Storage Assembly Maintenance Cutting height adjustment Preparing the lawn mower Checking the oil Fuelling Starting the engine To start the the mower with the electric start Warranty Power Tools Stopping the engine For full details please visit us at www.909.com...
Take special care to heed the Cautions and Warnings. Your 909 Lawn Mower has many features that will make Thrown objects and rotating blades your job faster and easier. Safety, performance, and can cause severe injury.
Specifications General safety instructions for handling power tools Engine: 99 cc Four Stroke WARNING: Read all safety warnings and all instructions. Engine Capacity: 99 cc Failure to follow the warnings and instructions may result in Bore: 56 mm electric shock, fire and/or serious injury. This unit may not be used by people (including children) Stroke: 40 mm...
Page 5
• Do not expose power tools to rain or wet conditions. • Dress properly. Do not wear loose clothing or jewellery. Water entering a power tool will increase the risk of Keep your hair, clothing and gloves away from moving electric shock.
5). Use and care of the battery pack • Never use to recharge third-party batteries. The charger is only designed to charge the supplied batteries (Li-Ion) • Ensure the key switch is in the OFF position and the using the voltages specified in the Technical Data. key is removed before connecting or disconnecting the Otherwise there is a risk of fire or explosion.
• Never allow children or people unfamiliar with these • Discharge openings must be guarded at all times. Do not instructions to use the lawn mower. Local regulations may remove the discharge guard or hold it up while mowing. restrict the age of the operator. •...
• To reduce the fire hazard, keep the engine, exhaust • Do not run the engine in an enclosed and/or poorly silencer, battery compartment and fuel storage area ventilated area. The gas of the engine contains carbon free of grass, leaves, or excessive grease. Do not leave monoxide, which is dangerous to your health.
Due to modern mass production techniques, it is unlikely therotating blade. This distance is the length of the that your 909 Lawn Mower is faulty or that a part is missing. handle. If you find anything wrong, do not operate the tool until the •...
Assembly WARNING: Stop the engine and unplug the spark plug before any repairs or maintenance operations. WARNING: DO NOT attempt to start this mower without first adding 0.4L of SAE 10W/30 engine oil to the Engine. Refer Page 10. WARNING: Do Not attempt to start this mower without the mower first being FULLY assembled.
Preparing the lawn mower 3. Push the catcher down until it locks into place. It is important to check the lawn mower before you 4. Release the discharge guard commence operating the unit. to secure the catcher in place IMPORTANT. Ensure that the engine is fully filled with oil between the 2 ribbed locking and fuel.
Fuelling Starting the engine IMPORTANT. Fuel goes off after about 3-4 months. If you find Note. Before starting the mower check the oil and fuel your mower does not start, first change the fuel in the tank levels. Warranty will be void if the engine becomes faulty with newly purchased fuel.
To connect the battery, check the key switch is in the off In the case where the primer has been over primed, position and REMOVE the key. Insert the battery plug continue to either pull on the recoil starter with the key in the into the mower plug fully firmly.
Refer page 14 for full air filter service details. Battery Charging The Battery Charger supplied with this mower, Model WMCH12 is for charging the ES99 Sealed 12V dc, 4.5A/h lead acid battery ONLY. • Do Not attempt to use this battery charger for Non...
Engine tipping DO NOT remove the blade mount drive from the motor spindle. When cleaning, or performing any maintenance such as Should the blade mount drive replacing the blades, it is very important that the mower detach or slide off the motor is only tipped backwards.
Note. Use a wooden block to stop the blade from turning. down with your thumbs to The blades should be tightened fully but check to ensure remove the air filter (14) cover. they can still swing back if they were to hit a solid object. Be careful to avoid dust and debris falling into the bottom If you do not have a torque wrench ask a mower service...
Transporting insulator is cracked or chipped. 3. Check that the end of the spark CAUTION. If the engine must be tipped to transport plug is not blackened by carbon equipment or to inspect or remove grass, keep the spark build up. Clean with a soft wire plug upwards.
Storage • When you finish working, clean the engine completely, making sure there is no grass or dirt on the engine. • Store the engine away from direct sunlight. • At the end of the season, give the engine an overall cleaning and a thorough check.
Need help?
Do you have a question about the ES99 and is the answer not in the manual?
Questions and answers