IMPORTANT NOTICE This manual has been provided for the use of authorized Yamaha Retailers and their service personnel. It has been assumed that basic service procedures inherent to the industry, and more specifically Yamaha Products, are already known and understood by the users, and have therefore not been restated.
http://www.xiaoyu163.com DTXTREME 3 7 63 1515 0 PANEL LAYOUT Front Panel SNARE TOM 1 TOM 2 TOM 3 TOM 4 RIDE CRASH HI-HAT KICK 11 12 13 14 15 16 INPUT ATTENUATION DC IN 12V STANDBY CONTRAST HOST SELECT TO HOST FOOT SW HI-HAT CONTROL...
Page 7
http://www.xiaoyu163.com DTXTREME 3 7 63 1515 0 Rear Panel t ! 4 L MONO t u t i INDIVIDUAL OUTPUT t ! 0 OUTPUT t ! 1 t ! 2 THRU t ! 3 MIDI MIDI PC-2 PC-1 STANDBY DC IN 12V HI-HAT FOOT SW TO HOST...
http://www.xiaoyu163.com DTXTREME 3 7 63 1515 0 UNIT LAYOUT and WIRING Front View Top case SNARE TOM 1 TOM 2 TOM 3 TOM 4 RIDE CRASH HI-HAT KICK 11 12 13 14 15 16 INPUT ATTENUATION DC IN 12V STANDBY CONTRAST HOST SELECT TO HOST...
Page 9
http://www.xiaoyu163.com DTXTREME 3 7 63 1515 0 Inside View 2 DM circuit board assembly to LCD Assembly to LCD Assembly to PN-CN705 to JK-CN508 CN204 CN102 to JK-CN507 to PN-CN707 CN202 to PN-CN703 CN103 CN205 CN206 to JK-CN302 to JK-CN506 Inside View 3 L 13942296513 PN circuit board assembly...
http://www.xiaoyu163.com DTXTREME 3 7 63 1515 0 DISASSEMBLY PROCEDURE Bottom Case (time required: about 1 minutes) 1-1 Remove the seven (7) screws marked [240] and the two (2) screws marked [300]. The bottom case can then be removed. (Fig. 1) [240] Bottom case [300]...
http://www.xiaoyu163.com DTXTREME 3 7 63 1515 0 JK Circuit Board (time required: about 4 minutes) 3-1 Remove the bottom case. (See Procedure 1.) 3-2 Remove the rear panel. (See Procedure 2.) 3-3 Remove the two (2) screws marked [160] and the four (4) PCB holder.
Page 12
http://www.xiaoyu163.com DTXTREME 3 7 63 1515 0 LCD Assembly (time required: about 8 minutes) PN Circuit Board (time required: about 9 minutes) 5-1 Remove the bottom case. (See Procedure 1.) 6-1 Remove the bottom case. (See Procedure 1.) 5-2 Remove the rear panel. (See Procedure 2.) 6-2 Remove the rear panel.
http://www.xiaoyu163.com DTXTREME 3 7 63 1515 0 LSI PIN DESCRIPTION HD6412352-F20 (XW832A00) CPU DM: IC001, 101 NAME FUNCTION NAME FUNCTION PG3//CS1 Port G Bus Control Ground PG4//CS0 Port G Bus Control Port 6 P60//DREQ0//CS4 Ground Ground Ground Power Supply P61//TEND0//CS5 PC0/A0 P62//DREQ1 Port 6...
Page 14
http://www.xiaoyu163.com DTXTREME 3 7 63 1515 0 TC203C760HF-002 (XS725A00) SWP30B (AWM Tone Generator coped with MEG) Standard Wave Processor DM: IC105 NAME FUNCTION NAME FUNCTION (Ground) (Ground) HMD0 HMD1 HMD2 HMD3 HMD4 Address bus of internal register HMD5 HMD6 Wave memory data bus (Upper 16 bits) HMD7 HMD8 HMD9...
http://www.xiaoyu163.com DTXTREME 3 7 63 1515 0 JG710069 (XM326B00) DDE1 (DAC Dynamic Range Enhancer) JK: IC501-503 NAME FUNCTION NAME FUNCTION Master clock SH 0 N.C. Sync signal SH 1 N.C. MIN 1 Signal input Latch enable for DAC MIN 0 Signal input DACO 0 Output (DAC)
Page 16
http://www.xiaoyu163.com DTXTREME 3 7 63 1515 0 NJM2902M-T1 (XR562A00) MM74HC74ASJX (XY153A00) NJM2904M (XV190A00) Dual Operational Amplifier Dual D-Type Flip-Flop Dual Operational Amplifier JK: IC307-314, 316 DM: IC012, 213-217 JK: IC317 A OUTPUT D OUTPUT +DC Voltage Output A 1CLR Supply A -INPUT D -INPUT Inverting...
Page 17
http://www.xiaoyu163.com DTXTREME 3 7 63 1515 0 TC7S32F (XM588A00) TC74HC4052AF (XS790A00) TC74VHC04F (XM332A00) Hex Inverter DM: IC014 JK: IC303-304 DM: IC207 IN A IN B Y-COM Y-COM X-COM X-COM TC74VHC14F-EL (XW876A00) TC74VHCT245AF (XV242A00) TC74VHC273F(EL) (XY254A00) Hex Inverter Dual D-Type Flip-Flop Octal 3-State Bus Transceiver DM: IC204 JK: IC318...
http://www.xiaoyu163.com DTXTREME 3 7 63 1515 0 TEST PROGRAM Test No. Title Judgment criteria, etc. MEASURING CONDITION TEST ENTRY CARRYING ON THE TEST AND THE TEST AT THE TIME OF FAIL TEST ITEM C-01. MAIN ROM Automatic test C-02. SUB ROM Automatic test C-03.
Page 24
http://www.xiaoyu163.com DTXTREME 3 7 63 1515 0 Test No. Title Judgment criteria, etc. C-51. TRIGGER SW IN 5 Check the trigger switch for ON/ OFF operation. C-52. ATTENUATION SW H IN 01 Input looped signals from PHONES. (Level) C-53. ATTENUATION SW H IN 02 Input looped signals from PHONES.
Page 25
3 7 63 1515 0 A. TEST ENTRY Activate power on the main unit by pressing the [PLAY] + [EXIT/ NO] keys at the same time. [Initial screen] YAMAHA DRUM TRIGGER MODULE DTXTREME After a while, the following indication appears. [DLAG 1]...
Page 26
http://www.xiaoyu163.com DTXTREME 3 7 63 1515 0 B. CARRYING ON THE TEST AND THE TEST AT THE C- 02. SUB ROM TIME OF FAIL 1. After setting each parameter in “A. TEST ENTRY”, [Initial indication] press the “ENTER/ YES” key. The following appears. SUB ROM [Indication screen] MAIN ROM...
Page 27
http://www.xiaoyu163.com DTXTREME 3 7 63 1515 0 C- 04. SUB SRAM [Content of FAIL judgment] None [Initial indication] [Completing the test] OK: Go on to the next test. NG: For handling the FAIL judgment, see “B. SUB SRAM CARRYING ON THE TEST”. C- 06.
Page 28
http://www.xiaoyu163.com DTXTREME 3 7 63 1515 0 In case of NG [Indication of judgment result] In case of OK SUB WAVE ROM 2 SUB WAVE ROM 4 FAIL (XXXX) Checksum in case of XXXX [Content of FAIL judgment] In case of NG None [Completing the test] SUB WAVE ROM 4...
Page 29
http://www.xiaoyu163.com DTXTREME 3 7 63 1515 0 C- 11. SUB WAVE DRAM 1 [Completing the test] OK: Go on to the next test. [Initial indication] NG: For handling the FAIL judgment, see “B. CARRYING ON THE TEST”. 11 SUB WAVE DRAM 1 C- 13.
Page 30
http://www.xiaoyu163.com DTXTREME 3 7 63 1515 0 In case of NG [Test method] Move each volume of CLICK ~ MISC up and down to the limit to display the figure 00 ~ 99 at the bottom of 14 SMART MEDIA LCD.
Page 31
http://www.xiaoyu163.com DTXTREME 3 7 63 1515 0 [Test method] [Completing the test] 1. Check that the LEDs corresponding to the following OK: Go on to the next test. panel switches light up in the sequential order below. C- 27. PANEL SW [ RHYTHM / INS] [ BASS / DEL] [ OTHERS]...
Page 32
http://www.xiaoyu163.com DTXTREME 3 7 63 1515 0 [Completing the test] In case of NG: None OK: Go on to the next test. [Content of FAIL judgment] NG: For handling the FAIL judgment, see “B. Working with the switch plug will not even proceed to CARRYING ON THE TEST”.
Page 33
http://www.xiaoyu163.com DTXTREME 3 7 63 1515 0 [Test method] C- 32. ROTARY ENCODER 1 Maximize PHONES VR. Connect the looped signals C- 33. ROTARY ENCODER 2 from PHONES to IN01 (SNARE) using a stereo cable. C- 34. ROTARY ENCODER 3 Take care to cut off DC by installing a capacitor (approx.
Page 34
http://www.xiaoyu163.com DTXTREME 3 7 63 1515 0 C- 48. TRIGGER SW IN 2 [Completing the test] C- 49. TRIGGER SW IN 3 Pressing the [ENTER/ YES] key proceeds to the next t C- 50. TRIGGER SW IN 4 est. For handling the FAIL judgment during the test, see C- 51.
Page 35
http://www.xiaoyu163.com DTXTREME 3 7 63 1515 0 [Initial indication] [Test content] For attenuation switches IN01 ~ IN16, add looped signals from PHONES on the left-hand side (ON and 52 ATTENUATION SW H IN01 upper side of JK board) and check that the inputted waiting signals are being inputted into the CPU at correct gain and correct attenuation level .
Page 36
http://www.xiaoyu163.com DTXTREME 3 7 63 1515 0 [Completing the test] C- 87. PHONES R 1 kHz Pressing the [ENTER/ YES] key proceeds to the next test. [Initial indication] C- 85. OUTPUT R 1 kHz 87 PHONES R [Initial indication] [Test content] 85 OUTPUT R Check that correct signals are being outputted from PHONES (R).
Page 37
http://www.xiaoyu163.com DTXTREME 3 7 63 1515 0 [Test content] C- 96. FACTORY SET Check that the signals inputted from AUX IN are being outputted from PHONES (L/ R) as correct ones. [Initial indication] [Test method] Input the following sine wave (“Check item” below) into 96 FACTORY SET AUX IN (L/ R).
Page 38
http://www.xiaoyu163.com DTXTREME 3 7 63 1515 0 Inspecting the Main Unit for Sound Production Turn off powder once. Then turn it on again and inspect the following in normal mode. In play mode subsequent to exit from test mode, check that the noise level meets the requirements below. (Maximize each volume.) OUTPUT(L/MONO): -75 dBm or less (DIN AUDIO)
Yamaha dealer on replacing the battery. broken. Replace the memory card. In any case, the data stored on the troubled card may be corrupted.
Page 56
http://www.xiaoyu163.com DTXTREME 3 7 63 1515 0 The DTXTREME cannot recognize the specified file (file format). Check if the file is suitable for the DTXTREME and is not corrupted. This message will be shown if you attempt to load a song from the memory card or by receiving bulk data when a preset song is selected (in Drum Kit Play mode).
http://www.xiaoyu163.com DTXTREME 3 7 63 1515 0 TROUBLESHOOTING The DTXTREME is Not Making a Sound or a Triggered Sound Make sure the pads and triggers are connected correctly to the input jacks of theDTXTREME. Make sure the connectors from the DTXTREME OUTPUT jack (and NOT the INDIV. OUTjack) are plugged correctly to the input jacks of the amplifier or mixer.
Page 60
http://www.xiaoyu163.com DTXTREME 3 7 63 1515 0 The Triggered Sound is Not Stable (When using accoustic drums) Make sure you have select the correct input type. Try a larger drum. Make sure the trigger pickup (DT series) is securely fastened with new sticky tape. Make sure the cable is securely inserted into the DT10 jack.
Page 61
http://www.xiaoyu163.com DTXTREME 3 7 63 1515 0 The Sound is Too Loud (The Velocity is Permanently Too High) Lower the gain setting. Lower the minimum value of the velocity range. Try another velocity curve. If you are using a sensor made by other manufacturers, it may be sending a large signal. Reset the INPUT A TTENUATION switch on the rear panel.
Page 66
http://www.xiaoyu163.com 3 7 63 1515 0 PARTS LIST CONTENTS OVERALL ASSEMBLY ............... 2 PN CIRCUIT BOARD ASSEMBLY ..........6 ELECTRICAL PARTS ..............8 L 13942296513 Notes: DESTINATION ABBREVIATIONS A: Australian model J: Japanese model B: British model U: U.S.A. model C: Canadian model V: General export model (110V) E: European model...
Page 67
http://www.xiaoyu163.com DTXTREME 3 7 63 1515 0 OVERALL ASSEMBLY Front View SNARE TOM 1 TOM 2 TOM 3 TOM 4 RIDE CRASH HI-HAT KICK 11 12 13 14 15 16 INPUT ATTENUATION DC IN 12V STANDBY CONTRAST HOST SELECT TO HOST FOOT SW HI-HAT CONTROL...
Page 68
http://www.xiaoyu163.com DTXTREME 3 7 63 1515 0 Inside View 1 C View D View E View L 13942296513 InsideView 2 B View A View u163 http://www.xiaoyu163.com...
Page 84
http://www.xiaoyu163.com DTXTREME Data Control Knobs to DM-CN102 DC/DC CONVERTER CLICK SNARE ACCOMP REVERB PLAY EXIT ENTER CLILK TRIGGER SNARE TOM1 OP AMP OP AMP TC74VHC32F (EL) KICK INVERTER CHAIN VOICE SHIFT Page Page Sound INVERTER TOM2 HI-HAT SONG EFFECT RHYTHM BASS INSERT DELETE...
Page 85
http://www.xiaoyu163.com DTXTREME to LCD Assembly to PN-CN707 to JK-CN505 to JK-CN302 to LCD Assembly CONTRAST LINE DRIVER LNB0509B-812 CH87142V100 SUB ROM 8M TO HOST to PN-CN705 INVERTER HOST SELECT MIDI CPU H8/2352 ASSP MAIN ROM 16M D-FF HTJ-064-04K HI-HAT CONTROL SRAM 256K SRAM 256K CPU H8S-2352...