Table of Contents
Advertisement
Quick Links
Advertisement
Table of Contents
Related Manuals for Aspire ECD30
Summary of Contents for Aspire ECD30
- Page 1 OUTDOOR COOKING Grill Cart Use & Care Manual Installation & Operation...
- Page 2 DANGER DANGER If you smell gas: Do not store or use gasoline or other flammable liquids or vapors Shut off gas to the appliance. in the vicinity of this or any other appliance. Extinguish any open flame. An LP cylinder not connected Open lid.
-
Page 3: Table Of Contents
TABLE OF CONTENTS MODEL NUMBERS INTRODUCTION PRECAUTIONS REGULATORY / CODE REQUIREMENTS PORTABLE LP CYLINDERS CART & GRILL ASSEMBLY GAS CONNECTIONS PARTS LIST SERVICE WARRANTY ©2017 Hestan Commercial Corporation... -
Page 4: Model Numbers En
MODEL NUMBERS Double Door Model CART MODELS Model No. Description ECD30 30” DOUBLE DOOR TOWER CART ECD36 36” DOUBLE DOOR TOWER CART ECD42 42” DOUBLE DOOR TOWER CART ©2017 Hestan Commercial Corporation... -
Page 5: Introduction
INTRODUCTION Thank you for choosing the Aspire by Hestan Outdoor Grill Cart. We have written this Installation Guide to help you properly install an Aspire Grill for years of safe and enjoyable use. Keep this guide handy, as it will help answer questions that may arise as you use your new Cart. -
Page 6: Precautions
Watch for corrosion, cracks, or insect activity. See the CLEANING AND MAINTENANCE section of the Aspire Grill manual for more information. 13. Do not overload the side shelves of the cart as this may result in damage to the unit, or personal injury. -
Page 7: Regulatory / Code Requirements
REGULATORY / CODE REQUIREMENTS Installation of this cooking appliance must be made in accordance with local codes. In the absence of local codes, this unit should be installed in accordance with the National Fuel Gas Code ANSI Z2231.1/NFPA 54 , Natural Gas and Propane Installation code CSA B149.1 , or Propane Storage and Handling Code B149.2 . All Electrical Components must be electrically grounded in accordance with local codes or in the absence of local codes with the National Electrical Code ANSI/NFPA 70 , or Canadian Electrical code CSA C22.1 . -
Page 8: Cart & Grill Assembly
Locate the grill only in a well-ventilated area. Never locate the grill in a building, garage, breezeway, shed or other such enclosed areas without an approved ventilation system. Never locate the grill over, under, or next to unprotected combustible construction. Please read the Aspire Grill manual for more information on proper placement. - Page 9 CART & GRILL ASSEMBLY (continued) Open the right door and install the electrical box supplied with your grill on the 2 studs at the rear, inside wall of the cart. Pass the electrical cord through the square hole. Reinstall both nuts and tighten with 3/8”...
- Page 10 CART & GRILL ASSEMBLY (continued) Remove the drip pan from the grill. Remove the control knobs from the grill. Two persons are required to lift the grill head onto the cart, as it is very heavy. Before lifting, be sure any wires are tucked out of the way and taped to the grill firebox so they don’t dangle and get caught on anything as you lower the grill onto the cart.
- Page 11 CART & GRILL ASSEMBLY (continued) 10. Remove the screws securing the control panel on the front of the grill. Carefully tilt down the control panel being careful not to damage the wires to the switch and LED light bar. Pull off the connectors to the switch and the LED light bar at this time.
- Page 12 CART & GRILL ASSEMBLY (continued) 12. Install 1 flat washer and hex bolt at the rear inside wall of the cart as shown here using a 7/16” wrench or socket wrench. Repeat this on the opposite side of the cart. If all cart panels are properly aligned with the grill head, you may now tighten all the bolts.
- Page 13 15. Proceed with the remainder of the grill installation as documented in the Use & Care Manual that came with your Aspire grill. Follow all instructions for regulator installation, gas connections, leak testing, burner adjustment, etc. before using your grill. After all these steps are completed, you can re- install the control panel and knobs, and the rear access panel on the cart.
- Page 14 CART & GRILL ASSEMBLY (continued) 16. Your new Aspire cart comes with doors pre-installed and adjusted at the factory. However, it may be necessary to adjust them once the grill head is installed. If for some reason you wish to detach the door, pinch the back of the hinge to un-clip it from the mounting base.
- Page 15 CART & GRILL ASSEMBLY (continued) 18. The side and depth adjustment of the doors are shown below. SIDE-TO-SIDE DEPTH ADJUSTMENT ADJUSTMENT 19. To re-install the door, follow the instructions shown below. MOUNTING MOUNTING BASE BASE PUSH HINGE UNTIL REAR CLIP ENGAGES CART WALL CART WALL ATTACH AT THIS...
-
Page 16: Gas Connections
Periodically check the whole system for leaks, or immediately check if the smell of gas is detected. Please read the Aspire Grill manual for complete instructions on proper leak testing of your grill before using. -
Page 17: Parts List
WHAT THIS LIMITED WARRANTY COVERS Hestan Commercial Corporation (“HCC”) warrants to the original consumer purchaser of an Aspire by Hestan outdoor gas product (the “Product”) from an HCC authorized dealer that the Product is free from defective materials or workmanship for a period of one (1) year from the date of original retail purchase or closing date for new construction, whichever period is longer (“Limited Warranty Period”). - Page 18 LIMITED WARRANTY (continued) 3. The Product’s spit rod, briquette trays, manifolds, gas valves and sealed burner assemblies (where applicable) are warranted to be free from defects in material and workmanship, under normal non-commercial use and service, for a period of five (5) years from the original date of purchase. This is limited to replacement of the defective parts, with the Purchaser paying all other costs, including labor, shipping, and handling, as applicable.
- Page 19 LIMITED WARRANTY (continued) INTERACTION OF LAWS WITH THIS LIMITED WARRANTY: Some states, provinces or territories may not allow limitations on how long an implied warranty lasts or the exclusion or limitation of incidental or consequential damages, so the above limitations or exclusions may not apply to you.
- Page 20 RETAIN THIS MANUAL FOR FUTURE REFERENCE Hestan Commercial Corporation 3375 E. La Palma Ave Anaheim, CA 92806 (888) 905-7463 ©2017 Hestan Commercial Corporation P/N 014117 REV B...
Need help?
Do you have a question about the ECD30 and is the answer not in the manual?
Questions and answers