Cabela's ULTIMATE COOKSTATION XL User Manual And Instruction Manual page 8

LEAK TESTING THE REGULATOR, VALVES, HOSES, AND CONNECTIONS
1. Ensure the LP cylinder valve and all burners are "OFF".
2. Ensure the LP cylinder is connected to the regulator.
3. Mix up a solution of 50% water and 50% liquid dish soap. Do not use any household cleaner
solution.
4. Open the LP tank valve by turning the hand wheel counterclockwise one turn. If you hear a
rushing sound, turn the gas off immediately. In that case, there could be a leak at the connection.
Reconnect the cylinder to the regulator.
5. Spray or brush on the solution covering the following areas: cylinder welds, regulator and
cylinder connection, gas hose connections to the regulator, all gas hoses, all gas hose
connections to the burners including the main and side burners.
6. Growing bubbles on any of the parts and connections listed above indicate a gas leak.
Immediately shut off the LP tank valve by turning the valve clockwise. Retighten the connections
or order replacement parts as needed. Continue to test as necessary until no leaks are detected.
7. Close the LP tank valve by turning the hand wheel clockwise.
If the information in 1 & 2 is not followed exactly, a fire causing death or serious injury may occur.
DO NOT USE THE GRILL if you cannot stop the leaks. Be sure the LP cylinder valve is closed.
If the LP cylinder is still leaking, contact your LP dealer or local fire department.
Do not use any match or open flame, or smoke, during leak testing.
Do not light a burner during leak testing.
The replacement hose assembly must be the one identified.
Minimum clearance from the sides and back of your
combustible construction below the top of the unit, 24 inches (60 cm) from the sides and
24 inches (60 cm) from the back.
Do not locate this your
surfaces.
Apartment Residents: Check with your apartment manager regarding your regulations
for barbecues.
Do not use your
type of overhead structure or canopy.
Operate your
ULTIMATE COOKSTATION XL
Keep any electrical supply cord and the fuel supply hose away from any heated surfaces and water.
Do not face your
7
ULTIMATE COOKSTATION XL
ULTIMATE COOKSTATION XL
ULTIMATE COOKSTATION XL
Please read this manual in its entirety prior to using this product
ULTIMATE COOKSTATION XL
under overhead-unprotected combustible
in any enclosed area, garage, shed, or under any
only in a well ventilated area.
directly into the wind.
to adjacent