Table of Contents
Advertisement
OPERATING
WARNING
OUTDOOR USE ONLY!
NEVER
LEAVE
UNATTNDED
WHEN
OPERATION.
DANGER
IF YOU SMELL GAS:
1.
Shut off gas to the appliance.
2.
Extinguish any open flame.
3.
Open lid.
4.
If odor continues, keep away from the
appliance and immediately call your gas
supplier or your fire department.
WARNING
1. Do not store or use gasoline or other
flammable liquids or vapors in the
vicinity of this or any other appliance.
2. An LP cylinder not connected for use
shall not be stored in the vicinity of this
or any other appliance.
DANGER
a) Do not store a spare LP cylinder under or
near this appliance.
b) Never fill the cylinder beyond 80% full.
c) If the information in (a) and (b) is not
followed exactly, a fire causing death or
serious injury may occur.
HAZARDOUS EXPLOSION MAY RESULT IF THESE WARNINGS AND INSTRUCTIONS ARE IGNORED. READ AND
FOLLOW ALL WARNINGS AND INSTRUCTIONS IN THIS MANUAL TO AVOID PERSONAL INJURY, INCLUDING DEATH OR
PROPERTY DAMAGE.
LEAVE THIS INSTRUCTION WITH THE GRILL OWNER FOR FURTURE REFERENCE.
Outdoor LP Gas Barbecue Grill
SAVE THIS MANUAL FOR FUTURE REFERENCE
THIS
APPLIANCE
IT
IS
IN
NOTICE TO INSTALLER:
BY16-101-003-04 / English
MODEL:
INSTRUCTIONS
WARNING
BY16-101-003-04
1/15
Advertisement
Table of Contents
Subscribe to Our Youtube Channel
Related Manuals for Backyard BY16-101-003-04
Summary of Contents for Backyard BY16-101-003-04
- Page 1 HAZARDOUS EXPLOSION MAY RESULT IF THESE WARNINGS AND INSTRUCTIONS ARE IGNORED. READ AND FOLLOW ALL WARNINGS AND INSTRUCTIONS IN THIS MANUAL TO AVOID PERSONAL INJURY, INCLUDING DEATH OR PROPERTY DAMAGE. NOTICE TO INSTALLER: LEAVE THIS INSTRUCTION WITH THE GRILL OWNER FOR FURTURE REFERENCE. BY16-101-003-04 / English 1/15...
-
Page 2: Table Of Contents
Follow all instructions in this manual and use only in well ventilated, outdoor ar For Replacement Parts ordering or any services, please contact customer service at customercare@henergy-group.com or 1-844-827-7693 Go to the Replacement Parts List of this manual to get the Replacement Parts number for ordering. BY16-101-003-04 / English 2/15... -
Page 3: General Warnings
USE CAUTION AND COMMON SENSE WHEN OPERATING YOUR GAS GRILL. FAILURE TO ADHERE TO THE SAFETY WARNINGS AND GUIDELINES IN THIS MANUAL COULD RESULT IN SEVERE BODILY INJURY OR PROPERTY DAMAGE. SAVE THIS MANUAL FOR FUTURE REFERENCE. BY16-101-003-04 / English 3/15... - Page 4 Canada, CAN/CSA-B339 Cylinders, Spheres and Tubes for Transportation of Dangerous Goods; and Commission, as applicable; and provided with a listed over-filling prevention device (OPD), and provided with a cylinder connection device compatible with the connection for outdoor cooking appliances. BY16-101-003-04 / English 4/15...
- Page 5 6. Hold the tank and loosen the M6 wing nut of Tank holder. 7. Press down / slide the Tank holder to lock the tank handle as shown on Figure CG2. 8. Tighten M6 wing nut to secure/fix the tank in its up-right position. BY16-101-003-04 / English 5/15...
-
Page 6: Hose And Regulator Specification And Installation
ON and relight grill. If burner flame is higher and grill heats up properly – proceed with cooking. Full Rest: Turn ALL burner control knobs to ‘OFF’, turn off the cylinder valve. Disconnect hose and regulator from cylinder. Wait two minutes, reattach hose and regulator and perform leak test. BY16-101-003-04 / English 6/15... -
Page 7: Danger
13. Wash off soapy residue with cold water and towel dry. 14. Wait 5 minutes to allow all gas to evacuate the area before lighting grill. DO NOT use the grill if leaks cannot be stopped. Contact a qualified gas appliance repair WARNING: service. BY16-101-003-04 / English 7/15... -
Page 8: Pre-Start Check List
DO NOT attempt to operate the grill until the problem is found and corrected. Note: Observe flame height when lit: Flame should be a Blue/Yellow color between 1” – 2” when burner is on ‘HI’. Adjust flame see ‘Burner Adjustment” section of this manual. BY16-101-003-04 / English 8/15... -
Page 9: Operating The Grill
Turn off LP cylinder first to prevent gas from being left in the system under pressure. To turn off the cylinder valve, Turn knob clockwise until it stops. CAUTION: The cylinder valve should always be in the off (or closed) position when the grill is not in use. BY16-101-003-04 / English 9/15... -
Page 10: Proper Care And Maintenance
Remove the cooking grid, heat tents, and burners from your grill. Use a brush with hot water and detergent to remove excess residue. NEVER use a commercial oven cleaner. Rinse completely with water. Towel dry and replace all components as described in the assembly instructions. BY16-101-003-04 / English 10/15... -
Page 11: Burner Adjustment
To adjust air shutter, loosen set screw and rotate air shutter to desired position to achieve normal flame. Tighten set screw after adjustment is made. Relight the grill to observe flame. Incremental adjustments may be needed to achieve a good flame. Set Screw BY16-101-003-04 / English 11/15... -
Page 12: Transporting And Storage
Place dust cap on cylinder valve outlet whenever the cylinder is not in use. Only install the type of duct cap on the cylinder valve outlet that is provided with the cylinder valve. Other types of caps or plugs may result in leakage of propane. BY16-101-003-04 / English 12/15... -
Page 13: Trouble Shooting
Obstructions in gas jets or gas hose Clean jets and gas hose Windy conditions Use BBQ in a more sheltered position Gas valve knob difficult to turn Possible cause Solution Gas valve jammed Replace gas valve BY16-101-003-04 / English 13/15... -
Page 14: Replacement Parts List
Burner Left brace Ignition Pin Rear brace Control panel Tank support bracket Manifold, Hose & Regulator ass’y Axle Tank heat shield Wheel Fire bowl support Leg cap Cart front panel – lower Side shelf Control knob BY16-101-003-04 / English 14/15... -
Page 15: Warranty
WARRANTY From the date of purchase, Henergy warrants the Backyard 2 Burner Gas Grill workmanship and/or materials to the original purchaser for: 5 years on burner 1 year on valves, body and cart, igniter, cooking grates and other related parts.
Need help?
Do you have a question about the BY16-101-003-04 and is the answer not in the manual?
Questions and answers