Page 1 Internal Use Only Service Manual LG-P895 Date: September, 2012 / Issue 1.0...
Page 2: Table Of Contents
4.21 Proximity Sensor on/off trouble ..........112 4.22 Illumination Sensor on/off trouble ..........115 4.23 HDMI Troubleshooting ..............118 4.24 Touch Troubleshooting ..............119 LGE Internal Use Only - 2 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 4 • When returning system boards or parts like EEPROM to the factory, use the protective package as described. LGE Internal Use Only - 4 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 5: Abbreviations
OPLL Offset Phase Locked Loop LGE Internal Use Only 6/140 Copyright © 2007 LG Electronics. Inc. All right reserved. Only for training and service purposes LGE Internal Use Only - 5 - Copyright © 2012 LG Electronics. Inc. All right reserved.
Page 6 Voltage Control Temperature Compensated Crystal Oscillator Wireless Application Protocol LGE Internal Use Only 7/140 Copyright © 2007 LG Electronics. Inc. All right reserved. Only for training and service purposes LGE Internal Use Only - 6 - Copyright © 2012 LG Electronics. Inc. All right reserved.
Page 7: Performance
2.3 Main Parts & Solution Item Part Name Comment AP Chip AP 33 : NVIDIA CP Chip XMM6260 : IMC LGE Internal Use Only - 7 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 8: Hw Features
E2 (GSM900) Class E2 (PCS) E2 (DCS) EDGE compatibility EDGE Class 12 Micro SIM SIM card type 2.85V /1.8V LGE Internal Use Only - 8 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 9 MPEG4, H.264, H.263 @ 1080p 30pfs Voice Recording Speaker Phone mode Support Travel Adapter CDROM Stereo Headset Data Cable T-Flash (External Memory) LGE Internal Use Only - 9 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 10: Sw Features
(add/edit/delete are not supported) Voice Memo Support voice recorder Call Reminder Missed call popup Network Selection Automatic Mute Call Divert LGE Internal Use Only - 10 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 11 Voice Dial IrDa Ver. 4.0 BLE (GAP, A2DP, AVRCP, DUN, FTP, Bluetooth GAVDP, GOEP, HFP, HSP, OPP, SDAP, SPP) LGE Internal Use Only - 11 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 12 EDGE Class 33 Hold / Retrieve Conference Call Max. 7 DTMF Memo pad Rich Note SyncML Gtalk Email LGE Internal Use Only - 12 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 13: Hw Spec
: -98dBm / -96dBm (2.439%) AM Suppression GSM : -31dBm -98dBm/-96dBm (2.439%) DCS : -29dBm Timing Advance ± 0.5T LGE Internal Use Only - 13 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 14 < 17.5 %, when Pout ≥ -20 dBm Peak Code Domain Error < -15 dB at Pout ≥ -20 dBm LGE Internal Use Only - 14 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 15 -0.5 / -1.5 -1 / -3 -1.5 / -4 group(10equal command group) +8 / +12 +16 / +24 LGE Internal Use Only - 15 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 16 Power Ratio (ACLR) > 43 dB @ ±10 MHz Error Vector Magnitude < 17.5 %, when Pout ≥ -20 dBm LGE Internal Use Only - 16 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 17 Sub-Test : 1=11/15, 2=6/15, 3=15/9, 4=2/15, 5=15/15 Leakage > 33 dB @ ±5 MHz Power Ratio > 43 dB @ ±10 MHz (ACLR) LGE Internal Use Only - 17 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 18 ※ACR shall be measured by setting the desired signal's strength 3 dB above the rate-dependent sensitivity specified in min input sensitivity LGE Internal Use Only - 18 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 19 ≥ -10dBm(1Mbps,2Mbps,5.5Mbps,11Mbps) @ FER ≤ 8% Rx Adjacent Channel ≥ 35dB @FER ≤ 8%, Rejection interference input signal -70dBm@fc±25MHz(11Mbps) LGE Internal Use Only - 19 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 20 ※ACR shall be measured by setting the desired signal's strength 3 dB above the rate-dependent sensitivity specified in min input sensitivity LGE Internal Use Only - 20 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 21 ≥ -20dBm @ PER ≤ 10%(2400 ~ 2483.5 MHz) Rx Max input Sensitivity ≥ -30dBm @ PER ≤ 10%(5150 ~ 5725.0 MHz) LGE Internal Use Only - 21 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 22 (DRX = 1.28) Low Pwr mode) 460 hours over 7 hours over (Paging Period = 5) (TX Level = Max) LGE Internal Use Only - 22 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 23 -104 ±2dBm -103 ±2dBm 1  0 -110 ±2dBm -105 ±2dBm No service < -110 dBm < -105 dBm LGE Internal Use Only - 23 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 24: Battery Bar
Critical Low Battery Pop-up 0% ~ 3% : Every Level change popup (No call) POWER OFF 1% under LGE Internal Use Only - 24 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 25: Lgp895 Figures
2. PERFORMANCE LG-P895 Product SPEC 2.7 P895 2.7 LGP895 Figures LGE Internal Use Only - 25 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 26: Cic And Service Center
With Power Off, press the power key + volume up key + quick memo key for 4-5 seconds (until the first LG logo disappears). Release those keys, and you will enter the RECOVERY Mode Menu. Then, see the menu with the Home Key. Browse the menu with the Col Up/Down Keys.
Page 27 1. Status Bar Slide Down 2. “USB connected” Touch 3. Select “Media sync(MTP)” 1.PC<-> SD CARD Request for development 2.PHONE<-> SD CARD LGE Internal Use Only - 27 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 28 If it is in uncheck condition, please check. Request for ex) 1. Europe<->Europe development 2. Europe<->Continents(North America, Asia etc) LGE Internal Use Only - 28 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 29 APPs. It will be confirmed if the APP with incompatibility is informed. Thank you. LGE Internal Use Only - 29 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 30 (Generally, SMTP user name and password is the same as the e-mail address and password entered in the first place) > Confirm LGE Internal Use Only - 30 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 31 For example, it is because e-mails and calls must be informed to the user even if kill is in progress. LGE Internal Use Only - 31 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 32 1) In Fig. 1, go to “Show advanced options”(Check) > “IP Settings”(Static) and set “IP adress”, “Gateway”, “Network prefix length”, “DNS 1” and “DNS 2” to access the AP. (Fig. 3) LGE Internal Use Only - 32 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 33 3. CIC AND SERVICE CENTER Q&A How do you install the PC Sync Program? Search the model on LG mobile web site and download. How do you install the Phone driver? Download the USB Driver fitting the model from the communication company web site.
Page 34 Can language be changed? Do the following. Setting > Language and Input > choose the language you want LGE Internal Use Only - 34 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 35 1. Go to Setting >Sound > ‘Sound Setting’ and set the sound on. 2.Choose various bell sounds under the ‘Phone Bell Sound’ menu. LGE Internal Use Only - 35 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 36 3. Connect HDMI terminal to devices(monitor, TV), and change to the external input mode(HDMI mode) on the device. LGE Internal Use Only - 36 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 37 3. Select wanted contents through searching library. 4. It can be played through selecting player in the player set up category. LGE Internal Use Only - 37 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 38 4. Uploading can’t be done. - Uploading DMS may not support uploading function. 5. P895(including all of LG Phones) is not found under To. -SmartShare-installed LG Phones do not support DMR. 6. When DMP is running, the pop-up for content loading won’t disappear shortly.
Page 39 How is the distribution schedule of OS or SW new version known? It can be checked at local LG Electronic service centers or LG Mobile homepage notice page. LGE Internal Use Only - 39 - Copyright ©...
Page 40 What kinds of phone accessories are there? You can purchase it from a local LG Electronics service center or on the internet. LGE Internal Use Only - 40 - Copyright ©...
Page 41: Trouble Shooting
U1000 RFIC (Transceiver) U1003 Transceiver PMU U1001 Duplexer Bank U1004 PAM DCDC U1002 PAM MMMB FL1001 Filter (ASM) LGE Internal Use Only - 41 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 42: Signal Path
B. WCDMA 1900 TX PATH C. WCDMA 900 TX PATH D. WCDMA 850 TX PATH E. COMMON TX/RX PATH LGE Internal Use Only - 42 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 43 B. WCDMA 1900 RX PATH C. WCDMA 900 RX PATH D. WCDMA 850 RX PATH\ E. COMMON TX/RX PATH LGE Internal Use Only - 43 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 44 D. GSM 1900 RX PATH E. GSM 850,900 TX PATH F. GSM 1800,1900 TX PATH G. COMMON TX/RX PATH LGE Internal Use Only - 44 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 45: Checking Tcxo Block
The output frequency (26MHz) of TCXO (X1000) is used as the reference one of PMB5712 X1000 1XXA26000FBA VCONT 26MHz C1029 C1030 Schematic of the Crystal Part (26MHz) LGE Internal Use Only - 45 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 46 1.7V ≤ VCC ≤ 1.9V Check the PMB5712 Check TP2 Check soldering and 26 MHz Signal components TCXO OK LGE Internal Use Only - 46 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 47: Checking Wcdma Block
4.4 Checking WCDMA Block START Check TCXO Block Check RF Switch (M/S) Check TX/RX Level Re-download & Cal Change the Board LGE Internal Use Only - 47 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 48 4. TROUBLE SHOOTING 4.4.1. Checking RF TX Leve (WCDMA) Test Point (TX Level) LGE Internal Use Only - 48 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 49 C1053 1.8n B4_TX LB_RFIN TX_L L1015 B5_TX C1054 L1016 B8_TX L1019 L1024 Schematic of WCDMA Band1,2,5,8 Tx Block LGE Internal Use Only - 49 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 50 Check TP2 Over 21dBm? Check Separator Check TP3 Over 21dBm? Check Duplexer Check TP4 Over 6dBm? Check PAM Check PMB5712 LGE Internal Use Only - 50 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 51 4. TROUBLE SHOOTING 4.4.2. Checking RF Rx Level (WCDMA) Test Point (Rx Level) LGE Internal Use Only - 51 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 52 B5/GSM850 FB1001 L1011 C1044 C1043 C1050 220p C1051 Rev.C Rev.C B8/EGSM L1014 Schematic of WCDMA Band1,2,5,8 Rx Block LGE Internal Use Only - 52 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 53 Set the phone Rx is ON Check TP1 Signal exist? Check RF Switch (M/S) Check TP2 Check Separator Signal exist? Check Duplexer, PMB5712 LGE Internal Use Only - 53 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 54: Checking Gsm Block
4.5 Checking GSM Block START Check TCXO Block Check RF Switch (M/S) Check TX/RX Level Re-download & Cal Change the Board LGE Internal Use Only - 54 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 55 4. TROUBLE SHOOTING 4.5.1 Checking RF Tx Block Test Point (Tx Level) LGE Internal Use Only - 55 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 56 HB_RFIN C1053 1.8n B4_TX LB_RFIN TX_L L1015 B5_TX C1054 L1016 B8_TX L1019 L1024 Schematic of GSM850/EGSM/DCS/PCS Tx Block LGE Internal Use Only - 56 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 57 Over 31 dBm(GSM850, EGSM) Check Separator Over 28 dBm(DCS, PCS) Check TP3 Check PAM Over 12 dBm Check PMB5712 LGE Internal Use Only - 57 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 58: Checking Rf Rx Block
4. TROUBLE SHOOTING 4.5.2 Checking RF Rx Block Test Point (Rx Level) LGE Internal Use Only - 58 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 59 Rev.C B5/GSM850 FB1001 L1011 C1044 C1043 C1050 220p C1051 Rev.C Rev.C B8/EGSM L1014 Schematic of GSM850/EGSM/DCS/PCS Rx Block LGE Internal Use Only - 59 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 60 Set the phone Rx is On Check TP1 Signal exist? Check RF Switch (M/S) Check TP2 Signal exist? Check Separator Check Duplexer, PMB5712 LGE Internal Use Only - 60 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 61: Wifi/Bt/Fm Module
Reference No. Description Reference No. Description FL11000 Filter Separator U11002 Tx module FL11001 Filter X11000 Crystal U11000 U11001 IC,Wifi/BT/FM LGE Internal Use Only - 61 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 62 Rx Path BT Tx Path BT Rx / Wifi Rx Signal Path BT Tx / Wifi Tx Signal Path LGE Internal Use Only - 62 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 63: Nfc Trouble
(1) Check Crystal Circuir (2) Check Conducted TX (3) Check NFC antenna Re-download SW or PN544 chip FW update LGE Internal Use Only - 63 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 64 27.12MHZ SIGIN FLOAT2 IN/OUT2 RFU2 TEST5 IN/OUT1 FLOAT1 GPIO0 XRCGB27M120F3M10R0 AVSS1 X10000 C10027 C10028 XTAL1 TP1 (Point: 27.12MHz) LGE Internal Use Only - 64 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 65 See next page to check Antenna NFC ANT. FEEDING NFC_ANT_FEED_[0] C10047 C10048 ANT10001 HJ-BCT-04Y ZD10000 ANT10000 C10049 C10050 HJ-BCT-04Y NFC_ANT_FEED_[1] Rev.1.0 120628 ZD10001 LGE Internal Use Only - 65 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 66 It has a deviation by means of equipment environment. Therefore it should be compared with a normal sample. LGE Internal Use Only - 66 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 67: Gps Trouble
(Resistance) setting (1) Check RF LINE and Component (2) Check Crystal Circuit (3) Check GPS LDO Re-Download SW LGE Internal Use Only - 67 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 68 GPS Antenna Connector OK? Replace CN12000, 12001 Replace TP1,2 GPS RF Connector OK? (C12012, C12019) TP1,2(C12012, C12019) OK See Next Page LGE Internal Use Only - 68 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 69 C12008 2.2u 2.2u 0.47u C12011 ON_OFF EXT_SRESET_B TMODE R12001 TCXO_IN JTCK XO_OUT JTMS TP1(26M _TCXO_IN Vpp 1.1V@ 26MHz) LGE Internal Use Only - 69 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 70 Replace U12001 F/W update TP1(U12001 VCC_GPS_1V8) VBAT BU18TD2WNVX U12001 VCC_GPS_1V8 VOUT GPS_LDO_EN STBY C12002 EUSY0407501 C12003 Rev.C TP1(U12001 VCC_GPS_1V8) LGE Internal Use Only - 70 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 71: Circuit Power On Trouble Shooting
Power-OFF in reverse order. SD2=1.8V (VDDIO_XXX) GPIO4 (32K_OUT1) 1.28ms LDO0=1.2V (AVDD_PLLA_P_C) LDO1=1.0V (VDD_DDR_HS) 1.28ms LDO5=2.8V (VDD_DDR_RX)& GPIO1=VBUS_DET 36 msec nRST_IO (SYS_RESET_N) LGE Internal Use Only - 71 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 72 +1V2_TPS_VPLL, +1V0_TPS_VDDRHS, +2V85_TPS_VMEM, Power up? Is clock ok? Check the X-tal X5000 : 32.768KHz Change the Main board LGE Internal Use Only - 72 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 73 TP8: +1V2_TPS_VPLL :C5008 TP9: +1V0_TPS_VDDRHS :C5009 TP10: +2V85_TPS_VMEM, :C5011 TP11: X5000 Main PCB BOTTOM place TP10 TP11 MAX77663 LGE Internal Use Only - 73 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 74 1UH 20% - 2.2A 2.2 2.45 0.075OHM - - SHIELD 2.0X1.6X1.0MM - R/TP C5028 C5029 6.8p XOUT X5000 Rev.C 32K_OUT NX3215SA 32.768KHz XGND C5030 6.8p INI2C LGE Internal Use Only - 74 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 75 TP5006 Delete 2012.04.05 GPIO2 R5036 Delete 2012.04.29 GPIO3 R5013 GPIO4 GPS_32K_CLK_IN R5014 GPIO5 WLAN_32K_CLK_IN R5035 GPIO6 AP_32K_CLK_IN GPIO7 PG_SD3 LGE Internal Use Only - 75 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 76: Switching Charger Troubleshooting
- -Check connection between TA(USB cable) and LGP895 connector. -Current flow to OVP IC to be protected from over voltage LGE Internal Use Only - 76 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 77 Check the Charger SMT soldering by using X-ray. Swap the Charger or Main board. Go to first step Charger Troubleshoot Flow LGE Internal Use Only - 77 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 78 C6002 U6000 C6006 MAX8971EWP Rev.B EAN62109401 2012.04.27 VICHG 4.7K -> 47K VBAT I2CIN IRQB CHARGER_IRQB PWR_I2C_SDA C6016 PWR_I2C_SCL LGE Internal Use Only - 78 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 79: Usb Trouble Shooting
C6013(TP2) is Check MUIC or charger IC 4.5~5V USB_D+(TP1) Check IC U6001 is 3.3V? Change The main board LGE Internal Use Only - 79 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 80 GND1 GND2 C6024 C6023 C6025 Rev.B CN6001 FL6001 USB_DM USB_DP USB_ID EAM62272401 C6027 ICMEF112P500MFR EAG63149901 production Issue. under 1pF LGE Internal Use Only - 80 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 81: Audio Troubleshooting
Check the waveform of TP1 Change The Lower FPCB waveform is OK? Change The Audio Codec IC Speaker Sound is OK? LGE Internal Use Only - 81 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 82 SPKRP1 EAN62114201 SPKRP2 C7015 INA1/EXTMICP C7016 INA2/EXTMICN EAR_L EAR_R Delete INB1 Delete FM_AUDIO_F/R 2012.04.20 2012.04.20 INB2 C7019 RECP/LOUTL/RXINP LGE Internal Use Only - 82 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 83: Receiver Troubleshooting
Check the waveform of TP1 Change The RCV waveform is OK? Change The Audio Codec IC Receiver Sound is OK? LGE Internal Use Only - 83 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 84 4. TROUBLE SHOOTING RECEIVER CN7000 L7000 RCV_P L7001 RCV_N EAB62410901 Rev.1.0 EMR1207 120628 LGE Internal Use Only - 84 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 85 Check the TP1 Change The Ant. FPCB Bias range 1.8V~2.2V Change The Main PCB Voice recording is OK LGE Internal Use Only - 85 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 86 4. TROUBLE SHOOTING C7021 MIC1P_DIGMICDATA MAIN_MIC_P C7023 MIC1N/DIGMICCLK MAIN_MIC_N C7024 SUB_MIC_P MIC2P C7025 SUB_MIC_N MIC2N FB7007 MAIN_MIC_BIAS MICBIAS JACKSNS LGE Internal Use Only - 86 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 87 Speaker phone call is OK? Check the TP1 Bias range 1.8V~2.2V Change The VCAM FPCB Speaker phone call is OK LGE Internal Use Only - 87 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 88 4. TROUBLE SHOOTING SUB-MIC BIAS LDO VBAT SUB_MIC_BIAS BU18TD2WNVX U7003 VOUT SUB_MIC_BIAS_LDO_EN STBY C7028 C7029 EUSY0407501 Rev.C LGE Internal Use Only - 88 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 89 Change The Upper FPCB. Change The Upper FPCB. Change The Code IC or Main PCB Sound or MIC is OK? LGE Internal Use Only - 89 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 90 FB101 1800 EAR_L M4-L EAR_SENSE_3.5PI M4-DETECT FB103 1800 EAR_R M1-R M6-GND C102 C103 C104 C105 0.0033uF 0.0033uF EAR_MIC_N LGE Internal Use Only - 90 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 91: Camera Troubleshooting
Check Camera Signal TP5(MCLK), TP6(MIPI_CLK) Change The main board TP7 (MIPI_DATA) OK? Change the Camera Module The Camera Works LGE Internal Use Only - 91 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 92 EPROM WP PIN = GND ( WRITE Enable ) 8M_CAM_EPROM_PR 8M_RESET_N CAM_I2C_SDA R9003 CAM_VCM_PWDN CAM_I2C_SCL ENBY0034201 GB042-24S-H10-E3000 ESD5205P6T6G D9000 EAH61794301 LGE Internal Use Only - 92 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 94: M) Camera Troubleshooting
Check Camera Signal TP4(MCLK), TP5 (MIPI_CLK) Change The main board TP6 (MIPI_DATA) OK? Change the Camera Module The Camera Works LGE Internal Use Only - 94 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 95 VT CAM IO CAM_I2C_SCL TP9001 VT_RESET_N ENBY0039601 VT_1.8V_CAM_VIO GB042-20S-H10-E3000 VBAT TP9002 U9002 VOUT ESD5205P6T6G VT_1.8V_EN STBY D9001 C9026 C9027 Rev.C LGE Internal Use Only - 95 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 97: Main Lcd Trouble
TP5(VCC_LCD_3V0) Change The LCD TP6(IOVCC_LCD_1V8) Module LCD Boost TP7 (LED A) Change the Main Board The LCD Works LGE Internal Use Only - 97 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 98 DATA_19 MGNDS/ESDPC5 LCD_RGB_B_4 DATA_20 R8014 LCD_RGB_B_5 DATA_21 MIPI_RESET_B LCD_BRIDGE_RESET_N LCD_RGB_B_6 DATA_22 DATA_23 LCD_RGB_B_7 +1V2_VPWR VA8002 +1V8_VPWR +1V8_VPWR VA8003 LGE Internal Use Only - 98 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 99 LCD_CP_EN LED_C2 HWEN HVLED2 U8001 LM3533TMX-40 R8021 CPOUT AP_LCD_PWM EAN62410501 R8022 LCD_PWM Rev.C LVLED1 LVLED2 LVLED3 LVLED4 LVLED5 LGE Internal Use Only - 99 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 101: Sim Detect Troubleshooting
Change SIM card Change SIM card Work well? Work well? Change Main board Change The main board LGE Internal Use Only - 101 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 102 X10000 C10027 C10028 NFC_VEN +3V0_USIM SIMVCC XTAL1 C10025 +1V8_TPS_VIO 470n C10025 NFC_VBAT C10009 GEN1_I2C_SDA Q10001 NFC_SWP USIM_DATA GEN1_I2C_SCL LGE Internal Use Only - 102 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 104: Side Key Troubleshooting
When the key is pressed? Change the Main board Change The main board * TP1 : R13009 TP2 : R13010 LGE Internal Use Only - 104 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 106: Vibrator Troubleshooting
Check +1V8_VIO(TP1), VBAT(TP2) , VIBE_PWM (TP3), VIBE_EN (TP4) IS it OK? Change The main board Work well? Change The Vibrator LGE Internal Use Only - 106 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 107 PWR_I2C_SCL U7002 SADD ISA1200 EAN61968701 R7014 VIBE_PWM PWM/CLK VIBE_EN VIB_L_P PGND VIB_L_N GAIN C7020 3.9n Motor Driver IC LGE Internal Use Only - 107 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 108: Motion/Gyro Sensor(Mpu-6050) Troubleshooting
Work well? Measurement VDD 3.0V : SENSOR_3.0V (TP1) Change The main board VLOGIC 1.8V : SENSOR_1.8V (TP2) CPOUT (TP3) LGE Internal Use Only - 108 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 109 SENSOR_INT CPOUT RESV1 C10051 2.2n C10054 C10055 C10056 0.1u 0.1u Gyro + Motion Sensor Top Of Main board LGE Internal Use Only - 109 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 110: Compass Sensor Trouble
IS it OK? Change the LDO Work well? Change The Compass IC Work well? Change The main board LGE Internal Use Only - 110 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 111: Compass Sensor
DRDY U10004 GEN1_I2C_SCL AMI306 VREG EBD60985501 C10043 C10044 GEN1_I2C_SDA X5R, 10% X5R, 10% LDO(3.0V) Bottom Of Main board LGE Internal Use Only - 111 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 112: Proximity Sensor On/Off Trouble
Check INT (TP2), I2C_SCL (TP3), I2C_SDA (TP4) IS it OK? Change the mina board Work well? Change the Main board LGE Internal Use Only - 112 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 113 C13010 0.1u Delete C13011 2012.04.06 2012.04.19 AP33 I2C MAP R3002 2.2K +1V8_TPS_VIO GEN1_I2C_SCL PROX R3003 2.2K GEN1_I2C_SDA (APDS9900) LGE Internal Use Only - 113 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 115: Illumination Sensor On/Off Trouble
Check INT (TP2), I2C_SCL (TP3), I2C_SDA (TP4) IS it OK? Change the mina board Work well? Change the Main board LGE Internal Use Only - 115 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 116 C13010 0.1u Delete C13011 2012.04.06 2012.04.19 AP33 I2C MAP R3002 2.2K +1V8_TPS_VIO GEN1_I2C_SCL PROX R3003 2.2K GEN1_I2C_SDA (APDS9900) LGE Internal Use Only - 116 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 118: Hdmi Troubleshooting
Is the circuit powered? Troubleshooting Connect the HDMI cable Video output OK? Change The main board HDMI works LGE Internal Use Only - 118 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 119: Touch Troubleshooting
Change the mina board 1.8V Touch(TP2) Change the Touch module Work well? Measurement 3.0V TOUCH (TP1) 1.8V TOUCH (TP2) LGE Internal Use Only - 119 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 120 Rev.1.0 C13015 C13016 47K -> 10K Delete R. Rev.C 2.2u GEN2_I2C_SCL_SW TOUCH_RESET_N GEN2_I2C_SDA_SW TOUCH_INT_N TOUCH_MAKER_ID CN13004 Bottom Side LGE Internal Use Only - 120 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 121: Download
Release 2011.11.01 Please Check the Version to “B2B” Name Part No. D/L Cable Micro 5P (56-open-910K) USB DLC RAD32167835 LGE Internal Use Only - 121 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 123 5. DOWNLOAD P895 MS695 [LGFlashV141]LGP895_20120919_Download [LGFlashTool1.3.77.21]LGMS695_20120208_Download P895 [LGFLASHv141] LGE Internal Use Only - 123 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 134 5. DOWNLOAD [LGFlashV141]LGP895_20120919_Download [LGFlashTool1.3.77.21]LGMS695_20120208_Download LGP895_20120919.dll LGMS695_20120208.dll LGP895_120919 LGMS695_20120208 P895 MS695 [LGFlashV141]LGP895_20120919_Download [LGFlashTool1.3.77.21]LGMS695_20120208_Download P895 MS695 P895 MS695 LGE Internal Use Only - 134 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 141: Block Diagram
Speaker • HSIC(High Speed Inter Chip) (MAX77663) • SDMMC(Secure Digital Multi-Media Card) VBAT 2080mAh 3.5 pi earjack 32.768KHz LGE Internal Use Only - 141 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 142: Rf Block Diagram
RX_B1_H2X DI3_TX_DATX DI3_TX_DATX RX_BAND1_1 RX_H2X RX_B1_H2 RX_BAND1_2 RX_H2 DI3_RX_DAT DI3_RX_DAT RX_GSM1800_M1X RX_M1X RX_GSM1800_1 RX_GSM1800_M1 DI3_RX_DATX DI3_RX_DATX RX_M1 RX_GSM1800_2 LGE Internal Use Only - 142 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 143 PA_RAMP DI3_RX_DAT DI3_RX_DAT V_RAMP PA_RAMP DI3_RX_DATX DI3_RX_DATX SPI_CLK MMMB SPI_SS SPI_DRW RF6260 PA_POW_DET FB_AM PA_POW_DET PA_RF RF_OUT PA_RF LGE Internal Use Only - 143 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 144 VSD2_1.8V SD2_FB VBAT VBAT VBAT VDD_IO L_OUTA VBAT_PAM (1.425A) PAM DCDC L_OUTB MMMB RF6560 CP_OUT CP_OUT VCMOS RF6260 LGE Internal Use Only - 144 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 145 UART_RX TCXO_IN VDD_GPS_TCXO VDD_TCXO_OUT 1XXB26000CAC VDD_1V8 VCC_GPS_1V8 GPS_RST_N VDD_SMPS_1V8_I GPIO_K05 EXT_SRESET_B GPS_PWR_ON GPS_LDO_EN GPIO_R06 BU18TD2WNVX ON_OFF GPIO_Y01 VBAT LGE Internal Use Only - 145 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 146 SW_5G_LNA_EN RF_SW_CTRL_7 PCM_AP_DO_BT_DI DAP4_DOUT / GPIO_P06 BT_PCM_IN MAX77663 WLAN_32K_CLK_IN AP33 GPIO4 XO_IN XTAL WRF_XTAL_OP X11000Q22FA1280013000 XO_OUT WRF_XTAL_ON (37.4MHz) LGE Internal Use Only - 146 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 147 HIGH(VBAT) NFC_SWP SWIO NFC_IRQ SPI2_CS1_N / GPIO_W02 VSIM_2.9V PMUVCC VDD_SIM XMM6260 +1V8_TPS_VIO SIMVCC PVDD +3V0_USIM IFSEL1 USIM_DATA EXT_SW_CTRL LGE Internal Use Only - 147 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 148 * MIPI: Mobile Industry Processor Interface USIF1_RTS GPIO_PU2 * HIS: High Speed Inter chip * IPC: Inter Processor Communication LGE Internal Use Only - 148 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 149 MEM_AD[15] MEM_WR_N MEM_WR_N WED_ MEM_CAS_N DDR_CAS_N /CAS MEM_RAS_N DDR_RAS_N /RAS MEM_CS1_N MEM_CS1_N MEM_CKE DDR_CKE MEM_BFCLKO_1 MEM_BFCLK0_1 MEM_SDCLKO DDR_CLK LGE Internal Use Only - 149 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 150 GSD5T GPS 32.768kHz 26MHz_GPS_REF GPS_32K_CLK_IN GPIO4 GPIO3/ECLK LPO_IN TCXO TCXO_IN 26MHz BCM4330X BT XO_IN WRF_XTAL_OP 37.4MHz WLAN_32K_CLK_IN WRF_XTAL_ON XO_OUT LGE Internal Use Only - 150 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 151: Power On Sequence
The assertion of SYS_RESET_N causes Tegra to tristate its CORE_PWR_REO and CPU_PWR_REO buffers. As a resuit. the state of the wires will depend on system-level hardware (e.g pull-ups/pull-downs) LGE Internal Use Only - 151 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 152 AP33 GEN2_I2C GEN2_I2C LED_A LED Boost LED_C1 LED_C2 (LM3533 VBAT Battery IOVCC_LCD_1V8 LDO(1.8V) VCC_LCD_3V0 LDO(3.0V) ULPI_CLK/ GPIO_Y00 LCD_EN LGE Internal Use Only - 152 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 153 BUCK CAM_I2C_SCL CAM_I2C_SDA CAM_I2C_SDA 8M_CAM_EPROM_PR GMI_CS2_N CAM Flash VOUT Isink LM3559(1.5A) FLASH_LED_EN GPIO_PBB3 VBAT CAM_I2C_SCL CAM_I2C_SCL CAM_I2C_SDA CAM_I2C_SDA LGE Internal Use Only - 153 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 154 VDD_IN XMM6260 (NFC) PM Block VSIM_2.9V VSIM MAX98089 (3.3V) MICBIAS Main MIC (Audio CODEC) HS_MICBIAS Sub MIC 3.5pi LGE Internal Use Only - 154 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 155 SII9244 IOVCC_LCD_1V8 (HDMI to MHL TX) (1.8V) +3V3_VHDMI (3.3V) VCC_LCD_3V0 (3.0V) 26MHz GSD5T VCC_GPS_1V8 (GPS) (1.8V) TCXO 26MHz LGE Internal Use Only - 155 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 156 [1.8A Operational] LOUTA VBATT2 VBAT VBATT1A LOUTB CP_OUT [10mA] VSPI VBATT1B CP_OUT DC/DC VCMOS RF6260 BGSF18DM20 RF6560 VSDI LGE Internal Use Only - 156 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 157 Current Sense PWR_I2C_SDA VBAT PWR_I2C_SCL PWR_I2C_SCL BATT FUEL GAUGE MAX17043G GAUGE_INT GAUGE_INT ALRT CELL PWR_I2C_SDA PWR_I2C_SDA PWR_I2C_SCL PWR_I2C_SCL LGE Internal Use Only - 157 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 158: Audio Block Diagram
SPI2_MOSI/ GPIO_X00 MIC2 INA1/ EXTMICP MODE SBIAS EARPOLE_DETECT GPIO_PBB6/ GPIO_BB06 HOOK_DETECT ULPI_DATA4/ GPIO_O05 EAR_SENSE_3.5PI DET_IN SUB_MIC_BIAS_LDO_EN GM1_CS7_N/ GPIO_I06 LGE Internal Use Only - 158 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 159 USIF1_RXD_MRSR GEN2_I2C_SCL IFX_USB_DP HSD2+ USB_DPLUS IFX_USB_DM HSD2- USB_DMINUS JTAG I/F UART_RX_IFX Sil9244 UART_TX_IFX CUSB_ID AP_UART_RX AP_UART_TX MHL_D MHL_DB LGE Internal Use Only - 159 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 160 MHL Mode MHL_LDO_EN MHL_1V8 IDCOM USB_ID USB_ID2 GPIO_PV2 +3V3_VHDMI HPD : Hot Plug Detect MHL_I2C_SDA KB_COL07 MHL_I2C_SCL KB_COL06 LGE Internal Use Only - 160 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 161 GEN2_I2C_SDA MUIC(MAX14526) LCD BL(LM3533) CAM PMIC(LP8720) 8M CAMERA(C8AA-Y412A) CAM_I2C_SCL VT(1.26M) CAMERA(C1FA-M383A) CAM_I2C_SDA Flash _LED Driver(LM3559) DDC_I2C_SCL HDMI(SII9244) DDC_I2C_SDA LGE Internal Use Only - 161 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 162: Circuit Diagram
SPI_CLK SDI_CLK LOUTB L1025 SPI_DRW SDI_DATA LOUTA C1077 C1078 C1079 C1080 2.2u 2.2u 100p C1081 C1082 5.6p 5.6p - 162 - LGE Internal Use Only Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 163 100K VBAT U2002 220n 2012.04.10 Q2000 SSM6L39TU UART_RX_IPC UART_RX_SW IFX_USB_VBUS_EN (Active high) C2042 R2014 100n EBK61693301 4.7K Rev.B - 163 - LGE Internal Use Only Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 164 AD10 AR15 1.2K 1% AP32 PEX_WAKE_N AP36 PEX_TERMP AP33,681PIN,CortexA9,1.5GHz,4Core,36MP,HD1080P,3D,IC,Digital SignalProcessors BGA R/TP 681P AP33,681PIN,CortexA9,1.5GHz,4Core,36MP,HD1080P,3D,IC,Digital SignalProcessors BGA R/TP 681P - 164 - LGE Internal Use Only Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 165 GND_093 AU13 GND_190 GND_094 AU19 GND_191 GND_095 AU25 GND_096 GND_097 AU31 GND_098 AU35 GND_099 Daisy_Chain Daisy Chain Rev.1.0 - 165 - LGE Internal Use Only Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 166 150K 470K REV G 1.364 ERHZ0000288 Change 2012.04.20 150K 680K REV_1.0 1.474 ERHZ0000537 150K 750K REV_1.1 1.500 ERHZ0000316 - 166 - LGE Internal Use Only Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 167 Q6001 EAN62344201 Q6002 SEL : LOW -> CP UART PWR_I2C_SCL SEL : HIGH -> CP USB CHANGE 2012.04.05 - 167 - LGE Internal Use Only Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 168 2012.04.19 DGND C7027 2.2u SUB-MIC BIAS LDO VBAT SUB_MIC_BIAS BU18TD2WNVX U7003 VOUT SUB_MIC_BIAS_LDO_EN STBY C7028 C7029 EUSY0407501 Rev.C - 168 - LGE Internal Use Only Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 169 MIPI_RESET_B LCD_BRIDGE_RESET_N VOUT LCD_RGB_B_6 DATA_22 RGB_IC_EN LCD_RGB_B_7 DATA_23 STBY C8012 +1V2_VPWR C8013 EUSY0407501 Rev.C VA8002 +1V8_VPWR +1V8_VPWR VA8003 - 169 - LGE Internal Use Only Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 170: Flash Led
VT CAM IO CAM_I2C_SCL TP9001 VT_RESET_N ENBY0039601 VT_1.8V_CAM_VIO VBAT GB042-20S-H10-E3000 TP9002 U9002 VOUT ESD5205P6T6G VT_1.8V_EN STBY D9001 C9026 C9027 Rev.C - 170 - LGE Internal Use Only Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 171 VOUT RESV1 PROXI_LDO_EN STBY Rev.1.0 120628 C10051 2.2n C10052 C10053 EUSY0410201 ZD10001 Rev.C C10054 C10055 C10056 0.1u 0.1u - 171 - LGE Internal Use Only Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 172 C11047 5G_WLAN_RX GND1 X11000Q22FA1280013000 XO_IN R11003 EAT61473401 XO_OUT 37.4MHz EAW61645401 +VPWR_WL C11051 C11052 C11053 Rev.1.0 120628 Rev.1.0 120628 - 172 - LGE Internal Use Only Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 173 AIO_1 GPIO2/TSYNC TP12006 AIO_0 GPIO3/ECLK 26MHz_GPS_REF GPIO4/EIT1 TP12005 GPIO5/TM GPS_LNA_EN GPIO6/UART_CTS R12005 UART_AP_RTS_GPS_CTS R12006 GPIO7/UART_RTS UART_AP_CTS_GPS_RTS Rev.B GPS_32K_CLK_IN - 173 - LGE Internal Use Only Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 174 Control Input(Sn) Function Rev.B nB0 Connected to nA C13020 Must Check Schematic 0.1u HIGH nB1 Connected to nA - 174 - LGE Internal Use Only Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 175 NC139 DQ25 DDR_DQ25 DDR_DQ26 DQ26 DDR_DQ27 DQ27 DDR_DQ28 DQ28 DDR_DQ29 DQ29 DDR_DQ30 DQ30 DDR_DQ31 DQ31 2012.04.09 R14023 Delete - 175 - LGE Internal Use Only Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 176 0.0033uF EAR_MIC_N SUB MIC HOT KEY KB100 SUB_MIC_BIAS KEY_C[0] KEY_R[1] gnd connect to sub_mic_n MIC100 D101 D100 SUB_MIC_P - 176 - LGE Internal Use Only Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 177 LD103 VB100 F_LED_MOTOR_P MIC100 F_LED_MOTOR_M R103 R102 MAIN_MIC_P R100 R101 C108 MAIN_MIC_N C107 0.1u KEY_LED_DRV_N MAIN_MIC_BIAS D100 D101 - 177 - LGE Internal Use Only Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 178: Bga Pin Map
8. BGA PIN MAP 8. BGA PIN MAP PMB5712,A2 (EAN62514301) PMB571 (EAN625 Not Used LGE Internal Use Only - 178 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 179 8. BGA PIN MAP H9DA1GH25HAMMR-4EM NAND/1G SDRAM/256M CP Memory (EAN62327101) Not Used LGE Internal Use Only - 179 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 181 8. BGA PIN MAP WIFI, BT Combo BCM4330HB2KUBG (EAN62508401) WIFI, BT BCM433 (EAN625 Not Used LGE Internal Use Only - 181 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 182 8. BGA PIN MAP SK Hynix –LPDDR Memory H9TCNNN8JDMMPR-NGM // EAN62529201 // E Not Used Not Used LGE Internal Use Only - 182 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 183 8. BGA PIN MAP SK Hynix –LPDDR Memory H9TCNNN8JDMMPR-NGM // EAN62529201 // E Not Used LGE Internal Use Only - 183 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 184 8. BGA PIN MAP SSD2825G44 (EAN62222401) RGB CONVERTER SSD28 (EAN62 RGB CO Not Used LGE Internal Use Only - 184 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 185 8. BGA PIN MAP MAX77663(EAN62216701)PMIC MAX7766 (EAN622 PMIC Not Used LGE Internal Use Only - 185 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 188 8. BGA PIN MAP MHL IC SiI9244 (EAN62095001) MHL IC SiI9244 (EAN62095001) Not Used LGE Internal Use Only - 188 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 189: Pcb Layout
U7002 : Motor Drive IC (ISA1200) - no Vibrator U10007 : GYRO+MOTION SENSOR (MPU-6050) - no GYRO sensing - no Motion sensing LG-P895_MAIN_EAX64912401-1.0-TOP - 189 - LGE Internal Use Only Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 190 CN12000/CN12001: GPS ANT. CN11000/CN11001 : BT/WLAN ANT CONTACT (HJ-ICT-06Y) CONTACT (HJ-ICT-06Y) - no GPS - no searching (BT/WIFI) LG-P895_MAIN_EAX64912401-1.0-BOT - 190 - LGE Internal Use Only Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 191 9. PCB LAYOUT CN100 U100 C100 C101 MIC100 C104 R100 LG-P895_ F_EAR_EAX65023501_1.0 - 191 - LGE Internal Use Only Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 192 9. PCB LAYOUT FB100 C102 FB101 C103 LG-P895_ F_EAR_EAX65023501_1.0 - 192 - LGE Internal Use Only Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 193 9. PCB LAYOUT C109 C110 R100 LD100 R101 LD101 R102 LD102 R103 LD103 LG-P895_F_LED_EAX64881201_1.0_TOP - 193 - LGE Internal Use Only Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 194 9. PCB LAYOUT C103 SW100 ANT1002 ANT1003 C112 C107 FB100 CN100 VB100 LG-P895__F_LED_EAX64881201-1.0-BOT - 194 - LGE Internal Use Only Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 195: Calibration
Power Supply 5.0V RF Test Equipment E5515C(8960) NOTICE 1. Use the Battery CMW500 RF Cable connection Reference to Attached image LGE Internal Use Only - 195 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 196 10. CALIBRATION P895 MS695 [TachyonV36]LGP895 20120821 Calibration [Tachyon36]LGMS695_20120213_Calibration LGE Internal Use Only - 196 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 200 10. CALIBRATION P895 MS695 LGP895 LGP895 P895 MS695 P895 MS695 MS695 P895 MS695 P895 MS695 P895 MS695 LGP895 LGE Internal Use Only - 200 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 203 10. CALIBRATION 5.5V 5 0V 5.0V MS-156C BJAY0024004 MS-156C 5.5V RAD32167861 BJAY0023732 LGE Internal Use Only - 203 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 212 10. CALIBRATION LG-P895 MS695 LG-P895 MS695 MS695 LGP895 MS695 MS695 LGP895 MS695 LGP895 LGP895 MS695 LGP895 MS695 LGE Internal Use Only - 212 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 215: Hidden Menu
All Auto Test – Partial All Auto Test Result – Partial All Auto Test – Full Normal Boot(+power key) FTM Boot(+power key) LGE Internal Use Only - 215 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 216 All Auto Test : -> All Auto Test menu click -> Continuous information on the menu, giving you ability test LGE Internal Use Only - 216 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 217 Item list : USIM Card SD Card Ear Phone Battery Key / Proximity / ALC / Compass Camera(Main) Test LGE Internal Use Only - 217 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 218 11. HIDDEN MENU Camcorder Test Camera(VT) Test CAMERA Display Check Test LGE Internal Use Only - 218 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 220 11. HIDDEN MENU Accelerometer Test Gesture Test Gyroscope Test LGE Internal Use Only - 220 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 222 List : All Auto Test – Partial All Auto Test Result – Partial All Auto Test Menu – Full LGE Internal Use Only - 222 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 223 RGB Bridge IC Test RTC Test Sound Test Touch Test Touch LED Brightness Wifi Scan Test HDMI Connection Repeat ELT Test LGE Internal Use Only - 223 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 224 Format Internal SD card : Internal SD Card Data reset Factory Rest : Changing the Factory Version Info Classified Information representation LGE Internal Use Only - 224 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 225 Fuel Gauge Reset FOTA Test Crash Handling SMPL Setting SMPL Count Wakelock Monitoring Setting RIL Recovery WLAN performance on SW LGE Internal Use Only - 225 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 227 LGE Internal Use Only - 227 - - 227 - Copyright © 2012 LG Electronics. Inc. All right reserved. Copyright © 2011 LG Electronics. Inc. All right reserved. Only for training and service purposes Only for training and service purposes...
Page 228 LGE Internal Use Only - 228 - - 228 - Copyright © 2012 LG Electronics. Inc. All right reserved. Copyright © 2011 LG Electronics. Inc. All right reserved. Only for training and service purposes Only for training and service purposes...
Page 230: Engineering Mode
11. HIDDEN MENU Engineering Mode GPS Test GPS HW Test LGE Internal Use Only - 230 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 236 11. HIDDEN MENU TouchArea Setting HDMI Resolution Test Fake Language LGE Internal Use Only - 236 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 239: Disassemble Guide
1. Disassemble Battery Cover Remove BATTERY COVER after unscrewing 2 points (Star-shaped screws on the bottom of the set) LGE Internal Use Only - 239 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 240 Remove REAR COVER by pulling the side of REAR COVER, after unscrewing 14 points (Follow the order of the pictures) LGE Internal Use Only - 240 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 241 2. After removing MAIN CAMERA, Remove POWER BUTTON FPCB 3. Remove BATTERY pushing tool on the right side of BATTERY LGE Internal Use Only - 241 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 242 2. Remove MOTOR 3. Remove MAIN ANTENNA by bending the bottom of the set 4. Remove MAIN MIC CAP LGE Internal Use Only - 242 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 244 2. Remove EAR JACK 3. Remove VT CAMERA with a pincette 4. Remove 4 PAD BRACKETs 5. Remove 4 LCD SCREWs LGE Internal Use Only - 244 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 245 10. Remove PAD GASKET from LED FPCB 11. Remove GASKET LCD 2 12. Remove LED FPCB from FRAME LGE Internal Use Only - 245 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 246 [ Going through the hole at the bottom part of the FRAME] 14. Remove LCD from FRAME 15. Remove GASKET LCD 1 from LCD LGE Internal Use Only - 246 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 247 7. Disassemble MAIN PCB Remove SHIELD CAN from MAIN PCB by unhooking 2 points 8. Complete disassembling P895 LGE Internal Use Only - 247 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 248: Exploded View & Replacement Part List
Cable,Assembly MBL04 MAZ00 Cap,Multimedia Card EAJ00 LCD,Module-TFT Cap,Receptacle EBR04 MBL00 PCB Assembly,Main EAU00 Motor,DC MBL01 ABM00 Can Assembly,Shield - 248 - LGE Internal Use Only Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 249: Replacementparts
Frame MDQ63316621 P895 FRAME, INSERT MOLD CASTING MG LGP895.ADEUBK ZZ:Without Color MDQ000000 Frame MDQ63280121 P895 FRAME, INSERT DIECASTING LGE Internal Use Only - 249 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 250 MJN68124501 F100s_insulator_top2 COMPLEX LGF100S.ASKTBK ZZ:Without Color MJN061108 Tape,Protect MJN68160601 F100_tape_protection_4 COMPLEX LGF100S.ASKTBK ZZ:Without Color MJN061107 Tape,Protect MJN68247001 F100_Tape_nsulator_top3 LGE Internal Use Only - 250 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 251 COMPLEX LGF100S.ASKTBK ZZ:Without Color MJN061103 Tape,Protect MJN68143001 insulator_l COMPLEX LG-LC3200 WA:White PRINTING, PPRI MEZ000000 Label MLAZ0038303 PRINTING LGE Internal Use Only - 251 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 252 MCQ000001 Damper MCQ67211802 P895 PAD LED 2 COMPLEX LGP895.AFRAWH ZZ:Without Color MCQ000000 Damper MCQ67211801 P895 PAD LED 1 LGE Internal Use Only - 252 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 253 BLACK - MOLD URETHANE LGP895.ADEUBK ZZ:Without MBL01 MBL65258511 Color - MOLD URETHANE LGF100S.ASKTBK ZZ:Without MBL02 MBL65258601 Color - LGE Internal Use Only - 253 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 254 MFB62853201 MCR000000 Decor MCR64768101 CASTING AL LGF100S.ASKTBK ZO:ZOUGE - CUTTING PSR LGF100S.ASKTBK ZZ:Without MCQ009400 Damper,Camera MCQ66916501 Color - LGE Internal Use Only - 254 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 255 MEV64314001 P895 Insulator Can PRESS SUS 301 0.08 LGP895.AGBRWH ZY:Color MBK070301 Can,Shield MBK63393401 Unfixed P895 Can, Shield Gasket LGE Internal Use Only - 255 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 256 Label,Unit Box MEZ64780802 P895 FRA USP Label (French) COMPLEX LGP880.ADEUBK ZZ:Without Color MEZ084100 Label,Unit Box MEZ64686901 UBox Bar_LGP880_STD LGE Internal Use Only - 256 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 257 COMPLEX LGP895.AFRABK ZZ:Without Color MBL007000 Cap,Box MBL65400401 G1C Type_Cap_For 1200*800 MGA000000 Pallet MPCY0012403 COMPLEX KG800 FRABK DB:DARK BLUE - LGE Internal Use Only - 257 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 258: Main Component
PCB Assembly EBR070300 EBR74704201 LGF100S.ASKTBK 1.0 Flexible Flexible,SMT Top EAX010500 PCB,Sidekey EAX64664601 LGF100S.ASKTBK 1.0 POLYI Multi 2 0.18 Sidekey LGE Internal Use Only - 258 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 259 LD102 SEMICONDUCTOR CO.,LTD LD103 R100 R101 MCR01MZP5J331 330OHM 5% 1/16W 1005 R/TP - Resistor,Chip ERHZ0000464 R102 ROHM. R103 LGE Internal Use Only - 259 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 260 Flexible,Insert PCB Assembly EBR070400 EBR76047201 LGP895.ADEUWH 1.0 Flexible Flexible,SMT PCB Assembly EBR070300 EBR76029701 LGP895.ADEUWH 1.0 Flexible Flexible,SMT Top LGE Internal Use Only - 260 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 261 Tape LS Mtron Ltd. LS01-I-12031-A0 DUAL -4DB 4 FPCB Type - GPS EAA030101 PIFA Antenna,GPS EAA62945001 Tape LS Mtron Ltd. LGE Internal Use Only - 261 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 262 1005 R/TP - ROHM Semiconductor KOREA Ceramic,Chip CORPORATION GRM0335C1E6R8BD01D 6.8 C5029 Capacitor pF,25V,B,C0G,TC,0603,R/TP,0.0000000000068,0. ECCH0042007 C5030 Ceramic,Chip 1PF,25V,C0G,-55TO+125C,0603,R/TP,0.3 mm MURATA MANUFACTURING CO.,LTD. LGE Internal Use Only - 262 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 263 Ceramic,Chip C6017 MECHANICS CO., LTD. C6018 C6032 C6032 C8004 C8005 C8006 C9005 C9008 C9010 C9011 C9019 C9021 C9022 LGE Internal Use Only - 263 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 264 R/TP - YAGEO CORPORATION C1080 Capacitor C0603C0G1H101JT00NN 100pF 5% 50V C0G - ECCH0009103 C6007 Ceramic,Chip 55TO+125C 0603 R/TP - TDK CORPORATION LGE Internal Use Only - 264 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 265 R/TP EPSON TOYOCOM CORP R3000 R3001 R3002 MCR006YZPF2201 2.2KOHM 1% 1/20W 0603 Resistor,Chip ERHY0009586 R3003 R/TP - ROHM. R3006 R3007 LGE Internal Use Only - 265 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 266 MCR01MZP5F33R0 33OHM 1% 1/16W 1005 R/TP R3027 Resistor,Chip ERHZ0000270 - ROHM. R13009 MCR006YZPF4700 470OHM 1% 1/20W 0603 R/TP Resistor,Chip ERHY0009541 R13010 - ROHM. LGE Internal Use Only - 266 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 267 Ceramic,Chip COOPERATION C12019 MCR01MZP5J474 470KOHM 5% 1/16W 1005 R/TP R2018 Resistor,Chip ERHZ0000487 - ROHM. LG HK 0603 1N5S-T 1.5H 0.3NH - 430mA - - L11004 Inductor EAP62227101 0.13OHM 10GHZ 4 SHIELD - 0.6X0.3X0.3MM R/TP L11045 Multilayer,Chip TAIYO YUDEN CO.,LTD CN13001 GB042-24S-H10-E3000 24P 0.40MM STRAIGHT...
Page 268 MANUFACTURING CO.,LTD. GRM188R61E105K 1uF 10% 25V X5R -55TO+85C Capacitor C6002 ECZH0003503 1608 R/TP - MURATA MANUFACTURING Ceramic,Chip CO.,LTD. LGE Internal Use Only - 268 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 269 MANUFACTURING CO.,LTD. MCH155C150J 15pF 5% 50V NP0 -55TO+125C Capacitor C11051 ECCH0000112 1005 R/TP - ROHM Semiconductor KOREA Ceramic,Chip CORPORATION LGE Internal Use Only - 269 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 270 TCTOM1A225M8R 2.2uF 20% 10V 2.2UA - Capacitor 55TO+105C 0.8OHM 1.6X0.85X0.9MM : C1077 EAE62682901 TA,Polymer 1.6X0.85X0.9MM NONE SMD R/TP 0.9 MM max. ROHM CO.,LTD. LGE Internal Use Only - 270 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 271 LQG15HS56NJ02D 56NH 5% - 200mA 0.82OHM L7002 Inductor ELCH0003825 800MHZ 8 SHIELD NONE 1.0X0.5X0.5MM R/TP L7003 Multilayer,Chip MURATA MANUFACTURING CO.,LTD. LGE Internal Use Only - 271 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 272 FB11002 MANUFACTURING CO.,LTD. GB042-14S-H10-E3000 14P 0.40MM STRAIGHT CN13000 Connector,BtoB EAG63013701 SOCKET SMD R/TP 1M - LS Mtron Ltd. LGE Internal Use Only - 272 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 273 CIM05J102NC 1000 ohm 1.0X0.5X0.5 25% 0.8 FB9001 Filter,Bead EAM62131001 ohm 0.25 SMD R/TP 2P 0 SAMSUNG ELECTRO- FB9002 MECHANICS CO., LTD. LGE Internal Use Only - 273 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 274 HPA01112AIRGTR o to 28V adj 0W QFN R/TP 16P U6006 IC,Current Monitor EAN62344201 - TEXAS INSTRUMENTS KOREA LTD, HONGKONG BRANCH. LGE Internal Use Only - 274 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 275 100mW TFSC R/TP 2P 1 KEC CORPORAITION VA7000 ICVL0518100Y500FR 18V 0% 10F 1.0*0.5*0.55 Varistor SEVY0004301 VA7001 NONE SMD R/TP INNOCHIPS TECHNOLOGY LGE Internal Use Only - 275 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 276 R/TP 90P - MAXIM INTEGRATED PRODUCTS INC. 1XXA26000FBA 26MHZ 1PPM 1.8V Oscillator X1000 EAW61443801 2.5x2.0x0.8MM ; SMD R/TP DAISHINKU VCTCXO CORPORATION. LGE Internal Use Only - 276 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 277 - ROHM. FCW401Z5L WHITE 3.7~4.3V 1A 160lm - 1170mW LD9000 LED,Flash EAV61694901 2016 R/TP 2P - SEOUL SEMICONDUCTOR CO.,LTD LGE Internal Use Only - 277 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 278 C5035 C5036 C9006 C9007 C9009 C9012 RC0201FR-074R7L 4.7OHM 1% 1/20W 0603 R/TP R2011 Resistor,Chip ERHY0040202 - YAGEO CORPORATION LGE Internal Use Only - 278 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 279 ELECTRO-MECHANICS CO., LTD. C4017 C4034 C4045 C4047 C9020 RC0201JR-0722RL 22OHM 5% 1/20W 0603 R/TP - R13019 Resistor,Chip EBC61856101 YAGEO CORPORATION LGE Internal Use Only - 279 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 280 MCR01MZP5J330 33OHM 5% 1/16W 1005 R/TP - R3062 Resistor,Chip ERHZ0000463 ROHM. R7004 U10005 IC,LDO Voltage EUSY0410201 BU30TD4WNVX ROHM. U10008 Regulator LGE Internal Use Only - 280 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 281 BU18TD4WNVX SSON004,4,R/TP,1.8V 150mA U13001 IC,LDO Voltage EUSY0407501 Single LDO,IC,LDO Voltage RegulatorIC,LDO U7003 Regulator Voltage Regulator ROHM. U8000 U8005 U9002 LGE Internal Use Only - 281 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 282 MIPS2520D3R3M 3.3UH 30% - 400mA 0.4 1 L2000 Inductor,Wire ELCP0008007 0.12OHM - - SHIELD 2.5X2X1MM NONE R/TP L2001 Wound,Chip FDK CORPORATION. LGE Internal Use Only - 282 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 283 ,3B,2LDO,CSP,1.732X1.722 ,; ,IC,DC,DC Converter MICRO DEVICES, INC. R5024 MCR006YZPJ102 1KOHM 5% 1/20W 0603 R/TP - Resistor,Chip ERHY0009504 R6001 ROHM. LGE Internal Use Only - 283 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 284 CL03A224KP3NNNC 220nF 10% 10V X5R - Capacitor C7001 EAE62762401 55TO+85C 0603 R/TP 0.33 MM SAMSUNG Ceramic,Chip ELECTRO-MECHANICS CO., LTD. LGE Internal Use Only - 284 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 285 SOLOMON SYSTECH LTD R3000 R3001 R3002 MCR006YZPF2201 2.2KOHM 1% 1/20W 0603 Resistor,Chip ERHY0009586 R3003 R/TP - ROHM. R3006 R3007 LGE Internal Use Only - 285 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 286 C4013 GRM188R60J106M 10000000 C4015 Capacitor ECCH0005604 pF,6.3V,M,X5R,TC,1608,R/TP,0.8 mm MURATA C4025 Ceramic,Chip MANUFACTURING CO.,LTD. C4027 C4048 C4050 C5027 C5028 LGE Internal Use Only - 286 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 287 1Ch/2CS) HYNIX SEMICONDOCTOR GRM1555C1H680F 68pF 1% 50V C0G - Capacitor C12017 ECCH0033301 55TO+125C 1005 R/TP - MURATA Ceramic,Chip MANUFACTURING CO.,LTD. LGE Internal Use Only - 287 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 288 CL10A105KB8NNNC 1uF 10% 50V X5R - Capacitor C6025 EAE62505701 55TO+85C 1608 R/TP 0.9T max. - SAMSUNG Ceramic,Chip ELECTRO-MECHANICS CO., LTD. LGE Internal Use Only - 288 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 289 55TO+125C 1005 R/TP - TDK KOREA Ceramic,Chip COOPERATION RC0201FR-07240RL 240OHM 1% 1/20W 0603 R14016 Resistor,Chip EBC61856201 R/TP - YAGEO CORPORATION LGE Internal Use Only - 289 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 290 2.3GHZ 8 SHIELD NONE 1.0X0.5X0.5MM R/TP Multilayer,Chip TAIYO YUDEN CO.,LTD RC0402FR-07453RL 453OHM 1% 1/16W 1005 R3035 Resistor,Chip ERHY0039802 R/TP - YAGEO CORPORATION LGE Internal Use Only - 290 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 291 EAA62769403 LS Mtron Ltd. LS01-I-11099-A0 SINGLE -2DB 5.0 FPCB Type - EAA030101 PIFA Antenna,RF EAA62769402 LS Mtron Ltd. LGE Internal Use Only - 291 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...
Page 292: Accessory
Card,Service Guide MBM63799205 PRINTING LGP895.AFRABK ZZ:Without Color - PRINTING LGP920.AFRAML ZZ:Without Color MBM087200 Card,Warranty MCDF0010001 Warranty card for France LGE Internal Use Only - 292 - Copyright © 2012 LG Electronics. Inc. All right reserved. Only for training and service purposes...

LG -P895 Service Manual

1 Introduction

2 Performance

3 CIC and Service Center

4 Trouble Shooting

5 Download

6 Block Diagram

7 Circuit Diagram

8 Bga Pin Map

9 Pcb Layout

10 Calibration

11 Hidden Menu

12 Disassemble Guide

13 Exploded View & Replacement Part List

Quick Links

Troubleshooting

Related Manuals for LG LG-P895

Summary of Contents for LG LG-P895

Table of Contents