Table of Contents
Advertisement
OWNER'S
MANUAL
MODEL
NUMBERS:
583.756700
583.756720
583.756730
SERIAL NO.
(owner - write in No.)
CAUTION:
Read Rules for
Safe Operation
and Instructions
Carefully
SAVE THIS MANUAL FOR
FUTURE REFERENCE
Sold by Sears, Roebuck and Co., 3333 Beverly Road, Hoffman Estates, IL 60179
Heater Sizes:
40,000 60,000 and 115,000 Btu/Hr
Operation and Maintenance
Instructions with Parts List
®
G 004
ARL LOGO
Advertisement
Table of Contents
Related Manuals for Sears 583.756700
Summary of Contents for Sears 583.756700
- Page 1 Safe Operation 40,000 60,000 and 115,000 Btu/Hr and Instructions Carefully Operation and Maintenance Instructions with Parts List SAVE THIS MANUAL FOR FUTURE REFERENCE ® G 004 ARL LOGO Sold by Sears, Roebuck and Co., 3333 Beverly Road, Hoffman Estates, IL 60179...
-
Page 2: Warranty
flammable fuels. air for each 100,000 Btu/Hr of rating. Sears will repair any defect in material or This heater produces carbon monoxide, workmanship in this portable heater at no •... -
Page 3: Product Identification
OWNER’S MANUAL PRODUCT IDENTIFICATION UNPACKING Remove all packing items applied to Upper Shell heater for shipment. Thermostat Knob Hot Air Outlet Handle Remove all items from carton. Check items for shipping damage. If Fan Guard heater is damaged, promptly inform dealer where you bought heater. - Page 4 40,000, 60,000 and 115,000 Btu/Hr PORTABLE FORCED AIR HEATERS ASSEMBLY FUELS 2. Place cap nuts on axle ends. Gently tap with hammer to secure. 3. Place heater on wheel support frame. Some models are furnished with wheels and WARNING: Use only kerosene Make sure air inlet end (rear) of heater a handle.
-
Page 5: Theory Of Operation
OWNER’S MANUAL THEORY OF OPERATION OPERATION The Ignition System: The ignition con- The Fuel System: The air pump forces WARNING: Review and un- air through the air line. The air is then trol assembly provides power to the ignitor. derstand the warnings in the pushed through the nozzle. -
Page 6: Storing, Transporting, Or Shipping
40,000, 60,000 and 115,000 Btu/Hr PORTABLE FORCED AIR HEATERS STORING, PREVENTATIVE WARNING: Never service heater TRANSPORTING, MAINTENANCE while it is plugged in, operating, or hot. Severe burns and electrical OR SHIPPING SCHEDULE shock can occur. If shipping, transport companies re- Note: Item How Often... -
Page 7: Troubleshooting
OWNER’S MANUAL TROUBLESHOOTING WARNING: Never service heater while it is plugged in, operating, or hot. Severe burns and electrical shock can occur. OBSERVED FAULT POSSIBLE CAUSE REMEDY Motor does not start five seconds after heater 1. No power to heater 1. -
Page 8: Service Procedures
40,000, 60,000 and 115,000 Btu/Hr PORTABLE FORCED AIR HEATERS SERVICE AIR OUTPUT, AIR INTAKE, AND LINT FILTERS PROCEDURES Remove fan from motor shaft IMPORTANT: before removing motor from heater. The 1. Remove upper shell (see Upper Shell weight of the motor resting on the fan could Removal). -
Page 9: Fuel Filter
OWNER’S MANUAL SERVICE FUEL FILTER IGNITOR 1. Remove side cover screws using 5/16" Remove upper shell and fan guard (see PROCEDURES nut-driver. page 8). Continued 2. Remove side cover. Remove fan (see page 8). PUMP PRESSURE 3. Pull upper fuel line off fuel filter neck. Remove 4 side cover screws with a ADJUSTMENT 5/16"... - Page 10 40,000, 60,000 and 115,000 Btu/Hr PORTABLE FORCED AIR HEATERS SERVICE NOZZLE ASSEMBLY Combustion Chamber 1. Remove upper shell (see page 8). PROCEDURES 2. Remove fan (see page 8). Continued 3. Remove fuel and air line hoses from Burner nozzle assembly (see Figure 16 or 17). CAUTION: Do not bend or Strap 4.
-
Page 11: Pump Rotor
OWNER’S MANUAL SERVICE PUMP ROTOR Gap Adjusting Screw Blade (Procedure if Rotor is Binding) PROCEDURES Remove upper shell (see page 8). .003"/.004" Continued Remove filter end cover screws using FUEL AND AIR LINE Measured 5/16" nut-driver. REPLACEMENT AND With Remove filter end cover and air filters Feeler PROPER ROUTING (see Figure 21). -
Page 12: Illustrated Parts Breakdown
40,000, 60,000 and 115,000 Btu/Hr 40,000 and 60,000 Btu/Hr PORTABLE FORCED AIR HEATERS ILLUSTRATED PARTS BREAKDOWN 40,000 & 60,000 BTU/HR 12-1 12-2 12-3 12-4 12-5 12-6 12-7 12-18 12-17 12-8 12-16 12-9 12-15 12-10 12-14 12-13 12-11 Motor and Pump Assembly 12-12 104980... -
Page 13: Parts List
OWNER’S MANUAL This list contains replaceable parts used in your heater. When ordering parts, be sure to provide the correct PARTS LIST model and serial numbers (from the model plate), then the part number and description of the desired part. 40,000 &... - Page 14 40,000, 60,000 and 115,000 Btu/Hr 115,000 Btu/Hr PORTABLE FORCED AIR HEATERS ILLUSTRATED PARTS BREAKDOWN 115,000 BTU/HR 10-1 10-2 10-3 10-4 10-5 10-6 10-7 10-17 10-8 10-16 10-15 10-9 10-13 10-10 10-14 Motor and Pump Assembly 10-13 10-12 10-11 104980...
- Page 15 OWNER’S MANUAL This list contains replaceable parts used in your heater. When ordering parts, be sure to provide the correct PARTS LIST model and serial numbers (from the model plate), then the part number and description of the desired part. 115,000 BTU/HR PART PART...
- Page 16 40,000, 60,000 and 115,000 Btu/Hr 115,000 Btu/Hr PORTABLE FORCED AIR HEATERS PARTS LIST WHEELS AND HANDLE PARTS LIST 115,000 BTU/HR MODEL PART PART NUMBER DESCRIPTION QTY. HA2203 Handle M12345-33 Screw, #10-24 x 1 " M12342-3 Wheel Support Frame NTC-3C Hex Nut, #10-24 097896-01 Wheel M28526...
-
Page 17: Wiring Diagram
OWNER’S MANUAL WIRING DIAGRAM ACCESSORIES Purchase accessories from your nearest Sears Ignitor Gray (40,000 & 60,000 Btu/Hr Models) Store. Gray Yellow (115,000 Btu/Hr Models) Yellow Ignitor Thermostat Motor Main Black Black 120V (L1) AC Neutral (L2) Green Motor Green Ignition Control... -
Page 18: How To Order Repair Parts
HOW TO ORDER Now that you have purchased your portable heater, should a need ever exist for repair parts or service, simply contact any Sears service center. Be sure to REPAIR PARTS provide all pertinent facts when you call or visit. The model and serial number of your portable heater will be found on a decal located on side of the Heater.