Sealey SHY900S Instructions

General
Refer to
Warning
Instruction
Manual
1. SAFETY
11
Read the manufacturer's manual for the vehicle being started: the manufacturer may have specific cautions and instructions regarding
9
emergency starting procedures.
Ensure that the vehicle is in a well ventilated area.
9
Apply the handbrake and select neutral or 'park' before attempting to start.
9
Ensure that the ignition switch and all ancillary electrical equipment is switched off.
9
Keep clear of any pulleys, belts etc. that will move once the engine starts.
9
Take care to ensure correct connection polarity; red clamp to positive, black clamp to negative.
9
Charge the jump start only at ambient temperatures between -40°C and 65°C.
9
When not in use, switch off and store in a cool, dry place out of the reach of children.
9
DO NOT allow this jump starter to become wet.
8
DO NOT dismantle: there are no user-servicable parts inside.
8
DO NOT use in explosive atmospheres (e.g. the presence of flammable liquids, gases or dust).
8
DO NOT use if the jump starter appears damaged in any way.
8
DO NOT use this product for any purpose other than that for which it is designed.
8
DO NOT leave in direct sunlight or expose to heat.
8
DO NOT use abrasive or solvent cleaners on this product.
8
DO NOT allow children to play with this product
8
DO NOT allow the positive and negative clamps to touch.
8
Modern vehicles contain extensive electronic systems. It is a requirement to check with the vehicle manufacturer, for any specific
instructions regarding the use of this type of equipment on each vehicle.
No liability will be accepted for damage/injury, where this product is not used in accordance with all instructions.
BATTERY SAFETY
WARNINGS

There are no user serviceable components. Do not dismantle.
DO NOT expose to temperatures above 60°C (140°F).
Replace the battery pack with genuine Sealey replacement product only.
If in doubt about electrical safety, contact a qualified electrician.
2. INTRODUCTION
2
Innovative capacitor technology, incorporating a 11.1V 2200mAh lithium battery pack to energise unit when vehicle battery is not sufficient to energise
capacitors. Digital display and LED front panel gives easy indication of battery voltage, capacitor charge, lithium battery charging, reverse polarity and
function selection. Simply connect to a flat vehicle battery and the unit will draw power from it and energise itself fully in a matter of minutes. Full power
is then safely put back through the starting system, jump starting the vehicle. Features a glow mode for cold starts on diesel engines and a bypass
mode for use when vehicle battery is disconnected. If the vehicle battery is faulty or is holding less than 5 volts (average) the Sealey/Schumacher
Hybrid units can be pre-charged via an internal lithium battery pack, another vehicle's battery or 12V accessory lead. The lithium battery pack can be
recharged by a Micro USB charging cable (2A or over). Capable of operating between -40°C and 65°C. Internal lithium battery can hold charge whilst
not in use meaning no waiting for the battery to charge which means it is ready to use in a matter of minutes. Compact, lightweight and designed
for portability for easier handling and storage yet still delivers the same result as heavy, bulky, lead acid battery equivalents. Fitted with heavy duty
clamps and a rubber boot for durability, the capacitors in these units have a 10,000 cycle life. Ideal for both professional mechanics and DIY users.
3. SPECIFICATION
3
Model No: . . . . . . . . . . . . . . . . . . . . . . SHY900S. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . SHY1200S
Output: . . . . . . . . . . . . . . . . . . . . . . . . . 12V . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12V
Output Start Peak(EN): . . . . . . . . . . . . 900A(450A) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1200A(600A)
Lithium battery:. . . . . . . . . . . . . . . . . . . 11.1V 2200mAh. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11.1V 2200mAh
Maximum Starting Capacity: . . . . . . . . Petrol: 5ltr, Diesel: 2ltr (Cold Weather) . . . . Petrol: 6.5ltr, 4ltr (Cold Weather)
Cable & Clamp Length: . . . . . . . . . . . . 940mm . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 940mm
Size (W x D x H). . . . . . . . . . . . . . . . . . 255 x 155 x 240mm. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 255 x 155 x 240mm
© Jack Sealey Limited
INSTRUCTIONS FOR:
HYBRID ULTRA CAPACITOR JUMP START 12V
900A, 1200A
PART NO'S:
Wear
Wear Eye
ProtectIve
Protection
Gloves
.
3ltr (Warm Weather)
Original Language Version
SHY900S, SHY1200S
Warning:
Electricity
5ltr (Warm Weather)
SHY900S,SHY1200S Issue:2(2) - 15/12/17