Table of Contents
Advertisement
Quick Links
D-250 REPAIR MANUAL
Table of Contents – Page 1 of 5
FOREWORD...
CHAPTER 1: PRE-DELIVERY SERVICE
REMOVE THE TRACTOR FROM THE SHIPPING CARTON
INSTALL FRONT WHEELS
INSTALL REAR WHEELS
ADJUST TIRE PRESSURE
MOUNT STEERING WHEEL
CHECK ENGINE OIL
CHECK HYDRAULIC FLUID
CHECK TRANSAXLE FLUID
CHECK COOLING SYSTEM
CHECK WIRING
SERVICE THE BATTERY
FILL THE FUEL TANK
LUBRICATE TRACTOR
TEST TRACTOR'S OPERATION
CHECK FRONT WHEEL ALIGNMENT
ATTACH OWNER'S MANUAL TO TRACTOR
CHAPTER 2: GENERAL MAINTENANCE
LUBRICATION CHART
MAINTENANCE CHART
MAINTENANCE SCHEDULE
CHANGE ENGINE OIL
CHANGE TRANSAXLE FLUID
CLEAN ENGINE AIR FILTER
CHECK GOVERNOR OIL
BODY LUBRICATION
CHECK STEERING GEAR OIL
CHAPTER 3: TUNE-UP
SPARK PLUGS
DISTRIBUTOR MAINTENANCE - DISTRIBUTOR CAP
DISTRIBUTOR MAINTENANCE - DISTRIBUTOR WIRES
DISTRIBUTOR MAINTENANCE - ROTOR
DISTRIBUTOR MAINTENANCE - POINTS AND CONDENSER REPLACEMENT
ENGINE TIMING - MARKING THE FLYWHEEL
ENGINE TIMING - STROBE LIGHT METHOD
ENGINE TIMING - TEST LIGHT METHOD
CARBURETOR ADJUSTMENT - ADJUSTING ENGINE IDLE
CARBURETOR ADJUSTMENT - ADJUSTING AIR/FUEL
CARBURETOR ADJUSTMENT - ADJUSTING MAXIMUM RPM
TUNE-UP SPECIFICATIONS
Advertisement
Chapters
Table of Contents
Related Manuals for Wheel Horse D-250
Summary of Contents for Wheel Horse D-250
- Page 1 D-250 REPAIR MANUAL Table of Contents – Page 1 of 5 FOREWORD... CHAPTER 1: PRE-DELIVERY SERVICE REMOVE THE TRACTOR FROM THE SHIPPING CARTON INSTALL FRONT WHEELS INSTALL REAR WHEELS ADJUST TIRE PRESSURE MOUNT STEERING WHEEL CHECK ENGINE OIL CHECK HYDRAULIC FLUID...
- Page 2 D-250 REPAIR MANUAL Table of Contents – Page 2 of 5 CHAPTER 4: ENGINE ENGINE SPECIFICATIONS ENGINE TROUBLESHOOTING - ENGINE IS OVERHEATING ENGINE TROUBLESHOOTING - ENGINE RUNS -- BUT MISFIRES ENGINE TROUBLESHOOTING - STARTER WORKS -- BUT ENGINE DOES NOT...
- Page 3 D-250 REPAIR MANUAL Table of Contents – Page 3 of 5 CHAPTER 5: TRANSAXLE - Continued TRANSAXLE INSTALLATION TRANSAXLE REBUILD/DISASSEMBLY - DISASSEMBLY TRANSAXLE REBUILD/DISASSEMBLY - REAR PTO ASSEMBLY REMOVAL TRANSAXLE REBUILD/DISASSEMBLY - REDUCTION GEAR ASSEMBLY TRANSAXLE REBUILD/DISASSEMBLY - GEARSHIFT HOUSING...
- Page 4 D-250 REPAIR MANUAL Table of Contents – Page 4 of 5 CHAPTER 8: HDYRAULIC SYSTEM GENERAL SPECIFICATIONS CHANGING HYDRAULIC FLUID BLEEDING HYDRAULIC SYSTEM HYDRAULIC LIFT CYLINDER REPLACEMENT HYDRAULIC PUMP REPLACEMENT CHAPTER 9: CHASSIS FRONT AXLE ASSEMBLY - REMOVAL FRONT AXLE ASSEMBLY - INSTALLATION...
- Page 5 D-250 REPAIR MANUAL Table of Contents – Page 5 of 5 CHAPTER 10: TOOLS - SPECIAL TOOLS - Continued SPECIAL TOOLS - PULLER FOR CRANKSHAFT PULLEY (251667) SPECIAL TOOLS - PULLER FOR CRANKSHAFT PULLEY (251668) SPECIAL TOOLS - PULLER FOR CAMSHAFT GEAR SPECIAL TOOLS - PULLER CLAWS FOR B.
Need help?
Do you have a question about the D-250 and is the answer not in the manual?
Questions and answers