Page 1 PIONEER CORPORATION 4-1, Meguro 1-chome, Meguro-ku, Tokyo 153-8654, Japan PIONEER ELECTRONICS (USA) INC. P.O. Box 1760, Long Beach, CA 90801-1760, U.S.A. PIONEER EUROPE NV Haven 1087, Keetberglaan 1, 9120 Melsele, Belgium PIONEER ELECTRONICS ASIACENTRE PTE. LTD. 253 Alexandra Road, #04-01, Singapore 159936 PIONEER CORPORATION 2008 K-ZZY.
Page 2: Safety Information
Caution: 1. During repair or tests, minimum distance of 13 cm from the focus lens must be kept. 2. During repair or tests, do not view laser beam for 10 seconds or longer . DVH-P5000UB/XN/EW5...
Page 3 CAUTION Danger of explosion if battery is incorrectly replaced. Replaced only with the same or equivalent type recommended by the manufacture. Discord used batteries according to the manufacture's instructions. DVH-P5000UB/XN/EW5...
Page 4 To protect products from damages or failures during transit, the shipping mode should be set or the shipping screws should be installed before shipment. Please be sure to follow this method especially if it is specified in this manual. DVH-P5000UB/XN/EW5...
Page 5: Table Of Contents
10.6 COMPOUND UNIT(A) AND COMPOUND UNIT(B) ................100 10.7 WAVEFORMS............................101 11. PCB CONNECTION DIAGRAM ........................104 11.1 TUNER AMP UNIT ..........................104 11.2 KEYBOARD UNIT..........................108 11.3 PANEL UNIT ............................109 11.4 DVD CORE UNIT..........................110 11.5 COMPOUND UNIT(A) AND COMPOUND UNIT(B) ................114 12. ELECTRICAL PARTS LIST......................... 115 DVH-P5000UB/XN/EW5...
Page 6: Service Precautions
Compared with eutectic solders, lead-free solders have higher bond strengths but slower wetting times and higher melting temperatures (hard to melt/easy to harden). The following lead-free solders are available as service parts: Parts numbers of lead-free solder: GYP1006 1.0 in dia. GYP1007 0.6 in dia. GYP1008 0.3 in dia. DVH-P5000UB/XN/EW5...
Page 7: Specifications
WAV signal format ....Linear PCM & MS ADPCM Slope ....... –12 dB/oct (Non-compressed) Subwoofer (mono): Frequency ......50/63/80/100/125 Hz FM tuner Slope ........–18 dB/oct Frequency range ....87.5 MHz to 108.0 MHz Gain ........+6 dB to –24 dB DVH-P5000UB/XN/EW5...
Page 8: Disc/Content Format
Usable sensitivity....30 μV (S/N: 20 dB) Signal-to-noise ratio....65 dB (IEC-A network) Note Specifications and the design are subject to mod- ifications without notice due to improvements. 2.2 DISC/CONTENT FORMAT is a trademark of DVD Format/Logo Licensing Corporation. DVH-P5000UB/XN/EW5...
Page 9: Panel Facilities
• This button is not effective when you con- 2 MULTI-CONTROL nected a Pioneer multi-channel proces- Move to perform manual seek tuning, fast sor (DEQ-P6600) to this unit. forward, reverse and track search controls. Also used for controlling functions.
Page 10: Remote Control
Press to turn the DVD auto-playback function on or off. RETURN button Press to display the PBC (playback control) menu during PBC playback. Press to operate the preprogrammed Press to turn the bookmark BOOKMARK button functions for each source. function on or off. DVH-P5000UB/XN/EW5...
Page 11 Click the thumb pad list, folder list or file list depending on the the DVD menu. source. MENU button Press to display the DVD menu during DVD playback. TOP MENU button Press to return to the top menu during DVD playback. DVH-P5000UB/XN/EW5...
Page 12: Display Indication
DVD mode operations. 3 NEWS indicator Appears when NEWS (news program inter- ruption) function is on. 4 TA indicator Appears when TA (traffic announcement standby) function is on. 5 TP indicator Appears when a TP station is tuned in. DVH-P5000UB/XN/EW5...
Page 13 Appears when a WMA file is playing. When a lower tier folder or menu exists, d appears. (MP3) indicator Appears when an MP3 file is playing. (Video CD) indicator Appears when a video CD is playing. When a CD is playing, only is displayed. DVH-P5000UB/XN/EW5...
Page 14 CND1250 1. Attach the holders to both sides of the 3. Flip the holders into upright front panel. positions. Screw BPZ20P060FTB 2. Replace the front panel to the unit. 4. Fix the front panel to the unit using screws. DVH-P5000UB/XN/EW5...
Page 15: Connection Diagram
2.4 CONNECTION DIAGRAM DVH-P5000UB/XN/EW5...
Page 16 DVH-P5000UB/XN/EW5...
Page 17: Basic Items For Service
For check items concerning image and voice, please refer to the followings: Check items concerning image Check items concerning voice t s i o i t Distorted image (Image skip) High volume Low brig ges in level Too brig Color fading Partial discoloration DVH-P5000UB/XN/EW5...
Page 18: Pcb Locations
: Keyboard Unit Unit Number : CWN3429 Unit Name : Panel Unit Unit Number : YWX5005 Unit Name : DVD Core Unit Unit Number : CWX3595 Unit Name : Compound Unit(A) Unit Number : CWX3559 Unit Name : Compound Unit(B) DVH-P5000UB/XN/EW5...
Page 19: Jigs List
Before shipping out the product, be sure to clean the following portions by using the prescribed cleaning tools: Portions to be cleaned Cleaning tools DVD pickup lenses Cleaning liquid : GEM1004 Cleaning paper : GED-008 Portions to be cleaned Cleaning tools Fans Cleaning paper : GED-008 DVH-P5000UB/XN/EW5...
Page 20: Block Diagram
SWVDD RESET Q1105 FU1103 Q1103 ACC5V IC602 USB33 RESET VDD5V BD4835G Q103 IC1141 S-1206B33-U3 OUT2 S601 ON/OFF ACCPW Q1106 USB33 VOUT DTC1 OSDPW VDD5V D/D CONVERTER Q1104 IC1101 FU1102 KYDT Q1102 AN8011S VD8V DPDT Q1101 CSENS OUT1 VR1101 DDCONF DVH-P5000UB/XN/EW5...
Page 21 Q731 B.G.SENS B.G.SENS RDS_LOCK BGENS RDS-LOCK TELMUTE Q741 RDS_HSLK TELM TELM RDS-HSLK TELIN Q402 ACC5V RDS_DATA RDS-DATA Q311 :DVH-P5000UB/XN/EW5 RDS_CK OPT3 :DVH-P500UB/XN/RE LDET LDET AMPPW L-MOS and Gate IC311 ELECTRONIC VOLUME/ TC7SET08FUS1 SOURCE SELECTOR IPL+ POWER IN4+_L OPT2(OPTOUT) CONNECTOR IPL-...
Page 22: Dvd Core Unit
XCSM NCSM HOME MCKI TEMP VOLTAGE DETECT VIN2RF IC1003 VIN2 S-80859CNNB-B9K VIN1RF VIN1 VSENS VSENCE VIN3RF VIN3 VIN4RF EXTRG1 VIN4 SCLOCK VIN5 VIN6 SDATA EXTRG0 CDMPD DVDMPD TRCCLK TRCDATA0 RFINN TRCDATA1 F+H_G+H TRCDATA2 E+G_E+F TRCDATA3 LPCO2 LPCO1 TRCST VDD5 DVH-P5000UB/XN/EW5...
Page 23 ACO1- ACO1+ CN1101 ACO2+ ACO2- TEMP 3.3V REG. IC1007 NJM2885DL1-33 VDD5 VCC33 CDMPD 78MD PICKUP UNIT 1.2V REG. DVDMPD 65MD IC1008 (SERVICE) (DP8) R1232D121B F+H_G+H F+H/G+H E+G_E+F E+G/E+F VCC12 Q1102 Q1104 LPCO2 LD(CD) Q1101 Q1103 LPCO1 LD(DVD) VREF VCC5 DVH-P5000UB/XN/EW5...
Page 24 DVH-P5000UB/XN/EW5...
Page 25: Diagnosis
In case of the above signal, the communication Source keys with Grille microcomputer may fail. operative If the time interval is not 300 msec, the oscillator may be defective. Source ON SYSPW <- H Pin46 Completes power-on operation. (After that, proceed to each source operation) DVH-P5000UB/XN/EW5...
Page 26: Inspection Method Of Pickup Unit
Perform lens Is it OK? cleaned? cleaning Replace the PICK UP Check point: Error rate check Error rate check PICK UP Perform lens Is it OK? cleaned? cleaning Replace the PICK UP Ckeck parts Finished other than PICK UP DVH-P5000UB/XN/EW5...
Page 27 DVDLD1 VCC5_3 Status: [Foucs closed] of TEST MODE Mode: CD Disc Check Point Threshold Remarks: LD current TCD-782 CDLD1 – VCC5_3 (mV) 10 – 60(mA) CDLD1 VCC5_3 Notes: Please pay attention to the laser diode damage by static electricity. DVH-P5000UB/XN/EW5...
Page 28 Watch carefully the value of ASMAX. Error rate check Status: [Tracking Closed] of TEST MODE Disc Check Point Threshold Remarks: less than GGV1025 ID: 40000 1.000E-03 less than GGV1025 ID: 200000 1.000E-03 less than TCD-782 ID: HOME Position 2.500E-03 DVH-P5000UB/XN/EW5...
Page 29: Diagnosis Flowchart
OK? Execute check 10. Go to FE section check. Repair the defective part. Go to FE section check. Normal? FE section check. Go to FE related Is FE section repair process. normal? Replace the unit. Normal? DVH-P5000UB/XN/EW5...
Page 30 <Check> Check the voltage at the “STANBY” test point while the power is on. Use the “DGND1” test point at the reference. Specification value Check point Module No. Unit STANBY-DGND1 VCC33 V- 0.6 V or more Side A DGND1 STANBY Fig 1.1: STANBY check point DVH-P5000UB/XN/EW5...
Page 31 Specification value Check point Module No. Unit VDD5_3 - DGND1 5.0 ± 0.4 VCC33_3 - DGND1 3.3 ± 0.15 VCC12_1 - DGND1 1.2 ± 0.12 Side A VDD5_3 VCC33 DGND1 VCC12_1 Fig 2.2: VDD5, VCC33, VCC12 voltage check points DVH-P5000UB/XN/EW5...
Page 32 <Check> Check the voltage at the “XRES” test point while the power is on. Use the “DGND1” test point at the reference. Check point Module No. Specification value Unit 1 XRES-DGND1 VCC33 × 0.7 or more Side A DGND1 XRES Fig 3.1: RESET check point DVH-P5000UB/XN/EW5...
Page 33 <Check> Check the voltage at the “VSENS” test point while the power is on. Use the “DGND1” test point at the reference. Specification value Check point Module No. Unit VSENS - DGND1 VCC33 × 0.7 or more Side A DGND1 VSENS Fig 4.2: VSENS check point DVH-P5000UB/XN/EW5...
Page 34 Specification value Check point Module No. Unit 27 MHz 2 IC1501 169pin ± 50 ppm Specification value Fig 5.2: Clock specification value Side A DGND1 IC1501 169pin Fig 5.3: 27 MHz check point DVH-P5000UB/XN/EW5...
Page 35 Be careful as XCSM, XWE, XCAS, XRAS and XSCM of IC1481 are called differently in IC1501, namely NCSM, NWE, NCAS, NRAS, NCSM. IC1501 MA0~11 1481 DVD-LSI MDQ0~31 SDRAM XWE (NWE) XCAS (NCAS) XRAS (NRAS) XCSM (NCSM) DQM0 DQM1 DQM2 DQM3 Fig 6.1: SDRAM I/F DVH-P5000UB/XN/EW5...
Page 36 DQM1 IC1481 28pin IC1501 26pin DQM2 56 ohm ± 5 % DQM3 IC1481 59pin IC1501 27pin 56 ohm ± 5 % IC1481 22pin IC1501 8pin 56 ohm ± 5 % IC1481 23pin IC1501 10pin 56 ohm ± 5 % DVH-P5000UB/XN/EW5...
Page 37 Side B Check point 1 (IC1481) Side A Check point 2 (IC1501) Fig 6.2: SDRAM I/F check point DVH-P5000UB/XN/EW5...
Page 38 Use the “PGND3 and AGND1” test point at the reference. Check point Module No. Specification value Unit VD8_1 - PGND3 8.0 ± 0.4 VD - PGND3 8.0 ± 0.4 VCC5_1- AGND1 5.0 ± 0.1 Side A VD8_1 AGND1 PGND3 VCC5_1 Fig 7.2: VD8, VCC5 voltage check points DVH-P5000UB/XN/EW5...
Page 39 Check with PGND and GNDAU being the reference. Check point Module No. Specification value Unit VD - PGND_3 8.0 ± 0.4 AVCC5 - GNDAU1 5.0 ± 0.1 Side A PGND3 GNDAU AVCC5 Fig 8.2: VD8, AVCC5 voltage check points DVH-P5000UB/XN/EW5...
Page 40 2.0 V~VCC33 V DGND~0.8 V 33.8688 MHz±300 ppm Specification value 1 Specification Specification value 2 value 3 Fig 9.2: Clock specification value Side A Check point 2 (IC1501 172 pin) Check point 1 (stylus) Fig 9.3: 27 MHz, DACCLK check point DVH-P5000UB/XN/EW5...
Page 41 Waveform 2 LRCK VCC33 V-0.6 V or higher 0.4 V or lower Waveform 3 Specification value 2 Specification value 1 Fig 10.2: Serial 3 lines specification value Side A SRCK LRCK ADOUT3 Fig 10.3: Serial 3 lines check points DVH-P5000UB/XN/EW5...
Page 42 1 400 ± 150 mV Waveform 4 1 400 ± 150 mV Waveform 4 Specification value is the root-mean-square value (rms). Fig 10.4: Analog audio out (LO, RO) specification value. Side A GNDAU1 Fig 10.5: Analog audio out check point DVH-P5000UB/XN/EW5...
Page 43 Check 2pin cord after connecting it to a jig, etc. Specification value 2 Check point 1 (stylus) Specification value 1 Reference waveform 6 IEC VCC33 V-0.6 V or higher 0.4 V or lower Waveform 5 Side A Fig 10.6: Digital audio signal (IECOUT) check point DVH-P5000UB/XN/EW5...
Page 44 ADOUT2 CLDCK AD3/DATA ADOUT3 DATA IEC/IPFLG IPFLG SBCK SBCK BMUTE BMUTE MCKENA High RIPP High EMPH EMPH EMPH Pins 1, 6, 8, 10, 12, 14, 16, 18, 20, 22 and 24 are GNDD. Fig 10.7: 6ch digital out/Ripping circuit DVH-P5000UB/XN/EW5...
Page 45 VCC33 V-0.6 V or higher 0.4 V or lower SBCK VCC33 V-0.6 V or higher 0.4 V or lower RIPP VCC33 V x 0.3 V or lower Specification value 1 Specification value 2 Fig 10.8: 6ch digital out/Ripping specification value DVH-P5000UB/XN/EW5...
Page 46 Side A SRCK LRCK ADOUT3 Side B ADOUT2 ADOUT1 ADOUT0 RIPP MCKENA SBCK Fig 10.9: 6ch digital out/Ripping check point DVH-P5000UB/XN/EW5...
Page 47 Turn the volume (VR1671) to adjust the video level within the range of 1.0 ± 0.02 Vpp. The adjustment specification is 1.0 ± 0.02 Vpp. CN1901 AVCC5 HOST I/F IC1501 Q1701(NoMount) Video buffer circuit Video Q1702(NoMount) Video buffer circuit section Q1704(NoMount) Video buffer circuit Fig 11.3: Video circuit (component) DVH-P5000UB/XN/EW5...
Page 48 Specification value BOTTOM PEAK Cb signal Specification value BOTTOM PEAK Cr signal Specification value BOTTOM 100% Color Bars signal Fig 11.4 Waveform for the case of component 100% Color Bars output Side A COMPO Fig 11.5: VIDEO signal check point DVH-P5000UB/XN/EW5...
Page 49 (Refer to the FE test mode for the method of displaying the LD energizing time.) 2.If the second digit from the left of the energizing time display is showing E, such as “ E ”, it means that the flash memory has reached its life. Example: 0E000BB8 DVH-P5000UB/XN/EW5...
Page 50 Reference voltage: DGND2 1 V/div. 500 nsec/div Waveform 7 G-> G-> Waveform 2 Waveform 5 [WHITE 100IRE] CH1 : LRCK CH1 : COMPO Reference voltage: GNDV1 200 mV/div. 10 usec/div Reference voltage: DGND2 1 V/div. 5 usec/div G-> Waveform 3 Waveform 6 DVH-P5000UB/XN/EW5...
Page 51: Error Code List
*5 AWM (Audio WaterMark): Electronic watermark. Information on the copyright owner or CCI (copy control information) are recorded so that illegally copied discs can be identified. *6 Notice as an error status will not be given *7 CPRM(Content Protection for Recordable Media) : A copyright protection technique for digital contents used for re-writable DVD or memory card. (DVD-VR model only) DVH-P5000UB/XN/EW5...
Page 52 Disconnect the USB device, and connect it again. ERROR-19 Communication failure Change to a different source. Then, return to the USB. USB device is not formatted with FAT16 or ERROR-23 Format the USB device with FAT16 or FAT32. FAT32 DVH-P5000UB/XN/EW5...
Page 53: Connector Function Description
5.5 CONNECTOR FUNCTION DESCRIPTION DVH-P5000UB/XN/EW5...
Page 54: Service Mode
RDM+EQ System version display When System version is displayed, the PD number, the system microcomputer version, and the CWW number is displayed. Example) For PEG123A VER1.05 CWW1111 1 2 3 A 1 0 5 C 1 1 1 1 DVH-P5000UB/XN/EW5...
Page 55: Dvd Test Mode
In order to F close after focus search (S character measurement mode), set to Power_OFF first then power on again FEMIN level before F close. ASMAX level ENVMAX level FE normalization coefficient Spindle gain coefficient TEMAX level indication TEMIN level indication DVH-P5000UB/XN/EW5...
Page 56 Designation of digit by command (1) and (2). UP/DOWN of numbers by command (3) and (4). Fix by command (5). Error occurrence at Power_OFF [Note] If an error occurs at Power_OFF, reset cannot be made. In such a case, it is necessary to turn the power off and start the test mode once again. Error display DVH-P5000UB/XN/EW5...
Page 57 [Note] If the power on time is 999999 hours or more, it is always reported as 999999 hours. [Note] If the power on time is “*E** ****”, the value may not be correct due to the life of the flash memory. DVH-P5000UB/XN/EW5...
Page 58: Disassembly
Remove the two screws.(Fig.6) Remove the Holder and then remove the Panel Unit.(Fig.7) Fig.6 Panel Unit Fig.7 Removing the DVD Mechanism Module (Fig.8) Remove the four screws. Disconnect the cable and then remove the DVD Mechanism Module. Fig.8 DVD Mechanism Module DVH-P5000UB/XN/EW5...
Page 59 Removing the Tuner Amp Unit (Fig.9,10) Holder Remove the screw and then remove the Holder.(Fig.9) Fig.9 Tuner Amp Unit Remove the two screws.(Fig.10) Straighten the tabs at three locations indicated and then remove the Tuner Amp Unit. (Fig.10) Fig.10 DVH-P5000UB/XN/EW5...
Page 60 While the photograph shown is slightly different from this model in shape, the disassembly procedure is the same. There are six hooks to remove. The hook in six places in total is removed by the thin one such as tweezers. * The hook breaks when forcibly removing. DVH-P5000UB/XN/EW5...
Page 61 7. Disconnect the connector of the 8-12 detection flexible PCB from the PCB. Fig 2 Module PCB Short Connector Connector (8-12 detection flexible) (pick up flexible) Solder land (load motor, lead wire of the clamp SW.) Connector (SPDL flexible) Fig 3 DVH-P5000UB/XN/EW5...
Page 62 Furthermore, make sure to hang the main shaft holding spring permanently. Holding plate spring Main shaft PU unit Main shaft holding spring Sub shaft Fig 5 CRG chassis temporary hanging section Temporary hanging Permanent hanging DVH-P5000UB/XN/EW5...
Page 63: Each Setting And Adjustment
Attention) Test mode starting procedure ACC + Back up OFF-ON while pressing the RDM and LIST keys together. Test mode stopping procedure Reset or ACC OFF-ON. DVH-P5000UB/XN/EW5...
Page 64 Oscilloscope Symptom in case the adjustment is not adequate: Worsening of the error rate 10 (Normally 10 or less.) Large RF jitter RF waveform distortion Tracking drawing/Unstable servo * Caution: Do not look into the laser light during adjustment. DVH-P5000UB/XN/EW5...
Page 65 Referring to the connection diagram, connect an oscilloscope so that RF signal can be monitored using AGND2 as the reference. AGND2 Oscilloscope In case of method 2: There is no need for setting equipment. Please go on to step 3. DVH-P5000UB/XN/EW5...
Page 66 8. In case of method 1: Please go on to step 9. In case of method 2: Perform all automatic adjustments after Tracking Open once, and then close the tracking with the command that is available for RF display. DVH-P5000UB/XN/EW5...
Page 67 * If the error rate does not fall within the abovementioned range by method 2, start over by method 1. 10. In FE Test Mode screen, after confirming the disc is stopped by Power OFF, eject the disc by Disc Eject. DVH-P5000UB/XN/EW5...
Page 68 Screw locking adhesive location(1401M : produced by THREE BOND) Screw locking adhesive location Apply the locking agent for more than half of the screw head circumference. * Caution: The locking agent shall not overflow to outside of the PU case. DVH-P5000UB/XN/EW5...
Page 69 Precautions in handling the PU. * Caution: Do not touch the shaded section in the drawing below. RF level adjustment section Do not touch the optical parts. Do not touch the springs. Hologram (be careful for the static electricity) GRT adjustment section DVH-P5000UB/XN/EW5...
Page 70: Tuner Amp Unit Adjustment
8.2 TUNER AMP UNIT ADJUSTMENT • Adjustment Point +14.4 V BACK UP DC Regulated Power Supply TUNER AMP UNIT(SIDE A) CORD ASSY CN751 VIDEO CN281 VR571 TC501 IC504 CN101 IC601 IC1101 VR1101 TUNER AMP UNIT(SIDE B) GND1 VOUT DD8V DD5V DVH-P5000UB/XN/EW5...
Page 71 Adjustment Remarks at adjustment point TUNER Source plate of Adjust to bring the source TC501 Adjust by displaying TUNER plate to the screen center. such as on AVX-7650. Adjusted by TC501 Source plate Circumference of monitor liquid crystal AVX-7650 DVH-P5000UB/XN/EW5...
Page 72: Pcl Output Confirmation
The frequency of the clock signal is 468.750 KHz that is one 32th of the fundamental frequency. The clock signal should be 468.750 kHz ( ± 19 Hz). If the clock signal out of the range, the X’tal (X601) should be replaced with new one. DVH-P5000UB/XN/EW5...
Page 73 DVH-P5000UB/XN/EW5...
Page 74: Exploded Views And Parts List
Screw adjacent to mark on the product are used for disassembly. For the applying amount of lubricants or glue, follow the instructions in this manual. (In the case of no amount instructions,apply as you think it appropriate.) 9.1 PACKING DVH-P5000UB/XN/EW5...
Page 75 Holder(L) CND2699 Remote Control Assy CXC7605 Handle CND3707 Case Assy QXA3049 Bush CNV3930 (2) CONTRAST TABLE DVH-P5000UB/XN/EW5 and DVH-P500UB/XN/RE are constructed the same except for the following: Mark Description DVH-P5000UB/XN/EW5 DVH-P500UB/XN/RE Unit Box CHG6511 CHG6512 Contain Box CHL6511 CHL6512 24-2...
Page 76: Exterior(1)
9.2 EXTERIOR(1) DVH-P5000UB/XN/EW5...
Page 77 Button (SRC, DISP, BAND, MUTE) CAI1763 Button (RDM, EQ) CAI1765 Remote IC(IC2102) GP1UX51RK Resistor RSV2PMF102J Button (COMP) CAI1770 (2) CONTRAST TABLE DVH-P5000UB/XN/EW5 and DVH-P500UB/XN/RE are constructed the same except for the following: Mark Description DVH-P5000UB/XN/EW5 DVH-P500UB/XN/RE Detach Grille Assy CXC9035 CXC9036 Grille Unit CXC9123...
Page 78: Exterior(2)
9.3 EXTERIOR(2) DVH-P5000UB/XN/EW5...
Page 79 Connector(CN1301) CKS5967 Holder CND3893 Wrapping Terminal (JH1301) CKF-047 Holder CND4386 Insulator CNN2307 (2) CONTRAST TABLE DVH-P5000UB/XN/EW5 and DVH-P500UB/XN/RE are constructed the same except for the following: Mark Description DVH-P5000UB/XN/EW5 DVH-P500UB/XN/RE Label CAN5448 Not used Chassis CNA3053 CNA3054 Tuner Amp Unit...
Page 80: Dvd Mechanism Module
9.4 DVD MECHANISM MODULE (A) : GEM1045 (B) : GEM1043 (C) : GEM1024 (D) : GEM1050 DVH-P5000UB/XN/EW5...
Page 81 CNC9933 Motor(SPDL)(M3) CXM1362 Holder CND2643 Screw JFZ20P018FTC Frame CND2250 Washer YE20FTC Holder CND2251 Pickup Unit(Service) CXX2118 Screw IMS20P030FTC Holder CND3936 Sheet CNM6883 Collar CNV9570 Sheet CNM8697 Shaft CLA4771 Sheet CNM9658 Sheet CNM9407 CNV7156 Clamper CNV7158 Roller CNV7165 Rack CNV7175 DVH-P5000UB/XN/EW5...
Page 82: Schematic Diagram
KYDT FM_ANT EJSW R705 ROT1 Q702 DTC114EUA RF_GND SWVDD5 DGND RFGND L401 5.0V AM_ANT CSENS R706 ILM+B EJECT FLPILM MANT CN402 L701 SWVDD ILMGND SWVDD JOYST ILMGND JOYST R707 RFGND ILMGND ILMGND PANEL UNIT TUND RFGND ILMGND ILMGND ILMGND DVH-P5000UB/XN/EW5...
Page 83 VGND VGND B.GEAR SENSE FLPILM BGSENS Q701 D731 R733 R734 L731 R710 2SA1576A UDZS6R8(B) R709 TELMUTE (3216 1/4W) ACC5V R742 Q702 DTC114EUA Q741 D741 4R7K R743 L741 TUNER:+24.1dBs 2SA1576A R744 4R7K IP-BUS:+36.3dBs TELIN CD/DVD:+36.2dBs DAN202U USB:+35.7dBs ILMGND AUX:+36.3dBs BACK DVH-P5000UB/XN/EW5...
Page 84 DVH-P5000UB/XN/EW5...
Page 85 DVH-P5000UB/XN/EW5...
Page 86 CN1901 CD/DVD:+5.1dBs DVH-P5000UB/XN/EW5...
Page 87 CN2101 IP-BUS:+2.2dBs .1dBs DVH-P5000UB/XN/EW5...
Page 88: Tuner Amp Unit (Power Supply)
RT1P241M-11 R1301 MSVDD USBGND R1302 5.0V USBGND R1412 ACC5V C1301 VDCONT C1302 JH1301 USBGND DDCONF ACCPW MSVD8 D1301 MALS068X IC1402 8.0V C1405 341S2159 D1302 MALS068X Ver2.0B CN1301 USBGND VDCONT C1402 IPOD CP 1301~1400 USBGND 1401 1500 R1405 USB:+0.6dBs 2R7K DVH-P5000UB/XN/EW5...
Page 89 R1112 C1106 R1153 VDCONT Q1152 R001 4R7K 2SC4081 R1116 5R6K R1108 R1110 R1152 220K 5R6K Q1106 C1108 R1118 ACC5V 2200P DDCONF ACCPW IC1161 BA00DD0WHFP MSVD8 IMH1A 8.0V R1161 VDCONT : The power supply is shown with the marked box. DVH-P5000UB/XN/EW5...
Page 90: Keyboard Unit
SEG14 SEG06 SEG5 SEG05 SEG4 SEG04 SEG3 SEG03 SEG2 DGND SEG02 SEG1 DGND SEG01 SEG0 SEG00 IC2102 COM0 R2106 COM00 COM1 COM01 COM2 COM02 SWVDD COM3 COM03 R2105 GP1UX51RK C2117 DISP KDT1 DGND BAND MUTE KDT2 COMP LIST KDT3 DVH-P5000UB/XN/EW5...
Page 91 CL-197HB1-D(CDE) CL-195SR-CD D2119 D2120 R2131 R2132 CL-197HB1-D(CDE) CL-195SR-CD IC2102 D2111 D2113 R2123 CL-195SR-CD D2121 D2123 R2133 R2134 CL-197HB1-D(CDE) ILBKGND CL-195SR-CD CL-195SR-CD CL-197HB1-D(CDE) D2112 D2114 D2122 D2124 R2124 R2135 R2136 GP1UX51RK CL-197HB1-D(CDE) CL-195SR-CD CL-195SR-CD ILBKGND BLUE ILM RED ILM ILBKGND DVH-P5000UB/XN/EW5...
Page 92: Dvd Core Unit (1/2) (Guide Page)
10.4 DVD CORE UNIT (1/2) (GUIDE PAGE) RF SIGNAL FOCUS SERVO LINE TRACKING SERVO LINE CARRIAGE SERVO LINE SPINDLE SERVO LINE CWW1465 DVH-P5000UB/XN/EW5...
Page 93 DVD CORE UNIT (1/2) M2,M3 CWW1466 DVH-P5000UB/XN/EW5...
Page 94 DVH-P5000UB/XN/EW5...
Page 95 DVH-P5000UB/XN/EW5...
Page 96 DVH-P5000UB/XN/EW5...
Page 97 DVH-P5000UB/XN/EW5...
Page 98: Dvd Core Unit (2/2)
10.5 DVD CORE UNIT (2/2) CN311 DVH-P5000UB/XN/EW5...
Page 99 DVD CORE UNIT (2/2) CN101 DVH-P5000UB/XN/EW5...
Page 100: Compound Unit(A) And Compound Unit(B)
10.6 COMPOUND UNIT(A) AND COMPOUND UNIT(B) COMPOUND UNIT(A) Q1299 R1298 R1299 CPT231SCTD S1205 CSN1070 CN1301 DISC SENS DISC SENS S1203 CSN1069 CSN1070 S1204 S1202 CSN1069 12cm S1201 CSN1069 COMPOUND UNIT(B) CLAMP CSN1067 DVH-P5000UB/XN/EW5...
Page 101: Waveforms
0.2 V/div(AC) 50 ns/div Inner peripheral Peripheral DVDRF(x 1.3 ZCAV) DVDRF(x 5 CAV DVDRF(x 5 CAV 2TD1 2TD1 0.5 V/div 100 us/div 0.1 V/div 100 us/div 0.1 V/div 100 us/div DVDRF(BD1 mm) Interval FWD Interval REV 2.2 V VHALF VHALF DVH-P5000UB/XN/EW5...
Page 102 B + -B - 4CH2 Play TD Focus Close ID search Inside t Outside VHALF VHALF 5FD1 5FD1 5FD1 0.5 V/div 20 ms/div 0.5 V/div 500 us/div 0.5 V/div 500 us/div Play FD Focus Jump L0tL1 Focus Jump L1tL0 VHALF VHALF VHALF DVH-P5000UB/XN/EW5...
Page 103 DVH-P5000UB/XN/EW5...
Page 104: Pcb Connection Diagram
C1112 R1152 C1102 C1117 R1105 C1113 R1101 L1102 C1104 Q1152 C1111 IC1101 R1153 R1132 C1119 C1121 R1102 Q1101 C1103 L1103 FU1103 L1101 R1103 R1121 VR1101 C1115 D1106 Q1103 DETACH Q1105 FU1101 S701 R1125 RESET R1127 D1105 S601 D1103 FRONT DVH-P5000UB/XN/EW5...
Page 105 D1052 C1144 D1102 D1051 Q1052 C1052 C1053 R1073 C1051 C1072 C1054 R1101 R626 R1074 R1051 R1072 R1132 C1101 C1071 Q1071 R1071 Q1051 Q1061 C1061 R1063 D709 D708 R644 L701 BZ601 FU1101 C701 CN1971 CN701 C702 ESET C703 S601 FRONT DVH-P5000UB/XN/EW5...
Page 106 R1231 IC1202 R666 R1232 C1226 R677 R635 R1221 C1207 R661 R1414 R614 R660 R1413 D1201 R616 R1052 D1141 R1053 C1141 IC1141 D1142 R1141 C1142 Q1072 D1071 R1062 C1062 C1143 C1122 R1061 C1073 R710 R702 R709 R708 R704 Q701 Q702 DVH-P5000UB/XN/EW5...
Page 107 R106 C1161 R110 R109 C1163 R531 R532 R108 L532 R1161 R1163 C533 IC1161 IC532 R1162 IC533 C1108 R1110 C1110 R1108 R1112 C1106 R1120 R1116 R1114 R1128 R1106 C1141 R1129 R1113 C1122 R1115 R1119 R1109 R1107 R1111 C1105 C1109 C1107 DVH-P5000UB/XN/EW5...
Page 108: Keyboard Unit
11.2 KEYBOARD UNIT KEYBOARD UNIT SIDE A KEYBOARD UNIT SIDE B R2137 CN1972 C2107 D2107 D2117 DVH-P5000UB/XN/EW5...
Page 109: Panel Unit
11.3 PANEL UNIT PANEL UNIT SIDE A CN2101 S1970 EJECT CN1972 D1970 PANEL UNIT SIDE B D1972 D1974 C1971 CN1971 D1971 D1975 R1970 R1971 D1977 D1976 C1970 R1974 D1973 CN701 DVH-P5000UB/XN/EW5...
Page 110: Dvd Core Unit
11.4 DVD CORE UNIT DVD CORE UNIT PICKUP UNIT (SERVICE) M2, M3 CN311 DVH-P5000UB/XN/EW5...
Page 111 SIDE A CN101 UNIT DVH-P5000UB/XN/EW5...
Page 112 DVD CORE UNIT DVH-P5000UB/XN/EW5...
Page 113 SIDE B DVH-P5000UB/XN/EW5...
Page 114: Compound Unit(A) And Compound Unit(B)
11.5 COMPOUND UNIT(A) AND COMPOUND UNIT(B) COMPOUND UNIT(A) COMPOUND UNIT(B) Q1299 R1298 CLAMP R1299 S1205 S1204 DISC SENS S1203 DISC SENS S1202 12cm S1201 CN1301 DVH-P5000UB/XN/EW5...
Page 115: Electrical Parts List
PML018A Q 711 (B,144,102) Transistor IMX1 IC 251 (A,88,133) IC PAL007C Q 731 (B,143,110) Transistor 2SC4081 IC 311 (A,143,125) L-MOS And Gate TC7SET08FUS1 Q 741 (B,146,112) Chip Transistor 2SA1576A IC 401 (B,145,86) IC NJM2794RB2 Q 1031 (A,9,88) Transistor 2SD2396 DVH-P5000UB/XN/EW5...
Page 116 (A,59,7) Diode 1SS355 (A,11,43) Fuse 750 mA CEK1279 D 1104 (A,58,33) Diode 1SS355 JH1301 (A,18,59) Terminal CKF-047 D 1105 (A,39,10) Diode RSX201L-30 BZ601 (A,140,10) Buzzer CPV1062 D 1107 (A,39,37) Diode RSX201L-30 FM/AM Tuner Unit CWE2097 D 1141 (B,97,30) Diode 1SR154-400 DVH-P5000UB/XN/EW5...
Page 117 R 287 (A,38,124) RS1/16S223J R 574 (B,36,83) RS1/16S471J R 288 (A,50,124) RS1/16S223J R 575 (B,37,85) RS1/16S102J R 289 (A,42,124) RS1/16S223J R 577 (A,43,84) RS1/16S152J R 290 (A,53,126) RS1/16S223J R 578 (B,34,83) RS1/16S471J R 291 (A,31,126) RS1/16S223J R 591 (B,32,83) RS1/16S101J DVH-P5000UB/XN/EW5...
Page 118 R 650 (A,147,74) RS1/16S102J R 1051 (A,142,25) RS1/16S223J R 651 (A,145,74) RS1/16S102J R 1052 (B,151,31) RS1/4SA821J R 652 (B,159,52) RS1/16S102J R 1053 (B,153,31) RS1/4SA390J R 653 (A,144,42) RS1/16S0R0J R 1061 (B,133,21) RS1/16S222J R 654 (A,166,64) RS1/16S473J R 1062 (B,140,21) RS1/16S103J DVH-P5000UB/XN/EW5...
Page 119 C 208 (A,50,107) CKSQYB225K10 R 1209 (B,124,46) RS1/16S154J C 209 (B,50,95) CKSQYB225K10 R 1210 (A,124,53) RS1/16S473J R 1211 (A,126,72) RS1/16S0R0J C 210 (B,51,112) CKSQYB225K10 C 211 (B,52,96) CKSRYB224K16 R 1213 (A,121,55) RS1/16S473J C 212 (B,53,111) CKSRYB224K16 R 1214 (B,124,43) RS1/16S221J DVH-P5000UB/XN/EW5...
Page 120 C 418 (B,133,86) CKSRYB104K16 C 1052 (A,134,27) CEVW101M10 C 419 (B,135,86) CKSYB106K10 C 1053 (A,142,27) CKSRYB103K50 C 420 (B,138,85) CKSQYB225K10 C 1054 (A,159,24) CEAT102M16(P45) C 504 (B,76,73) CKSRYB104K16 C 1062 (B,131,21) CKSRYB102K50 C 505 (B,72,75) CCSRCH7R0D50 C 1071 (A,119,22) CEVW1R0M50 DVH-P5000UB/XN/EW5...
Page 121 R 2108 (B,44,16) RS1/16S103J C 1302 (A,121,45) CKSRYB104K16 R 2109 (B,133,16) RS1/16S102J C 1304 (A,127,54) CKSRYB103K50 R 2111 (B,66,24) RS1/16S272J C 1402 (A,126,69) CKSRYB104K16 R 2114 (B,130,16) RS1/16S102J C 1405 (B,123,74) CKSRYB104K16 R 2115 (B,148,23) RS1/16S102J R 2116 (B,150,23) RS1/16S102J DVH-P5000UB/XN/EW5...
Page 122 IC 1352 (B,79,13) IC TC74LCX16373FT R 1117 (B,64,49) RS1/16SS104J IC 1401 (B,61,32) Flash ROM Unit CWW1465 R 1118 (B,70,49) RS1/16SS104J R 1202 (A,19,12) RS1/16SS221J *IC1402 (B,37,10) Flash ROM Unit CWW1466 IC 1403 (B,47,29) IC TC7SZ32FU R 1203 (A,19,11) RS1/16SS221J DVH-P5000UB/XN/EW5...
Page 123 R 1520 (A,35,8) RS1/16SS221J R 1715 (A,60,56) RS1/16SS201J R 1521 (A,41,11) RAB4CQ101J R 1716 (A,62,57) RS1/16SS101J R 1522 (B,56,3) RAB4CQ560J R 1719 (A,60,50) RS1/16SS201J R 1523 (A,39,11) RS1/16SS101J R 1720 (A,62,51) RS1/16SS101J R 1524 (A,39,12) RS1/16SS101J R 1803 (A,72,56) RS1/16SS821J DVH-P5000UB/XN/EW5...
Page 124 C 1405 (B,48,8) CKSSYB103K16 C 1603 (A,37,23) CCSSCH680J50 C 1406 (B,25,15) CKSSYB104K10 C 1604 (A,39,25) CCSSCH680J50 C 1407 (B,74,27) CKSQYB475K6R3 C 1608 (A,41,26) CKSSYB103K16 C 1408 (B,47,27) CKSSYB104K10 C 1609 (A,43,26) CKSSYB103K16 C 1481 (B,72,5) CKSSYB104K10 C 1610 (A,53,39) CCSSCH101J50 DVH-P5000UB/XN/EW5...
Page 125 S 1203 Spring Switch(DISC SENS) CSN1069 S 1204 Spring Switch(DISC SENS) CSN1070 S 1205 Spring Switch(8cm) CSN1070 R 1298 RS1/16S0R0J R 1299 RS1/16S0R0J Unit Number : CWX3559 Unit Name : Compound Unit(B) S 1206 Switch(CLAMP) CSN1067 Miscellaneous Parts List DVH-P5000UB/XN/EW5...

This manual is also suitable for:

Dvh-p5000ubew5 Dvh-p500ub Dvh-p5000ubxn Dvh-p500ubxn Dvh-p500ubre

Pioneer DVH-P5000UB Service Manual

1 Service Precautions

2 Specifications

3 Basic Items for Service

4 Block Diagram

5 Diagnosis

6 Service Mode

7 Disassembly

8 Each Setting and Adjustment

9 Exploded Views and Parts List

10 Schematic Diagram

11 Pcb Connection Diagram

12 Electrical Parts List

Quick Links

Related Manuals for Pioneer DVH-P5000UB

Summary of Contents for Pioneer DVH-P5000UB

This manual is also suitable for:

Table of Contents