Related Manuals for A2Z Ozone SP-3
Summary of Contents for A2Z Ozone SP-3
- Page 1 A2Z OZONE, INC. OWNER'S MANUAL SWIMMING POOL OZONE GENERATOR MODEL: SP-Series 110 or 220/240VAC 50/60Hz A2Z OZONE, INC. 1844 Cargo Court Louisville, KY 40299 - USA www.A2Zozone.com...
- Page 2 CONTROL PANΕL • CONNECTION FITTING • TROUBLESHOOTING • • APPLICATIONS HEALTH HAZARDS OF OZONE • SAMPLE SCHEMATIC DIAGRAMS • • INJECTION MANIFOLD DRAWING • INSTALLATION DRAWING # 1 INSTALLATION DRAWING # 2 • WARRANTY • • A2Z Ozone WARRANTY REGISTRATION CARD...
-
Page 3: Important Safety Instructions
CAUTIONS AND GENERAL NOTES This manual covers the SWIMMING POOL OZONE GENERATOR MODEL SP-Series Corona Discharge (CD) Ozone Generators. A2Z Ozone Systems Inc. reserves the right to make changes to the product covered in this manual to improve performance, reliability, or manufacturability. - Page 4 DESCRIPTION The SWIMMING POOL OZONE GENERATOR MODEL SP-Series is a compact, regulated output with Corona Discharge (CD) ozone cell with 3, 5, 8 and 16 g/hr of ozone output. The units are air- cooled, robustly built and reliable. They produce ozone concentrations between 3 to 16 g/hr. The components are made of high quality material and the controls are easy to use and view.
-
Page 5: Specifications
SPECIFICATIONS SP SERIES Model SP-3 SP-5 SP-8 SP-16 Ozone output g/h Concentration g/m3 Oxygen : 25-45 Air: 5-15 Electric 220/240 OR 110/120 VAC 50/60 Hz Power Watt Size Inch 11X8X14.3 12X8X14.3 15X8X18 Weight lbs 14.5 22.5 Cooling System Air Cooling Fan... -
Page 6: Installation
If the pool volume is say 60000 liters then the pump should be capable of re-circulating the water at a rate of at least 15000 liters per hour. This way, the total volume of water through the pool will be passing through the injector at least once each 4 hour period. Less pump run time for the minimum liters. -
Page 7: Main Power
Schematic diagram of injector manifold point of installation with “Hartford loop” DETAILS OF VENTURI INJECTOR MANIFOLD: Attention: Install venturi with bypass valve on water recirculation pipeline. Arrow on venturi MUST be set as the same direction as water flow. Turn water pump on and close the by- pass valve until vacuum is created at venturi input. Note1: Use the installed flow-meter to check vacuum -2 to -3 PSI (-0.14 to -0.21 bars) or place finger over end of venturi valve to feel vacuum while adjusting the by-pass venturi valve. - Page 8 TUBE CONNECTION AND START UP: Connect silicone tube (if you use oxygen generator or oxygen tank or external air compressor) to ozone generator (Air IN) and direct it away from hot and humid air to the ozone cell. This will serve as oxygen, or fresh air for ozone production.
- Page 9 is not operating. Bromine needs to be maintained at only 1.0 PPM (parts per million) so that the trace amount of the product in the water will not be noticed. Chlorine will also work as a residual oxidizer and may be used effectively in conjunction with the ozone system. Ozone and Chlorine For outdoor pools, we recommend the use of chlorine to supplement the ozone.
- Page 10 PROCEDURE TURN OZONE GENERATOR OFF. CLEAN FILTER SCREEN WITH WATER AND SOAP AND DRY IT WITH A CLEAN TOWEL. INSTALL BACK THE SCREEN. TURN ON THE OZONE GENERATOR. BE SURE SCREEN DOES NOT TOUCH FAN BLADE. MAINTENANCE - SWIMMING POOL FILTER Ozone will keep the water much cleaner than any other type of water purification system.
-
Page 11: Troubleshooting
D. Check wire from terminal to ozone board. E. Check Pot wire is connected to ozone board. If you are still experiencing problems, please contact A2Z Ozone Systems for more information. HEALTH HAZARDS OF OZONE Do not allow the ozone gas level in any living area to exceed FDA-recommended level of PPB. -
Page 12: Sample Schematic Diagram
SAMPLE SCHEMATIC DIAGRAM... - Page 13 A2Z Ozone Systems, Inc. ozone systems are built with the finest components available. All are air-cooled and use a venturi injector system to create the best possible contact and mixing of ozone while maintaining a high level of safety.
- Page 14 polluted water. A few years later in 1891, the German scientist Froelich reported the bactericidal properties of ozone from pilot plant tests conducted at a drinking water treatment plant in Martinkenfeld, Germany. In 1893, the first drinking water treatment plant to employ ozone was built in Oudshoorn in the Netherlands.
- Page 15 Bacteria kill rate is up to three thousand times faster • 50% stronger oxidizer than chlorine • Reduces traditional chemical use between 60% - 95% • Reduce handling and storage of unsafe chemicals • Reduce constant purchasing of harmful chemicals •...
- Page 16 influence the half-life. Factors are temperature, pH, concentration and sort solutes. Because ozone reacts with all kinds of components, the concentration of ozone will reduce quickly. When most of the components are oxidized, the residual ozone will remain, and the concentration of ozone will reduce.
- Page 17 properly installed and plumbed all of the ozone generated will be dissolved in the water or used up oxidizing impurities in your water. 15) Does ozone affect water balance? Ozone has a neutral pH (about 7.0) so it does not affect pH. Ozone has no calcium, no alkalinity, and no dissolved solids.
- Page 18 Shock treat with Hydrogen peroxide • Maintain total alkalinity with Hydrochloric acid or Sodium Bicarbonate 80-100ppm • Maintain pH 7.2 to 7.8 (HCL acid to lower and Sodium Bicarbonate to increase ) • Shock treat with Hydrogen Peroxide 35% ( 100mL / 1000 Liters pool water ) •...
- Page 19 The limited warranty set forth below applies to products manufactured by A2Z Ozone Systems Inc. - and sold by A2Z Ozone Systems or its authorized dealers. This limited warranty is given only to the first retail purchaser of such products and is not transferable to any subsequent owners or purchasers of such products.
- Page 20 This information can be also send by EMAIL to us. Please provide ALL pertinent information and send within twenty (20) days to: service@a2zozone.com Otherwise, please fill out completely and return to A2Z Ozone by post within twenty (20) days of purchase. Customer Info:...