Section 13: Off-Season Storage; Section 14: Trouble Shooting Guide - Yard Machines 550 Operator's Manual

SECTION 13: OFF-SEASON STORAGE

If the log splitter will not be used for a period longer
than 30 days, the following steps should be taken to
prepare the log splitter for storage.
1. Clean the engine and the entire log splitter
thoroughly.
2. Refer to the engine manual for correct engine
storage instructions.

SECTION 14: TROUBLE SHOOTING GUIDE

Problem Possible Cause(s)
Engine fails to start Dirty air cleaner.
Fuel shut-off valve closed (if so
equipped).
Fuel tank empty, or stale fuel.
Choke not in ON position.
Blocked fuel line.
Spark plug wire disconnected.
Faulty spark plug.
Engine runs erratic Unit running on CHOKE.
Spark plug wire loose.
Blocked fuel line or stale fuel.
Water or dirt in fuel system.
Dirty air cleaner.
Carburetor out of adjustment.
Engine Engine oil level low.
overheats Dirty air cleaner.
Air flow restricted.
Carburetor not adjusted properly.
Will not split logs Reservoir fluid level low.
Leaking cylinder Broken seals.
Scored cylinder.
Note:
For repairs beyond the minor adjustments
above, contact your local authorized service dealer.
3. Wipe unit with an oiled rag to prevent rust,
especially wedge and beam.
4. Store unit in a clean, dry area. Do not store next
to corrosive materials, such as fertilizer.
NOTE:
When storing any type of power equipment
in an unventilated or metal storage shed, care
should be taken to rustproof the equipment by
coating with a light oil or silicone.
Corrective Action
Refer to the engine manual packed with your unit.
Open fuel shut-off valve.
Fill tank with clean fresh gasoline. Fuel will not last over thirty
days unless a fuel stabilizer is used.
Move switch to ON position.
Clean fuel line.
Connect wire to spark plug.
Clean, adjust gap or replace.
Move choke lever to OFF position.
Connect and tighten spark plug wire.
Clean fuel line; fill tank with clean fresh gasoline. Fuel will not last
over thirty days unless a fuel stabilizer is used.
Drain fuel tank. Refill with fresh fuel.
Refer to the engine manual packed with your unit.
Refer to the engine manual packed with your unit.
Fill crankcase with proper oil.
Refer to the engine manual packed with your unit.
Stop engine and disconnect spark plug wire. Remove blower
housing and clean.
Refer to the engine manual packed with your unit.
Check and fill reservoir tank as instructed in Operation section of
this manual.
Return unit for authorized repair.
Return unit for authorized repair.
16