Download  Print this page

Philips HTL3110B/F7 Service Manual

Hide thumbs

Advertisement

Quick Links

TV BAR
Service
Service
Service
Service Manual
©
Copyright 2014 WOOX Innovations limited.
All rights reserved. No part of this publication may be reproduced, stored in a retrieval system or
transmitted, in any form or by any means, electronic, mechanical, photocopying, or otherwise
without the prior permission of WOOX Innovations. Philips and the Philips' shield Emblem are
registered trademarks of Koninklijke Philips N.V. and are used by WOOX Innovations Limited
under license from Koninklijke Philips N.V.
Published by
SW_HF1402
Version 1.0
TABLE OF CONTENTS
Location Of PCBA & Versions Variation.................... 1-2
Technical Specification .............................................. 1-3
Safety instruction ...................................................... 1-4
Software upgrade instruction ........................................ 2
Trouble Shooting............................................................ 3
Dismantling instructions ................................................ 4
Block Diagram................................................................ 5
Wiring Diagram .............................................................. 6
MAIN+MP3&USB+SPK+VFD&BT+AUX&OPTICAL PCB
WIRELESS PCB(Main unit) .......................................... 8
AMP+LED PCB(Subwoofer) .......................................... 9
POWER PCB(Subwoofer) .......................................... 10
Mechanical Exploded .................................................. 11
Revision List ................................................................ 12
1 - 1
Chapter
(Main unit) .......... 7
HTL3110B/F7
GB
3140 038 61420
PHILIPS

Advertisement

loading

  Also See for Philips HTL3110B/F7

  Summary of Contents for Philips HTL3110B/F7

  • Page 1 WOOX Innovations. Philips and the Philips’ shield Emblem are registered trademarks of Koninklijke Philips N.V. and are used by WOOX Innovations Limited under license from Koninklijke Philips N.V.
  • Page 2 1 - 2 LOCATION OF PCBA USB PCB AUX PCB SPK_R PCB SPK_L PCB WIRELESS PCB NFC PCB TOUCH PCB VFD PCB MAIN PCB Main Unit Wireless TX module MAIN PCB LED PCB POWER PCB Subwoofer VERSIONS VARIATION: HTL3110B Type/Versions Board in used MAIN+MP3&USB+SPK+VFD&BT+AUX&OPTICAL Board WIRELESS Board...
  • Page 3: Main Unit

    • RMS Total output power: 120W RMS (+/- • Power supply: 0.5 dB, 10% THD) • Model (Philips AC power adapter): • Frequency response: 20 Hz-20 kHz / ±3 DYS602-210309W; AS650-210-AA309 • Input: 100-240 V~, 50/60 Hz 1.5 A •...
  • Page 4: Safety Instruction

    Unplug this apparatus during lightning storm or when unused for long periods of Your product is designed and manufactured with high quality materials and components, time. which can be recycled and reused. Please visit www.recycle.philips.com for additional • Refer all servicing to service personnel.
  • Page 5: Software Upgrade Instruction

    < TREBLE -, BASS- and - (Volume) > on the remote control. 3) Software Upgrade via USB a) Check the latest software version on www.philips.com/support. • Search for your model and click on“Software and drivers”.
  • Page 6: Trouble Shooting

    3 - 1 3 - 1 Trouble Shooting(main unit) MAIN UNIT REPAIR CHART 1/2 Power Supply All Function Standby LED Didn't power ON AUX IN Wireless optical&COAXIAL IN Audio line IN Bluetooth No Output HDMI ARC No Sound red light is not bright No Working No Sound No Output...
  • Page 7 3 - 2 3 - 2 Trouble Shooting(main unit) MAIN UNIT REPAIR CHART 2/2 Audio line IN Bluetooth Wireless No Output No Output No Output No Output Check JK305 Check BT401 Check MD401 Check CN302 RB302 Check Q404 R419 L403 Check L401 L402 and Change this jk Change this jack...
  • Page 8 3 - 3 3 - 3 Trouble Shooting(subwoofer) IC401 and IC501 8pin Check power D905,D910,IC901, BK3.3V IC902, Q902,Transformer and their conjoint part D905, IC901, IC906 L202, L203 Change transmitter module...
  • Page 9 4- 1 4 - 1 Note:In some service positions the components or copper patterns of one board may risk touching its Dismantling of the VFD+BT Boards 1) Loosen 2 screws “F” on the top of VFD+BT board as shown in fi gure 7. neighbouring pc boards or metallic parts.
  • Page 10 4 - 2 4 - 2 Dismantling of the WIRELESS Boards assembly Dismantling Instructions(SUBWOOFER) 1) Loosen 1 screws “J” on the top of WIRELESS Board as shown in fi gure 10. Dismantling of Back panel assembly 1) Loosen 8 screws “K” to remove the back panel as shown in fi gure 12. Figure 10 Dismantling of the TOUCH Boards assembly 1) Remove the top lens to take the TOUCH Board out as shown in fi gure 11.
  • Page 11: Block Diagram

    5 - 1 5 - 1 Block Diagram(main unit) 74HC04 2219M40 Optical Wireless CS5343 4052 Switch MPEG Dolby Digital DAMP 27MHz TAS5715 NFC- H1 MP3/WMA SDRAM decode BM84 FLASH Bluetooth EN25F16 v3.0, A2DP MT8307OQE Reset AVRCP LM809 TPS2553 eKTF5705 Touch IC Transistor 8 Digit VFD PT6315...
  • Page 12 5 - 2 5 - 2 Block Diagram(subwoofer)
  • Page 13: Wiring Diagram

    6 - 1 WIRING Diagram(main unit)
  • Page 14 6 - 2 6 - 2 WIRING Diagram(subwoofer)
  • Page 15 7- 1 7 - 1 IC303 INTERNAL IC DIAGRAM - CD4052BM MAIN+MP3&USB+SPK+VFD&BT+AUX&OPTICAL BOARD TABLE OF CONTENTS Internal IC Diagram ................7-1 Circuit Diagram .................. 7-2 Component Layout_Top View ............7-3 IC302 INTERNAL IC DIAGRAM - CS5343-CZZ Component Layout_Bottom View ............7-4...
  • Page 16 7 - 2 7 - 2 CIRCUIT DIAGRAM D201 1N4148 PL33 R201 BT_ON/OFF R217 SUB Speaker JACK PCB Board R559 R202 PLAY/PAUSE_STATE R218 C203 R203 PLAY/PAUSE_CONTROL R219 R509 C517 C518 RB501 JK501 R204 BT_NEXT R220 R205 BT_PREV R221 C523 C527 60W 10% 4OHM R206 BT_MUTE...
  • Page 17 7- 3 7 - 3 COMPONENT LAYOUT_TOP View LFM110990-0001 20131125 REV:A O4.0 O4.0 C417 R422 R421 PIN2 BT-R LFM110998-0001 131125 REV:A bar code location BM84 BT-L 20131125 LFM110997-0001 REV:A RB405 RB301 DP101 TSDA R119 C118 C128 C124 Q404 C117 C105 R117 BK3.3V TO MAIN...
  • Page 18 7 - 4 7 - 4 COMPONENT LAYOUT_Bottom View R112 IC102 C113 R104 C114 R107 C115 Q402 Q401 R105 R106 R108 R109 D401 C116 C409 R111 C104 C126 R411 R110 C102 R413 R412 STANDBY VOL+ VOL- SOURCE C257 R260 C945 C211 C214 C206...
  • Page 19 8 - 1 8 - 1 WIRELESS BOARD TABLE OF CONTENTS Circuit Diagram .................. 8-2 Component Layout_Top View ............8-3 Component Layout_Bottom View ............8-4...
  • Page 20 8 - 2 8 - 2 CIRCUIT DIAGRAM MD401 CN402 R401 TSD 2 DATA W_INT1 R402 R403 W_SCL R404 W_SDA LRCK standby R405 TSD 2 MUTE R406 MCLK R407 ID pairing RX Link TX Link WSCL R408 CN403 WSDA CN4/20 R409 R425 USDA...
  • Page 21 8 - 3 8 - 3 Component Layout_Top View MD401 C408 R407 C406 CN403 R405 C407 R406 R408 CN402 R409 R425 R404 R403 R426 C405 C404 R402 L402 R401 C402 L401 C401 C422 C403...
  • Page 22 8 - 4 8 - 4 Component Layout_Bottom View...
  • Page 23 9 - 1 9 - 1 IC501 INTERNAL IC DIAGRAM - TAS5715PHRR AMP & LED BOARD TABLE OF CONTENTS Internal IC Diagram ................9-1 Circuit Diagram .................. 9-2 Component Layout_Top View ............9-3 Component Layout_Bottom View ............9-4...
  • Page 24 9 - 2 9 - 2 CIRCUIT DIAGRAM +3.3V C518 C520 R525 C523 C521 C522 C517 R523 C519 R524 FB502 20V1 +23V +3.3V 100MHZ 470U/35V L502 R522 15UH/3A AVDD AVDD PGND_AB PGND_AB OUT_B POWER OFF MUTE D501 C505 C533 R520 +3.3V FAULT(BKEND_ERROR) PVCC_ B...
  • Page 25 9 - 3 9 - 3 Component Layout_Top View LFM110940-0201 RESET 3.3V 3.3V PIN1...
  • Page 26 9 - 4 9 - 4 Component Layout_Bottom View RESET 3.3V 3.3V PIN1...
  • Page 27 10 - 1 10 - 1 IC903/904/909 INTERNAL IC DIAGRAM - AZ431AZ-A CATHODE POWER BOARD TABLE OF CONTENTS Internal IC Diagram ................10-1 ANODE Circuit Diagram ................. 10-2 Component Layout_Top View ............10-3 Component Layout_Bottom View ............10-4...
  • Page 28 10 - 2 10 - 2 CIRCUIT DIAGRAM L-6uH-5A 330K 330K 330K 330K C937 R912 R913 R914 R915 L903 HVCC C934 D905 1000U 50V FMX-G22S R909 222P/630V C911 C936 R936-939 102P-500V VCC2 PR2007 R940 R910 D901 R04-220 R04-220 R04-220 R04-220 15mR M-CU WIRE R9020-9031 ER34...
  • Page 29 10 - 3 10 - 3 Component Layout_Top View WARNING: FOR CONTINUED PROTECTION AGAINST RISK OF FIRE REPLACE WITH SAME TYPE FUSE. CN902 PIN1 P903 P901 C939 C905 IC909 J912 C907 BD901 J905 C932 T902 L903 C911 R940 Q902 L902 C937 C902 J901...
  • Page 30 10 - 4 10 - 4 Component Layout_Bottom View C961 PIN1 R956 R951 C908 R948 R959 D908 C928 R945 D907 C940 C906 R954 R910 R949 C942 R953 R950 R911 R909 R955 R9014 R9013 R9012 R912 R9020 R9004 C938 R913 R9021 R9003 R914 R9002...
  • Page 31 11- 1 11- 1 Mechanical Exploded View(Main unit) Note:A1=8+10+17+19+20+26+30 Power Adapter Power Cord...
  • Page 32: Power Cord

    11- 2 11- 2 Mechanical Exploded View(subwoofer) SW14 SW13 SW12 SW11 SW10 Note:B1=SW11+SW13 Power Cord...
  • Page 33: Revision List

    12- 1 REVISION LIST Version 1.0 *Initial release...