All rights reserved. No part of this publication may be reproduced, stored in a retrieval system or transmitted, in any form or by any means, electronic, mechanical, photocopying, or otherwise without the prior permission of Philips. Published by LM 0463 Service PaCE...
EN 2 TDVD1.1E Technical Specifications, Connection Facilities, and Chassis Overview 1. Technical Specifications, Connection Facilities, and Chassis Overview Technical Specifications Cinch (Input) 1 Vpp / 75 Ω 1 - CVBS 2 - Audio - L 0.5 Vrms / 10 kΩ...
Page 3
Technical Specifications, Connection Facilities, and Chassis Overview TDVD1.1E EN 3 1.2.3 DVD Module Connections 9 - F/R (SCK) Front Right Audio 10 - A-GND Audio Ground 11 - F/L (BCK) Front Left Audio DC Power Connector (CN401) 12 - MUTE (LRCK) Mute for Audio...
EN 4 TDVD1.1E Safety and Maintenance Instructions, Warnings, and Notes 2. Safety and Maintenance Instructions, Warnings, and Notes Safety Instructions Safety regulations require that during a repair: • Due to the chassis concept, a part of the circuitry is 'hot'.
Page 5
Safety and Maintenance Instructions, Warnings, and Notes TDVD1.1E EN 5 • Together with the deflection unit and any multi-pole unit, flat square picture tubes form an integrated unit. The deflection and the multi-pole units are set optimally at the factory.
EN 14 TDVD1.1E Mechanical instructions 4. Mechanical instructions Index of this chapter: DVD Module Removal 1. Rear Cover Removal 2. Service Position Main Panel Remove the complete DVD module after unscrewing the four 3. DVD Module Removal fixation screws [1].
1. LLLLLLL. This is the used IC type. of standby (DVD Mode) automatically. 2. PAB#-XX. This is the software identification. – P = Philips. How to enter the Dealer Mode – A = the region (W = West Europe, E = East Europe).
Page 16
EN 16 TDVD1.1E Service Modes, Error Codes, and Fault Finding D e a l e r M o d e CL 26532120_019.eps 311002 Figure 5-2 Dealer Mode menu How to exit Use a standard RC-transmitter and key in the code 9999 directly followed by the MENU button.
Wiring Diagram, Block Diagrams and Overviews TDVD1.1E C Bus Interconnection Diagram I²C BUS INTERCONNECTION DIAGRAM TUNER R012 R013 RV34 R049 RV33 R048 EEPROM VIDEO u-CONTROLLER PROC. CL 26532120_005.eps 251002...
Circuit Diagrams and PWB Layouts TDVD1.1E 7. Circuit Diagrams and PWB Layouts Main Panel: Video Processor Main Panel: Tuner CL 26532120_039.eps 021202 CL 26532120_042.eps 021202...
Circuit Diagrams and PWB Layouts TDVD1.1E Front AV Module CL 26532120_037.eps 021202 CL 26532120_030.eps 021202 Layout Front AV Module (Top Side) CL 26532120_045.eps 281102 CL 26532120_048.eps 281102...
Page 34
Circuit Diagrams and PWB Layouts TDVD1.1E Line Out Module ersonal Notes: CL 26532120_032.eps 021202 Layout Line Out Module (Top Side) CL 26532120_049.eps 281102...
00: Alps tuner D V D H o t e l O F F 10: Philips UV1316 tuner V o l u m e --- --- --- --- --- --- --- --- --- --- --- --- --- --- --- 01: Thomson/Orega tuner CL 26532120_018.eps...
Page 36
EN 36 TDVD1.1E Alignments 8.2.4 0: Two crystals applied (for NTSC playback) Video 1: AVL Auto Volume Level (Mono 22XX) 0: not available 1: 2248E (microprocessor) 0: 2248C (microprocessor) 1: Standby after power 'on' 0: No Standby after power 'on' CL 26532120_023.eps...
Page 37
Alignments TDVD1.1E EN 37 4. Choose the PIF COARSE L’ and PIF FINE L’ items, and adjust the settings until the ':' indicator (displayed as >:< ) turns into red by pressing < and > on the remote control.
EN 38 TDVD1.1E Circuit Descriptions and Abbreviation List 9. Circuit Descriptions and Abbreviation List List of Abbreviations TXTSW Teletext switch V_AMP Vertical Amplitude DAC output V_OSD Vertical OSD 110VOUT 110 V Horizontal power supply VCLK VFD control clock signal...
Circuit Descriptions and Abbreviation List TDVD1.1E EN 39 IC Data Sheets In this paragraph, the internal block diagrams and pinning are given of ICs that are drawn as a “black box” in the electrical diagrams (with the exception of “memory” and “logic” ICs).
Page 40
EN 40 TDVD1.1E Circuit Descriptions and Abbreviation List CL 26532120_009.eps 251002 Figure 9-2 STV2248 pin definitions (1)
Page 41
Circuit Descriptions and Abbreviation List TDVD1.1E EN 41 CL 26532120_010.eps 251002 Figure 9-3 STV2248 pin definitions (2) CL 26532120_008.eps 251002 Figure 9-4 STV2248 pinning...
Page 42
EN 42 TDVD1.1E Circuit Descriptions and Abbreviation List 9.2.2 ST92195 C/D Up to 64 P0[7:0] Kbytes ROM PORT 0 256 bytes P2[5:0] PORT 2 Up to 8 Kbytes P3[7:4] PORT 3 TDSRAM P4[7:0] 256 bytes PORT 4 Register File...
Page 44
EN 44 TDVD1.1E Circuit Descriptions and Abbreviation List 9.2.3 TDA1771 Vertical Deflection Circuit VOLTAGE FLYBACK REGULATOR GENERATOR TRIGGER IN CLOCK POWER RAMP AMP. GENERATOR PULSE BUFFER THERMAL STAGE PROTECTION CL 26532120_015.eps 251002 Figure 9-7 TDA 1771 internal block diagram...
Page 45
Circuit Descriptions and Abbreviation List TDVD1.1E EN 45 9.2.4 TDA 16846 Fold Back Point Correction x 1/3 Primary Voltage Check 30 k 1.5 V 75 k 15 k Control Voltage Off Time 3.5 V Comparator Limit N.C. RSTC/RSTF Error 3.5 V...
Page 46
EN 46 TDVD1.1E Circuit Descriptions and Abbreviation List 9.2.5 TDA7057AQ CL 26532120_052.eps 051202 Figure 9-11...
(0703 621 10151) also the following components are different: • Position FBT1 changed into LOT (6042 000 00421) During production the DVD loader of the TDVD1.1E has been • Position CD03 changed into 470pF 2kV 5% (0400 401 changed. Below the history of the DVD loaders in the 74711) TDVD1.1E is given.