Page 60
http://www.xiaoyu163.com 6ZG-1 English 3 7 63 1515 0 SERVICE MANUAL L 13942296513 CD MECHANISM BASIC CD MECHANISM :3ZG-2 E2NM TYPE ZZRNDM YZZRNDM ZZRNIM YZZRNDCM u163 S/M Code No. 09-001-338-7N8 http://www.xiaoyu163.com...
Page 61
http://www.xiaoyu163.com PROTECTION OF EYES FROM LASER BEAM DURING SERVICING 3 7 63 1515 0 This set employs laser. Therefore, be sure to follow carefully the CAUTION instructions below when servicing. Use of controls or adjustments or performance of procedures other than those specified herein may result in hazardous WARNING! radiation exposure.
Page 62
http://www.xiaoyu163.com Precaution to replace Optical block (KSS-213F) 3 7 63 1515 0 Body or clothes electrostatic potential could ruin laser diode in the optical block. Be sure ground body and workbench, and use care the clothes do not touch the diode. 1) After the connection, remove solder shown in the right figure.
Page 63
http://www.xiaoyu163.com DISASSEMBLY INSTRUCTIONS-1/3 3 7 63 1515 0 1. How to replace PICK UP. PICKUP Open the TRAY. Push the stopper to arrow direction and release half of the SHAFT SLED. Turn GEAR MAIN CAM to the counterclockwise (arrow “a”) direction, and lift up CD mechanism. (Fig-1) Remove SHAFT SLED.
Page 64
http://www.xiaoyu163.com DISASSEMBLY INSTRUCTIONS-2/3 3 7 63 1515 0 3. The disassemble and reassemble the TRAY 3-1. Disassembling procedure. Push the PLATE GEAR’S Boss at the bottom part of CHAS MECHA strongly to the outside (arrow “b” direction). (Fig-3) (Confirm that TRAY appears a little in the front.) Draw TRAY to the open position.
Page 65
http://www.xiaoyu163.com DISASSEMBLY INSTRUCTIONS-3/3 3 7 63 1515 0 4. How to reassemble the TURN TABLE. (Fig-7) Push LEVER TT in the direction of “C”, and put in the TURN TABLE 5CD. (Fig-7) After reassembly, one of the TURN TABLE DISC TRAY (can be either one of the five disc trays) must be aligned with TURN TABLE 5CD.
Page 66
http://www.xiaoyu163.com ELECTRICAL MAIN PARTS LIST-1/2 3 7 63 1515 0 REF. NO PART NO. KANRI DESCRIPTION REF. NO PART NO. KANRI DESCRIPTION C158 87-A11-132-080 CAP,TC U 0.01-50 K B<ZZRNIM> C160 87-010-405-040 CAP,E 10-50 87-A21-821-130 C-IC,LC78645NE C201 87-010-759-080 C-CAP,U, 0.1-25F 87-001-982-010 IC,TA7291S C202 87-010-382-040...
Page 67
http://www.xiaoyu163.com ELECTRICAL MAIN PARTS LIST-2/2 3 7 63 1515 0 • Regarding connectors, they are not stocked as they are not the initial order items. The connectors are available after they are supplied from connector manufacturers upon the order is received. CHIP RESISTOR PART CODE Chip Resistor Part Coding Figure...
Page 68
http://www.xiaoyu163.com TRANSISTOR ILLUSTRATION-1/1 3 7 63 1515 0 E C B E C B 2SC1815 2SA1235 2SC2001 PT380F KTA1266 2SD2172 2SC3052 CSA952K DTC143TK RT1N141C L 13942296513 u163 http://www.xiaoyu163.com...
Page 69
http://www.xiaoyu163.com IC BLOCK DIAGRAM-1/1 IC, BA6998FP 3 7 63 1515 0 IC, TA7291S L 13942296513 PROTECTOR CIRCUIT (TSD) STOP u163 BRAKE : HI IMPEDANCE NOTE : INPUT “H” ACTIVE -10- http://www.xiaoyu163.com...
Page 70
http://www.xiaoyu163.com BLOCK DIAGRAM-1/1 3 7 6 3 1 5 1 5 0 1 3 9 4 2 2 9 6 5 1 3 PS401 w w w u 1 6 3 -11- http://www.xiaoyu163.com...
Page 72
http://www.xiaoyu163.com SCHEMATIC DIAGRAM-1/1 3 7 6 3 1 5 1 5 0 1 3 9 4 2 2 9 6 5 1 3 w w w u 1 6 3 SG-240 -13- http://www.xiaoyu163.com...
Page 73
http://www.xiaoyu163.com WIRING-2/2 (T-T/CD MOTOR) 3 7 63 1515 0 TO 5CD C.B CN301 TO 5 C D C. B C N 5 0 1 L 13942296513 u163 -14- http://www.xiaoyu163.com...
Page 75
http://www.xiaoyu163.com IC DESCRIPTION-1/1 (LC78645NE)-1/2 3 7 63 1515 0 Pin No. Pin Name Description SLCO Control output. SLCIST SLCO output current adjustment resistor connection pin. EFMIN RF signal input pin. RF monitor pin. RFVDD — RF power supply pin. RFVSS —...
Page 76
http://www.xiaoyu163.com IC DESCRIPTION-1/1 (LC78645NE)-2/2 3 7 63 1515 0 Pin No. Pin Name Description LCHO L channel output pin. LVSS — L channel ground pin. Must be connected to 0V. RVSS — R channel ground pin. Must be connected to 0V. RCHO R channel output pin.
Page 77
http://www.xiaoyu163.com MECHANICAL EXPLODED VIEW-1/1 3 7 63 1515 0 L 13942296513 (AZF-H) 3ZG-2 E2 CUSH CD A u163 -18- http://www.xiaoyu163.com...
Page 78
http://www.xiaoyu163.com MECHANICAL PARTS LIST-1/1 3 7 63 1515 0 REF. NO PART NO. KANRI DESCRIPTION REF. NO PART NO. KANRI DESCRIPTION 1 86-ZG1-001-410 TRAY,5CD 31 86-ZG1-215-110 HLDR,CHUCK 2 84-ZG1-267-010 PULLEY,LOAD MO 8 32 86-ZG1-238-010 HLDR,MAGNET 6ZG N 3 87-A90-036-010 MOT ASSY,RF-300CA-11 33 86-ZG1-225-010 BELT,SQ1.2-32.9 4 86-ZG1-228-110...
Page 79
http://www.xiaoyu163.com 3 7 63 1515 0 COLOR NAME TABLE Basic color symbol Color Basic color symbol Color Basic color symbol Color Black Cream Orange Green Gray Blue Transparent Blue Gold Pink Silver Titan Silver Brown Violet White Transparent White Yellow Transparent Yellow Metallic Blue Light Blue...
Page 80
http://www.xiaoyu163.com CD MECHANISM EXPLODED VIEW 1/1 (3ZG-2 E2) 3 7 63 1515 0 L 13942296513 u163 -21- http://www.xiaoyu163.com...
Page 81
http://www.xiaoyu163.com CD MECHANISM MAIN PARTS LIST 1/1 (3ZG-2 E2) 3 7 63 1515 0 REF. NO PART NO. KANRI DESCRIPTION 1 83-ZG2-261-010 CHAS ASSY, E2 2 87-A90-836-010 PICKUP,KSS-213F(E2) 3 83-ZG2-235-010 GEAR,A3(E2) 4 83-ZG2-205-210 GEAR,B(E2) 5 83-ZG2-236-010 GEAR,MOTOR 3(E2) 6 83-ZG2-253-110 SHAFT,SLIDE 5(E2) 7 87-045-356-010 MOT,RF-310TA 30(E2)
Page 82
http://www.xiaoyu163.com 3 7 63 1515 0 L 13942296513 u163 2–11, IKENOHATA 1–CHOME, TAITO-KU, TOKYO 110-8710, JAPAN TEL:03 (3827) 3111 Printed in Singapore 0251431 http://www.xiaoyu163.com...