Table of Contents
Advertisement
Advertisement
Table of Contents
Related Manuals for VALPRO VPIM-420
Summary of Contents for VALPRO VPIM-420
- Page 1 Commercial Ice Machine User’s Manual l l l Model: VPIM-420/1000 Valpro Commercial Refrigeration Be sure the ice machine has been standing upright 5256 EagleTrail Drive Tampa, Florida 33634 Email: info@valpromail.com for at least 24 hours prior to plug-in. http://www.valprorefrigeration.com...
-
Page 3: Table Of Contents
TABLE OF CONTENTS ICE MAKER SAFETY………………………………………......2 IMPORTANT SAFEGUARDS ……………………………......…3 TECHNICAL INFORMATION ………………………………....6 INTRODUCTION …………………………………………....7 COMPONENT LOCATIONS ……………………………......…8 ICE MAKER INSTALLATION …………………………….......…9 Unpacking …………………………………………......9 Location Requirements ………………………………......9 Typical installation of ice storage bin………………….......10 Electrical Requirements ……………………………….......11 Water Supply ………………………………………….......12 Installation Types …………………………………......…13 OPERATION ………………………………………………….......13 Final Checklist before Operation ……………………......13 Setting Initial Data of Water Filter ………………………....14... -
Page 4: Ice Maker Safety
Service and Installation Manual Service and Installation Manual ICE MAKER SAFETY Problem Possible Cause Probable Correction Check if the water supply pressure Your safety and the safety of others are very important. Cubes are is below 20psig. We have provided many important safety messages in this manual and on your partially Not enough water in the Check water supply--filter may be... -
Page 5: Important Safeguards
Service and Installation Manual Service and Installation Manual Troubleshooting IMPORTANT SAFEGUARDS Before Calling for Service If the unit appears to be malfunctioning, read through the OPERATION Before the ice maker is used, it must be properly section of this manual first. If the problem persists, check the Troubleshooting positioned and installed as described in this manual, so Guide below and on the following page. - Page 6 Service and Installation Manual Service and Installation Manual Use two or more people to move and install ice maker. Failure to do so can When this LED is on, the unit is working in the cleaning mode. • result in back or other injury. 6.
- Page 7 Service and Installation Manual Service and Installation Manual on. If you want to restart the ice-making process after cleaning, press the These cleaners may transmit taste to the ice cubes, or damage or discolor the ICE button directly more than 3 seconds and the ice machine will interior.
-
Page 8: Technical Information
Service and Installation Manual Service and Installation Manual Technical Information Control Panel (located at top of right side panel) Model VPIM420 VPIM1000 115VAC ~ 60Hz 230VAC ~ 60Hz Electrical input Power consumption 2.4kW · h /100 lbs of ice 5.6kW ·... -
Page 9: Introduction
Service and Installation Manual Service and Installation Manual If you want to make ice cubes after cleaning, press the ICE button to start Introduction the ice –making cycle. When the ice machine start making ice, make sure The model Refrigeration420 IM Series of Ice Cube Machine finds wide the front door is reinstalled. -
Page 10: Component Locations
Service and Installation Manual Service and Installation Manual water tank. Component Locations Keep the ice maker connected to the water supply. Keep the ice maker is plugged in. Press the CLEAN button. The machine will run the Automatic Clean mode. The green clean cycle LED will be Right side panel Top panel Water sprinkler... -
Page 11: Ice Maker Installation
Service and Installation Manual Service and Installation Manual the sprinkler back to its original position. Be sure the holes straight down. If Ice Maker Installation the sprinkler is badly blocked, clean it as follows: Unpacking 1. Disconnect power to the unit and open the front door. Remove packaging materials 2. -
Page 12: Typical Installation Of Ice Storage Bin
Service and Installation Manual Service and Installation Manual Typical installation of ice storage bin Interior Cleaning Clean the water tank before the ice maker is used for the first time and reused Connecting lock is attached to the upper rear edge of the ice storage bin. Close after stopping for an extended period of time. -
Page 13: Electrical Requirements
Service and Installation Manual Service and Installation Manual Cleaning and Maintenance Electrical Requirements Periodic cleaning and proper maintenance will ensure efficiency, top performance, and long life. The maintenance intervals listed are based on normal conditions. You may want to shorten the intervals if you have pets or there are other special considerations. -
Page 14: Water Supply
Service and Installation Manual Service and Installation Manual Water Supply Normal Sounds Your new ice cube machine may make sounds that are unfamiliar to The water supply should be ready at the point of installation. The water supply you. Most of the new sounds are normal. Hard surfaces like the floor pressure should be a minimum of 20 psig with a static pressure not more than and walls can amplify the sounds. -
Page 15: Installation Types
Service and Installation Manual Service and Installation Manual How the Machine Makes Ice Installation Types The machine is in Stand-by mode when plugged in. When the ICE button is This ice maker has only been designed for mobile (free-standing) installation. pressed, it will automatically proceed to the ice-making stage. -
Page 16: Setting Initial Data Of Water Filter
Service and Installation Manual Service and Installation Manual Setting Initial Data of Water Filter 2. After about 2 minutes, the ice maker will automatically proceed to the ice-making stage, and the sound of flowing water will be heard. Only the If you use a water filter, before usage the unit should equipped with water green ice making indicator light lights.
Need help?
Do you have a question about the VPIM-420 and is the answer not in the manual?
Questions and answers