Important Safety Instructions; Operating Procedures - Mart Cart 280-4036 Owner's Manual

Important Information
Please read before operation.
CONGRATULATIONS!
You have just purchased the best electric shopping cart on
the market today. Mart Cart incorporates the very latest in
technological advances. To assure you of the best and safest
performance as well as longest life, please read the enclosed
information. After reading this manual, should you have a
service problem or need help, please call our customer service
department with the serial number of your cart, at our toll free
1-800-548-3373 or (479)
number:
DAMAGE: Check the shipping carton for any visible damage.
Report the damage to the freight carrier immediately. File
a claim with the carrier if actual damage to your cart has
occurred. Check the contents of the carton. The contents
should agree with the information listed on the packing
list. Report any discrepancy to the carrier and the factory
immediately.
TO ORDER PARTS: Call 1-800-548-3373 or (479) 636-5776
visit www.martcart.com
the service department personnel. The Mart Cart serial number
is located on the seat support tube under the seat as shown in
parts list portion of this manual.
TERMS: All parts will be shipped with approved credit card,
check in advance or C.O.D. Commercial accounts are allowed 15
day terms from date on invoice with approved credit.
FREIGHT: All freight will be paid by the customer. Special
consideration will be given to items under warranty coverage.
ATTENTION: It is the responsibility of the owner of this cart to
maintain the cart in a safe and reliable operating condition at all
times.
NOTE: Specifications found in this manual are subject to
change without notice.

Important Safety Instructions

Please read before operation.
WARNINGS!
• Never attempt to charge the battery in this cart without
using an electrical outlet that is protected by a GFCI.
• Replace charging cord if plug is damaged or if the cord is
worn or frayed.
• Never use the charging cord without proper grounding.
Do not use if plug does not have all 3 prongs.
• Never allow the cart to be used out-of-doors or on any
surface that is not level.
• Always disconnect power before servicing.
• See "Daily Maintenance Checklist" and follow instructions.
• Cart can roll. Enter and exit the cart with care.
636-5776.
Be sure to give the serial number to

OPERATING PROCEDURES

• New carts will need charging! Charge the cart's battery for
8 hours prior to first use.
• THIS CART IS FOR USE INDOORS, ON LEVEL SURFACE ONLY.
• DO NOT STAND ON CART. (See "Operating & Warning
Instructions" on cart).
• After battery is charged, disconnect power supply cord
before operating cart.
• DO NOT exceed the load limitations as shown on the cart.
• Return power cord to the cord storage area when not
charging.
• DO NOT allow children to operate or play on cart. Keep
cart secured with key (if applicable), at service counter.
Your cart is equipped with the Intelli-Charge™ system. While
operating the cart, the LED (Light Emitting Diode) will be solid
green
until the battery runs lower than 2/3 full charge. It will
then turn amber. When the battery charge falls below 11 volts,
the LED will begin flashing red. The customer riding the cart
should have ample time to return the cart to the charging station
before the power is cut off to the motor. When the customer
exits the cart, the horn will start beeping in unison with the
or
flashing LED. This will alert those responsible for maintaining the
cart to plug in the charger. When plugged into a 120v AC wall
socket, the LED will flash
charging is complete, the LED will start flashing green. The
charger may be left plugged in even longer. It will NOT harm the
battery.
LED Color Status
LED Off
Green
Amber
Red
– Flashing
Amber
– Flashing
Green – Flashing
• The battery should be charged each night and at every
opportunity. The battery is fully charged when the LED on the
control box flashes green.
• A Ground Fault Circuit Interrupter (GFCI) in the circuit is
required wherever the cart is being charged.
• Before servicing the cart, the battery should be charged to a
voltage above the "depletion" level (above 11 volts).
• Never allow the battery to completely "discharge. " This will
cause premature battery failure.
2
amber and the horn will silence. When
Description
Off/On rocker switch is set to "Off" position
or no one is sitting in the seat
Off/On rocker switch is set to "On" position
and someone is sitting in the seat
Battery's charge is below 2/3 full charge
Battery needs to be charged
Charger is plugged in and battery is being
charged
Charger is plugged in and the battery is
charged
red