SERVICE MANUAL AUDIO/VIDEO CONTROL RECEIVER RX-DP20VBK EA N TR NSM T S AND Y ONE 1 ZO E 2 Z NE 1 N/ F O /O F ST NDB / N ST NDB / N ZO E 1 ZONE 2...
Page 2
SPECIFICATION Amplifier Output Power At Stereo operation Front channels 120 W per channel, min. RMS, driven into 8 Ω, 20 Hz to 20 kHz with no more (Analog Direct On) than 0.02% total harmonic distortion. 120 W per channel, min. RMS, driven into 4 Ω, 20 Hz to 20 kHz with no more than 0.07% total harmonic distortion.
Page 3
FM tuner Tuning Range 87.5 MHz to 108.0 MHz 12.8 dBf (1.2 µV/75 Ω) (IHF) Usable Sensitivity Monaural 18.2 dBf (2.2 µV/75 Ω) 50 dB Quieting Sensitivity Monaural 38.2 dBf (22.3 µV/75 Ω) Stereo Signal-to-Noise Ratio (IHF-A weighted) Monaural 78 dB at 85 dBf Stereo 73 dB at 85 dBf Total Harmonic Distortion...
SECTION 1 PRECAUTION Safety Precautions (1) This design of this product contains special hardware and voltmeter. many circuits and components specially for safety purpos- Move the resistor connection to each exposed metal es. For continued protection, no changes should be made part, particularly any exposed metal part having a return to the original design unless authorized in writing by the path to the chassis, and measure the AC voltage across...
Page 5
Importance administering point on the safety WR42 FC44 FC43 WR48 TH41 FC41 FC42 WR41 D4004 FC401 FC402 D4003 D4002 R4011 D4001 R4012 IC44 TW41 TW42 CN25 WR26 Caution: For continued protection against risk of fire, replace only with same type 8A/250V for F21, 0.5A/250V for F41 and 2A/125V for F42 and F43.
SECTION 3 DISASSEMBLY Main body section 3.1.1 Removing the top cover (See Fig.1) (1) Remove the eight screws A attaching the top cover on both Top cover sides of the body. (2) Remove the three screws B on back of the body. (3) Remove the top cover from behind in the direction of the ar- row while pulling both sides outward.
Page 8
3.1.3 Removing the V compo 2 board & RF remote unit & tuner unit & compu link board (See Fig.2 and 4) • Prior to performing the following procedure, remove the top Front panel assembly cover. (1) Disconnect the harness from the connector CN581 on the V compo 2 board.
Page 9
3.1.7 Removing the system control board (See Fig.5 and 6) • Prior to performing the following procedure, remove the top CN983 System control board cover and front panel assembly. CN977 (1) Disconnect the card wires and harness from the connector Plastic rivet CN981 CN985...
Page 10
3.1.9 Removing the audio signal 1 board (See Fig.8) • Prior to performing the following procedure, remove the top CN224 cover, rear panel and DSP board. CN234 CN208 CN207 (1) Disconnect the harness from the connector CN202, CN204, CN234, CN224, CN208, CN207, CN218 CN218 CN223...
Page 11
3.1.12 Removing the input base board CN44 Power supply (See Fig.12) (on the power CN62 1 board supply 2 board) • Prior to performing the following procedure, remove the top cover, rear panel, DSP board, audio signal 1 board, audio sig- nal 2 board, video board, S video board and V compo 1 board.
Page 12
3.1.15 Removing the power transformer 1 with the power supply 2 board (See Fig.14) • Prior to performing the following procedure, remove the top Power supply 2 board cover and power supply 1 board. (1) Disconnect the harness from the connector CN46 CN47 on the power supply 2 board.
Page 13
3.1.18 Removing the power transformer 3 with the power supply 3 board (See Fig.17) • Prior to performing the following procedure, remove the top cover, power supply 1 board, power transformer 1 and power Power supply 3 board transformer 2. (1) Disconnect the harness from the connector CN41 on the...
Page 14
3.1.21 Removing the power amp. Assembly (See Fig.20 and 21) • Prior to performing the following procedures, remove the top cover, rear panel, front panel assembly, system control board, DSP board, audio signal 1 board, audio signal 2 board, video Power board, S video board, V compo 1 board and speaker board.
Page 15
Power amp. assembly section 3.2.1 Removing the relay board & Rch amp. board & Lch amp. board & Cch amp. board & SL/SRch amp. board (See Fig.1 to 3) • Prior to performing the following procedure, remove the power top side amp.
Page 16
3.2.2 Removing the thermal SW 2 board (See Fig.4) • Prior to performing the following procedure, remove the power bottom side amp. assembly, relay board and each amp. board of Lch, Cch, Power ICs Heat sink Thermal SW 2 board SL/SRch, Rch.
Page 17
Front panel assembly section 3.3.1 Removing the FL display board & front AV in board (See Fig.1 and 2) • Prior to performing the following procedure, remove the top Front panel assembly cover and front panel assembly. Operation switch panel (1) Pull out the volume knob on the front side of the front panel assembly and remove the nut attaching the FL display board.
SECTION 4 ADJUSTMENT Adjustment of idling current Measuring point Alignment point Measuring condition B903 & B904 VR701 No load and No signal.Rated line voltage SURROUND : OFF B911 & B912 VR751 Room temperature : 20~25ºC B907 & B908 VR801 SLch B907 &...
Page 19
Idling Current graph (1/2) SL ch / SR ch SL ch SR ch Time(Min) SBL ch / SBR ch SBL ch SBR ch Time(Min) (No.22008)1-19...
Page 20
Idling Current graph (2/2) L ch / R ch L ch R ch Time(Min) C ch Time(Min) 1-20 (No.22008)
SECTION 5 TROUBLE SHOOTING This service manual does not describe TROUBLE SHOOTING. (No.22008)1-21...
Page 22
VICTOR COMPANY OF JAPAN, LIMITED AV & MULTIMEDIA COMPANY AUDIO/VIDEO SYSTEMS CATEGORY 10-1,1chome,Ohwatari-machi,Maebashi-city,371-8543,Japan (No.22008) Printed in Japan...
SCHEMATIC DIAGRAMS AUDIO/VIDEO CONTROL RECEIVER RX-DP20VBK CD-ROM No.SML200307 Area suffix J ----------------------------- U.S.A. C -------------------------- Canada T AN M T S AND Y Z NE 1 Z NE 2 TV CA V D S V R 1 N/ F F...
Page 24
RX-DP20VBK In regard with component parts appearing on the silk-screen printed side (parts side) of the PWB diagrams, the parts that are printed over with black such as the resistor ( ), diode ( ) and ICP ( ) or identified by the " "...
RX-DP20VBK Block diagrams Signal input/output & Main section IC601 DSP board IC602 WR632 CN631 WR204 CN203 Lch/SBLch PRE AMP bo IC603 Audio signal 1 board CN223 IC604 WR323 Rch/SBRch PRE AMP b Audio signal 2 board IC605 WR322 IC606 Video...
Page 27
RX-DP20VBK Speaker board Q710 Q714 FRONT Q711 Q715 RY901 SPK1 Q1710 Q1714 Q1711 Q1715 FRONT RY902 AMP board SPK2 Q764 Q760 Q765 Q761 RY906 CENTER Q1764 Q1760 Q1765 Q1761 REAR L RY904 REAR R E AMP board S. BACK L...
Page 28
RX-DP20VBK Audio signal 1 section CN207 TUNER V SIG L/R IC201 PHONO SUB VI L/R IC262 SUB ROOM VOLUME A/D. C A/D.S TAPE/MD IC212 A/D.SB SUB ROOM IC202 SWITCH TAPE/MD IC203 SOURCE SUBROOM SELECTOR IC221 IC213 Volume A/D SW IC211...
Page 29
RX-DP20VBK Audio signal 2 section TV/DBS VCR1 VIDEO L/R IC321 VCR1 IC322 A/D. L/R, V SIG L/R SOURCE A/D. C/SW, SUB.VI L/R SELECTOR A/D.S L/R, VCR2 A/D.SB L/R VCR2 ROOM L/R SUBROOM L/R Fr L/R Fr L/R FRONT CENTER/SW Sr L/R...
Page 39
R2280 100K R292 Fr R R2274 R2353 R2354 2 4K C2266 10/80 5 1K 5 1K R300 Q292 R2260 2SC3576 JVC T IC241 C2252 NJM4580E W 22/50 R299 Q291 2SC3576 JVC T R291 Fr L C2064 R2066 C2063 100/25 R2065...
Page 40
RX-DP20VBK Audio signal intput 2 section R7751 IC701 NJM5532D R7702 C701 R7701 NJM5532D FR H FL H R7734 R7733 C7751 ZIST R Z ST L 47/50 R7710 R7709 FR C FL C C7734 C7733 R7726 R7725 C7752 47/50 J701 J701...
Page 41
RX-DP20VBK IC382 IC382 BA15218N BA15218N R2122 R2123 R2118 D2111 Q2111 1SS355 X KTC3199 R2120 C2115 Q2112 C2114 10 25 DTC144ESA 10 25 R2121 D2123 D2121 3 3K MTZJ5 1C 1SS355 X C2116 R2119 10/25 Audio signal Tuner signal Front audio signal...
Page 42
RX-DP20VBK Video signal intput 1 section C4702 47/25 C4701 0 01 Q4701 C471 BU4051BC KRC102S X MA N1 Q4702 KRC102S X VCR1R S12 R4704 MA N2 VCR2R S12 R4705 C4501 C4521 R4501 0 01 0 047 TV C MONI S12...
Page 51
RX-DP20VBK A GND AD/DIR C681 SN74LV157APW X C3811 R3813 R3811 A BCK R3814 R3815 LRCK S MCK R3812 A LRCK A DATA DATIN0 R3816 R3818 S LRCK R3817 S BCK S LRCK S BCK C3622 C818 SN74LV126APW X C3641 R3624...
Page 76
VICTOR COMPANY OF J APAN, LIMITED AV & MULTIMEDIA COMPANY AUDIO/VIDEO SYSTEMS CATEGORY 10-1,1chome,Ohwatari-machi,Maebashi-city,371-8543,Japan Printed in Japan (No.22008SCH)
PARTS LIST [ RX-DP20VBK ] * All printed circuit boards and its assemblies are not available as service parts. Area suffix J ----------------------------- U.S.A. C -------------------------- Canada - Contents - 3- 2 Exploded view of general assembly and parts list (Block No.M1) 3- 6 Electrical parts list (Block No.01~07)
Page 78
Exploded view of general assembly and parts list Block No. Power supply 1 board Power / fuse board Power trans 1 board Power trans 2 board Power supply 3 board Therm SW boa Power supply 2 board REG. board Head phone board 9.5 0.3mm e' J Power SW board...
Page 79
Compu link Speaker board board 153 153 Y/C separator board Audio 7.1ch V compo in board 2 board V compo 1 board T. c. board T. c. board S Video board T. c. board Video board Audio signal 2 board Power amp.
Page 80
TRANS BASE LV10536-024A FRONT BASE QYSDSG3008E TAPP NG SCREW 3mm x 8mm(x10) LV30225-0D5A SPACER LV10543-003A CENTER BKT(L) PQ45130-1-1 JVC MARK QYSBSGG3008E TAPP NG SCREW 3mm x 8mm(x5) E60912-003 SPEED NUT LV10544-002A CENTER BKT(R) LV43263-001A K2 MARK QYSBSGG3008E TAPP NG SCREW...
Page 81
Symbol No. Part No. Part Name Description Local QYSBSGY3008E SPECIAL SCREW 3mm x 8mm(x8) QYSBSGY3008E SPECIAL SCREW 3mm x 8mm(x4) QYSBSGY3008E SPECIAL SCREW 3mm x 8mm(x6) QYSBSGY3008E SPECIAL SCREW 3mm x 8mm QYSBSGY3008E SPECIAL SCREW 3mm x 8mm(x4) QYSBSGY3008E SPECIAL SCREW 3mm x 8mm(x4) QYSBSGY3008E...
Electrical parts list Power amp. board Block No. [0][1][0][0] Symbol No. Part No. Part Name Description Local Symbol No. Part No. Part Name Description Local Q1631 2SC2412K/RS/-X TRANSISTOR Q1632 DTA124EKA-X DIGI TRANSISTOR IC601 VC5022-2 Super A Q1651 2SC1775A/E/-T TRANSISTOR IC602 VC5022-2...
Page 83
Symbol No. Symbol No. Part No. Part Name Description Local Part No. Part Name Description Local D716 MTZJ33C-T2 Z DIODE D1921 1SS133-T2 DIODE D717 MTZJ33C-T2 Z DIODE D1931 1SS133-T2 DIODE D745 F10P20F DIODE D1941 1SS133-T2 DIODE D746 F10P20FR DIODE D1951...
Page 84
Symbol No. Symbol No. Part No. Part Name Description Local Part No. Part Name Description Local C1608 QFN31HJ-472Z M CAPACITOR 4700pF 50V J C1975 QETN1HM-226Z E CAPACITOR 22uF 50V M C1609 QCS32HJ-470Z C CAPACITOR 47pF 500V J C1981 QETN1HM-105Z E CAPACITOR 1uF 50V M...
Page 85
Symbol No. Symbol No. Part No. Part Name Description Local Part No. Part Name Description Local R779 QRZ0182-R10 EMIT.RESISTOR 0.1Ω R1620 QRJ146J-121X UNF C RESISTOR 120Ω 1/4W J R781 QRL027J-472 OMF RESISTOR 4.7kΩ 2W J R1621 QRJ146J-121X UNF C RESISTOR 120Ω...
Page 86
Symbol No. Symbol No. Part No. Part Name Description Local Part No. Part Name Description Local R1712 QRE141J-680Y C RESISTOR 68Ω 1/4W J R1912 NRSA02J-153X MG RESISTOR 15kΩ 1/10W J R1713 QRE141J-152Y C RESISTOR 1.5kΩ 1/4W J R1913 NRSA02J-123X MG RESISTOR 12kΩ...
Page 87
E-SI C WIRE C-B Q271 2SD468/BC/-T TRANSISTOR WR714 WJK0139-003A E-SI C WIRE C-B Q272 2SD468/BC/-T TRANSISTOR WR715 WJK0139-002A E-SI C WIRE C-B Q291 2SC3576-JVC-T TRANSISTOR WR716 WJK0140-001A E-SI C WIRE C-B Q292 2SC3576-JVC-T TRANSISTOR WR717 WJK0140-002A E-SI C WIRE C-B Q293 2SC3576-JVC-T TRANSISTOR...
Page 88
Symbol No. Symbol No. Part No. Part Name Description Local Part No. Part Name Description Local Q2041 2SC3576-JVC-T TRANSISTOR C209 QFN31HJ-472Z M CAPACITOR 4700pF 50V J Q2042 2SC3576-JVC-T TRANSISTOR C210 QFN31HJ-472Z M CAPACITOR 4700pF 50V J Q2043 KRA107S-X...
Page 89
Symbol No. Symbol No. Part No. Part Name Description Local Part No. Part Name Description Local C417 QETN1EM-476Z E CAPACITOR 47uF 25V M C2213 NCB31HK-223X C CAPACITOR 0 022uF 50V K C418 NCB31HK-103X C CAPACITOR 0.01uF 50V K C2221 NCB31HK-223X C CAPACITOR...
Page 90
Symbol No. Symbol No. Part No. Part Name Description Local Part No. Part Name Description Local C4606 QETN1EM-476Z E CAPACITOR 47uF 25V M R227 NRSA63J-472X MG RESISTOR 4.7kΩ 1/16W J C4607 NCB31HK-103X C CAPACITOR 0.01uF 50V K R228 NRSA63J-103X MG RESISTOR 10kΩ...
Page 91
Symbol No. Symbol No. Part No. Part Name Description Local Part No. Part Name Description Local R309 NRSA63J-474X MG RESISTOR 470kΩ 1/16W J R438 NRSA63J-471X MG RESISTOR 470Ω 1/16W J R311 NRSA63J-102X MG RESISTOR 1kΩ 1/16W J R439 NRSA63J-0R0X MG RESISTOR 0Ω...
Page 92
Symbol No. Symbol No. Part No. Part Name Description Local Part No. Part Name Description Local R2261 NRSA63J-473X MG RESISTOR 47kΩ 1/16W J R2622 QRJ146J-680X UNF C RESISTOR 68Ω 1/4W J R2262 NRSA63J-473X MG RESISTOR 47kΩ 1/16W J R2623 QRJ146J-680X UNF C RESISTOR...
Page 93
Symbol No. AC supply board Part No. Part Name Description Local Block No. [0][3][0][0] R4846 NRSA63J-221X MG RESISTOR 220Ω 1/16W J Symbol No. R4901 NRSA63J-750X MG RESISTOR 75Ω 1/16W J Part No. Part Name Description Local R4902 NRSA63J-750X MG RESISTOR 75Ω...
Page 94
Symbol No. Symbol No. Part No. Part Name Description Local Part No. Part Name Description Local QCBB1HK-222Y C CAPACITOR 2200pF 50V K QRZ0133-911 C RESISTOR 910Ω QETN1CM-107Z E CAPACITOR 100uF 16V M QRZ0133-911 C RESISTOR 910Ω R65 QETN1AM-227Z E CAPACITOR 220uF 10V M...
Page 95
Symbol No. Symbol No. Part No. Part Name Description Local Part No. Part Name Description Local QQR0779-001Z COIL D1202 1SS133-T2 DIODE QQR0779-001Z COIL D1203 MTZJ12C-T2 Z DIODE QSK0109-001 RELAY D1211 MTZJ6 2C-T2 Z DIODE RY21 QSK0098-001 RELAY RY101 QSK0131-001 RELAY...
Page 96
Symbol No. Symbol No. Part No. Part Name Description Local Part No. Part Name Description Local R1045 NRSA63J-103X MG RESISTOR 10kΩ 1/16W J R1164 NRSA63J-221X MG RESISTOR 220Ω 1/16W J R1046 NRSA63J-103X MG RESISTOR 10kΩ 1/16W J R1165 NRSA63J-221X MG RESISTOR 220Ω...
Symbol No. Symbol No. Part No. Part Name Description Local Part No. Part Name Description Local J1211 QNS0073-001 JACK IC691 BA033FP-X Regulator J1212 QNS0073-001 JACK IC692 BA033FP-X Regulator J1213 QNS0077-001 3.5 JACK IC693 BA033FP-X Regulator JS961 QSW0867-001 SWITCH IC700 SN74LVC1G04K-X K472...
Page 98
Symbol No. Symbol No. Part No. Part Name Description Local Part No. Part Name Description Local C3544 NCB31HK-103X C CAPACITOR 0.01uF 50V K C3735 NCF31CZ-104X C CAPACITOR 0.1uF 16V Z C3545 NCB31HK-103X C CAPACITOR 0.01uF 50V K C3736 NCF31CZ-104X C CAPACITOR 0.1uF 16V Z...
Page 99
Symbol No. Symbol No. Part No. Part Name Description Local Part No. Part Name Description Local C4853 NEA71HM-105X E CAPACITOR 1uF 50V M R3651 NRSA63J-302X MG RESISTOR 3kΩ 1/16W J C4859 NCS31HJ-470X C CAPACITOR 47pF 50V J R3652 NRSA63J-102X MG RESISTOR 1kΩ...
Page 100
Symbol No. Symbol No. Part No. Part Name Description Local Part No. Part Name Description Local R4840 NRSA63J-102X MG RESISTOR 1kΩ 1/16W J Q7096 2SC3422/OY/ TRANSISTOR R4841 NRSA63J-102X MG RESISTOR 1kΩ 1/16W J Q7097 2SC3422/OY/ TRANSISTOR R4842 NRSA63J-511X MG RESISTOR 510Ω...
Symbol No. Symbol No. Part No. Part Name Description Local Part No. Part Name Description Local R7736 QRV12DF-1000 CMF RESISTOR 100Ω 1/2W F Q581 KRC105M-T DIGI TRANSISTOR R7737 QRV12DF-1000 CMF RESISTOR 100Ω 1/2W F Q582 KRC105M-T DIGI TRANSISTOR R7738 QRV12DF-1000 CMF RESISTOR...
Page 102
Symbol No. Symbol No. Part No. Part Name Description Local Part No. Part Name Description Local C1525 NCF21EZ-224X E CAPACITOR 0.22uF 25V Z C3175 NCB31HK-103X C CAPACITOR 0.01uF 50V K C1526 QETN1HM-225Z E CAPACITOR 2.2uF 50V M C3179 NCF21CZ-155X C CAPACITOR 1.5uF 16V Z...
Page 103
Symbol No. Symbol No. Part No. Part Name Description Local Part No. Part Name Description Local C3352 QEZ0629-107 E.CAPA AWF 100uF R507 NRSA63J-750X MG RESISTOR 75Ω 1/16W J C3353 QEZ0538-476Z C CAPACITOR 47uF R508 NRSA63J-750X MG RESISTOR 75Ω 1/16W J C3354 QEZ0538-476Z C CAPACITOR...
Page 104
Symbol No. Symbol No. Part No. Part Name Description Local Part No. Part Name Description Local R3010 NRSA63J-103X MG RESISTOR 10kΩ 1/16W J R3172 NRSA63J-221X MG RESISTOR 220Ω 1/16W J R3011 NRSA63J-220X MG RESISTOR 22Ω 1/16W J R3173 NRSA63J-221X MG RESISTOR 220Ω...
Page 105
Symbol No. Symbol No. Part No. Part Name Description Local Part No. Part Name Description Local R3288 NRSA63J-221X MG RESISTOR 220Ω 1/16W J R3412 NRSA63J-163X MG RESISTOR 16kΩ 1/16W J R3289 NRSA63J-221X MG RESISTOR 220Ω 1/16W J R3413 NRSA63J-162X MG RESISTOR 1.6kΩ...
Page 106
Symbol No. Part No. Part Name Description Local K3282 NQR0229-001X FERRITE BEADS K3283 NQR0229-001X FERRITE BEADS K3284 NQR0229-001X FERRITE BEADS K3381 NQR0229-001X FERRITE BEADS K3382 NQR0229-001X FERRITE BEADS K3383 NQR0229-001X FERRITE BEADS K3384 NQR0229-001X FERRITE BEADS K3481 NQR0229-001X FERRITE BEADS K3482 NQR0229-001X FERRITE BEADS...
Page 108
Packing materials and accessories parts list Block No. 3-32...
Page 109
Packing and accessories Block No. [M][3][M][M] Symbol No. Part No. Part Name Description Local DP20 LVT0965-002A INST BOOK ENG,FRE VBKC DP20 LVT0965-001A INST BOOK VBKJ QAL0236-001 ANTENNA QAL0219-001 LED CABLE ASSY EWP503-001C ANT.WIRE QAL0204-001 AM LOOP ANT DP20 BT-51028-2 J=REGIST CARD VBKJ DP20...