR MODEL GAS DECK OVEN OPERATION MANUAL INSTALLATION INSTRUCTIONS Assembling The Stand: Legs are shipped in a separate carton complete with mounting bolts. a) Bolt four legs to the four of the stand using the supplied 3/8-16 x 3/4 bolts, flat washers, and lock washers. -
Page 6: Installation With Casters
FLOOR MODEL GAS DECK OVEN OPERATION MANUAL INSTALLATION INSTRUCTIONS Installation With Casters (Optional): A. Three Deck Installation: Four Casters (two with wheel brakes) and the mounting (a) Slide one deck into the baking chamber and hardware is packed and included in the shipment if push it as far as possible to one side. -
Page 7: Gas And Electric Connections
FLOOR MODEL GAS DECK OVEN OPERATION MANUAL INSTALLATION INSTRUCTIONS (e) To minimize warpage and extend the life of NOTICE the Fibrament Stones, they must be pre-dried before use. If the side wedges are pushed in too tight, the (1) KEEP THE OVEN DOOR CLOSED DURING heat controls, operated by the black knobs, THE ENTIRE PRE-DRYING PROCESS. -
Page 8: Flue Connection-Ventilation
FLOOR MODEL GAS DECK OVEN OPERATION MANUAL INSTALLATION INSTRUCTIONS (h) The gas pressure regulator is part of the NOTICE combination valve and is adjusted to yield a pressure of 3.5”water column (9mbar) for Natural Do not put a damper in the flue and do not Gas. -
Page 9: (A) Pilot Burner Lighting Procedure
FLOOR MODEL GAS DECK OVEN OPERATION MANUAL INSTALLATION INSTRUCTIONS Pilot Burner Lighting Procedure: Burner Operation: (a) Turn the red handle on gas shut off valve to ‘OFF’ (A) Main Burner: (horizontal) position. After the pilot burner is ignited, when heat is (b) Wait for five minutes to allow gas, which may desired, turn gas cock dial to ‘ON’() position and have accumulated in the burner compartment, to... -
Page 10: Operating Instructions
FLOOR MODEL GAS DECK OVEN OPERATION MANUAL OPERATING INSTRUCTIONS Baking: NOTICE Pizza can be baked on the deck, on a screen or in a pan. When you determine the combination of Only Pizza and Bread Products can have direct ingredients and temperature that gives the right bake for contact with Fibrament Decks. -
Page 11: Helpful Hints
FLOOR MODEL GAS DECK OVEN OPERATION MANUAL OPERATING INSTRUCTIONS Helpful Hints: (c) Frequently scrape and brush off decks to remove burnt residue which can cause an ‘off’ flavor and (a) An instructions plate is attached behind the bake times to increase. damper knobs indicating how to set the oven for more top or bottom heat. -
Page 12: Flue Vent
FLOOR MODEL GAS DECK OVEN OPERATION MANUAL CLEANING AND MAINTENANCE Flue Vent: (C) Burner Compartment: Ventilation system must be inspected every six months Vacuum out any carbon, crumbs or residue in the and maintained clean and free of obstructions. burner compartment and all around the doors. The holes and louvers on the outer surfaces of the oven Oven Interior: must be kept free of obstructions to allow free... -
Page 13: Troubleshooting Chart
Thermopile may not be positioned in pilot flame. Ensure that the tip of thermopile is in pilot flame. Thermopile may be defective Call local authorized Bakers Pride Service Agent. Oven too Hot Thermostat set too high. Lower the thermostat setting and see if flame reduces in size. -
Page 14: Exploded Views & Parts Lists
FLOOR MODEL GAS DECK OVEN OPERATION MANUAL EXPLODED VIEWS & PARTS LISTS Exploded View – Y600/Y800... - Page 15 FLOOR MODEL GAS DECK OVEN OPERATION MANUAL EXPLODED VIEWS & PARTS LISTS Exploded View – Y600/Y800 Controls/Burners...
- Page 16 FLOOR MODEL GAS DECK OVEN OPERATION MANUAL EXPLODED VIEWS & PARTS LISTS Parts List – Y600 ITEM PART # DESCRIPTION ITEM PART # DESCRIPTION 21910330 ASSY, BOTTOM DOOR Y600/800 N5232A NIPPLE, 3/4” X 6-3/4” BLK PIPE, 3/4 OFFSET 21910331 ASSY, TOP DOOR Y600/800 N3002A TEE, 3/4”...
- Page 17 Parts List – Y800 ITEM PART # DESCRIPTION ITEM PART # DESCRIPTION 21910330 ASSY, BOTTOM DOOR Y600/800 N5232A NIPPLE, 3/4” X 6-3/4” BLK PIPE, 3/4 OFFSET 21910331 ASSY, TOP DOOR Y600/800 N3002A TEE, 3/4” X 3/4” X 1”, BLK PIPE REDUCING A8057K...
-
Page 18: Wiring Diagram
FLOOR MODEL GAS DECK OVEN OPERATION MANUAL WIRING DIAGRAM Wiring Diagram – Gas Oven Series – 120V, 208, OR 230V, 1PH –Auto Starter Option... -
Page 19: Warranty
Bakers Pride Factory Authorized Service Center. This Warranty is in lieu of all other warranties, expressed or implied, and all other obligations or liabilities on the manufacturer’s part. Bakers Pride shall in no event be liable for any special, indirect or consequential damages, or in any event for damages in excess of the purchase price of the unit. - Page 20 IMPORTANT FOR FUTURE REFERENCE Please complete this information and retain this manual for the life of the equipment. For Warranty Service and/or Parts, this information is required. Model Number Serial Number Date Purchased NOTES...
- Page 21 NOTES...
- Page 22 Food Service Equipment Group The Standex Food Service Equipment Group (FSEG) is a manufacturer of innovative commercial food service equipment offering a wealth of refrigeration and cooking expertise. Products include walk-in coolers and freezers; hot and cold display cabinets, cases, and storage systems; commercial ovens, rotisseries, and cooking equipment;...