Page 3
1/17/16 Model information table Model DCR-HC44E DCR-HC46 DCR-HC46E US, CND, E, KR, AEP, UK, EE, NE, AEP, UK, EE, NE Destination E, AUS, CH, HK, JE Color system NTSC DV Interface on the Cradle IN/OUT IN/OUT (Handycam Station) • Abbreviation...
Page 4
CRITIQUES POUR LA SÉCURITÉ DE FONCTIONNEMENT. NE COMPONENTS WITH SONY PARTS WHOSE PART NUMBERS REMPLACER CES COMPOSANTS QUE PAR DES PIÈSES SONY APPEAR AS SHOWN IN THIS MANUAL OR IN SUPPLEMENTS DONT LES NUMÉROS SONT DONNÉS DANS CE MANUEL OU PUBLISHED BY SONY.
Select page: 0, address: 01, and set data:01. Select page: A, address: 10, set data:00 and press the “PAUSE (Write)” button of the adjustment remote commander. Select page: 0, address: 01, and set data: 00. DCR-HC44E/HC46/HC46E_L2 Published in Heiloo, Holland.
Refer to “1-5-3. Self-diagnosis Code Table”. C : Corrected by customer Indicates the appropriate H : Corrected by dealer step to be taken. E : Corrected by service E.g. engineer 31 ..Reload the tape. 32 ..Turn on power again. DCR-HC44E/HC46/HC46E_L2 Published in Heiloo, Holland.
Page 8
PG fault during normal drum Remove the battery or power cable, connect, and perform operations. operations from the beginning. Phase fault during normal drum Remove the battery or power cable, connect, and perform operations. operations from the beginning. DCR-HC44E/HC46/HC46E_L2 Published in Heiloo, Holland.
When the data has changed because of board replaceing etc, check the data setting (Exif Model Data) is right. If not, rewrite to the right value. Exif Model Data Data Page Address DCR-HC44E DCR-HC46 DCR-HC46E Writing Method: 1) Select page: 0, address: 01 and set data: 01.
• When remove a connector, dont’ pull at wire of connector. It is possible that a wire is snapped. pieces of gilt may be left inside) • When installing a connector, dont’ press down at wire of connector. It is possible that a wire is snapped. DCR-HC44E/HC46/HC46E_L2 Published in Heiloo, Holland.
Page 15
2 Hang it on the claw after putting the FP-380 4 Attach two hinge covers as shown in figure. flexible board on the hinge cover (M). Claw Claw Hinge cover (M) Claw Adhesive tape Claw DCR-HC44E/HC46/HC46E_L2 HELP Published in Heiloo, Holland.
FLEXIBLE CAPSTAN MOTOR FLEXIBLE FLAT CABLE (FFC-065) BOARD CR-063 BOARD VIDEO HEAD FP-228 M902 LOADING MOTOR FLEXIBLE BOARD M901 DRUM MOTOR IC5202 (Not supplied) FP-031 FLEXIBLE BOARD CN002 N MECHANISM DECK MULTI CONNECTOR (MDX-N110) DCR-HC44E/HC46/HC46E_L2 FRAME Published in Heiloo, Holland.
FP-031, FP-032, FP-228 FLEXIBLE BOARD (PANEL REVERSE DETECT) CONTROL KEY BLOCK (SB10600) CONTROL KEY BLOCK (CF17000) CR-063 BOARD (CRADLE TERMINAL) CONTROL KEY BLOCK (SS17000) SI-053 BOARD (PITCH/YAW SENSOR, AV CONNECTOR) COMMON NOTE FOR SCHEMATIC DIAGRAMS DCR-HC44E/HC46/HC46E_L2 Published in Heiloo, Holland.
Page 28
In addition, ensure that the receiver is not covered with dusts nor exposed to strong light. Les composants identifiés par une marque 0 sont critiques pour la sécurité. Ne les remplacer que par une pièce portant le numéro spécifie. DCR-HC44E/HC46/HC46E_L2 Published in Heiloo, Holland.
Page 29
R214 R203 IDRV R204 R213 R205 XX L202 R201 XX C214 C208 C207 C210 C212 C213 4.7u 0.1u R215 R216 R202 VC-418 (1/18) CN3202 THROUGH THE FLEXIBLE FLAT CABLE (FFC-064) PAGE 4-6 of LEVEL3 DCR-HC44E/HC46/HC46E_L2 CD-633 Published in Heiloo, Holland.
Page 30
1/17/16 Schematic diagrams of the VC-418 board are not shown. Pages from 4-6 to 4-23 are not shown. DCR-HC44E/HC46/HC46E_L2 Published in Heiloo, Holland.
SI-053 BOARD PD-283 BOARD (SIDE A) LB-123 BOARD PD-283 BOARD (SIDE B) MS-313 BOARD FP-386 FLEXIBLE BOARD FP-381 FLEXIBLE BOARD CR-063 BOARD FP-031, FP-032, FP-228 FLEXIBLE BOARD COMMON NOTE FOR PRINTED WIRING BOARDS MOUNTED PARTS LOCATION DCR-HC44E/HC46/HC46E_L2 Published in Heiloo, Holland.
Page 38
: pattern of the rear side (The other layers’ patterns are not indicated) • Through hole is omitted. • There are a few cases that the part printed on diagram isn’t mounted in this model. • C: panel designation DCR-HC44E/HC46/HC46E_L2 4-31 Published in Heiloo, Holland.
Page 39
R211 R210 C205 R204 R208 R206 IC201 C219 Q202 C220 R207 C206 C204 C211 R203 C209 C201 1-868-295- 11 Note: IC201 is not supplied, but this is included in CCD block assy. 1-868-295- DCR-HC44E/HC46/HC46E_L2 CD-633 4-33 Published in Heiloo, Holland.
Page 40
1/17/16 Printed wiring boards of the VC-418 board are not shown. Pages from 4-34 to 4-35 are not shown. DCR-HC44E/HC46/HC46E_L2 Published in Heiloo, Holland.
Page 41
1/17/16 PD-283 (2 layers) : Uses unleaded solder. PD-283 BOARD (SIDE A) R9601 CN9601 C9601 C9604 R9609 R9605 R9603 D9602 R9604 R9602 C9605 C9602 C9603 CN9602 CN9604 CN9605 1-868-307- DCR-HC44E/HC46/HC46E_L2 PD-283 (SIDE A) 4-36 Published in Heiloo, Holland.
Page 42
1/17/16 PD-283 (2 layers) : Uses unleaded solder. PD-283 BOARD (SIDE B) D9605 (BACKLIGHT) D9603 (BACKLIGHT) D9604 (BACKLIGHT) 1-868-307- DCR-HC44E/HC46/HC46E_L2 PD-283 (SIDE B) 4-37 Published in Heiloo, Holland.
Page 43
Note: CN002 (multi connector) is not supplied, but this is included in CR-063 complete board. CAUTION Danger of explosion if battery is incorrectly replaced. Replace only with the same or equivalent type. DCR-HC44E/HC46/HC46E_L2 FP-386, CR-063, SI-053 4-38 Published in Heiloo, Holland.
Page 47
1/17/16 Mounted parts location of the VC-418 board are not shown. Page 4-42 to 4-43 are not shown. DCR-HC44E/HC46/HC46E_L2 Published in Heiloo, Holland.
ELECTRICAL PARTS LIST Link Link ACCESSORIES ACCESSORIES CD-633 BOARD FP-228 FLEXIBLE BOARD LB-123 BOARD CR-063 BOARD FP-380 FLEXIBLE BOARD MS-313 BOARD FP-031 FLEXIBLE BOARD FP-381 FLEXIBLE BOARD PD-283 BOARD FP-032 FLEXIBLE BOARD FP-386 FLEXIBLE BOARD SI-053 BOARD DCR-HC44E/HC46/HC46E_L2 Published in Heiloo, Holland.
Page 50
AUS : Australian model : Brazilian model : Chinese model CND : Canadian model : East European model HK : Hong Kong model : Japanese model : Tourist model : Korea model : North European model DCR-HC44E/HC46/HC46E_L2 Published in Heiloo, Holland.
Page 58
3-703-816-08 SCREW (M1.4X1.4), SPECIAL HEAD A-1080-997-A MD (N100) SUB ASSY A X-2024-450-1 COMPARTMENT ASSY, CASSETTE 3-703-816-13 SCREW (M1.4X2.0), SPECIAL HEAD 2-342-926-01 SPRING (ARM S), TENSION COIL 3-315-414-31 WASHER 2-546-417-01 SCREW (M1.4) M901 A-1154-545-A DRUM (DEH-33E-R) (SERVICE) DCR-HC44E/HC46/HC46E_L2 Published in Heiloo, Holland.
Page 59
X-2024-466-1 COASTER (T) ASSY 2-342-902-01 SPRING, TENSION REGULATOR X-2024-469-1 ARM (T) ASSY, GL X-2024-474-1 TABLE ASSY, T REEL 2-342-716-01 SPRING (T), TORSION COIL X-2024-476-1 ARM ASSY, PINCH 3-703-816-08 SCREW (M1.4X1.4), SPECIAL HEAD (for adjustment) DCR-HC44E/HC46/HC46E_L2 5-10 Published in Heiloo, Holland.
1-817-560-51 CONNECTOR, FPC (ZIP) 21P H901 8-719-067-74 ELEMENT, HOLE HW-105A-CDE-T (S REEL) H902 8-719-067-74 ELEMENT, HOLE HW-105A-CDE-T (T REEL) Note: Be sure to read “Precautions for Replacement of DCR-HC44E/HC46/HC46E_L2 Imager” on page 4-3 when changing the imager. 5-12 Published in Heiloo, Holland.
Page 62
R9607 1-218-978-11 RES-CHIP 120K 1/16W R9609 1-218-989-11 RES-CHIP 1/16W • Refer to page 5-1 for mark 0. CAUTION Danger of explosion if battery is incorrectly replaced. DCR-HC44E/HC46/HC46E_L2 Replace only with the same or equivalent type. 5-13 Published in Heiloo, Holland.
Page 63
Part No. Description < SENSOR > SE601 1-476-807-31 SENSOR, ANGULAR VELOCITY (PITCH) SE602 1-476-807-41 SENSOR, ANGULAR VELOCITY (YAW) Electrical parts list of the VC-418 board is not shown. Pages 5-15 to 5-20 are not shown. DCR-HC44E/HC46/HC46E_L2 5-14 Published in Heiloo, Holland.
Wireless Remote Commander 1-829-868-31 RMT-831 1-478-495-41 21-pin Adaptor Rechargeable Battery Pack 1-770-783-21 NP-FP50 0 A-1144-869-A (US, CND) (AEP, UK, EE, NE) 0 A-1144-870-A (EXCEPT US, CND) Refer to page 5-1 for mark 0. • DCR-HC44E/HC46/HC46E_L2 5-21E Published in Heiloo, Holland.
Page 65
www.freeservicemanuals.info 1/17/16 HARDWARE LIST #1: M1.7 X 2.5 (Black) #2: M1.7 X 4.0 (Black) #3: M1.7 X 2.5 (Red) #4: M1.4 X 2.5 (Dark Silver) 2-635-562-11 2-635-562-31 2-660-401-01 3-348-998-81 #5: M1.7 X 3.5 (Black) #6: M1.4 X 1.7 (Silver) #7: M1.7 X 1.6 (Black) #8: M1.7 X 3.5 (Silver) 3-080-204-01 2-598-474-01...
Page 66
www.freeservicemanuals.info 1/17/16 [Description of main button functions on toolbar of the Adobe Acrobat Reader Ver5.0 (for Windows)] Toolbar Printing a text Reversing the screens displayed once • To reverse the previous screens (operation) one by one, click 1. Click the Print button 2.
1/17/16 Reverse 987693031.pdf Revision History S.M. Rev. Ver. Date History Contents issued 2006.01 Official Release — — DCR-HC44E/HC46/HC46E_L2 Published in Heiloo, Holland.