Page 1 When it comes to service, remember that your Toyota dealer knows your vehicle best and is interested in your complete satisfaction. He will provide quality maintenance and any other assistance you may require. If there is not a Toyota dealer near you, or you need emergency assistance for any reason, please call the following number: U.S. OWNERS: Toyota Customer Assistance Center Toll–free:1–800–331–4331...
Page 2: Toyota
’02 Corolla U (L/O 0105) Important information about this manual Safety and vehicle damage warnings Safety symbol Throughout this manual, you will see safety and vehicle dam- age warnings. You must follow these warnings carefully to avoid possible injury or damage. The types of warnings, what they look like, and how they are used in this manual are explained as follows: CAUTION...
Page 3: Table Of Contents
....... Your Toyota’s identification ........
Page 4: Break-In Period
To help prevent gas station mix–ups, your Use of unleaded fuel with an octane num- to the future economy and long life of Toyota has a smaller fuel tank opening. ber or rating lower than stated above will your vehicle: The special nozzle on pumps with un- cause persistent heavy knocking.
Page 5: Toyota
Toyota does not recommend the use of is expected to be applied world wide. Toyota, be sure that it has an octane gasoline that contains MMT. If fuel con- The WWFC consists of three categories rating no lower than 87.
Page 6: Fuel Pump Shut Off System
’02 Corolla U (L/O 0105) Fuel pump shut off system Operation in foreign countries The fuel pump shut off system stops sup- If you plan to drive your Toyota in NOTICE plying fuel to the engine to minimize the another country...
Page 7: Three-Way Catalytic Converter
Do not drive with an extremely low vehicle in for a check–up as soon fuel level; running out of fuel could as possible. Remember, your Toyota cause the engine to misfire, creat- dealer knows your vehicle and its ing an excessive load on the three–...
Page 8: Engine Exhaust Cautions
’02 Corolla U (L/O 0105) Facts about engine oil Engine exhaust cautions consumption FUNCTIONS OF ENGINE OIL CAUTION Keep the trunk lid closed while Engine oil has the primary functions of driving. An open or unsealed trunk lubricating and cooling the inside of the Avoid inhaling the engine exhaust.
Page 9: Iridium-Tipped Spark Plugs
More oil is consumed by high–speed driv- regularly. Toyota recommends that the oil ing and frequent acceleration and decel- level be checked every time you refuel Your engine is fitted with iridium–tipped eration.
Page 10: Brake System
’02 Corolla U (L/O 0105) Brake system The tandem master cylinder brake system Effective way to press the ABS brake CAUTION is a hydraulic system with two separate pedal: When the anti–lock brake system sub–systems. If either sub–system should function is in action, you may feel the Do not pump the brake pedal if the fail, the other will still work.
Page 11 ’02 Corolla U (L/O 0105) You may hear a click or motor sound in CAUTION Driving on rough, gravel or snow– the engine compartment for a few seconds covered roads. when the engine is started or just after overestimate anti–lock the vehicle is started.
Page 12 Contact your Toyota dealer as soon as possible to service the vehicle. The light does not come on when the ignition key is turned to the “ON” posi- tion, or remains on.
Page 13: Brake Pad Wear Limit Indicators
Toyota Section 8. Never allow anyone to ride in the dealer as soon as possible. Expensive ro- tor damage can result if the pads are not enlarged trunk. It is not designed replaced when necessary.
Page 14: Your Toyota's Identification
This number is on the left top of the instrument panel, and can be seen through the windshield from outside. This is the primary identification number for your Toyota. It is used in registering the ownership of your vehicle. 2002 Corolla_U (OM12743U)
Page 15: Theft Prevention Labels
’02 Corolla U (L/O 0105) Theft prevention labels (except Suspension and chassis Types of tires for Canada) Your new vehicle carries theft preven- Determine what kind of tires your ve- CAUTION tion labels which are approximately 56 hicle is originally equipped with. mm (2.20 in.) by 16 mm (0.63 in.).
Page 16 ’02 Corolla U (L/O 0105) CAUTION Do not mix summer and all season tires on your vehicle as this can cause dangerous handling charac- teristics, resulting in loss of con- trol. Do not use tires other than the manufacturer’s designated tires, and do not mix tires or wheels of the sizes different from the originally equipped tires and wheels.
Page 17 Important information about your Toyota New vehicle warranty Accessories, spare parts and modification of your Toyota Your new vehicle is covered by the following Toyota limited warranties: A wide variety of non–genuine spare parts and accessories D New vehicle warranty for Toyota vehicles are currently available in the market.
Page 18 Standard. have the systems of the SRS airbag and seat belt preten- sioner removed and disposed of by a qualified service shop or by your Toyota dealer before you dispose of your Installation of a mobile vehicle. two–way radio system As the installation of a mobile two–way radio system in...
Page 19: Starting And Driving
’02 Corolla U (L/O 0105) SECTION STARTING AND DRIVING Before starting the engine ........How to start the engine .
Page 20: Before Starting The Engine
’02 Corolla U (L/O 0105) How to start the engine— Before starting the engine (b) Starting the engine (a) Before cranking 1. Check the area around the vehicle be- 1. Apply the parking brake firmly. Before starting the engine, be sure to fol- fore entering it.
Page 21: Tips For Driving In Various Conditionsns
If they still do not work safely, pull to the side of the road and call a Toyota dealer for assistance. 2002 Corolla_U (OM12743U)
Page 22: Winter Driving Tips
“TOYOTA Long Life Coolant” or equivalent. harder starting. If you are not sure about Driving over 140 km/h (85 mph) may which oil to use, call your Toyota deal- See Section 7–2 for details about coolant result in tire failure, loss of control er—he will be pleased to help.
Page 23: Dinghy Towing
’02 Corolla U (L/O 0105) Dinghy towing Dinghy towing (with automatic transmission) (with manual transmission) Do not use your parking brake when there is a possibility it could freeze. When parking, put the transmission into “P” (automatic) or into first or reverse (manual) and block the rear wheels.
Page 24: Trailer Towing
Toyota warranties do not apply to damage or NOTICE malfunction caused by towing a trailer for commercial purposes.
Page 25 ’02 Corolla U (L/O 0105) Trailer hitch assemblies have differ- The load on either the front or rear ent weight capacities established by axle resulting from distribution of the hitch manufacturer. Even though the gross vehicle weight on both the vehicle may be physically capa- axles must not exceed the Gross ble of towing a higher weight, the Axle Weight Rating (GAWR) listed...
Page 26 Lubricate the hitch aged or separated. For correct safety ball with a light coat of grease. chain procedures, follow the hitch or Toyota recommends removing the trail- trailer manufacturer’s recommenda- Tongue load er hitch whenever you are not towing tions.
Page 27 Make sure the trailer cargo is securely move the trailer to the right. (This pro- loaded so that it can not shift. Toyota recommends that you do not cedure is generally opposite to that tow a trailer with a new vehicle or a Check that your rear view mirrors con- when backing without a trailer).
Page 28 ’02 Corolla U (L/O 0105) Because stopping distance may be in- Remember that when making a turn, In order to maintain engine braking effi- creased, vehicle–to–vehicle distance the trailer wheels will be closer than ciency do not use fifth gear (manual should be increased when towing a the vehicle wheels to the inside of the transmission) or overdrive (automatic...
Page 29 ’02 Corolla U (L/O 0105) How to save fuel and make your vehicle last longer 1. Apply the brakes and hold. Improving fuel economy is easy—just take CAUTION it easy. It will help make your vehicle last 2. Have someone place wheel blocks un- longer, too.
Page 30 ’02 Corolla U (L/O 0105) Avoid long engine idling. If you have Keep front wheels in proper CAUTION a long wait and you are not in traffic, alignment. Avoid hitting the curb and it is better to turn off the engine and slow down on rough roads.
Page 31 ’02 Corolla U (L/O 0105) SECTION IN CASE OF AN EMERGENCY If your vehicle will not start ........If your engine stalls while drivingng .
Page 32: If Your Vehicle Will Not Start
3. If the light is out, dim or goes out If the engine still will not start, it needs when the starter is cranked, the battery adjustment or repair. Call a Toyota dealer is discharged. You may try jump start- or qualified repair shop for assistance.
Page 33 ’02 Corolla U (L/O 0105) (c) Jump starting To avoid serious personal injury and JUMP STARTING PROCEDURE The gas normally produced by a damage to your vehicle which might re- 1. If the booster battery is installed in battery will explode if a flame or sult from battery explosion, acid burns, another vehicle, make sure the vehicles spark is brought near.
Page 34 ’02 Corolla U (L/O 0105) Discharged battery Jumper cable Booster battery Positive terminal (“+” mark) Discharged battery Jumper cable Booster battery Negative terminal Positive terminal (“–” mark) (“+” mark) Connecting point 4. Make the cable connections in the or- c. Connect the clamp of the negative der a, b, c, d.
Page 35: If Your Engine Stalls While Drivingng
’02 Corolla U (L/O 0105) If your engine stalls while If your vehicle overheats driving 5. Start your engine in the normal way. If your engine stalls while driving... your engine coolant temperature After starting, run it at about 2000 rpm gauge indicates overheating, if you ex- 1.
Page 36: If You Have A Flat Tire
Park on a level system. You should have it checked as spot with firm ground. soon as possible at your Toyota dealer. CAUTION 2. Stop the engine and turn on your emergency flashers.
Page 37 ’02 Corolla U (L/O 0105) Do not put any part of your body Use the jack only for lifting your under the vehicle supported by the vehicle during wheel changing. jack. Personal injury may occur. Do not raise the vehicle with some- Do not start or run the engine while one in the vehicle.
Page 38 CAUTION The compact spare tire was de- signed especially for your Toyota. Vehicles with compact spare tire Do not use it on any other vehicle. Do not exceed 80 km/h (50 mph)
Page 39 ’02 Corolla U (L/O 0105) 1. Get the required tools and spare tire. Vehicles with compact spare tire 1. Jack handle 2. Wheel nut wrench 3. Jack 4. Spare tire Vehicles without compact spare tire 1. Spare tire 2. Jack handle 3.
Page 40 ’02 Corolla U (L/O 0105) —Blocking the wheel —Removing wheel ornament 3. Remove the wheel ornament. Pry off the wheel ornament, using the beveled end of the wheel nut wrench as shown. CAUTION Do not try to pull off the ornament by hand.
Page 41 ’02 Corolla U (L/O 0105) —Loosening wheel nuts —Positioning the jack —Raising your vehicle 4. Loosen all the wheel nuts. 5. Position the jack at the correct jack 6. After making sure that no one is in point as shown. the vehicle, raise it high enough so Always loosen the wheel nuts before rais- that the spare tire can be installed.
Page 42 ’02 Corolla U (L/O 0105) —Changing wheels CAUTION Never get under the vehicle when the vehicle supported jack alone. 7. Remove the wheel nuts and change Before putting on wheels, remove any cor- tires. rosion on the mounting surfaces with a wire brush or such.
Page 43 ’02 Corolla U (L/O 0105) —Reinstalling wheel nuts —Lowering your vehicle CAUTION When lowering the vehicle, make sure all portions of your body and all oth- er persons around will not be injured the vehicle is lowered to the ground. 8.
Page 44 ’02 Corolla U (L/O 0105) —Reinstalling wheel ornament —After changing wheels 10. Reinstall the wheel ornament. 11. Check the air pressure of the re- placed tire. 1. Put the wheel ornament into position. Adjust the air pressure to the specification On some models, align the cutout of the designed in Section 8.
Page 45: If Your Vehicle Needs To Be Toweded
If towing is necessary, we recommend (a) Towing with wheel lift type truck you to have it done by your Toyota From front—Release the parking brake. (a) Towing with wheel lift type truck— dealer or a commercial tow truck ser- —From front...
Page 46 (b) Using flat bed truck (c) Towing with sling type truck If towing is necessary, we recommend you to have it done by your Toyota NOTICE dealer or a commercial tow truck ser- vice. Do not tow with sling type truck, ei- If towing service is not available in an ther from the front or rear.
Page 47: If You Cannot Shift Automatic Transmission Selector Leverer
’02 Corolla U (L/O 0105) If you cannot shift automatic transmission selector lever NOTICE NOTICE Only specified towing eyelet; Use only a cable or chain specifically otherwise your vehicle may be dam- intended for use in towing vehicles. aged. Securely fasten the cable or chain to the towing eyelets provided.
Page 48: If You Lose Your Keys
’02 Corolla U (L/O 0105) If you lose your keys You can purchase a new key at your Toyota dealer if you can give them the key number. See the suggestion given in “Keys” in Section 1–2. If your keys are locked in the vehicle and...
Page 49 ..... . . Washing and waxing your Toyota ......
Page 50: Protecting Your Toyota From Corrosionon
Now, it is up to you. Proper more harm than good to simply wet the High ambient temperatures can cause care of your Toyota can help ensure long– mud and debris without removing them. corrosion to those components of the term corrosion prevention.
Page 51: Washing And Waxing Your Toyota
’02 Corolla U (L/O 0105) Washing and waxing your Toyota Check the interior of your vehicle. Wa- Washing your Toyota 1. Rinse off loose dirt with a hose. Re- ter and dirt can accumulate under the move any mud or road salt from the...
Page 52 To prevent damage to the antenna, damage. low the manufacturer’s instructions and make sure it is retracted before driv- precautions. Be sure to polish and wax ing your Toyota through an automatic the chrome trim as well as the paint. 3. Rinse thoroughly—dried soap car wash.
Page 53: Cleaning The Interior
’02 Corolla U (L/O 0105) Cleaning the interior Vinyl interior Carpets CAUTION The vinyl upholstery may be easily Use a good foam–type shampoo to cleaned with a mild soap or detergent clean the carpets. Vehicles with side airbags: and water. Begin by vacuuming thoroughly to remove Be careful not to splash water or First vacuum over the upholstery to re-...
Page 54 ’02 Corolla U (L/O 0105) Windows z If you use a liquid car freshener, do NOTICE The windows may be cleaned with any not spill the liquid onto the ve- z If a stain should fail to come out household window cleaner. hicle’s interior surfaces.
Page 55 . z Improper cleaning of the leather up- holstery could result in discolor- ation or staining. If you have any questions about the cleaning of your Toyota, your local Toyota dealer will be pleased to answer them. 2002 Corolla_U (OM12743U)
Page 56 ’02 Corolla U (L/O 0105) 2002 Corolla_U (OM12743U)
Page 57 ’02 Corolla U (L/O 0105) SECTION VEHICLE MAINTENANCE AND CARE Maintenance requirements ........General maintenance .
Page 58: Maintenance Requirements
Simple instructions for how to per- or if you prefer, your Toyota dealer will be dating this warranty. See “Owner’s War- form them are presented in Section 7.
Page 59 Booklet” or “Owner’s Manual Supple- should investigate the cause or take your check the nuts for looseness. Tighten ment” for the details. vehicle to your Toyota dealer or a quali- them if necessary. fied service shop immediately. It is recom- Tire rotation...
Page 60 ’02 Corolla U (L/O 0105) Lights Accelerator pedal IN THE ENGINE COMPARTMENT Make sure the headlights, stop lights, tail Check the pedal for smooth operation and Items listed below should be checked lights, turn signal lights, and other lights uneven pedal effort or catching. from time to time, e.g.
Page 61: Does Your Vehicle Need Repairing?G
If you notice any of these clues, take your Check the level through the reservoir. The mance, sounds, and visual tip–offs that vehicle to your Toyota dealer as soon as level should be in the “HOT” or “COLD” indicate service is needed. Some impor- possible.
Page 62: Emissions Inspection And Maintenance (I/M) Programs
Also, depending on your driving habits, the codes may not be completely set. recommend contact your Toyota dealer to check the OBD system before taking the vehicle for testing. 2002 Corolla_U (OM12743U)
Page 63 ’02 Corolla U (L/O 0105) SECTION SPECIFICATIONS Dimensions and weight ........Engine .
Page 64 ’02 Corolla U (L/O 0105) Dimensions and weight Engine Fuel Overall length mm (in.): 4420 (174.0) Model: Fuel type: 1ZZ–FE Unleaded gasoline, Octane Rating 87 Overall width mm (in.): 1695 (66.7) (Research Octane Number 91) or higher ∗ Type: Overall height mm (in.): 1385 (54.5)
Page 65 Oil grade: IFR5A11 Coolant type: API grade SJ, “Energy–Conserving” or Spark plug gap, mm(in.): ILSAC multigrade engine oil is recom- “TOYOTA Long Life Coolant” or equiva- 1.1 (0.043) mended. lent Recommended oil viscosity (SAE): With ethylene–glycol type coolant for a...
Page 66 ’02 Corolla U (L/O 0105) CLUTCH Differential (3–speed type only) STEERING Pedal free play, mm (in.): Fluid capacity L (qt., Imp. qt.): Wheel free play: 5—15 (0.2—0.6) 1.4 (1.5, 1.2) Less than 30 mm (1.2 in.) Fluid type: Fluid type: Power steering fluid type: SAE J1703 or FMVSS No.116 DOT 3 Automatic transmission fluid D–II or...
Page 67 ’02 Corolla U (L/O 0105) Tires Fuses Tire size: Compact spare tire T115/70D14 T125/70D14 Except compact spare tire P175/65SR14 P185/65SR14 Tire pressure, kPa (kgf/cm or bar, psi): Compact spare tire 420 (4.2, 60) Except compact spare tire 210 (2.1, 30) Engine compartment Engine compartment Wheel size:...
Page 68 ’02 Corolla U (L/O 0105) 23. STOP 15 A: Stop lights, high mounted stoplight, anti–lock brake system, auto- matic transmission shift lock system, cruise control system, multiport fuel in- jection system/sequential multiport fuel injection system 24. TAIL 15 A: Tail lights, gauges and me- ters, instrument panel light control, cig- arette lighter, clock, car audio system, rear window defogger,...
Page 69: 2002 Corolla_U (Om12743U)
’02 Corolla U (L/O 0105) 31. CIG 15 A: Car audio system, clock, cigarette lighter, power rear view mir- rors, SRS airbag system, seat belt pre- tensioners, automatic transmission shift lock system Fuses (type B) 32. HTR 50 A: Air conditioning system, “A/C”...
Page 70 ’02 Corolla U (L/O 0105) 2002 Corolla_U (OM12743U)
Page 71 ’02 Corolla U (L/O 0105) SECTION REPORTING SAFETY DEFECTS FOR U.S. OWNERS AND UNIFORM TIRE QUALITY GRADING Reporting safety defects for U.S. owners ..... . Uniform tire quality grading .
Page 72 Toyota Motor ington,D.C. 20590. You can also quality grading. Sales, U.S.A., Inc. obtain other information about mo- Your Toyota dealer will help answer any (Toll–free: 1–800–331–4331). tor vehicle safety from the Hotline. questions you may have as you read this information.
Page 73 ’02 Corolla U (L/O 0105) Treadwear—The treadwear grade Temperature A, B, C—The temperature comparative rating based on the wear rate grades are A (the highest), B, and C, of the tire when tested under controlled representing the tire’s resistance to the conditions on a specified government test generation of heat and its ability to dissi- course.
Page 74 ’02 Corolla U (L/O 0105) 2002 Corolla_U (OM12743U)
Page 75 ’02 Corolla U (L/O 0105) SECTION – OPERATION OF INSTRUMENTS AND CONTROLS Overview of instruments and controls Instrument panel overview ........Instrument cluster overview .
Page 76 ’02 Corolla U (L/O 0105) Instrument panel overview 1. Rear view mirror remote control levers 2. Side vents 3. Instrument cluster 4. Center vents 5. Electric moon roof switches 6. Personal light (with electric moon roof) 7. Personal lights (without electric moon roof) 8.
Page 77 ’02 Corolla U (L/O 0105) 1. Power rear view mirror control switches 2. Headlight, turn signal and front fog light switches 3. Wiper and washer switches 4. Emergency flasher switch 5. Clock 6. Car audio 7. Rear window defogger switch 8.
Page 78 ’02 Corolla U (L/O 0105) Instrument cluster overview "Type A 1. Service reminder indicators and 3. Fuel gauge 6. Odometer and two trip meters indicator lights 4. Speedometer 2. Engine coolant temperature gauge 5. Trip meter reset knob 2002 Corolla_U (OM12743U)
Page 79 ’02 Corolla U (L/O 0105) "Type B 1. Service reminder indicators and 3. Speedometer 6. Odometer and two trip meters indicator lights 4. Fuel gauge 7. Outside temperature display 2. Tachometer 5. Trip meter reset knob 8. Engine coolant temperature gauge 2002 Corolla_U (OM12743U)
Page 80 ’02 Corolla U (L/O 0105) "Type C 1. Service reminder indicators and 3. Speedometer 6. Odometer and two trip meters indicator lights 4. Fuel gauge 7. Outside temperature display 2. Tachometer 5. Trip meter reset knob 8. Engine coolant temperature gauge 2002 Corolla_U (OM12743U)
Page 81 ’02 Corolla U (L/O 0105) Indicator symbols on the instrument panel ∗ 1 Open door warning light ∗ 1 Brake system warning light ∗ 1 SRS warning light ∗ 1 windshield washer fluid level warning Seat belt reminder light ∗ 1 light ∗...
Page 82 ’02 Corolla U (L/O 0105) 2002 Corolla_U (OM12743U)
Page 83 ’02 Corolla U (L/O 0105) SECTION – OPERATION OF INSTRUMENTS AND CONTROLS Keys and Doors Keys ............Side doors .
Page 84: Keys
To unlock: Turn the key backward. trunk. need additional keys, duplicates can be Vehicles with power door lock system—All made by a Toyota dealer using the key To protect things locked in the trunk when the doors lock and unlock simultaneously number.
Page 85 ’02 Corolla U (L/O 0105) With power windows (driver’s side) Without power windows LOCKING UNLOCKING WITH INSIDE LOCK BUTTON LOCKING UNLOCKING WITH Move the lock button. POWER DOOR LOCK SWITCH To lock: Push the button down. Push the switch. To unlock: Pull the button up. Vehicles with power windows—...
Page 86: Power Windows
’02 Corolla U (L/O 0105) Power windows CAUTION Before driving, be sure that the doors closed locked, especially when small children are in the ve- hicle. Along with the proper use of seat belts, locking the doors helps prevent the driver and passengers from being thrown out from the ve- hicle during an accident.
Page 87 ’02 Corolla U (L/O 0105) Window lock switch Automatic operation open only): OPERATING PASSENGERS’ Push the switch completely down and then WINDOWS release it. The window will fully open. To Use the switches on the passengers’ stop the window partway, lightly pull the doors.
Page 88: Trunk Lid
’02 Corolla U (L/O 0105) Trunk lid— CAUTION CAUTION To avoid serious personal injury, you Keep the trunk lid closed while driv- must do the following. ing. This not only keeps the luggage from being thrown out but also pre- Always make sure the heads, hands vents exhaust gases from entering and other parts of the bodies of all...
Page 89 ’02 Corolla U (L/O 0105) —Lock release lever —Lock release lever —Internal trunk release handle cancelling system To open the trunk lid from the driver’s After closing the trunk lid, insert the If a person is locked in the trunk, pull seat, pull up on the lock release lever.
Page 90: Hood
’02 Corolla U (L/O 0105) Hood CAUTION Always lock the trunk lid and all doors, and keep away the vehicle keys out of children’s reaches. Never leave children unattended in the vehicle. Unsupervised children may lock themselves in the vehicle or trunk and suffer serious injuries or death.
Page 91: Fuel Tank Cap
’02 Corolla U (L/O 0105) Fuel tank cap 3. Hold the hood open by inserting the This indicates that the fuel filler door 1. To open the fuel filler door, pull the support rod into the slot. is on the left side of your vehicle. lever up.
Page 92: Electric Moon Roof
’02 Corolla U (L/O 0105) Electric moon roof The indicator lamp goes off after driving several times. If the indicator lamp does not go off, contact your Toyota dealer as soon as possible. CAUTION Make sure the cap is tightened se- curely to prevent fuel spillage in case of an accident.
Page 93 ’02 Corolla U (L/O 0105) To operate the moon roof, use the Tilting operation— Always make sure nobody places switches beside the personal light. To tilt up: Push the switch on the “UP” his/her head, hands and other parts The moon roof works when the ignition side.
Page 94 ’02 Corolla U (L/O 0105) 2002 Corolla_U (OM12743U)
Page 95 ’02 Corolla U (L/O 0105) SECTION – OPERATION OF INSTRUMENTS AND CONTROLS Seats, Seat belts, Steering wheel and Mirrors Seats ............Front seats .
Page 96: Seats
Do not put objects under the seats. injury. Consult your Toyota dealer if The objects may interfere with the you insist on modifications of this seat–lock mechanism or unexpect- kind.
Page 97 ’02 Corolla U (L/O 0105) —Adjusting front seats 1. SEAT POSITION ADJUSTING LEVER While adjusting the seat, do not put Hold the center of the lever and pull it your hands under the seat or near up. Then slide the seat to the desired the moving parts.
Page 98: Fold-Down Rear Seat
’02 Corolla U (L/O 0105) Fold–down rear seat CAUTION When returning the seatback to the upright position, observe the follow- ing in order to prevent personal inju- ry in a collision or sudden stop: Make sure the seatback is securely locked by pushing forward and rear- ward on the top of the seatback.
Page 99 ’02 Corolla U (L/O 0105) CAUTION Disconnect the rear center seat belt only under the above mentioned cir- cumstances; do not disconnect it in other circumstances. (B) PREVENTING DAMAGE REAR (C) BEFORE RETURNING REAR SEAT CENTER SEAT BELT WEBBING Make sure shoulder belt...
Page 100: Head Restraints
You will hear a click when the tab locks If the seat belt does not function into the buckle. normally, immediately contact your Toyota dealer. Rear 2002 Corolla_U (OM12743U)
Page 101: Seat Belts
’02 Corolla U (L/O 0105) Seat belts— —Seat belt precautions For your safety and comfort, adjust the Toyota strongly urges that the driver and Do not allow the child to stand up or head restraint before driving. passengers in the vehicle be properly re- kneel on either rear or front seats.
Page 102 ’02 Corolla U (L/O 0105) —Front and rear seat belts When using the seat belts, observe Replace the belt assembly (includ- the following: ing bolts) if it has been used in a severe impact. The entire assembly Use the belt for only one person at should be replaced even if damage a time.
Page 103 If the seat belt does not function normally, immediately contact your Toyota dealer. Do not use the seat until the seat belt is fixed. It cannot protect an adult occupant or your child from injury. 2002 Corolla_U (OM12743U)
Page 104 ’02 Corolla U (L/O 0105) CAUTION Take up slack Both high–positioned lap belts and loose–fitting belts could cause seri- ous injuries due to sliding under Too high the lap belt during a collision or other unintended result. Keep the lap belt positioned as low on hips as possible.
Page 105 ’02 Corolla U (L/O 0105) CAUTION Make sure the both buckles are cor- rectly located and securely latched. Failure to properly match the buckle and tab may cause severe injury in case of an accident or a collision. REAR CENTER SEAT BELT (WITH...
Page 106 Please contact your local Toyota dealer so nally intended for. that the dealer can order the proper re- quired length for the extender. Bring the heaviest coat you expect to wear for prop- er measurement and selection of length.
Page 107 If the seat belt does not function normally, immediately contact your Toyota dealer. Do not use the seat To connect the extender to the seat The driver and front passenger’s seat until the seat belt is fixed. It cannot...
Page 108 ’02 Corolla U (L/O 0105) When the front seat belt pretensioners are activated, an operating noise may be heard and a small amount of smoke–like gas may be released. This gas is harm- less and does not indicate that a fire is occurring.
Page 109 Repairs on or near the front seat belt retractor assemblies This front seat belt pretensioner system In the following cases, contact your Toyota z Modification of the suspension sys- has a service reminder indicator to inform dealer as soon as possible: the driver of operating problems.
Page 110: Srs Driver And Front Passenger Airbags
Toyota strongly recommends that: The driver sit as far back as pos- The SRS (Supplemental Restraint Sys- This indicator comes on when the igni- sible from the steering wheel while tem) front airbags are designed to pro- tion key is turned to the “ACC”...
Page 111 ’02 Corolla U (L/O 0105) However, this threshold velocity will be considerably higher if the vehicle strikes an object, such as a parked vehicle or sign pole, which can move or deform on impact, or if it is involved in an underride collision (e.g.
Page 112 ’02 Corolla U (L/O 0105) In a severe frontal impact, the sensors detect deceleration and the system trig- gers the airbag inflators. Then a chemical reaction in the inflators quickly fills the Hitting a curb, edge Falling into or airbags with non–toxic gas to help restrain of pavement or jumping over a the forward motion of the occupants.
Page 113 Toyota tems. The front seat occupants can be killed or seriously injured by the strongly recommends that all in- inflating airbags if they do not wear...
Page 114 ’02 Corolla U (L/O 0105) instructions concerning installation of a child restraint sys- tem, see “Child restraint” in this section. Move seat fully back Never put a rear–facing child re- A forward–facing child restraint sys- straint system on the front passen- tem should be allowed to be put on ger seat because the force of the the front passenger seat only when...
Page 115 ’02 Corolla U (L/O 0105) Do not sit on the edge of the seat Do not allow a child to stand up, Do not put objects or your pets on or lean over the dashboard when or to kneel on the front passenger or in front of the dashboard or the vehicle is in use.
Page 116 Attachment of a grille guard (bull malfunction of the airbags. Contact your bar, kangaroo bar, etc.), snowplow, Toyota dealer as soon as possible to ser- winches or any other equipment to vice the vehicle. the front end...
Page 117: Srs Side Airbags
SRS side airbags NOTICE Do not disconnect the battery cables before contacting your Toyota dealer. In the following cases, contact your Toyota The SRS (Supplemental Restraint Sys- dealer as soon as possible: tem) side airbags are designed to pro- vide further protection for the driver...
Page 118 ’02 Corolla U (L/O 0105) Your vehicle is equipped with a crash sensing and diagnostic module, which will record the use of the seat belt restraint system by the driver when the SRS side airbags are inflated. CAUTION SRS side airbags inflate with consid- erable force.
Page 119 ’02 Corolla U (L/O 0105) In a severe side impact, the side airbag sensor triggers the side airbag inflators. Then a chemical reaction in the inflators quickly fills the airbags with non–toxic gas Collision from the rear to help restrain the lateral motion of the occupants.
Page 120 Toyota belt systems. To ensure maximum protection in an accident, the driver strongly recommends that all in- and all passengers in the vehicle fants and children be placed in the rear seat of the vehicle and proper- must wear their seat belts properly.
Page 121 Modification of the suspension sys- injury. Consult your Toyota dealer if you insist on modifications of this Do not attach a cup holder or any z Modification of the side structure of kind.
Page 122 Toyota dealer. This side airbag system has In the following cases, contact your Toyota service reminder indicator to inform the dealer as soon as possible: driver of operating problems. If either of The SRS side airbags have been in-...
Page 123: Child Restraint
’02 Corolla U (L/O 0105) Child restraint— —Child restraint precautions Toyota strongly urges the use of child Toyota strongly urges use of A forward–facing child restraint sys- restraint systems children small proper child restraint system which tem should be allowed to be put on enough to use them.
Page 124 ’02 Corolla U (L/O 0105) —Child restraint system A child restraint system for a small CAUTION After installing the child restraint child or baby must itself be properly system, make sure it is secured in restrained on the seat with the lap por- Never put a rear–facing child re- place following the manufacturer’s tion of the lap/shoulder belt.
Page 125 ’02 Corolla U (L/O 0105) —Built–in child restraint The built–in child restraint system mainly consists of a child seat integrated in the rear seat and 5–point seat belts. Refer to the illustration to become familiar with the parts of the system. This child restraint system conforms to U.S.
Page 126 ’02 Corolla U (L/O 0105) This child restraint is designed for use CAUTION Keep the belts clean and dry. If only by children who weigh between 10 they need cleaning, use a mild soap and 30 kg (22.1 and 66.1 pounds), and Make sure the child is securely re- solution or lukewarm water.
Page 127 ’02 Corolla U (L/O 0105) 1. Separate the fastener tapes under 2. Unlock and remove the head re- 3. While pulling the seat belt release the right rear seatback and fold the straint, then reinstall it facing back- strap (black), pull both shoulder...
Page 128 ’02 Corolla U (L/O 0105) 4. Compress the shoulder belt clip to 5. Pull down the seatback part of the 6. Press the removable pad against the separate the right and left shoulder removable pad. Make sure the child’s fastener tapes and install the pad to belts.
Page 129 Contact your Toyota dealer immediately. Do not use the built–in child restraint until the seat belt is fixed. 7. Sit the child on the child seat. Place 8. Adjust the shoulder pads. a shoulder belt over each shoulder.
Page 130 ’02 Corolla U (L/O 0105) 9. Fasten the shoulder belt clip. 10. Pull the seat belt adjustment strap 11. To release the child from the seat (gray tab) firmly until the shoulder belts, separate the shoulder belts The purpose of the clip is to keep the belts are snugly adjusted around the then press the buckle release button.
Page 131 ’02 Corolla U (L/O 0105) —Types of child restraint system Child restraint systems are classified into the following 3 types depending on the child’s age and size. (A) Infant seat (B) Convertible seat (C) Booster seat Install the child restraint system following the instructions provided by its manufac- turer.
Page 132 ’02 Corolla U (L/O 0105) —Installation with 3–point type seat belt (A) Infant seat (C) Booster seat (A) INFANT SEAT INSTALLATION An infant seat is used in rear–facing position only. (B) Convertible seat 2002 Corolla_U (OM12743U)
Page 133 ’02 Corolla U (L/O 0105) 1. Run the lap and shoulder belt through CAUTION Do not put a rear–facing child re- or around the infant seat following the straint system on the rear seat if it instructions provided by its manufactur- Never put a rear–facing child re- interferes with the lock mechanism er and insert the tab into the buckle...
Page 134 2. Fully extend the shoulder belt to put it 3. While pressing the infant seat firmly Toyota dealer immediately. Do not in the lock mode. When the belt is against the seat cushion and seatback, use the seat until the seat belt is...
Page 135 ’02 Corolla U (L/O 0105) 4. To remove the infant seat, press the (B) CONVERTIBLE SEAT INSTALLATION CAUTION buckle–release button and allow the A convertible seat is used in forward– belt to retract completely. The belt will facing or rear–facing position depend- Push and pull the child restraint sys- move freely again and be ready to ing on the child’s age and size.
Page 136 ’02 Corolla U (L/O 0105) Move seat fully back CAUTION A forward–facing child restraint sys- Do not put a rear–facing child re- tem should be allowed to be put on straint system on the rear seat if it Never put a rear–facing child re- the front passenger seat only when interferes with the lock mechanism straint system on the front passen-...
Page 137 1. Run the lap and shoulder belt through 2. Fully extend the shoulder belt to put it Toyota dealer immediately. Do not or around the convertible seat following in the lock mode. When the belt is use the seat until the seat belt is...
Page 138 ’02 Corolla U (L/O 0105) 3. While pressing convertible seat 4. To remove the convertible seat, press CAUTION firmly against the seat cushion and the buckle–release button and allow the seatback, let the shoulder belt retract belt to retract completely. The belt will Push and pull the child restraint sys- as far as it will go to hold the convert- move freely again and be ready to...
Page 139 ’02 Corolla U (L/O 0105) On vehicles with side airbags, do not allow the child to lean against the front door or around the front door even if the child is seated in the child restraint system. It is dan- gerous if the side airbag inflates, and the impact could cause death or serious injury to the child.
Page 140 Always make sure the shoulder belt child from injury. Contact your Toyota dealer immediately. Do not is positioned across the center of child’s shoulder. The belt should be use the seat until the seat belt is kept away from child’s neck, but fixed.
Page 141 ’02 Corolla U (L/O 0105) —Using a top strap Anchor brackets 2. To remove the child restraint system, Follow the procedure below for a child Use the anchor bracket on the package press the buckle–release button and al- restraint system that requires the use tray behind the rear seat to attach the top low the belt to retract.
Page 142 ’02 Corolla U (L/O 0105) TO USE THE ANCHOR BRACKET: 2. Fix the child restraint system with 3. Outside anchor brackets only— the seat belt. Replace the head restraint. 1. Outside anchor brackets only— Remove the head restraint. Latch hook onto the anchor bracket and tighten the top strap.
Page 143 ’02 Corolla U (L/O 0105) —Installation with child restraint lower anchorages The lower anchorages for the child re- straint system interfaced with FMVSS225 specification are installed in the rear seat. The anchorages are installed in the clear- ance between the seat cushion and seat- back of both outside rear seats.
Page 144 ’02 Corolla U (L/O 0105) Tilt steering wheel CHILD RESTRAINT SYSTEM CAUTION INSTALLATION 1. Widen the clearance between When using the lower anchorages seat cushion and seatback a little for the child restraint system, be and confirm the position of the low- sure that there are no irregular ob- er anchorages below the tag in the jects around the anchorages or that...
Page 145 ’02 Corolla U (L/O 0105) Outside rear view mirrors— CAUTION CAUTION Do not adjust the steering wheel Do not adjust the mirror while the while the vehicle is moving. It may vehicle is moving. It may cause the cause the driver to mishandle the driver to mishandle the vehicle and vehicle and an accident may occur an accident may occur resulting in...
Page 146 ’02 Corolla U (L/O 0105) —Rear view mirror remote —Power rear view mirror control control NOTICE If ice should jam the mirror, do not operate the control or scrape the mir- ror face. Use a spray de–icer to free the mirror. To adjust the rear view mirror, simply To adjust a mirror, use the switches.
Page 147 ’02 Corolla U (L/O 0105) Anti–glare inside rear view Vanity mirror mirror CAUTION Do not adjust the mirror while the vehicle is moving. It may cause the driver to mishandle the vehicle and an accident may occur resulting in death or serious injuries. Adjust the mirror so that you can just To use the vanity mirror for the driver, see the rear of your vehicle in the mir-...
Page 148 ’02 Corolla U (L/O 0105) 2002 Corolla_U (OM12743U)
Page 149 ’02 Corolla U (L/O 0105) SECTION – OPERATION OF INSTRUMENTS AND CONTROLS Lights, Wipers and Defogger Headlights and turn signals ........Emergency flashers .
Page 150: Headlights And Turn Signals
’02 Corolla U (L/O 0105) Headlights and turn signals NOTICE To prevent the battery from being dis- charged, do not leave the lights on for a long period when the engine is not running. Daytime running light system The headlights turn on at reduced intensi- ty when the parking brake is released with the engine started, even with the light switch in the “OFF”...
Page 151: Emergency Flashers
’02 Corolla U (L/O 0105) Emergency flashers High–Low beams—For high beams, turn TURN SIGNALS To turn on the emergency flashers, the headlights on and push the lever away push the switch. To signal a turn, push the headlight/ from you (position 1). Pull the lever to- turn signal lever up or down to position All the turn signal lights will flash.
Page 152: Instrument Panel Light Control
’02 Corolla U (L/O 0105) Instrument panel light control Front fog lights NOTICE To prevent the battery from being dis- charged, do not leave the switch on longer than necessary when the en- gine is not running. To adjust the brightness of the instru- To turn on the front fog lights, twist ment panel lights, turn the knob.
Page 153: Interior Light
’02 Corolla U (L/O 0105) Interior light Ignition switch light Personal lights With electric moon roof To turn on the interior light, slide the For easy access to the ignition switch, switch. the ignition switch light comes on when any of the doors are opened. The interior light switch has the following positions: The light remains on for a certain time...
Page 154: Windshield Wipers And Washer
’02 Corolla U (L/O 0105) Windshield wipers and washer To turn on the personal light, push the To turn on the windshield wipers, move switch. To turn it off, push the switch the lever to the desired setting. once again. The key must be in the “ON”...
Page 155: Rear Window Defogger
’02 Corolla U (L/O 0105) Rear window defogger To squirt washer fluid, pull the lever Make sure you turn the defogger off when toward you. the window is clear. Leaving the defogger on for a long time could cause the battery With interval adjuster: If the windshield to discharge, especially during stop–and–...
Page 156 ’02 Corolla U (L/O 0105) 2002 Corolla_U (OM12743U)
Page 157 ’02 Corolla U (L/O 0105) SECTION – OPERATION OF INSTRUMENTS AND CONTROLS Gauges, Meters and Service reminder indicators Fuel gauge ..........Engine coolant temperature gaugege .
Page 158: Fuel Gauge
Fill the fuel tank immediately. The indicator lamp goes off after driving several times. If the indicator lamp does not go off, contact your Toyota dealer as soon as possible. Without tachometer Without tachometer 2002 Corolla_U (OM12743U)
Page 159: Tachometer
’02 Corolla U (L/O 0105) Tachometer The gauge indicates the engine coolant z Do not continue driving with an temperature when the ignition switch is overheated engine. See “If your ve- on. The engine operating temperature hicle overheats” in Section 4. will vary with changes in weather and engine load.
Page 160: Odometer And Two Trip Meters
B, then back to the odometer each and contact time you push. Toyota dealer. To reset the trip meter A to zero, dis- play the meter A reading, then push Fasten seat belt. and hold the knob until the meter is set to zero.
Page 161 Have your vehicle checked your Toyota dealer in the following case: Close all doors. The light does not come on even if the parking brake is applied when the igni- tion key is in the “ON” position. Take vehicle to Toyota dealer immediately.
Page 162 If the fuel tank is not empty or the fuel pedal firmly and bring the vehicle to the nearest Toyota dealer or repair shop. tank cap is not loose... an immediate stop. There is a problem somewhere in the...
Page 163 Contact your warning light on—even for one block. the tank as soon as possible. Toyota dealer as soon as possible to It may ruin the engine. On inclines or curves, due to the move- service the vehicle.
Page 164 (l) Light Reminder Buzzer ing buzzer does not function as described This buzzer will sound if the head light above, have it checked by your Toyota switch is left on and the driver’s door is dealer as soon as possible.
Page 165 ’02 Corolla U (L/O 0105) SECTION – OPERATION OF INSTRUMENTS AND CONTROLS Ignition switch, Transmission and Parking brake Ignition switch with steering lock ....... Automatic transmission .
Page 166: Ignition Switch With Steering Lock
’02 Corolla U (L/O 0105) Ignition switch with steering lock You must push in the key to turn the key from “ACC” to the “LOCK” position. On vehicles with an automatic transmission, the selector lever must be put in the “P” position before pushing the key.
Page 167: Automatic Transmission
’02 Corolla U (L/O 0105) Automatic transmission "3–speed Your automatic transmission has a shift lock system to minimize the possibility of Lock release button incorrect operation. This means you can To prevent misshifting Selector lever only shift out of “P” position when the brake pedal is depressed (with the ignition switch in “ON”...
Page 168 ’02 Corolla U (L/O 0105) (b) Normal driving Shift into the “L” position when the With the selector lever in “L”, the trans- vehicle speed is lower than 49 km/h mission is engaged in first gear. 1. Start the engine as instructed in “How (30 mph).
Page 169 ’02 Corolla U (L/O 0105) (e) Backing up (g) Good driving practice (h) Rocking your vehicle if stuck 1. Bring the vehicle to a complete stop. CAUTION CAUTION 2. With the brake pedal held down with your foot, shift the selector lever to the Always keep your foot on the brake your vehicle becomes...
Page 170 ’02 Corolla U (L/O 0105) z Do not race the engine and avoid spinning the wheels. z If your vehicle remains stuck after rocking the vehicle several times, consider other ways such as tow- ing. (i) If you cannot shift the selector le- ver out of “P”...
Page 171 ’02 Corolla U (L/O 0105) "4–speed Your automatic transmission has a shift lock system to minimize the possibility of Lock release button incorrect operation. This means you can To prevent misshifting only shift out of “P” position when the Selector lever brake pedal is depressed (with the ignition switch in “ON”...
Page 172 ’02 Corolla U (L/O 0105) Vehicles with cruise control—When the 3. Release the parking brake and brake cruise control is being used, even if you pedal. Depress the accelerator pedal downshift the transmission by pushing and slowly for smooth starting. releasing overdrive switch,...
Page 173 ’02 Corolla U (L/O 0105) For ways to decrease the vehicle speed, (g) Parking NOTICE see “Cruise control” in this section. 1. Bring the vehicle to a complete stop. z Be careful not to over–rev the en- 2. Pull the parking brake lever up fully to CAUTION gine.
Page 174 ’02 Corolla U (L/O 0105) (i) Rocking your vehicle if stuck z Do not race the engine and avoid CAUTION spinning the wheels. CAUTION Always keep your foot on the brake z If your vehicle remains stuck after pedal while stopped with the engine rocking the vehicle several times, your vehicle becomes...
Page 175: Manual Transmission
’02 Corolla U (L/O 0105) Manual transmission Low altitude Downshift to the appropriate gear if accel- —1219 m (4000 ft.) or lower eration is needed when you are cruising gear km/h (mph) below the above downshifting speeds. 1 to 2 or 2 to 1 (15) Upshifting too soon or downshifting too ∗...
Page 176: Parking Brake
’02 Corolla U (L/O 0105) Parking brake Good driving practice When parking, firmly apply the parking brake to avoid inadvertent creeping. If it is difficult to shift into reverse, put the transmission in neutral, release the To set: Pull up the lever. For better hold- clutch pedal momentarily, and then try ing power, first depress the brake pedal again.
Page 177: Cruise Control
’02 Corolla U (L/O 0105) Cruise control The cruise control allows you to cruise the vehicle at a desired speed over 40 km/h (25 mph) even with your foot off the accelerator pedal. Your cruising speed can be maintained up or down grades within the limits of engine performance, although...
Page 178 Toyota deal- switch, with the cruise control on, engine the set speed. When you release it, the er at the earliest opportunity.
Page 179 The indicator light does not come on. The indicator light flashes again. The indicator light goes out after it comes on. If this is the case, contact your Toyota dealer and have your vehicle inspected. 2002 Corolla_U (OM12743U)
Page 180 ’02 Corolla U (L/O 0105) 2002 Corolla_U (OM12743U)
Page 181 ’02 Corolla U (L/O 0105) SECTION – OPERATION OF INSTRUMENTS AND CONTROLS Car audio system Reference ..........Using your audio system .
Page 182 ’02 Corolla U (L/O 0105) Reference Type 1: AM·FM ETR radio Type 3: AM·FM ETR radio/cassette player Type 4: AM·FM ETR radio/compact disc (with compact disc auto changer control- player (with compact disc auto changer ler) controller) Type 2: AM·FM ETR radio/cassette player 2002 Corolla_U (OM12743U)
Page 183 This section describes some of the basic TONE AND BALANCE YOUR RADIO ANTENNA features on Toyota audio systems. Some For details about your system’s tone and To lower a manual antenna, carefully push information may not pertain to your sys- balance controls, see the description of it down.
Page 184 ’02 Corolla U (L/O 0105) YOUR COMPACT DISC PLAYER NOTICE When you insert a disc, gently push it in Do not use an adaptor for compact with the label side up. (The player will disc singles—it could cause tracking automatically eject a disc if the label side errors or interfere with the ejection of is down.) The compact disc player will compact discs.
Page 185 ’02 Corolla U (L/O 0105) —Controls and features "Type 1 Details of specific buttons, controls and features are described in the alphabetical listing that follows. 2002 Corolla_U (OM12743U)
Page 186 Turn the “BAL” knob with pulling to adjust Tuning tune in radio stations. the balance between the right and left Your Toyota has an electronic tuning radio speakers. To preset a station to a button: Tune in (ETR). Push and release the “ ” (up) or the desired station (see “TUNE”...
Page 187 ’02 Corolla U (L/O 0105) "Type 2 Details of specific buttons, controls, and features are described in the alphabetical listing that follows. 2002 Corolla_U (OM12743U)
Page 188 ’02 Corolla U (L/O 0105) 1 2 3 4 5 6 (Preset buttons) BAL (Balance) ST (Stereo reception) display These buttons are used to preset and Move the “BAL” ring around “TONE” to Your radio automatically changes to stereo tune in radio stations. adjust the balance between the right and reception when a stereo broadcast is re- left speakers.
Page 189 ’02 Corolla U (L/O 0105) TUNE Tuning Your Toyota has an electronic tuning radio (ETR). Push and release the “ ” (up) or “ ” (down) side of “TUNE” to step up or down the station band. (If you hear a beep, you held the button too long and the radio will go into the seek mode.)
Page 190 ’02 Corolla U (L/O 0105) "Type 3 Details of specific buttons, controls, and features are described in the alphabetical listing that follows. 2002 Corolla_U (OM12743U)
Page 191 ’02 Corolla U (L/O 0105) 1 2 3 4 5 6 (Preset buttons) (Reverse/Fast forward buttons) These buttons are used to preset and Push “AM” to switch the AM band. “AM” Cassette Player tune in radio stations. will appear on the display. Push the fast forward button to fast for- To preset a station to a button: Tune in If the audio system is off, you can turn...
Page 192 If the malfunction is not rectified, take CONTROL / MODE” repeatedly until “BAL” er and automatic changer. your vehicle to your Toyota dealer. appears on the display. Then turn the If the player malfunctions, your audio sys- knob to adjust the left/right balance.
Page 193 ’02 Corolla U (L/O 0105) ∗ PROG (Program) RAND (Random) Dolbyr B NR Push “PROG” to select the other side of There are two random features—you can If you are listening to a tape that was a cassette tape. The display indicates either listen to the tracks on all the com- recorded with Dolbyr B Noise Reduction, pact discs in the magazine in random or-...
Page 194 ’02 Corolla U (L/O 0105) RPT (Repeat) SCAN Compact disc player There are two repeat features—you can Radio There are two scan features—you can ei- either replay a disc track or a whole com- ther scan the tracks on a specific disc or You can either scan all the frequencies on pact disc.
Page 195 Your radio automatically changes to stereo Tuning reception when a stereo broadcast is re- Your Toyota has an electronic tuning radio ceived. “ST” appears on the display. If the (ETR). Push and release the “ ” (up) or signal becomes weak, the radio reduces “...
Page 196 ’02 Corolla U (L/O 0105) "Type 4 Details of specific buttons, controls, and features are described in the alphabetical listing that follows. 2002 Corolla_U (OM12743U)
Page 197 ’02 Corolla U (L/O 0105) 1 2 3 4 5 6 (Preset buttons) high–pitch tone adjustment, push (Reverse/Fast forward buttons) “AUDIO CONTROL / MODE” repeatedly These buttons are used to preset and If you want to fast forward or reverse until “TRE”...
Page 198 If the malfunction is not rectified, take disc player and automatic changer. tracks in the magazine in random order. your vehicle to your Toyota dealer. To turn off the random feature, push the If the player malfunctions, your audio sys- DISC ”RAND”...
Page 199 ’02 Corolla U (L/O 0105) RPT (Repeat) SCAN Compact disc player There are two repeat features—you can Radio There are two scan features—you can ei- either replay a disc track or a whole com- ther scan the tracks on a specific disc or You can either scan all the frequencies on pact disc.
Page 200 Your radio automatically changes to stereo Tuning To ensure the correct audio system reception when a stereo broadcast is re- Your Toyota has an electronic tuning radio operation: ceived. “ST” appears on the display. If the (ETR). Push and release the “ ” (up) or...
Page 201 ’02 Corolla U (L/O 0105) Here are some common reception prob- Use high–quality cassettes. lems that probably do not indicate a prob- Fading—AM broadcasts are reflected by Low–quality cassette tapes can cause lem with your radio: the upper atmosphere—especially at night. many problems, including poor sound, These reflected signals can interfere with inconsistent...
Page 202 ’02 Corolla U (L/O 0105) If moisture gets into your compact disc player, you may not hear any sound even though your compact disc player appears to be working. Remove the disc from the player and wait until it dries. CARING FOR YOUR COMPACT DISC PLAYER AND DISCS Use only compact discs labeled as...
Page 203 ’02 Corolla U (L/O 0105) Your compact disc player cannot play CAUTION special shaped or low–quality compact discs such as those shown here. Do Compact disc players use an invisible not use them as the player could be laser beam which could cause hazard- damaged.
Page 204 ’02 Corolla U (L/O 0105) 2002 Corolla_U (OM12743U)
Page 205 ’02 Corolla U (L/O 0105) SECTION – OPERATION OF INSTRUMENTS AND CONTROLS Air conditioning system Controls ........... Air flow selector settings .
Page 206 ’02 Corolla U (L/O 0105) Controls 1. Temperature selector 2. Air intake selector 3. Air flow selector 4. “A/C” button (on some models) 5. Fan speed selector 2002 Corolla_U (OM12743U)
Page 207 ’02 Corolla U (L/O 0105) Fan speed selector This position allows the air intake to select FRESH automatically. This is to Turn the knob to adjust the fan speed—to clean up the front view more quickly. the right to increase, to the left to de- crease.
Page 208 The air intake selector button is used to conditioning automatically switch the air intake FRESH mode that shuts off. If this happens, take your ve- draws outside air into the system and hicle to a Toyota dealer for service. RECIRCULATED mode that recirculates the air inside vehicle.
Page 209 ’02 Corolla U (L/O 0105) Air flow selector settings Operating tips To cool off your Toyota after it has been parked in the hot sun, drive with the windows open for a few minutes. This vents the hot air, allowing the air conditioning to cool the interior more quickly.
Page 210 ’02 Corolla U (L/O 0105) When driving on dusty roads, close all Heating Air conditioning windows. If dust thrown up by the ve- For best results, set controls to: For best results, set controls to: hicle is still drawn into the vehicle after closing the windows, it is recommended Fan speed—Any setting except “OFF”...
Page 211 ’02 Corolla U (L/O 0105) Defogging On humid days, do not blow cold air To heat the vehicle interior while de- on the windshield—the difference be- frosting windshield, choose The inside of the windshield tween the outside and inside tempera- floor/windshield air flow.
Page 212 ’02 Corolla U (L/O 0105) Side vents If air flow control is not satisfactory, check the side vents. The side vents may be opened or closed as shown. 2002 Corolla_U (OM12743U)
Page 213 ’02 Corolla U (L/O 0105) SECTION – OPERATION OF INSTRUMENTS AND CONTROLS Other equipment Clock ............Outside temperature display .
Page 214: Clock
“–E” or “E” will appear on the display. If “–E” or “E” appears on the display, contact your Toyota dealer. Centigrade display The digital clock indicates the time. The key must be in the “ACC” or “ON”...
Page 215: Cigarette Lighter And Ashtray
Do not hold the cigarette lighter pressed blown, do not use the electricity over the total vehicle capacity of 12 Use a Toyota genuine cigarette lighter or V/120W. equivalent for replacement. z To prevent the battery from being...
Page 216: Glove Box
’02 Corolla U (L/O 0105) Glove box Auxiliary boxes z Close the power outlet lid when the power outlet is not in use. Inserting a foreign object other than the ap- propriate plug that fits the outlet, or allowing any liquid into the out- let may cause electrical failure or short circuits.
Page 217: Cup Holders
’02 Corolla U (L/O 0105) Cup holders Type C Type A (front) Type C (rear) To use the box, do the following. The cup holder is designed for holding cups or drink–cans securely. Type A and B: Pull on the handle. Type C: Open the center console box as Type A: To use the holder, push in and shown above.
Page 218: Floor Mat
’02 Corolla U (L/O 0105) Floor mat CAUTION Do not place anything else other than cups or drink–cans in the cup holder, such items thrown about in the compartment and possibly injure people in the vehicle during sudden braking or in an accident.
Page 219 ’02 Corolla U (L/O 0105) CAUTION Make sure the floor mat is properly placed on the floor carpet. If the floor slips and interferes with movement of the pedals during driv- ing, it may cause an accident. 2002 Corolla_U (OM12743U)
Page 220 ’02 Corolla U (L/O 0105) 2002 Corolla_U (OM12743U)
Page 221 ’02 Corolla U (L/O 0105) SECTION – DO–IT–YOURSELF MAINTENANCE Introduction Engine compartment overview ....... Fuse locations .
Page 222: Engine Compartment Overview
’02 Corolla U (L/O 0105) Engine compartment overview 1. Power steering fluid reservoir 2. Engine oil level dipstick 3. Engine oil filler cap 4. Brake fluid reservoir 5. Fuse blocks 6. Battery 7. Engine coolant reservoir 8. Electric cooling fans 9.
Page 223: Fuse Locations
’02 Corolla U (L/O 0105) Fuse locations Spare fuses 2002 Corolla_U (OM12743U)
Page 224 Toyota Warranty statement for details and exhaust manifold and spark plug where you may be exposed to flying suggestions. boots, etc.—will be hot. So be care- or falling material, fluid spray, etc.
Page 225: Positioning The Jack
’02 Corolla U (L/O 0105) Positioning the jack z Do not reuse iridium–tipped spark Be extremely cautious when work- plugs by cleaning or regapping. ing on the battery. It contains poi- sonous and corrosive sulfuric acid. z Do not overfill automatic transmis- sion fluid, transmission...
Page 226: Parts And Tools
Remember all Toyota parts are de- alone; use vehicle support stands. signed in metric sizes, so your tools must be metric.
Page 227 Checking brake fluid Checking and replacing fuses Parts (if level is low): Parts (if replacement is necessary): SAE J1703 or FMVSS No.116 DOT 3 Genuine Toyota fuse or equivalent with brake fluid same amperage rating as original Tools: Adding washer fluid...
Page 228 ’02 Corolla U (L/O 0105) 2002 Corolla_U (OM12743U)
Page 229 ’02 Corolla U (L/O 0105) SECTION – DO–IT–YOURSELF MAINTENANCE Engine and Chassis Checking the engine oil level ....... . . Checking the engine coolant level .
Page 230: Checking The Engine Oil Level
’02 Corolla U (L/O 0105) Checking the engine oil level If the oil level is below or only slightly Engine oil selection above the low level, add engine oil of Use API grade SJ, “Energy–Conserving” Low level Full level the same type as already in the engine. or ILSAC multigrade engine oil.
Page 231: Checking The Engine Coolant Level
Visually check the radiator, hoses, engine coolant filler cap, radiator cap and drain cock and water pump. If you can find no leak, have your Toyota dealer test the cap pressure and check for leaks in the cooling system. ILSAC certification mark...
Page 232: Checking Brake Fluid
’02 Corolla U (L/O 0105) Checking brake fluid We recommend to use 50% solution for CAUTION your Toyota, to provide protection down to about –35_C (–31_F). When it is extreme- To prevent burning yourself, do not ly cold, to provide protection down to remove the radiator cap when the en- about –50_C (–58_F), 60% solution is rec-...
Page 233: Checking Power Steering Fluid
’02 Corolla U (L/O 0105) Checking power steering fluid To check the fluid level, simply look at CAUTION the see–through reservoir. The level should between “MAX” If hot O.K. If cold Take care when filling the reservoir O.K. “MIN” lines on the reservoir. because brake fluid can harm your Open Close...
Page 234: Checking Tire Pressure
If a tire frequently needs refilling, have it Keep your tire pressures at the proper checked by your Toyota dealer. level. CAUTION The following instructions for checking The recommended cold tire pressures, tire...
Page 235: Checking And Replacing Tires
REPLACING YOUR TIRES The tires on your Toyota have built–in as soon as possible. tread wear indicators to help you know When replacing a tire, use only the when the tires need replacement.
Page 236: Rotating Tires
See “If you have a flat tire” in Section 4 for tire change procedure. Toyota recommends all four tires, or at least both front or rear tires be re- Vehicles with compact spare tire When rotating tires, check for uneven placed as a set.
Page 237: Installing Snow Tires And Chains
If you need snow tires, select the same TIRE CHAIN SELECTION lower. size, construction and load capacity as Use the tire chains of correct size and the original tires on your Toyota. Drive carefully avoiding bumps, type.
Page 238: Replacing Wheels
This must be observed on compact spare tires, too. Correct replacement wheels are available at your Toyota dealer. A wheel of a different size or type may adversely affect handling, wheel and bear- ing life, brake cooling, speedometer/odom-...
Page 239: Aluminum Wheel Precautions
1600 km (1000 miles). When using tire chains, be careful not to damage the aluminum wheels. Use only the Toyota wheel nuts and wrench designed for your aluminum wheels. When balancing your wheels, use only Toyota balance weights or equivalent and a plastic or rubber hammer.
Page 240 ’02 Corolla U (L/O 0105) 2002 Corolla_U (OM12743U)
Page 241 ’02 Corolla U (L/O 0105) SECTION – DO–IT–YOURSELF MAINTENANCE Electrical components Checking battery condition ........Battery recharging precautions .
Page 242: Checking Battery Condition
’02 Corolla U (L/O 0105) Checking battery condition— —Checking battery exterior —Precautions CAUTION If electrolyte gets on your skin, Ground cable Terminals thoroughly wash the contact area. If BATTERY PRECAUTIONS you feel pain or burning, get medi- cal attention immediately. The battery produces flammable and explosive hydrogen gas.
Page 243: Battery Recharging Precautions
Charging necessary. Have battery Dark White checked by your NOTICE Toyota dealer. Clear or Have battery Never recharge the battery while the light checked by your engine is running. Also, be sure all yellow Toyota dealer.
Page 244: Checking And Replacing Fuses
’02 Corolla U (L/O 0105) Checking and replacing fuses Type A fuses can be pulled out by the pull–out tool. The location of the pull–out tool is shown in the illustration. Type A If you are not sure whether the fuse has blown, try replacing the suspected fuse with one that you know is good.
Page 245: Adding Washer Fluid
When replacing tem. Have your Toyota dealer correct it as light comes on, the washer tank may be a bulb, make sure the ignition switch and soon as possible.
Page 246 Personal light inside of the lens, or if there is water — (with electric moon pooled inside light, contact your roof) Toyota dealer. Personal lights (without electric Bulb Light bulbs Type moon roof) 1. Open the hood. Interior light —...
Page 247 ’02 Corolla U (L/O 0105) 2. LEFT–HAND HEADLIGHT: Remove the clip and take out the upper cover of the air cleaner duct unit from the lower base as shown in the illustra- tion. Remove and install the cover clip as shown in the following illustrations.
Page 248 Install a new bulb. clockwise to the front of the vehicle. Aiming is not necessary after replacing the bulb. When aiming adjustment is nec- essary, contact your Toyota dealer. 2002 Corolla_U (OM12743U)
Page 249: 2002 Corolla_U (Om12743U)
’02 Corolla U (L/O 0105) —Front fog lights 1. Loosen the retainer nut and take out 2. Turn the cover counterclockwise and 3. Disconnect the cords. the beam unit. remove it. 2002 Corolla_U (OM12743U)
Page 250 ’02 Corolla U (L/O 0105) —Parking/front side marker/front turn signal lights Use a Phillips–head screwdriver. 4. Release the bulb retaining spring 5. Connect the cords and install the and remove the bulb. Install a new cover by turning it clockwise. bulb and the bulb retaining spring.
Page 251 ’02 Corolla U (L/O 0105) —Rear side maker, rear turn signal, and stop/tail lights Remove and install the clips as shown in Removing clips (type A): Use a flat–bladed the following illustrations. screwdriver or equivalent. Installing clips (type A) 2002 Corolla_U (OM12743U)
Page 252 ’02 Corolla U (L/O 0105) Removing clips (type B): Use a Phillips– a: Stop/tail light head screwdriver. b: Rear turn signal light c: Rear side marker light Installing clips (type B) 2002 Corolla_U (OM12743U)
Page 253 ’02 Corolla U (L/O 0105) —License plate lights —Back–up lights (left side) 2002 Corolla_U (OM12743U)
Page 254 ’02 Corolla U (L/O 0105) —License plate lights (right side) 2002 Corolla_U (OM12743U)
Page 255 ’02 Corolla U (L/O 0105) —High mounted stoplight 2002 Corolla_U (OM12743U)
Page 256 ’02 Corolla U (L/O 0105) 2002 Corolla_U (OM12743U)
Page 257 ’02 Corolla U (L/O 0105) eU−6 Quick index D If a service reminder indicator or warning buzzer comes on ..D If your vehicle will not start ........D If your engine stalls while driving .
Page 258 The Toyota authorized Repair Manual is packed with literally everything you need to know to perform your own maintenance in virtually every area of your new vehicle.
Page 259 English, may be purchased as applicable from work yourself step−by−step. any Toyota dealer. Areas covered include such things as spark plug re Pub. Name: 2002 COROLLA Repair Manual placement, valve clearance adjustment and engine oil Pub. No.: RM857U1 (Maintenance, and filter replacement.
Page 260 ’02 Corolla U (L/O 0105) WE REALLY CARE ABOUT YOU — PLEASE BUCKLE UP Toyota has made a special effort to encourage use of seat belts. Toyota belts are: Comfortable Easy to use Convenient We encourage you to use your belts every time you drive.

Toyota 2002 Corolla Owner's Manual

2 Section

3 Section

4 Section

5 Section

6 Section

1 2 Section -

1 3 Section -

1 4 Section -

1 5 Section -

1 6 Section -

1 9 Section -

7 1 Section -

7 2 Section -

Quick Links

Chapters

Related Manuals for Toyota 2002 Corolla

Summary of Contents for Toyota 2002 Corolla

Table of Contents