Poulan pro garden tractor repair parts manual (36 pages)
Summary of Contents for Poulan Pro 419055
Page 1
MODEL: PB19542LT LAWN TRACTOR ALWAYS WEAR EYE PROTECTION DURING OPERATION Visit our website: www.poulan-pro.com 419055 Rev 1 02.08.08 TH DO NOT THROW AWAY 03076 WARNING: Read this Man u al and follow all Warnings and Safety Instructions. Fail ure to do so can re sult in serious in ju ry.
Safe Operation Practices for Ride-On Mowers DANGER: THIS CUTTING MACHINE IS CAPABLE OF AMPUTATING HANDS AND FEET AND THROW ING OBJECTS. FAILURE TO OBSERVE THE FOLLOWING SAFETY INSTRUCTIONS COULD RESULT IN SERIOUS INJURY OR DEATH. WARNING: In order to prevent ac ci - den tal starting when setting up, trans- port ing, ad just ing or making repairs, al ways dis con nect spark plug wire...
Page 3
Safe Operation Practices for Ride-On Mowers III. CHILDREN Tragic accidents can occur if the operator is not alert to the presence of children. Children are often attracted to the ma chine and the mowing activity. Never assume that children will remain where you last saw them. •...
Your new tractor has been assembled at the factory with exception of those parts left unassembled for shipping purposes. To ensure safe and proper operation of your tractor all parts and hardware you assemble must be tightened securely. Use the correct tools as necessary to insure proper tightness. TOOLS REQUIRED FOR ASSEMBLY A socket wrench set will make assembly easier.
Page 7
INSTALL SEAT (See Figs. 2A and 2B) • Remove bolt and flat washer se cur ing seat to cardboard packing and set aside for as sem bly of seat to tractor. Remove the cardboard packing and discard. • Connect switch to seat. •...
Page 8
TO DRIVE TRACTOR OFF SKID (See Op- er a tion section for location and func tion of con trols) • Be sure all the above assembly steps have been com- plet ed. • Check engine oil level and fill fuel tank with gasoline. •...
These symbols may appear on your tractor or in literature supplied with the product. Learn and understand their mean- ing. REVERSE NEUTRAL REVERSE ENGINE ON ENGINE OFF OPERATION SYSTEM (ROS) OIL PRESSURE FUEL OVER TEMP LIGHT ATTACHMENT ATTACHMENT CLUTCH ENGAGED CLUTCH DISENGAGED LIGHTS ON FREE WHEEL...
KNOW YOUR TRACTOR READ THIS OWNER'S MANUAL AND SAFETY RULES BEFORE OPERATING YOUR TRACTOR Compare the illustrations with your tractor to familiarize yourself with the locations of various controls and ad just ments. Save this manual for future reference. THROTTLE/CHOKE THROTTLE/CHOKE CONTROL CONTROL...
The operation of any tractor can result in foreign objects thrown into the eyes, which can result in severe eye dam age. Always wear safety glass es or eye shields while operating your tractor or per form ing any adjustments or repairs. We rec om mend a wide vision safety mask over spec- tacles or stan dard safety glasses.
Page 12
TO ADJUST MOWER CUT TING HEIGHT (See Fig. 9) The po si tion of the at tach ment lift le ver (A) de ter mines the cut ting height. Fig. 9 • Put attachment lift lever in desired cutting height slot. The cutting height range is ap prox i mate ly 1"...
TO OPERATE ON HILLS WARNING: Do not drive up or down hills with slopes great er than 15° and do not drive across any slope. • Choose the slowest speed before starting up or down hills. • Avoid stopping or changing speed on hills. •...
TO START ENGINE (See Fig. 4) When starting the engine for the first time or if the engine has run out of fuel, it will take extra cranking time to move fuel from the tank to the engine. • Sit on seat in operating position, depress clutch/brake pedal and set parking brake.
TRACTOR Always observe safety rules when per form ing any main- te nance. BRAKE OPERATION If tractor requires more than five (5) feet to stop at highest speed in high est gear on a level, dry concrete or paved surface, then brake must be checked and ad just ed. (See “TO CHECK BRAKE”...
• Slide blade on to an unthreaded portion of the steel bolt or pin and hold the bolt or pin parallel with the ground. If blade is balanced, it should remain in a horizontal position. If either end of the blade moves downward, sharpen the heavy end until the blade is balanced.
CLEAN AIR SCREEN Air screen must be kept free of dirt and chaff to prevent engine dam age from overheating. Clean with a wire brush or com pressed air to re move dirt and stubborn dried gum fibers. AIR FILTER Your engine will not run properly using a dirty air filter.
SERVICE AND ADJUSTMENTS WARNING: TO AVOID SE RI OUS IN JU RY, BEFORE PERFORMING ANY SERVICE OR ADJUSTMENTS: • Depress clutch/brake pedal fully and set parking brake. • Place gearshift lever in neutral (N) position. • Place attachment clutch in “DISENGAGED” position. •...
SERVICE AND ADJUSTMENTS • ATTACH MOWER SIDE SUSPENSION ARMS (A) TO CHASSIS - Position hole in arm over pin (B) on outside of tractor chassis and secure with retainer spring. • Repeat on opposite side of tractor. FIG. 20 • ATTACH REAR LIFT LINKS (C) - Lift rear corner of mower and position slot in link assembly over pin (D) on rear mower bracket and secure with washer and...
Page 21
SERVICE AND ADJUSTMENTS TO LEVEL MOWER Make sure tires are properly inflated to the PSI shown on tires. If tires are over or under inflated, it may affect the appearance of your lawn and lead you to think the mower is not adjusted properly.
SERVICE AND ADJUSTMENTS TO REPLACE MOWER BLADE DRIVE BELT (See Fig. 29) The mower blade drive belt may be replaced without tools. Park the tractor on level surface. Engage parking brake. BELT REMOVAL - • Remove mower from tractor (See “TO REMOVE MOW ER”...
Page 23
SERVICE AND ADJUSTMENTS TRANSAXLE GEAR SHIFT LEVER NEU TRAL- ADJUSTMENT (See Fig. 31) The transaxle should be in neutral when the gear shift lever is in neutral (N) (lock gate) position. The adjustment is preset at the factory; however, if adjustment is needed, proceed as follows: •...
Page 24
SERVICE AND ADJUSTMENTS REPLACING BATTERY ( See Figs. 34 WARNING: Do not short battery ter- mi nals by allowing a wrench or any other object to contact both terminals at the same time. Before connect- ing battery, remove metal bracelets, wristwatch bands, rings, etc.
Immediately prepare your tractor for storage at the end of the season or if the tractor will not be used for 30 days or more. WARNING: Never store the trac tor with gas o line in the tank inside a building where fumes may reach an open flame or spark.
TROUBLESHOOTING POINTS PROBLEM CAUSE Will not start Out of fuel. Engine not “CHOKED” properly. Engine flooded. Bad spark plug. Dirty air filter. Dirty fuel filter. Water in fuel. Loose or damaged wiring. Carburetor out of adjustment. Engine valves out of adjustment. Hard to start Dirty air filter.
Page 27
TROUBLESHOOTING POINTS PROBLEM CAUSE Engine dies when Reverse operation system tractor is shifted (ROS) is not "ON" while into reverse mower or other attachment is engaged. Engine continues to run Faulty operator-safety presence control system. when operator leaves seat with attachment clutch engaged Poor cut - uneven Worn, bent or loose blade.
The Manufacturer warrants to the original consumer purchaser that this product as manufactured is free from defects in materi- als and work man ship. For a period of two (2) years from date of purchase by the original consumer purchaser, we will repair or replace, at our option, without charge for parts or labor incurred in replacing parts, any part which we find to be defective due to materials or workmanship.
Page 31
1975. droits donne vous garantie Cette vous. conséquent, implicite garantie d’une Certaines FABRICANT. EXPLICITES IMPLICITE GARANTIE TOUTE CONSÉQUENT concession- l’adresse ainsi machine Ontario contactez: concessionnaire à machine votre retourner standard, visserie normaux, réglages normal. usage livraison modifiés, été produits ins- conformément entretenus quatre-vingt-...
moteur. avant lent) rapide (entre intermédiaire position dans commande l’alternateur. régulateur. connexions. toutes Vérifiez/remplacez batterie. fusible. connexions. câblage phares. l’interrupteur Vérifiez/remplacez lampe(s). l'ampoule(s) (ON). marche position à l’interrupteur trous ouvrir pour mandrin faces manuel. recomman- lames avec lames tranchant bord avec lames d’entraînement...
Page 35
endommagées. pièces Remplacez lâches. pièces lame. mandrin lame. boulon fond à Serrez lame. autorisé. d’entretien centre Réglages. Entretien dans Carburateur” Régler “Pour section câblage. tout silencieux. Nettoyez/remplacez moteur/ailettes. d’air tamis d’allumage. bougie serrez d’essence. filtre fraîche, l’essence avec réservoir carburateur, réservoir l’essence fraîche.
Page 36
SONT D’ÉCHAPPEMENT ENDROITS QUAND TRACTEUR JAMAIS COUVREZ tracteur. condensation formation permet obstrue plastique plastique. N’uti perméable. couverture avec saleté. poussière couvrez-le possible, l’intérieur, à tracteur causera l’essence dans saleté et/ou rouiller. à commence s’il d’essence l’autre. à saison d’une d’essence SUPPLÉMENTAIRE d’allumage.
Page 37
réglage. et/ou réaration autorisé d'entretien centre gazon à tondeuse teur, avec problèms cause tion fonc moteur votre réglable. CARBURATEUR voir nécessaire, réglage nécessaire. réglage l’usine à préréglée été CÂBLE FIG. PHARES CÂBLES CONNECTEUR CAPOT ci-dessus. étapes inversez tracteur. moteur vers inclinez-le latéraux, capot...
Page 38
FIG. CHARGÉE MENT TIÈ BATTERIE batteries. deux ROUGE câble complètement. chargée batterie châssis NOIR câble premièrement RENVERSEZ CÂBLES, d’es réservoir loin câbles Maintenez châssis NOIR câble extrémité chargée. complètement batterie NÉGA- borne à NOIR câble extrémité châssis). contre court-circuiter attention bien faisant batterie...
Page 39
FIG. Manual 02954 manuel). section présente TON- INSTALLER POUR « (voir tondeuse dispositifs guides ainsi poulies, dans place bien courroie (B). d’embrayage fixe tension poulie dans courroie retenue. dispositif courroie Assurez-vous (D). d’entrée transmission ventilateur sous soigneu- Enroulez tracteur. l’arrière (E).
Page 40
réglage. l’écrou contre fermement serrez clé avec place réglage inférieure 1/2’’ à 1/8’’ lame avant jusqu’à nécessaire ajustez mesures, 1/8’’. d’environ tondeuse modifie réglage l’écrou complet tour FIG. d’abord. contre-écrou 02950 tondeuse. baisser pour d’ajustement tondeuse. l’écrou Desserrez d’ajustement FIG. 02548 tondeuse.
Page 41
"UTILISATION" section dans montré d’utiliser avant réglage roues ajustez haute. plus position à levage tondeuse. poulies place bien courroie Assurez-vous FIG. moteur poulie retenue(K). avec fixez-le guide collier dans d’embrayage câble carter (R). tondeuse braya trou tondeuse d’embrayage FIG. (J). ressort-arrêtoir d’une l’aide...
Page 42
celui-ci. soit qu’elle jusqu’à tracteur, sous tracteur. glisser avant l’avant vers pointent laté- suspension bras Assurez-vous basse. plus position enclen- lentement abaissez-le levier fermement Tenez ressort. mé- possède levier ATTENTION basse. plus position à levage stationnement. frein surface trouve tracteur 20–24) Figs.
votre tracteur votre débris gazon, enlever pour feuilles à souffleuse l’air Utiliser tracteur. votre transmission, moteur l’intérieur. à l’eau l’infiltration soient transmission moteur votre nettoyer pour pression sous lavage d’arrosage tuyau d’un l’utilisation d’auto. cire avec peintes surfaces etc. l”huile l’essence, enlevant roues...
Page 44
l’usure. elles courroies Remplacez réglables. né Remplacez-les d’utilisation. l’usu détérioration pour trapézoïdales TRAPÉZOÏDALES correct. ment froi balle saleté libre conservée TRANSMISSION REFROIDISSEMENT manuel). REGLAGES ENTRETIEN dans BATTERIE” “REPLACER (Voir pétrolatum. graisse avec brillent. qu’ils jusqu’à métallique avec batterie câbles bouts séchez-la.
Page 45
FIG. (SPÉCIAL) CENTRE TROU ÉTOILE MANDRIN ENSEMBLE CHALEUR. SOUMIS LAME SPÉCIAL BOULON livre). (couple solidement lame boulon L'ÉTOILE AVEC LAME CENTRE ADÉQUAT, L'ASSEMBLAGE ASSURER l’assemblage tondeuse à face faisant l’embouti avec affilée lame lame montre. d’une aiguilles sens dans tournant lame épais.
Page 46
GRAPHITE. TYPE POUDRE MODÉRATION AVEC SEULEMENT ÊTRE DOIVENT QU’ILS PENSEZ VOUS LUBRIFICATION À PALIERS DURABILITÉ SALETÉS POUSSIÈRE ATTIRENT NYLON. PALIERS GRAISSE HUILE METTEZ MOTEUR SOUS ENTRETIEN SECTION USAGE 10W30 VITESSE MENT CHAN PIVOTS TEUR ANTÉRIEURE ROUE PALIER PRESSION À GRAISSEUR BROCHE PRESSION À...
Page 47
utilisé. l'ac à terrain toujours choisissez accessoires, coupe. meilleure rendement basse suffisamment vitesse ment char dé rendement meilleur plein à commande avec avant l'herbe sécher Laissez tondeuse. L'herbe mouillée. elle quand l'herbe désirée. hauteur à faire doit haute. assez coupe pour l'appareil sèche.
Page 48
causés. être raient sinon d’es carburateur moteur nettoyage jamais N’uti ments. l’en instructions saison fraîche l’es soient carburateur jusqu’à tion fonc laissez-le dé d’es réservoir jours l’entreposage tout doit d’es système moteur, éviter Pour l’en d’un d’essence système rier l’entreposage. dant d’acide tion...
Page 49
FIG. lieu. ramasse-herbe sans déflecteur tondeuse N’utilisez ATTENTION: (DISENGAGED). position à d’accessoire d’embrayage TONDEUSE LAMES (ENGA- embrayée position à d’accessoire commande déplaçant tondeuse levier l’aide à désirée tonte hauteur collines. accidenté terrain quand s'arrête hésite moteur milieu assis bien rester devez Vous braya...
Page 50
FIG. RACCOURCIRA. TRANSMISSION DURABILITÉ PAS, FAITES CHANGER AVANT TRACTEUR ARRÊTIEZ VOUS ASSUREZ-VOUS déplacement. pour frein/embrayage pédale position à vitesse changement position à vitesse changement frein/embrayage pédale avec tracteur vitesse. commandées sont déplacement RECULER POUR FIG. performance meilleure permet (rapide) moteur. l’efficacité...
moteur. commencer pour Utilisé D'ETRANGLE/BUSE inverse. sens qu'en pendant autre gazon à tondeuse pont POSI- » « (ROS) D'OPERATION frein pédale saisissent Serrures phares Allume LEGER commencer pour Utilisé D'ALLUMAGE Institute. dards Stan CHANGEMENT CHANGEMENT DE LEVIER LEVIER LE ADAPTER ADAPTER D'ALLUMAGE D'ALLUMAGE...
Page 52
propriété. l'endommagement blessures mort, conséquence pourrait évité, n'est s'il propriété. et/ou sérieuses conséquence comme avoir s'il qui, risque indique et/ou tracteur résulter pourrait situation symbole sans utilisé mineures blessures évité, n'est s'il qui, risque sérieuses. conséquence comme n'est s'il qui, risque mort conséquence...
manuel). Entretien chapitres (Cf. correctement fonctionnent arrière marche fonctionnement l’opérateur présence Système ris- sans fonctionne frein système com- toutes l’emplacement fonction vous assurez-vous moteur, plomb sans d’essence (rempli moteur. ATTENTION UTILISER À APPRENEZ VOUS ment soient fils attachées nexions toutes Assurez-vous guides-courroie.
Page 54
contre décharge déflecteur tient rouler. faisant palette point position à vitesse changement stationnement. dégager pour frein/embrayage pédale haute. plus position à levier placez piston levage com- fonction connaître pour ment tion (Voir ROULER FAISANT TRACTEUR objet. qu'il S'assurer aérée. bien zone S'assurer d’instructions.
Page 55
FIG. 03125 TION RALLONGE PATTES FENTES TEUR ADAP DIRECTION VOLANT PLATE GRANDE 5/16 FREIN RONDELLE 5/16 HEXAGONAL ÉCROU pour outils bons Utilisez fond. à serrées cor- l’utilisation assurer Pour l’expédition. CREVER centre 5/16 frein, direction. l'inte- à glissez-le soient tracteur manchon par-dessus inférieur.
Page 56
Clés Vidange Tube Guide-pente Siège Boulon Rondelle Siège direction Serrure Rondelle Manchon Adaptateur rallonge Arbre Rondelle direction volant Insert Boulon direction Volant direction Volant MONTAR PIEZAS...
Page 57
PAGE ...VERSO 28-43 SÉPARE 26-27 DÉPANNAGE 19-24 RÉGLAGES 15-18 manuel). PIÈCES tion (Voir proche plus centre disponible silencieux l’opérateur. etat maintenu être doit Quand applicables. locales lois pare-étincelles d’un muni n’est d’herbe d’arbrisseaux, d’arbres, près utilisé être doit à moteur d’un équipé...
Page 58
descente. dans lentement tournez dans nécessaire, n’est cela pentes dans virage lentement. reculez arrière lames, dégagez montée, s’arrête pente. vers lames dégagez plus, n’adhèrent dans virages arrêts démarrages, pentes. dans vitesse devoir afin faible vitesse pénètre enfant moteur éteignez transversalement. maxi), (15°...
Page 59
s’éboule. bord par-dessus l’improviste à culbuter risque fossés ravins, proximité pied mettant machine stabiliser l’utilisez machine. risquent accessoires d’autres avec machine utilisez vous lorsque machine. culbuter faire vitesse brusquement jamais changez lents mouvements n’effectuez pente. vers lames dégagez plus, n’adhèrent dans virages arrêts...
Page 60
AVERTISSEMENT: JETEZ www.poulan-pro.com l’utilisation. lors PELOUSE struc vous sures tions struc tous suivez Lisez PROPRIÉTAIRE 03076 02.08.08 web: site notre sécurité lunettes toujours TRACTEUR PB19542LT MODÈLE: MANUEL IMPORTANT 419055 Visitez Portez MANUEL...
Need help?
Do you have a question about the 419055 and is the answer not in the manual?
Questions and answers