Page 1 Thank you for purchasing a quality built Grand Design recreational vehicle and choosing the RV lifestyle as a family friendly form of leisure, recreation, and fun. It is the intent of the Grand Design RV Team and our Dealer Partners to do our absolute best to assure that you enjoy a positive ownership experience and capitalize on all the exciting opportunities this “Grand”...
Page 2 This page is intentionally blank...
Page 3: Table Of Contents
Table of Contents TABLE OF CONTENTS Section Description Page Introduction .......................... 1 Reporting Safety Defects ....................... 5 Service & Warranty ....................... 7 Component Manufacturer List ....................23 Occupant Safety ........................25 Pre-Travel Information ......................41 Towing & Leveling ......................... 55 Electrical Systems ........................
Page 4 Table of Contents This page is intentionally blank Page | B...
Page 5 Website: www.granddesignrv.com OWNER’S INFORMATION PACKAGE Your new Imagine RV includes an Owner’s Information Package containing various component manufacturer manuals, and registrations. Some component manufacturers offer warranties beyond that offered through the Limited Base and Structural Warranties. Some components are excluded from the Limited Base and Structural Warranties, and are warranted separately and exclusively by the individual component manufacturer.
Page 6: Introduction
RV is listed on the Federal Certification label, and is stamped on a permanently affixed metal tag attached to the RV A-frame. A breakdown of a typical Grand Design RV VIN is shown in the example below: SAE World Identifier: 573 –...
Page 7 Introduction SAFETY PRECAUTIONS Nothing is more important than the personal safety of you, your family and others. Safety encompasses several areas related to the RV experience. This includes driving/towing safety, Various warning, caution and occupant safety, operational safety, environmental safety, and information labels are located more.
Page 8 [Customer Supplied] This denotes aftermarket items not installed or included by Grand Design RV. Items noted as “customer supplied” are not covered by the Limited Base and Structural Warranties. The inclusion of items noted as “customer supplied”...
Page 9 National Highway Traffic Safety Administration (NHTSA) in addition to notifying Grand Design RV. If NHTSA receives similar complaints, it may open an investigation, and if it finds that a safety defect exists in a group of vehicles, it may order a recall and remedy campaign.
Page 10: Reporting Safety Defects
Reporting Safety Defects This page is intentionally blank Page | 6...
Page 11 6. Service all Grand Design RV products. 7. Complete and return your “Warranty Registration and New Vehicle Pre-Delivery Inspection Check List” form within thirty (30) days from the date of delivery to Grand Design RV to activate your applicable warranty coverage. OWNER’S RESPONSIBILITIES As the owner, you are responsible for the regular care and proper maintenance of your RV.
Page 12: Service & Warranty
In the event the issue should re-occur after you have left the dealership, contact the repair center and Grand Design RV Customer Support as soon as possible, so the situation can be resolved expediently.
Page 13 Design RV does not sell parts retail direct or to non-authorized return requested original dealers. If an original part is no longer available, Grand Design RV parts may result in loss of or your dealer will try to provide an appropriate substitute. reimbursement and/or loss of warranty.
Page 14 (or any effect of the alterations) to any of the parts, components, systems, or assemblies installed by Grand Design RV. Grand Design RV is not responsible for the safety or quality of design features, materials, or workmanship of any alterations by such suppliers.
Page 15 SUMMARY What does this Warranty cover? Grand Design RV, LLC (“Warrantor”) provides this One (1) Year (“Warranty Period”) Limited Base Warranty [which begins to run from the earlier of (i) the date of purchase by the original retail consumer purchaser or (ii) when the recreational vehicle is put into service] against certain...
Page 16 Service & Warranty 3. The defective material or workmanship for which the warranty work and/or part is sought must be to the RECREATIONAL VEHICLE itself only. 4. The other terms and conditions of this Limited Warranty must be satisfied. What types of things are excluded from the Warranty? This Warranty does not cover: a.
Page 17 Service & Warranty u. Damage caused by improper ventilation resulting in excessive condensation which results in water damage and/or mold or mildew; v. Damage, fading or deterioration caused by prolonged exposure to natural elements; w. Damage caused by infestation by insects or other animals; x.
Page 18 Service & Warranty  Maintain the recreational vehicle in accordance with the maintenance requirements contained in the Owner’s Manual;  Make minor adjustments including (but limited to) doors, drawers, latches, regulators, controls, mechanisms, etc. after 90 days of ownership;  Maintain all exterior seals and sealant, which must be inspected every 6 months to assure there are no gaps or voids, and correcting as necessary;...
Page 19 Service & Warranty DISCLAIMER OF CONSEQUENTIAL, PUNITIVE AND INCIDENTAL DAMAGES What other conditions or limitations apply to this Warranty? The original retail purchaser of the recreational vehicle and any person to whom the recreational vehicle is transferred or given or conveyed, and any person who is an intended or unintended user or beneficiary of this Limited Warranty, shall not be entitled to recover from Warrantor any consequential, punitive or incidental damages resulting from any defect in the recreational...
Page 20 Limited Warranty, Purchaser (and all assigns) is agreeing on behalf of the purchaser and all assigns to be bound by the terms and conditions of this Limited Warranty. Grand Design RV, LLC 11333 County Road 2, Middlebury, IN 46540...
Page 21 SUMMARY What does this Warranty cover? Grand Design RV, LLC (“Warrantor”) provides this Three (3) Year (“Warranty Period”) Limited Structural Warranty [which begins to run from the earlier of (i) the date of purchase by the original retail consumer purchaser or (ii) when the recreational vehicle is put into service] against...
Page 22 Service & Warranty 2. The person seeking the replacement of the defective part or labor must be the original retail consumer purchaser. An assignment of the recreational vehicle to another person voids this Limited Warranty. 3. The defective material or workmanship for which the warranty work and/or part is sought must be to the STRUCTURAL COMPONENTS only.
Page 23 Service & Warranty u. Fading, yellowing or aging of exterior materials due to UV or sunlight or weather exposure; v. Damage that has occurred as a result of misuse, abuse, neglect, or lack of maintenance; w. Damage caused by unregulated water pressure, tank over-fill or plumbing system modifications resulting in flooding of the vehicle;...
Page 24 Service & Warranty vehicle for warranty service shall be borne by purchaser unless otherwise approved in advance by Warrantor. What are purchaser’s obligations? The purchaser shall give written notice to the Warrantor or an Authorized Dealer of any defect within Twenty (20) days after it is or should have been discovered, and any action to enforce it shall be commenced not more than three (3) months thereafter;...
Page 25 Service & Warranty punitive or incidental damages resulting from any defect in the recreational vehicle, or loss of use, time or revenues. This warranty also excludes costs of transportation to any authorized dealer or service representative or to the Warrantor to get warranty service, loss of use of the recreational vehicle, loss of time, loss of revenues, inconvenience, or other incidental or consequential damage and any punitive damages, with respect to business or property, whether as a result of breach of warranty, negligence, or...
Page 26 Limited Warranty, Purchaser (and all assigns) is agreeing on behalf of Purchaser and all assigns to be bound by the terms and conditions of this Limited Warranty. Grand Design RV, LLC 11333 County Road 2, Middlebury, IN 46540...
Page 27 Component Manufacturer List Page | 23...
Page 28: Component Manufacturer List
Component Manufacturer List This page is intentionally blank Page | 24...
Page 29 Occupant Safety OCCUPANT SAFETY Your RV is designed with comfort and safety as a priority. It complies with applicable codes and safety standards in effect at During severe weather the time it was built. A number of required safety items are conditions move indoors to a installed for your safety and the safety of other occupants of the place of safety or shelter as...
Page 30: Occupant Safety
Occupant Safety change with little or no warning. Earthquakes, hail, flooding, hurricanes, wintry weather, tornadoes - these and other extreme weather conditions can threaten your safety and damage your tow vehicle or RV. Local radio and TV stations normally broadcast weather Familiarize yourself with the conditions and warnings as they occur.
Page 31 Occupant Safety Maintenance Occasionally open the windows to prevent the seals from sticking. The egress window must be locked during transit. FIRE SAFETY If you feel a fire was caused by If a fire starts, execute your family safety plan. Make sure product failure, contact Grand everyone knows to stop, drop to the ground and roll back and Design RV Customer Support at...
Page 32: Smoke Alarm
Occupant Safety The factory-installed dry chemical fire extinguisher, suitable for extinguishing small fires of the Class B and Class C type, is located near the entry door. Operation Keep your back to a clear exit when you use the fire extinguisher so you can make an easy escape if the fire cannot be controlled.
Page 33: Carbon Monoxide
Occupant Safety If this alarm sounds During an alarm, you will hear a loud, repeating horn pattern and the red LED will flash rapidly. If the alarm sounds and you are not testing the smoke alarm, it is warning you of a potentially dangerous situation that requires your immediate attention.
Page 34 Occupant Safety Medium exposure: dizziness, drowsiness, vomiting. Extreme exposure: unconsciousness, brain damage and death. If you are in a RV with either a CO gas is produced when any type of fuel is incompletely nearby vehicle engine burned. Potential sources of CO in and around your RV can running or the generator (if so include gas or diesel engine exhaust, portable space heaters, gas equipped) running there is a...
Page 35 Occupant Safety Batteries The CO alarm will not function if the batteries are missing, disconnected, dead, the wrong type of battery is used or the batteries are installed incorrectly. When the batteries become weak, the CO alarm will "beep" (the low battery warning). If the low battery warning sounds, the batteries MUST be replaced.
Page 36 Occupant Safety 4. Do not touch any electrical switch or use any phone or radio in the RV. 5. Do not start any vehicle engine or generator. 6. Determine and repair the source of the leak. 7. Do not re-enter the RV until the problem is corrected. If the propane alarm keeps sounding at regular intervals, a propane leak may be present.
Page 37 Occupant Safety 3. Control mold  Clean your bathroom and kitchen often to fight mold.  Fix any water leaks.  Clean up any mold you see or smell with a mix of no more that 1 cup of bleach mixed with 1 gallon of water. Never mix bleach with ammonia.
Page 38 (MDF), and plywood which are commonly used throughout the Recreational Vehicle Industry. As mandated by the RV Industry, Grand Design RV recreation vehicles contain composite wood products (hardwood plywood, particle board, and MDF) that comply with the California Air Resource Board (CARB) formaldehyde emission standards under California Code of Regulations §...
Page 39 Occupant Safety EFFECTS OF PROLONGED OCCUPANCY Your RV was designed primarily for recreational use and extended stay use. If you expect to occupy your RV for an extended period, be prepared to deal with condensation and the If the tips presented here are not humid conditions that may be encountered.
Page 40 Occupant Safety  Manage the inside temperature during cold weather. The higher inside temperature along with colder outside temperatures will cause condensation to form on areas that are not insulated as well as others (windows, vents, wall studs, etc.).  Use a fan to keep air circulating inside the vehicle so condensation and mildew cannot form in dead air spaces.
Page 41 Grand Design RV hereby disclaims and sets forth as follows: Website disclaimer of warranty The services, information and materials on websites listed in this manual are provided 'AS IS' and Grand Design RV shall have absolutely no liability whatsoever in connection with these Page | 37...
Page 42 Grand Design RV has no control and for which Grand Design RV assumes no responsibility: Grand Design RV shall have no liability for any loss or injury caused, in whole or in part, by its actions, omissions or negligence, or for any contingencies beyond its control in procuring, compiling or delivering any information.
Page 43 Occupant Safety may be. Refer to the Tire & Wheel section of this manual for lug nut torque specifications and patterns. Always use a calibrated torque wrench to confirm proper torque. Propane Appliances & Equipment – Be sure all propane equipment &...
Page 44 Occupant Safety This page is intentionally blank Page | 40...
Page 45 If you intend to be away for more than two weeks, you may want to consider requesting police surveillance for your house. Grand Design RV disclaims any  Carry an extra set of vehicle and house keys with you on a liability with respect to damages separate key ring.
Page 46: Pre-Travel Information
Pre-Travel Information WEIGHT RATINGS & DEFINITIONS Ratings are limits established by Grand Design RV and our component manufacturers which are not to be exceeded. Exceeding a rating may result in Exceeding a rating may result in unsafe conditions, potential unsafe...
Page 47 Pre-Travel Information Tire and loading information label This label specifies the maximum amount of cargo that can be safely added to the RV. It is located on the exterior front left of the vehicle. The actual weight of the vehicle, all options, liquids, the hitch weight, and your personal cargo is important for you to know so...
Page 48 Do not store anything in the areas reserved If you have further questions, please contact your dealer or for the converter, electrical Grand Design RV Customer Service. panels or the furnace or water heater, etc. LOADING YOUR RV Store and secure all loose items inside the RV before traveling.
Page 49 Pre-Travel Information 3. Weigh the RV while attached to but excluding the tow vehicle. This will result in the actual weight that is exerted on all of the RV tires. This weight may be subtracted from the overall RV GVWR to determine the actual “tongue” weight. Total weight of your tow vehicle and RV must not exceed the 4.
Page 50 Pre-Travel Information These actions, along with other care and maintenance activities, can also:  Improve vehicle handling. Keep tires properly inflated. A  Help protect you and others from avoidable breakdowns and tire that is run long distances or accidents. at high speeds while seriously under-inflated will overheat to ...
Page 51 Pre-Travel Information Vehicle manufacturers determine this number based on the vehicle’s design load limit, that is, the greatest amount of weight a vehicle can safely carry and the vehicle’s tire size. The proper tire pressure for your vehicle is referred to as the “recommended cold inflation pressure.”...
Page 52 Pre-Travel Information TIRE SAFETY TIPS Preventing tire damage  Slow down if you have to go over a pothole or other object in the road. There is no way to tell exactly  Do not run over curbs or other foreign objects in the roadway how long a tire lasts.
Page 53 Pre-Travel Information  The last two-digit number is the wheel or rim diameter in inches. TIRE TREAD The tire tread provides the gripping action and traction that prevent your vehicle from slipping or sliding, especially when the road is wet or icy. In general, tires are not safe and should be replaced when the tread is worn down to 1/16 of an inch.
Page 54 Tires are warranted by the tire manufacturer and not by Grand Design RV. In the event that you need tire warranty assistance, please contact your dealer or refer to the tire warranty pamphlets provided with your RV for details.
Page 55 If equipped, the spare tire can be utilized in an emergency if a axle weight no longer exceeds trailer tire loses air pressure or goes flat. Certain Grand Design RV the GAWR before operating the brands may use different spare wheels than original with the unit.
Page 56 Pre-Travel Information WHEEL NUT TORQUE Torque is the amount of rotating force applied to a fastener, such as a lug nut. The axle and wheel assemblies of your RV are designed differently than those on your car. The overall size, Always torque the wheel nuts to weight and center of gravity of a RV subject the wheels to wheel...
Page 57 Pre-Travel Information 3. Place the third warning indicator 100 feet in front of the RV in the center of the lane and away from the traffic approaching from behind. The hazard-warning flasher provides additional safety if the RV is stopped on the side of the roadway and presents a possible hazard to other motorists.
Page 58 Pre-Travel Information This page is intentionally blank Page | 54...
Page 59 Towing & Leveling TOWING & LEVELING Driving safety and protection against injury cannot be fully ensured; however, we recommend you pay special attention to Do not leave children or pets the following: unsupervised in or around the RV (even if children are secured ...
Page 60: Towing & Leveling
Towing & Leveling Use caution when using the internet as a resource tool. Verify the information is from a credited and reliable source in the RV industry, and it pertains to your RV. If in doubt, contact your dealer for assistance. RV BRAKING SYSTEM The RV brakes are designed to work with your tow vehicle brakes.
Page 61 Towing & Leveling your dealer or the brake controller OEM to decide what is right for your towing combination. 7-WAY WIRE HARNESS/CONNECTOR PLUG A 7-way wire harness/connector plug is wired into your FW to Do not remove the following connect electrical power from the tow vehicle for travel. This label affixed to the A-frame: supplies power to the RV brakes, tail lights, clearance lights, turn signals, brake lights, etc.
Page 62 Towing & Leveling  Inspect the length of the chains once attached to the tow vehicle frame. They should be long enough to allow for sharp turns, but short enough so they do not drag on the ground. Slack for each length should be the same but not more than Using an oversized or undersized necessary to permit the vehicle to turn at its minimum radius.
Page 63 Towing & Leveling measurement in the box for future reference. Adjust the equalizing bars of the hitch assembly so that the tow vehicle and the RV are essentially level. A high hitch will transfer weight behind the axles and cause the RV to fishtail. A low hitch will transfer additional weight to the hitch.
Page 64 Towing & Leveling Manually crank the stabilizer jacks downwards, using the supplied crank handle, until they contact the ground firmly. Place wooden blocks under the foot pads if necessary. DO NOT overextend or retract the power tongue jack or stabilizer jacks as that could cause damage which would not be warrantable.
Page 65 Towing & Leveling TOWING THE RV You will find that your RV will travel safely and comfortably at most posted trailer highway speed limits. However, it will take Both the power tongue jack and longer than a passenger automobile to reach that speed. Keep the stabilizer jacks must be fully this in mind when overtaking and passing another vehicle.
Page 66 Towing & Leveling Turning corners When turning, the tires do not follow the path of your tow vehicle tires. The RV will make a tighter turn than the tow vehicle. You must compensate for this action by carefully pulling the tow vehicle out into the intersection further than you would normally so that the RV clears the curb (or any parked vehicles along the curb).
Page 67 Towing & Leveling Before operating the leveling system make sure: 1. The RV is parked on a reasonably level surface. 2. The towing vehicle is disengaged from the RV. Ensure that the trailer is level 3. Make sure all persons, pets and property are clear of the RV before operating the slideout while leveling checking is in progress.
Page 68 Towing & Leveling This page is intentionally blank Page | 64...
Page 69 Electrical Systems ELECTRICAL SYSTEMS The RV electrical system is comprised of two independent electrical systems. One operates off 12-volt DC power, and the Use caution when using metal other off 120-volt 60hz AC power. All installations have been tools. If a tool contacts a battery made in compliance with industry standards applicable on the terminal or metal connected to date of manufacture.
Page 70: Electrical Systems
Electrical Systems 120-VOLT CIRCUIT BREAKERS The 120-volt AC circuit breakers located inside the main load center protect all 120-volt wiring and components in the RV from Circuit breakers and fuses will circuit overloads and short circuits. Should a circuit overload or not offer complete protection of short circuit occur the circuit breaker protecting the affected the electrical system in the event...
Page 71 Electrical Systems 4. Return to your RV and turn “on” the load center main circuit breaker. 5. To help prevent power surges from damaging the connected  Do not hook up the power loads, please follow these instructions when hooking up to cord to any receptacle until the external power source.
Page 72 Electrical Systems Test all GFCI receptacles monthly • Push in the GFCI “TEST” button. The GFCI “RESET” button should pop out indicating the GFCI receptacle has been “tripped” and interrupted 120-volt power.  Push in the GFCI “RESET” button to restore 120-volt power. Contact your dealer for assistance if the GFCI “RESET”...
Page 73 Electrical Systems BATTERY DISCONNECT SWITCH There is a master battery disconnect switch located in the large, front pass-thru compartment. When the RV is not in use or storage, shut the battery disconnect switch off and disconnect on of the battery cables from the auxiliary battery terminal. Remember to reconnect the battery cable and turn the battery disconnect switch on when you are ready to use the RV or perform periodic maintenance checkups.
Page 74 Electrical Systems Replacement and maintenance Some equipment in your RV will draw small amounts of current even when turned OFF. To prevent the auxiliary battery from being discharged when your RV is not connected to shore line power, disconnect the auxiliary battery negative cable at the battery.
Page 75 Electrical Systems SOLAR PORT (IF SO EQUIPPED) The Furrion quick connect solar charging inlet is designed for use with the (customer supplied) Furrion 95W portable solar power charging system (FSPP10SA-BL). REPLACING LIGHT BULBS Before replacing a bulb, be sure the light is off. Do not touch the glass part of the new bulb with your bare fingers.
Page 76 Electrical Systems APPROXIMATE ELECTRICAL LOAD RATINGS Use actual amperage (or wattage divided by 120) of appliance being used whenever possible. 120 Volts: Labeled watts divided by 120 = power consumed in amps. *Momentary Load Page | 72...
Page 77 Plumbing Systems PLUMBING SYSTEMS There are two different water systems in your RV: the fresh water system and the waste water system. The fresh water DO NOT drink water deemed system consists of the fresh water holding tank, fresh water microbiologically unsafe or of connections, water pump, outside shower assembly (if so unknown quality.
Page 78: Plumbing Systems
Plumbing Systems 2. When pushing the “BAT” switch, the highest LED light illuminated indicates the estimated auxiliary battery condition. Water pump switch When the water pump switch is ON the water pump runs until 45 pounds of pressure has been achieved. The red light will stay ON.
Page 79 Plumbing Systems FRESH WATER CONNECTIONS There are two types of direct exterior fresh water connections in your RV: The city water fill is typically used at a campground The fresh water connection when there is access to an external, pressurized potable water should be unplugged (i.e., the source.
Page 80 Plumbing Systems Filling the fresh water tank (gravity fill only) Follow these directions to fill the fresh water tank if you are not at a campground or other facility where the RV can be hooked up to an external, pressurized water source. 1.
Page 81 Plumbing Systems WATER HEATER The water heater is designed to heat water quickly and efficiently. The water heater manufacturer has preset the sensing If you smell propane gas then limit to maintain the water temperature when the water heater STOP! Follow the procedures is activated.
Page 82 Plumbing Systems Pressure and temperature relief valve When cold water is heated in the water heater tank, the water pressure will rise. For this reason, a pressure and temperature (P&T) relief valve is required for safety in all water heaters. It is normal for the P&T relief valve to release a small quantity of water during the heating cycle and does not indicate a defective P&T relief valve.
Page 83 Plumbing Systems SPRAY PORT A quick connect spray port is available for washing or rinsing outside the RV. To use, attach one end of the quick connect hose to the spray port and attach a sprayer nozzle (customer supplied) to the other end of the quick connect hose. When the spray port is not in use, disconnect the quick connect hose and any drain excess water from the hose and sprayer nozzle.
Page 84 Plumbing Systems DRAINING THE FRESH WATER SYSTEM The low-point drains valves release water in the supply lines by opening the valves and all faucets. The water heater has its own drain plug. To drain the permanent fresh water holding tank and supply lines: 1.
Page 85 Plumbing Systems Note: as an option, several commercial solutions are available, and should be used as directed on the package. To sanitize the fresh water system, including the fresh water tank: Please read, understand and 1. Pour the chlorine/water mixture into the gravity water fill follow all instructions before inlet.
Page 86 Plumbing Systems b. Remove the three kitchen drawers from the base kitchen cabinet: Pull the drawer out until it stops. ii) Gently push and hold down the plastic drawer release clip located on the right-hand side of the drawer while - at the same time - push and hold up the plastic drawer release clip located on the left hand side of the same drawer, and iii) Continue to pull the drawer out towards you to...
Page 87 Plumbing Systems Chart 1 - Part number 961027 Sanitization and winterization label Page | 83...
Page 88 Plumbing Systems Chart 2 - Part number 961034 Sanitization and winterization label Page | 84...
Page 89 Plumbing Systems Chart 3 - Part number 961035 Sanitization and winterization label Page | 85...
Page 90 Plumbing Systems BLACK/GREY WATER SYSTEM Water from the sinks and shower flow into the grey water (or waste water) holding tank. Water from the toilet will flow into the sewage (or black water) holding tank. The weight of the holding tank contents is not calculated into the RV cargo carrying capacity (this extra weight would reduce your available cargo capacity).
Page 91 Plumbing Systems VENTS & VENT PIPES Another important part of this system is the vent pipes and vents that release air from the grey and black water holding tanks. The exterior vent cap is attached to the roof and must be kept clear of obstructions to perform as intended.
Page 92 Plumbing Systems BLACK TANK FLUSHER The black tank flusher is designed to rinse the interior of the black tank. A separate water hookup is located in the docking station. Flush the tank after dumping by: 1. Connecting the sewer hose and attaching a garden hose – not your fresh water hose –...
Page 93 Plumbing Systems Waste (grey) holding tank preparation No special preparation is required, however, placing a small quantity of chemicals into this tank, such as baking soda or an approved RV chemical, will reduce odors from food particles in the system. Cleaning and maintenance The toilet should be cleaned regularly for maximum sanitation and operational efficiency.
Page 94 Plumbing Systems This page is intentionally blank Page | 90...
Page 95 Maintenance Although both Grand Design RV and your selling dealer carefully test for leakage, travel vibrations can loosen fittings. Test the alarm operation after...
Page 96: Propane System
Propane System on this alarm; also read and follow the component manufacturer instructions supplied in your Owner Information Package. PROPANE GAS CONTAINER Never turn the 12-volt battery Propane “container” is a general all inclusive term used to disconnect control to the OFF describe a vessel that is used for storage and delivery of propane position and disconnect the gas.
Page 97 Propane System Do not remove the following label from your RV: Servicing or filling Have the RV checked for leaks at the connections on the propane system soon after the purchase and the initial filling of each propane cylinder. When you have a new cylinder filled for the first time, make sure your propane supplier purges your new cylinder of trapped air.
Page 98 Propane System Installing the propane cylinders 1. Make sure all the RV appliances are shut off. 2. Make sure each LP cylinder shut-off valve is closed. 3. Place the LP cylinders on the LP cylinder brackets or LP tray (if so equipped) located on the trailer a-frame, and secure them.
Page 99 Propane System operating pressure. The first stage reduces the container pressure to 10-13 lbs. The second stage reduces the 10-13 lbs. of pressure further to an operating pressure of 11” W.C. (water column) or 6.35 oz. of outlet pressure to your appliances. The second stage is adjustable and will need to be adjusted by your dealer or qualified propane service technician for optimum performance (this adjustment should always be made with a...
Page 100 Propane System operation: 1. Close ALL burner valves, controls and pilot light valves. 2. Open the main valve in the propane container slowly to avoid a fast rush of propane vapor through the excess flow valve When you have double cylinders causing propane “freeze-up.”...
Page 101 Propane System CALCULATING PROPANE USAGE It is important to remember that (if applicable) your furnace, refrigerator, water heater and range all may use propane to Gas appliances must never be operate. Each has a different BTU rating, and you will need to operated while vehicle is in consider them to determine how long your propane supply will motion.
Page 102 Propane System This page is intentionally blank Page | 98...
Page 103 Appliances APPLIANCES The following contains quick highlights of the RV appliances and equipment, written for original factory-installed equipment If you smell propane gas STOP! usage. If there have been modifications or replacements made to Quickly and carefully perform your RV then these instructions may not apply (please contact the procedure below: the service center or technician who performed the modifications or substitutions if assistance is required).
Page 104: Appliances
Appliances 4. Never pick up a flaming pan. 5. Flaming grease outside of the pan can be extinguished with baking soda or a multipurpose dry chemical or foam-type fire Do not turn the gas range burner extinguisher. controls ON and allow propane gas to escape before lighting.
Page 105 Electronics ELECTRONICS AUDIO/VISUAL SYSTEM GUIDE The following is a basic overview of the audio/visual (A/V) electronics operation. The information in this section is written for original factory-installed equipment usage. If there have been modifications or replacements made to your electronics system then these instructions may not apply (please contact the service center or technician who performed the modifications or Typical speaker control location...
Page 106: Electronics
Electronics becomes. TV broadcasting is a point-to-point communication. Any obstructions between the transmitter and the antenna will degrade the signal strength, affecting the picture quality. The TV power supply should be TV SIGNAL BOOSTER turned OFF when connecting For good station reception, the TV signal booster must be and/or disconnecting the cables turned ON to view local television stations.
Page 107 Electronics 5. Scan for channels. If you are not satisfied with the quantity of channels you have received, rotate the antenna 90 degrees and rescan for channels. If your converter box has the signal strength option, use it to fine-tune the antenna for Lowering the antenna with the maximum signal strength.
Page 108 Electronics This page is intentionally blank Page | 104...
Page 109 Heating & Cooling HEATING & COOLING The following contains quick highlights of the RV heating and cooling components. It is written for original factory-installed Do not leave a roof vent open equipment usage. If there have been modifications or when the RV is stored or replacements made to your RV then these instructions may not unattended for long periods.
Page 110: Heating & Cooling
If you have any questions contact your do not obstruct or alter the dealer or Grand Design RV Customer Service. A qualified RV furnace in any manner. Do not technician should perform all furnace maintenance at least once install screens over the vent for a year (more often depending on furnace usage).
Page 111 Heating & Cooling Lippert Solera patio awning light Shut the patio awning light switch OFF when the Lippert Solera awning is in the storage or travel (rolled up) position. DO NOT attempt any repairs to any awning (patio awning or slideout awning).
Page 112 Heating & Cooling This page is intentionally blank Page | 108...
Page 113 OR if the slide room does the RV to the tow vehicle. not close and seal tightly, call your dealer or Grand Design RV FAILURE TO FOLLOW THESE Customer Service for trouble shooting and/or repair assistance.
Page 114: Slideout Systems
(or not at all), immediately Manually push the slide room in override stop and call your dealer or 1. Locate the circuit board. Grand Design RV Customer Service. 2. Unplug both motors from circuit board (this releases the motor brake).
Page 115 Slideout Systems 3. Push or pull slide room in as desired; a. Larger rooms may require several people to push. b. Keep both sides of room relatively even. Never ‘jump’ or charge the auxiliary battery from the power 4. When the bedroom slide is completely in, plug both the connections on the Schwintek motors back in to the control board (this applies the motor InWall Controller.
Page 116 Slideout Systems recommended that the auxiliary battery be placed on a charger until it is fully charged. Only one (1) side moving For long-term storage, it is The Schwintek InWall slide system has a separate motor to recommended that the slide operate each side of the room.
Page 117 Interior INTERIOR CLEANING THE INTERIOR To keep the value of your RV, perform regular maintenance Some, but not all, recliner using the proper materials and procedures. Using the wrong loveseats have storage in the cleaner may result in damage to the surfaces in your RV. Check middle armrest.
Page 118: Interior
Interior but do not rub it in or saturate the area. Use a professional furniture cleaning service for an overall cleaning. Clean the suede or vinyl upholstery only as recommended. Using other processes than those listed may produce undesired results and possibly damage the upholstery.
Page 119 Interior COUNTERTOPS To prevent permanent damage: • Always use hot pads or trivets under hot pans, dishes, or heat producing appliances such as frying pans. • Always use a cutting board; never use a knife on the countertop. • Avoid harsh chemicals such as drain cleaners, oven cleaners, etc.
Page 120 Interior Some spills contain chemicals that will destroy carpet fibers and dyes. If you have doubts about what caused the spot, contact a professional carpet cleaner. Because of the additional dirt typically associated with camping, we recommend that you vacuum the carpet frequently. Have tough and deep stains professionally steam cleaned.
Page 121 Interior ADDENDUM Imagine 2800BH How to convert the dinette into a bed Page | 117...
Page 122 Interior ADDENDUM Imagine 2800BH How to convert the sofa into a bed Page | 118...
Page 123 Exterior EXTERIOR CLEANING THE EXTERIOR To protect your RV's exterior finish, wash it often and thoroughly. Regular cleaning and waxing will help protect the exterior. If chalking occurs, wash and try to wax a small area to see if the luster returns. If the exterior becomes scratched, nicked or cracked have your dealer inspect the RV.
Page 124: Exterior
Exterior Do not wash the RV when it is in direct sunlight. Park the RV in the shade and spray it with water to remove dust. Next, using an ample amount of clean water and a car-washing mitt or sponge, wash the RV from top to bottom.
Page 125 Exterior Cleaning plastic parts Use a sponge or chamois to clean plastic parts. Use warm water and a soft cloth or chamois to remove any white residue from dark colored plastic surfaces. Do not use a scrubbing brush or Do not use a buffer and a buffing other hard tools as they may damage the plastic surface.
Page 126 Exterior TRAILER FRAME Sand, pebbles, objects on the highway, climate (salt air exposure) or ice inhibiting chemicals used during the winter Do not add items to the RV rear months will damage the paint, inviting rust and other bumper. Add-on items will deterioration.
Page 127 Exterior system when it will not be in use for an extended period of time, especially if it is stored in colder climates. Periodically inspect your RV for damage during storage, and seal off any area that can offer an entry point for rodents, birds or insects.
Page 128 Exterior SUGGESTED MAINTENANCE CHECKLIST This list is a quick reference sheet for suggested areas of regular maintenance. Review all manufacturer’s operators manuals supplied with your RV to perform these listed maintenance items. Prior to first trip • Inspect and reseal as needed. •...
Page 129 Exterior Page | 125...
Page 130 Exterior This page is intentionally blank Page | 126...
Page 131 Basic Troubleshooting BASIC TROUBLESHOOTING ELECTRICAL POWER Turn thermostat and furnace gas control valve off and contact No AC power to RV your dealer or authorized service • Check circuit breakers at power center. The 120-volt circuit center. DO NOT attempt to breaker may be off or tripped.
Page 132 Basic Troubleshooting  Breaker may be off or tripped inside power center. Reset main breaker if necessary. Generator makes clicking sound when trying to start • Battery condition may be low. Recharge if necessary. • Check for poor ground or battery connection. INTERIOR LIGHTS Lights flicker •...
Page 133 Basic Troubleshooting OUTSIDE RECEPTACLE No power to outside receptacle • Make sure you have power to the shoreline. Never use a match or flame to  check for propane gas leaks. Check breaker on generator. Failure to follow this warning ...
Page 134: Basic Troubleshooting
Basic Troubleshooting Have the gas system checked immediately and leakage source corrected by your dealer or a qualified service center before using again. REFRIGERATOR The control panel lights are not illuminated • Check coach circuit breakers and GFCI receptacle. • Verify that refrigerator is plugged into the 120-volt outlet.
Page 135 Basic Troubleshooting Does not get cold enough • Start the unit before the day gets too hot. • To offset heat gain: Close all windows and blinds. Keep entrance doors closed. Use awnings. Avoid using heat-producing appliances. • Make sure the outside coil is not blocked or damaged. •...
Page 136 Basic Troubleshooting TERMINATION VALVE Termination valve leaks • Debris keeps valve from seating. Clear debris from and around valve O-ring set. • Bad gasket. Have your dealer or qualified RV technician replace gasket with new. TV ANTENNA Poor TV reception •...
Page 137 Basic Troubleshooting WATER HEATER Temperature-pressure relief valve weeping • Weeping or dripping of relief valve while water heater is running does NOT mean it is faulty. There is an odor that smells like rotten eggs • If your fresh water source has a rotten egg odor, you will need to find another source of fresh water before flushing or refilling the entire RV water storage system.
Page 138 Basic Troubleshooting Upon completion of the steps above, close the drain plug as well as the relief valve. Refill with fresh water, circulate and rinse.  If you use your vehicle frequently or for long periods of time, flushing the water heater several times a year will prolong the life of the water heater storage tank.
Page 139 Glossary & Index GLOSSARY OF TERMS AC ELECTRICITY – Alternating current also known as shoreline power. For purposes of this manual, it refers to 120-volt AC (abbreviated 120 VAC). AMP - Short for ampere, the electric current unit of measure. RV sites with electric hookup will specify the maximum amps supported, which generally come in units of 20, 30, or 50 amps.
Page 140: Glossary & Index
Glossary & Index BRITISH THERMAL UNIT (BTU) - Measurement of heat that is the quantity required to raise the temperature of one pound of water 1°F. RV air-conditioners and furnaces are BTU-rated. CAMBER (WHEEL ALIGNMENT) - The number of degrees each wheel is off of vertical.
Page 141 DEALER – For purposes of this manual, this refers to the independent dealer authorized to sell and/or service your camper by Grand Design RV. This term will be used in this context unless specified otherwise. DINETTE - Booth-like dining area. Table usually drops to convert unit into a bed at night.
Page 142 Glossary & Index DUMP STATION – Site where you drain your gray water (waste) and your black water (sewage) tanks. In most states, it is illegal to drain your tanks anywhere except dump stations. DUMP VALVE – Another name for the T-handle valve used to release and drain the black tank (sewage) and gray tank (waste).
Page 143 Glossary & Index the axle on its weakest link. The GAWR assumes that the LOAD IS EQUAL ON EACH SIDE. GROSS CARRYING CAPACITY (GCC) - Means the maximum carrying capacity of your camper. The GCC is equal to the GVWR minus UVW.
Page 144 Glossary & Index HOLDING TANKS - There are three different holding tanks on most RVs; fresh water tank, gray water tank and black water tank. The fresh water tank holds fresh water that can be stored for later use. The gray water tank holds the waste water from the sinks and showers.
Page 145 Glossary & Index JACKKNIFE - 90% angle obtained from turning/backing fifth wheel or travel trailer with tow vehicle. Jackknifing a short bed truck towing a fifth wheel without the use of a slider hitch or extended fifth wheel pin box can result in damage to the truck cab or breaking out the back window of the truck cab from the truck and fifth wheel "colliding".
Page 146 Glossary & Index PARK MODEL - A travel trailer that requires park facilities to function. It lacks holding tanks and dual-voltage appliances, requiring to be plugged into water, sewage, and electrical facilities. A park model is more of a small mobile home than a recreational vehicle, in appearance and function.
Page 147 Glossary & Index ROADSIDE – This refers to the side of the camper that faces the road when it is parked. Often called the off-door side. ROOF AIR CONDITIONING - Air conditioning unit mounted on roof of RV, to cool the RV when it is parked. When moving, most RVs are cooled by separate air conditioning units which are components of the engine, or they may be cooled by a roof top if a proper size generator is installed.
Page 148 Glossary & Index THERMOCOUPLE - A thermocouple is a device that monitors the pilot flame of a pilot model propane appliance. If the pilot flame is extinguished the thermocouple causes the gas valve to shut off the flow of gas to both the pilot flame and the main burner. TIP OUT - The term used for an area or room in an RV that tips out for additional living space.
Page 149 Glossary & Index tire: tread wear, traction and temperature. Following government prescribed test procedures, tire manufacturers perform their own evaluations for these characteristics. Each manufacturer then labels the tire, according to grade. ↑ UV DEGRADATION - A breaking down of material due to the sun's harsh ultraviolet rays.
Page 150 Glossary & Index WORK CAMPER - A person living in an RV and working. Many spell it as "workamper" after the web site and service by that name. YAW - Fishtailing action of the trailer caused by external forces that set the trailer's mass into a lateral (side-to-side) motion. The trailer's wheels serve as the axis or pivot point.
Page 151 Glossary & Index Index Fire extinguisher ........27 Fire safety ..........27 120-volt AC system ........ 65 Fireplace ..........105 12-volt DC outlet ........70 Flooring ..........115 12-volt DC system ........68 Formaldehyde ........34 7-way wire harness/connector plug ..57 Frame, trailer .........
Page 152 Glossary & Index Propane system ........91, 95 Warranty, service repair ....... 8 Range hood ..........100 Washing the RV ........119 Range top with oven......100, 129 Water heater bypass ......78 Receptacle, exterior ......129 Water heater ......... 77, 133 Receptacle, power cord ......

Grand Design Imagine Owner's Manual

Quick Links

Troubleshooting

Need help?

Questions and answers

Related Manuals for Grand Design Imagine

Summary of Contents for Grand Design Imagine

Table of Contents