C0322 through C1030 E Series Air and Water Cooled User Manual Installation: Product Specifications Location Limitations: Environmental Limitations The product is designed to be installed indoors, in a Minimum Maximum controlled environment. Air cooled models discharge Air temperature very warm air into the room out the back. Space must Water temperature be allowed at the sides and back for air discharge.
03= nominal ice capacity in 100s of pounds combinations include: • 22= nominal width of cabinet • HD22 – use with C0322 or C0522 • S= Cube size. S=small or half dice cube. • HD30 – use with C0330 or C0530 M=medium or full dice cube Ice and Beverage Dispensers –...
C0322 through C1030 E Series Air and Water Cooled User Manual Product Description & Electrical Requirements Dimensions w" x d" x h" Model Series Electrical Condenser Minimum Maximum volts/Hz/ Circuit Fuse Size* phase Ampacity C0322SA-1 115/60/1 12.7 C0322SW-1 115/60/1 Water 11.9...
Testing has shown that using a filter that does not remove chlorine, such as the Scotsman Aqua Patrol, will greatly improve this situation, while the ice making process itself will remove the chlorine from the ice, resulting in no taste or odor impact.
C0322 through C1030 E Series Air and Water Cooled User Manual Panel Removal 1. Locate and loosen the two screws at the bottom of the front panel. 2. Pull the front panel out at the bottom. Dataplate 3. Lower the front panel down and off the machine.
FPT inlet water connection; a 3/8” FPT to 3/8” male Tee the condenser drain into the reservoir or bin drain. flare adapter is available from the local Scotsman distributor or from a hardware store. Vent the reservoir drain. A vertical vent at the back of the drain, extended about 8 - 10”...
C0322 through C1030 E Series Air and Water Cooled User Manual Electrical The machine is not supplied with a power cord as the machine is designed to be permanently connected. The dataplate on the back of the cabinet details the power requirements, including voltage, phase, minimum circuit ampacity and maximum fuse size.
C0322 through C1030 E Series Air and Water Cooled User Manual Final Check List After connections, 9. Have the drain connections been checked for leaks? 1. Wash out the bin. If desired, the interior of the bin could be sanitized.
C0322 through C1030 E Series Air and Water Cooled User Manual Initial Start Up 1. Remove front panel and evaporator cover. Check mechanism is activated. The purge valve opens to machine for any packing or wires rubbing moving drain some water, when it does the inlet water valve parts.
Air and Water Cooled User Manual Adjustments Ice Bridge Thickness Measurement Bridge Thickness - For the Service Tech Only Note: Indentations may be deeper on C0322 and C0330 1. Push and hold Off till the machine stops. 1/8-3/16” 2. Remove evaporator cover.
Contact an level drops, the ice machine will resume making ice. authorized Scotsman service agent and have the machine cleaned, de-scaled and sanitized. Caution: Do not place anything on top of the ice machine, including the ice scoop.
C0322 through C1030 E Series Air and Water Cooled User Manual Control Switches The On and Off switch buttons are front accessible. Use of control De-scale Status Power Water To switch the machine OFF, push and release the Off There are several positions the ice level can be set to, button.
5. Observe code display, when it blinks the characters “A d 1” immediately go to the next step. 6. Pour 8 ounces (C0322 or C0330) or 10 ounces (C0522, C0530 or C0630) or 12 ounces (C0830 Pull here or C1030) of Scotsman Clear 1 ice machine scale remover into the reservoir.
Page 20
13. Separate probes from housing and wash all 1. Remove and discard all ice. surfaces with ice machine scale remover solution. 2. Mix a solution of 7 ounces of Scotsman Clear Rinse and return probes to holder. 1 ice machine scale remover in 84 ounces of 14.
C0322 through C1030 E Series Air and Water Cooled User Manual Air cooled condenser filter Clean air filters when they become visibly dirty. They will need cleaning more often than the other items. Air Filter 1. Pull air filter(s) from the front panel.
C0322 through C1030 E Series Air and Water Cooled User Manual What to do before calling for service Reasons the machine might shut itself off: • Lack of water. • Freeze cycle takes too long. • Harvest cycle takes too long.
Page 23
SCOTSMAN ICE SYSTEMS 101 Corporate Woods Parkway Vernon Hills, IL 60061 www.scotsman-ice.com 800-726-8762 17-3599-01...