Table Of Contents - Land Pride PATRIOT FDR1648 Operator's Manual

Rear discharge grooming mowers

Hide thumbs Also See for PATRIOT FDR1648:

Operator's manual (34 pages)

Operator's manual (41 pages)

Table Of Contents

Table of Contents

Important Safety Information . . . . . . . . . . . . . 1

Look For The Safety Alert Symbol . . . . . . . . . . . . . 1

Safety at All Times . . . . . . . . . . . . . . . . . . . . . . . . . 1

Safety Labels . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

Introduction . . . . . . . . . . . . . . . . . . . . . . . . . . . 8

Application . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8

Using This Manual . . . . . . . . . . . . . . . . . . . . . . . . . 8

Owner Assistance . . . . . . . . . . . . . . . . . . . . . . . . . . 8

Serial Number . . . . . . . . . . . . . . . . . . . . . . . . . . . 8

Further Assistance . . . . . . . . . . . . . . . . . . . . . . . . 8

Section 1: Assembly & Set-Up . . . . . . . . . . . 10

Tractor Requirements . . . . . . . . . . . . . . . . . . . . . . 10

Torque Requirements . . . . . . . . . . . . . . . . . . . . . . 10

Dealer Preparations . . . . . . . . . . . . . . . . . . . . . . . 10

Vented Dipstick Installation . . . . . . . . . . . . . . . . . . 10

Upper 3-Point Hitch Assembly . . . . . . . . . . . . . . . 10

Gauge Wheel Assembly . . . . . . . . . . . . . . . . . . . . 11

Lower 3-Point Clevis Hitch Assembly . . . . . . . . . . 11

Tractor 3-Point Hook-up . . . . . . . . . . . . . . . . . . . . 12

Top Center Link Adjustment . . . . . . . . . . . . . . . . . 12

Quick Hitch Hook-up . . . . . . . . . . . . . . . . . . . . . . . 13

Driveline Hook-up to Gearbox . . . . . . . . . . . . . . . . 13

Driveline Hook-up to Tractor . . . . . . . . . . . . . . . . . 14

Check Driveline Collapsible Length . . . . . . . . . . 14

Shorten Driveline . . . . . . . . . . . . . . . . . . . . . . . . 14

Check Maximum Allowable Length . . . . . . . . . . 15

Check Driveline Interference . . . . . . . . . . . . . . . 15

Section 2: Accessories & Set-up . . . . . . . . . 16

Front Roller Assembly . . . . . . . . . . . . . . . . . . . . . . 16

Cutting Blades . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16

Low Lift Blades . . . . . . . . . . . . . . . . . . . . . . . . . 16

Medium Lift Blades (Factory Standard) . . . . . . . 16

High Lift Blades . . . . . . . . . . . . . . . . . . . . . . . . . 16

Mulching Blades . . . . . . . . . . . . . . . . . . . . . . . . 16

Accessory Part Numbers . . . . . . . . . . . . . . . . . . . 16

Section 3: Operating Instructions . . . . . . . . 17

Operating Check . . . . . . . . . . . . . . . . . . . . . . . . . . 17

Tractor Shut Down Procedure . . . . . . . . . . . . . . . . 17

Inspection Procedures . . . . . . . . . . . . . . . . . . . . . 17

Transporting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18

Safety Information . . . . . . . . . . . . . . . . . . . . . . . . . 18

Unhooking the Mower . . . . . . . . . . . . . . . . . . . . . . 20

General Operating Instructions . . . . . . . . . . . . . . . 20

Land Pride provides this publication "as is" without warranty of any kind, either expressed or implied. While every precaution has been taken in the

preparation of this manual, Land Pride assumes no responsibility for errors or omissions. Neither is any liability assumed for damages resulting from the use

of the information contained herein. Land Pride reserves the right to revise and improve its products as it sees fit. This publication describes the state of this

product at the time of its publication, and may not reflect the product in the future.

Land Pride is a registered trademark.

All other brands and product names are trademarks or registered trademarks of their respective holders.

Printed in the United States of America.

FDR1648, FDR1660 & FDR1672 Rear Discharge Grooming Mowers 310-366M

Section 4: Adjustments . . . . . . . . . . . . . . . . . 21

Leveling the Mower . . . . . . . . . . . . . . . . . . . . . . . . 21

Cutting Height Adjustment . . . . . . . . . . . . . . . . . . . 21

3-Point Hitch Adjustments . . . . . . . . . . . . . . . . . . . 21

Belt Tension . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 21

Section 5: Maintenance & Lubrication . . . . . 22

Maintenance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 22