Page 3
6. Improper or careless use of this sprayer can cause serious injury. Minors should never be allowed to use this sprayer. This sprayer should not be used when bystanders or animals are in the area. This sprayer should never be used while children are in the area. www.tti.com.au Call 1800 816 277...
Page 4
11.Never leave the sprayer unattended without turning off the engine and relieving the line pressure, and flushing the sprayer of any harmful chemicals. www.tti.com.au Call 1800 816 277...
Page 5
RISK ASSESSMENT OPERATORS HANDBOOK 5 PRODUCT INFORMATION RISK ASSESSMENT SHEET TTI SPOT PRO CONTROL MEASURES TASK HAZARDS RISK 1. Partially fill the tank with water, Manual handling; slips, trips Concentrate on task; follow safe start the motor & test the spray unit or falls;...
Page 6
When the hand gun is released the increased pressure in the system will be automatically adjusted by the pressure regulator valve and excess flow will be returned to the spray tank. www.tti.com.au Call 1800 816 277...
Page 7
• After every 100 hectares of spraying When calibrating a sprayer, a minimum of coverall, gloves and boots must be worn. A face shield and PVC apron may be included depending on the task and the cleanliness of the sprayer. www.tti.com.au Call 1800 816 277...
Page 8
Application rate = 600 x 5 = 62.5 L/ha 6 x 8 If the application rate is less than specified, increase the pressure and repeat calibration to achieve correct rate. Nozzle Fitted Type (Drop Size Application Rate Spray Pressure www.tti.com.au Call 1800 816 277...
Page 9
DIAGRAM - MOTOR PARTS OPERATORS HANDBOOK 9 Exploded Diagram – Motor Parts OPERATOR HANDBOOK www.tti.com.au Call 1800 816 277...
DIAGRAM - MOTOR PARTS OPERATORS HANDBOOK 10 Operation Procedure OPERATOR HANDBOOK www.tti.com.au Call 1800 816 277...
Page 11
Remove fuel from the tank once more. • Check the engine oil and change it. Check for oil leaks. • Set the throttle lever in the low speed position. • Wipe away any dirt or dust. www.tti.com.au Call 1800 816 277...
Page 12
Never blow through the nozzles with your mouth nor use wire or pins to clear any blockages. • When re-assembling ensure that the nozzle cap gasket is correctly positioned. www.tti.com.au Call 1800 816 277...
Page 13
OPERATORS HANDBOOK 13 1. WARRANTY POLICY: TTI will, at its option, repair or replace, without charge, any part covered by this warranty which is found to be defective in material and/or workmanship within one (1) year* after date of sale to the original retail purchaser unless the product is used for rental purposes, in which case this warranty is limited to ninety (90) days.
Page 14
C. Only the warranty expressed in this limited warranty shall apply and no dealer, distributor, or individual is authorized to amend, modify, or extend this warranty in any way. Accordingly, addition- al statements, whether oral or written, do not constitute warranties by TTi, and should not be relied upon.
Page 15
Alternatively if you are unable to register on-line fill in all the details below, copy and email to warranty@tti.com.au or post to the address on the back cover. I have read and understood the instructions in this booklet. Model ________________________...
Page 16
Trans Tank International Murray Valley Hwy, Nathalia VIC 3638 PO Box 137, Nathalia VIC 3638 FREECALL: 1800 816 277 FAX: 03 5866 3019 www.tti.com.au warranty@tti.com.au...