Advertisement
SET-UP
Step 1: Cart Assembly
• Remove bolts, washers and locking washers
from the two "X" connectors.
• Remove paper washers and begin assembling
the "X" connectors and legs.
• Please Note: Top & Bottom "X" Connectors must
be assembled at the same time in order to fit
together.
• Assemble cart by inserting the two "X"
connectors into leg ends and install bolts and
washers in the same order they were removed
from "X" connectors.
• While assembling, only finger-tighten bolts, to allow adjustment in cart.
Otherwise it can be difficult to get all of the bolts inserted.
• Screw in Standard Rubber Wheels to rear Cart Legs and the Locking Rubber
Wheels to the front Cart Legs (fig. 1b).
• Tighten nuts using wrench provided.
• After cart is assembled, confirm all bolts are tightened.
Step 2: Shelf Brackets
• Remove the nuts and washers from
the bolts welded on the bottom
banding and remove the paper
washers.
• Mount shelf brackets over studs on
the sides of the metal bands on the
bottom ceramic grill body with bracket
slots facing up. Brackets are stamped
on the back with letters indicating their
position (e.g., LF=Left Front bracket
and RB=Right Back bracket).
• Mount flat washer and nut on each stud and tighten
with wrench provided.
Step 3: Grill Assembly
• Take all parts out of grill before lifting. The grill is
heavy and will require two people to lift and guide the
Kamado into cart.
• Be sure bottom vent is centered and the grill is resting
against the two back legs.
• (Step 3a:) Lower fire bowl into the grill, then place the
cast iron grate into the fire bowl.
Long-Term Maintenance
1. The Wood Side Shelves should be covered when not in use and may require refinishing from time to time.
2. Routinely check the Spring Assist Band to make sure the 25/8" bolts are tight and secure.
3. When moving your grill please remember to make sure locking casters are in the unlocked position and always pull your grill. Never Push it. Pull
from the Back Hinge. Not the Handle. Your grill is more likely to tip if you push it and it hits a bump or indention on the ground. Have a friend help.
4. Do not remove your Fire Bowl. Clean with an Ash Rake only when coals are cooled. The purpose of the Fire Bowl is to hold your lump charcoal and
will continue to work even if it is cracked.
WARNING
ATTENTION! Use caution when cooking, as grill surfaces get hot. To avoid burns, always use protective
gloves to adjust top and bottom vents when grill is in use. Do not wear loose clothing near the grill.
ATTENTION! This barbecue will become very hot, do not move it during operation. For outdoor cooking
use only. Do not operate grill indoors or in an enclosed space. Use grill only in well-ventilated areas. Keep
immediate area around the grill free from combustible materials. Allow for at least 3 feet/1 meter of
clearance around grill (house, other outdoor products, hanging tree limbs, shrubs, etc.)
WARNING! Keep children and pets away from the grill at all times.
Do not allow children to operate grill. Never leave grill unattended when in use.
Grill should be placed securely on a level base prior to use. Only operate grill on a hard, stable, level surface
(concrete patio, ground, etc.) capable of supporting the weight of the grill when loaded with food. Never
operate grill on wood support surface, wood deck or like combustible support surfaces. Never attempt
to move grill when in operation or cooling down. Never operate this grill within 25 feet/7.5 meters of
any flammable liquid. Never operate this grill within 10 feet/3 meters of a gas cylinder. The grill should
not be placed under combustible structures, like garages, porches, patios, or carports. Burning charcoal
produces carbon monoxide, an odorless gas, which can cause death.
The use of alcohol, prescription or non-prescription drugs may impair the operator's ability to properly
assemble or safely operate the grill.
Do not use on boats or recreational vehicles.
CAUTION: Never use lighter fluid, gasoline, or other volatiles to start your charcoal, as it is dangerous and
will leave a residual taste in your food. Use only firelighters complying to EN 1860-3. Use utmost care
when adding charcoal to grill. Dispose of cooled ash by placing it in aluminum foil, soaking with water and
discarding in a non-combustible container. Always wait for grill to completely cool before opening built-in
ash drawer.
When cooking above 500ºF/260ºC, with both top and bottom vents closed, rapidly opening the lid
creates a sudden rush of oxygen into the grill, which can cause a flare-up. When in this cooking mode, we
recommend that, prior to opening the lid, you open top and bottom vents to allow oxygen to stabilize inside
the grill, minimizing the possibility of a flare-up.
STEP 1
STEP 1
STEP 1
STEP 3b
• Remove the nuts and washers from the
bolts welded on the top banding opposite
the hinge.
• Remove paper washers and attach
handle bracket over studs. On each stud
place a flat washer and an acorn nut,
then tighten.
• Mount side shelves by inserting the shelf
rod into the shelf bracket. Tilting the shelf
up slightly and sliding in or out allows you
to remove or store the shelves.
STEP 2
Step 5: Ash Drawer Usage
• When grill is cool it is safe to remove ash from Ash Drawer
• (Step 5a:) Using both bottom knobs on Ash Drawer, lift slightly and (Step 5b:) pull
drawer out.
• Once ashes are emptied, reinstall by pushing Ash Drawer back into grill body until
it drops down back into place.
WARNING: ALWAYS WAIT FOR ASHES TO COOL BEFORE REMOVING ASH
DRAWER. NEVER PULL OUT ASH DRAWER WHILE GRILL IS HOT.
STEP 3a
STEP 5a
Step 3: Grill Assembly (cont.)
• Place cooking grates onto grill with hinged
section facing towards front of grill.
• (Step 3b:) Close lid and press top vent onto grill
with calibrations facing the front.
Step 4: Handle and Side Shelf
Mounting
STEP 4
STEP 5b
FUELS USED IN LIQUEFIED PROPANE GAS
WARNING:
APPLIANCES, AND THE PRODUCTS OF COMBUSTION OF SUCH
FUELS, CAN EXPOSE YOU TO CHEMICALS INCLUDING BENZENE,
WHICH IS KNOWN TO THE STATE OF CALIFORNIA TO CAUSE
CANCER AND CAUSE BIRTH DEFECTS OR OTHER REPRODUCTIVE
HARM.
For more information go to: www.P65Warnings.ca.gov.
LOS COMBUSTIBLES USADOS EN EQUIPOS
ADVERTENCIA:
PARA LICUAR GAS PROPANO, ASÍ COMO LOS PRODUCTOS DE SU
COMBUSTIÓN, PUEDEN EXPONERTE A SUSTANCIAS QUÍMICAS,
ENTRE ELLAS EL BENCENO, QUE EL ESTADO DE CALIFORNIA
RECONOCE COMO CAUSA DE CÁNCER Y DE MALFORMACIONES
CONGÉNITAS Y OTROS DAÑOS AL SISTEMA REPRODUCTOR.
Para más información, visite www.P65Warnings.ca.gov
FUELS USED IN WOOD OR CHARCOAL BURNING
WARNING:
APPLIANCES, AND THE PRODUCTS OF COMBUSTION OF SUCH FUELS,
CAN EXPOSE YOU TO CHEMICALS INCLUDING CARBON BLACK, WHICH
IS KNOWN TO THE STATE OF CALIFORNIA TO CAUSE CANCER, AND
CARBON MONOXIDE, WHICH IS KNOWN TO THE STATE OF
CALIFORNIA TO CAUSE BIRTH DEFECTS OR OTHER REPRODUCTIVE
HARM.
For more information go to: www.P65Warnings.ca.gov.
ADVERTENCIA:
LOS COMBUSTIBLES USADOS EN EQUIPOS PARA
QUEMAR MADERA O CARBÓN, ASÍ COMO LOS PRODUCTOS DE
TAL COMBUSTIÓN, PUEDEN EXPONERTE A SUSTANCIAS
QUÍMICAS, ENTRE ELLAS EL NEGRO DE HUMO Y EL MONÓXIDO
DE CARBONO, QUE EL ESTADO DE CALIFORNIA RECONOCE COMO
CAUSA, RESPECTIVAMENTE, DE CÁNCER Y DE MALFORMACIONES
CONGÉNITAS Y OTROS DAÑOS AL SISTEMA REPRODUCTOR.
Para más información, visite www.P65Warnings.ca.gov
www.visiongrills.com
help@visiongrills.com
1-877-917-4273
Vision Grills 1531 Fairview Avenue, Suite B, St. Louis, MO 63132
Advertisement
