1. Manuals
  2. Brands
  3. Samsung Manuals
  4. Monitor
  5. RS21A Series
  6. Service manual

Samsung RS21A Series Service Manual

Tft-lcd
Hide thumbs
Table of Contents

Advertisement

Quick Links

Download this manual
SERVICE
TFT-LCD MONITOR
TFT-LCD MONITOR
RS21A*/RS24A*
Manual
CONTENTS
4. Alignment & Adjustments
7. Electrical Parts List
11. Panel Description
CONFIDENTIAL

Advertisement

Table of Contents
loading

Related Manuals for Samsung RS21A Series

Summary of Contents for Samsung RS21A Series

  • Page 1: Table Of Contents

    CONFIDENTIAL TFT-LCD MONITOR RS21A*/RS24A* SERVICE Manual TFT-LCD MONITOR CONTENTS 1. Precautions 2. Product Specifications 3. Disassembly & Reassembly 4. Alignment & Adjustments 5. Troubleshooting 6. Exploded View & Parts List 7. Electrical Parts List 8. Block Diagram 9. Wiring Diagram 10.

  • Page 2: Precautions

    CONFIDENTIAL 1 Precautions Follow these safety, servicing and ESD precautions to prevent damage and to protect against potential hazards such as electrical shock. 1-1 Safety Precautions 1-1-1 Warnings For continued safety, do not attempt to modify the (READING SHOULD circuit board. NOT BE ABOVE 0.5mA) Disconnect the AC power and DC Power Jack before servicing.

  • Page 3: Servicing Precautions

    CONFIDENTIAL 1 Precautions 1-2 Servicing Precautions WARNING: An electrolytic capacitor installed with the wrong polarity might explode. Caution: Before servicing units covered by this service manual, read and follow the Safety Precautions section of this manual. Note: If unforeseen circumstances create conflict between the following servicing precautions and any of the safety precautions, always follow the safety precautions.

  • Page 4: Product Specifications

    CONFIDENTIAL 2 Product Specifications 2-1 Specifications Description Item RS21A* RS24A* LCD Panel TFT-LCD panel, RGB vertical stripe, normally black TFT-LCD panel, RGB vertical stripe, normally black transmissive, (21.3-Inch) viewable, 0.27 pixel pitch transmissive, (24.06-Inch) viewable, 0.27 pixel pitch Scanning Frequency Horizontal : 30 kHz ~ 85 kHz (Analog) Vertical : 55 Hz ~ 85 Hz Display Colors...

  • Page 5: Pin Assignments

    CONFIDENTIAL 2 Product Specifications 2-2 Pin Assignments Sync 15-Pin Signal Cable Connector Type Separate Composite Sync-on-green Pin No. Green Green Green + H/V Sync. Blue Blue Blue GND (DDC Return) GND (DDC Return) GND (DDC Return) GND-Red GND-Red GND-Red GND-Green GND-Green GND-Green GND-Blue...

  • Page 6: Timing Chart

    CONFIDENTIAL 2 Product Specifications 2-3 Timing Chart This section of the service manual describes the timing that the computer industry recognizes as standard for computer-generated video signals. Table 2-1 Timing Chart Mode VGA3/60 Hz VGA/72 Hz VGA/75 Hz VGA/85 Hz MAC/60 Hz MAC/66 Hz SVGA/56 Hz...
  • Page 7 CONFIDENTIAL 2 Product Specifications Table 2-2 Timing Chart (continued) Mode SVGA/75 Hz SVGA/85 Hz MAC/74 Hz XGA/60 Hz XGA/70 Hz XGA/75 Hz XGA/85 Hz MAC/60 Hz MAC/74 Hz VESA/75 Hz MAC/75 Hz 800 x 600 832 x 624 1024 x 768 1024 x 768 1024 x 768 1024 x 768...
  • Page 8 CONFIDENTIAL 2 Product Specifications Table 2-3 Timing Chart (continued) Mode NCD/70 Hz SXGA/75 Hz SUN/66 Hz SUN/76 Hz HP/72 Hz SUN/76 Hz SXGA/60 Hz 1280 x 1024 1280 x 1024 1152 x 900 1152 x 900 1280 x 1024 1280 x 1024 1280 x 1024 Timing fH (kHz)
  • Page 9 CONFIDENTIAL 2 Product Specifications Table 2-4 Timing Chart (continued) Mode NCD/64Hz UXGA/60Hz UXGA/65Hz UXGA/70Hz SUN/66 Hz WUXGA2/60 Hz 1920 x 1200 1600 x 1200 1600 x 1200 1600 x 1200 1600 x 1200 1600 x 1200 Timing 81.25 87.5 80.038 89.286 74.52 fH (kHz)

  • Page 10: Disassembly And Reassembly

    CONFIDENTIAL 3 Disassembly and Reassembly This section of the service manual describes the disassembly and reassembly procedures for the RS21A*/RS24A* monitor. WARNING: This monitor contains electrostatically sensitive devices. Use caution when handling these components. 3-1 Disassembly Cautions:1. Disconnect the monitor from the power source before disassembly. 2.
  • Page 11 CONFIDENTIAL 3 Disassembly and Reassembly 3-2 Replacement Order of Lamp Assemblies 1. Remove the lamp wire holding tape from the metal chassis on the bottom side. 1-1. Taking out the lamp wire from the lamp wire holder. 2. Unscrewing the screw. Unscrewing force : 0.8 ~ 1Kg - f.cm 3.
  • Page 12 CONFIDENTIAL 3 Disassembly and Reassembly 4. Dis-Assembled the lamp Ass’y from LCD completely. Replacement of lamp unit should be done at the power off state and rcommended clean bench condition. 3-3 Reassembly Reassembly procedures are in the reverse order of Disassembly procedures. RS21A*/RS24A*...
  • Page 13 CONFIDENTIAL 3 Disassembly and Reassembly Memo RS21A*/RS24A*...

  • Page 14: Alignments And Adjustments

    CONFIDENTIAL 4 Alignments and Adjustments This section of the service manual explains how to use the DDC JIG to adjust the black, red, green, and blue levels of the FPD when you replace the AD Board, and how to update the microprocessor when you change the Panel or Lamp(s).
  • Page 15 CONFIDENTIAL 4 Alignments and Adjustments Memo RS21A*/RS24A*...

  • Page 16: Troubleshooting

    CONFIDENTIAL 5 Troubleshooting 5-1 No Power Does proper DC 14 V appear at Check SMPS PCB and Adapter. DC jack connected to CN800? Does proper DC 5 V appear at Check IC815 and IC 816 Pin 2 of IC815 and IC816? Does proper DC 5 V appear at Check IC810.
  • Page 17 CONFIDENTIAL 5 Troubleshooting 5-2 No Video (PC Analog Signal) Power indicator is green Check R226, R228, R229, Does the signal appear at Pin 7, C237, C238, C239, R246, R247, 15 and 22 of IC203, IC206? R249, C258, C260, C262. Does the clock pulse appear at Check IC203 and related circuit of IC203.
  • Page 18 CONFIDENTIAL 5 Troubleshooting 5-3 No Picture (CVBS, S-VHS, Scart Video) Check Pin 4 (5V_Tuner) of IC816 Check CN301 (Tuner), Pin 20 (Scart_Vin) of CN302. CN302 (Scart connector). Check Pin 15 Replace Tuner. (RF_CVBS) of CN301. Check related circuit of IC303 Check IC303 (VPC3230D).
  • Page 19 CONFIDENTIAL 5 Troubleshooting 5-4 No Sound Does the Low signal at Check Pin 4 and 6 of CN102. Pin 9 and of IC101? Check Pin 1 and 5 of IC101? Replace IC101. Check Pin 67 of Replace IC103 (MSP3451). IC103 (MSP3451)? Check CN301 and tuner and related circuit of CN301 and tuner.
  • Page 20 CONFIDENTIAL 6 Exploded View and Parts List 6-1 RS21A* RS21A*/RS24A*...

  • Page 21: Exploded View & Parts List

    CONFIDENTIAL 6 Exploded View & Parts List 6-2 RS24A* RS21A*/RS24A*...
  • Page 22 Item No Design LOC 품 명 Spec SERVICE LW24R15WX/XEC SL-LW24R15WX/XEC SEC,W1-L01 BN90-00230A ASSY STAND RS24NS 6011-001443 STAND+B/HINGE BOLT-SOCKET M8,L24(19),ZPC(BLK),SWRCH18A BN75-00218A UNIT-STAND-SET RU24NS,-,AL DIECASTING,-,-,-,-,- 6001-001114 SCREW-MACHINE FH,+,M4,L6,ZPC(BLK),SWRCH18A,FP 6001-001551 SCREW-MACHINE FH,+,M4,L20,ZPC(BLK),SWRCH18A,FP BH73-60339A RUBBER-LEG SLC1400,EVA,GRAY,65HB,DIA13*H2 BN61-00061A BRACKET-STAND RU24NS,SECC,T2.0,-,-,-,- BN67-00025A STAND RACK-BASE RU24NS,-,-,-,-,-,- BN67-00026A STAND RACK-SUPPORT RU24NS,-,-,-,-,-,- BN73-00016A...
  • Page 23 6003-000117 SH/PCB+SH/D_SUB SCREW-TAPTITE BH,+,B,M3,L6,ZPC(YEL),SWRCH18A 6003-000122 C/F+P/SHIELD SCREW-TAPTITE BH,+,B,M4,L12,ZPC(YEL),SWRCH18 BN39-00223A H_AV_SMALL LEAD CONNECTOR-ASSY RS24NS,UL2464#24,UL/CSA,6P,-,-,#24,SMH200-06,SMH200-06,BK,-,-,300MM,2464#24,-,- BN39-00224A H_AV_LARGE LEAD CONNECTOR-ASSY RS24NS,UL20276#32,UL/CSA,12P,-,-,#32,SMH200-12,SMH200-12,BK,-,-,560MM,20276#32,- BN39-00225A H_IR LEAD CONNECTOR-ASSY RS24NS,UL2464#26,UL/CSA,3P,-,-,#26,SMH250-03,SMH250-03,BK,-,-,400MM,2464#26,SJ01 BN39-00226A H_LVDS LEAD CONNECTOR-ASSY RS24NS,UL1571#28,UL/CSA,31P,-,-,#28,FI-W31S,FI-W31S,BK,-,-,150MM,1571#28,SJ01-01 BN39-00227A H_LVDS_P LEAD CONNECTOR-ASSY RS24NS,UL1061#28,UL/CSA,12P,-,-,#28,12505HS-12,12505HS-12,BK,-,-,130MM,1061#28,S BN39-00228A H_INVERTER LEAD CONNECTOR-ASSY RS24NS,UL1061#28,UL/CSA,15P,-,-,#28,12505HS-15,12505HS-15,BK,-,-,70MM,1061#28,SJ BN39-00229A H_FUNCTION LEAD CONNECTOR-ASSY RS24NS,UL2835#28,UL/CSA,15P,-,-,#28,12505HS-15,12505HS-15,BK,-,-,230MM,2835#28,S BN44-00044A...
  • Page 24 3711-004261 CN103 CONNECTOR-HEADER BOX,12P,1R,2MM,ANGLE,SN 3722-000183 CN302 JACK-SCART 21P,4mm,SN,BLK,NO 3722-001055 CN101 JACK-PHONE 5P/2C,3.6PI,AG,BLK,#16-22 3722-001267 CN800 JACK-DC POWER 4P,-,SN,BLK,- BN63-00086B CIS6 SHIELD-D_SUB RU24AS,SPTE,T0.5,PAL BN97-00096J ASSY MICOM RS24AS 1102-001128 IC404 IC-EPROM M27C2001,256KX8BIT,PDIP,32P,535MIL,55NS,5V,10%,PLASTIC,0TO+70C,-,-,ST BN46-00012K S/W MICOM RS24AS BN97-00097A ASSY SMD RS24AS 0202-001162 SOLDER-CREAM RMA-20-21L,S63,-,SN63/PB36.6/AG0.4,FLUX9.5% 0401-001056 D101 DIODE-SWITCHING...
  • Page 25 0403-001052 ZD312 DIODE-ZENER RD8.2MB,8.2V,7.7-8.64V,200mW,S 0403-001052 ZD313 DIODE-ZENER RD8.2MB,8.2V,7.7-8.64V,200mW,S 0403-001052 ZD314 DIODE-ZENER RD8.2MB,8.2V,7.7-8.64V,200mW,S 0403-001052 ZD315 DIODE-ZENER RD8.2MB,8.2V,7.7-8.64V,200mW,S 0403-001052 ZD316 DIODE-ZENER RD8.2MB,8.2V,7.7-8.64V,200mW,S 0403-001052 ZD317 DIODE-ZENER RD8.2MB,8.2V,7.7-8.64V,200mW,S 0403-001052 ZD318 DIODE-ZENER RD8.2MB,8.2V,7.7-8.64V,200mW,S 0403-001052 ZD319 DIODE-ZENER RD8.2MB,8.2V,7.7-8.64V,200mW,S 0403-001340 ZD103 DIODE-ZENER UDZ15B,14.34-14.98V,200mW,SOD-323,TP 0403-001340 ZD104 DIODE-ZENER UDZ15B,14.34-14.98V,200mW,SOD-323,TP 0501-000462 Q101 TR-SMALL SIGNAL...
  • Page 26 1105-001301 IC602 IC-DRAM 4S643232,512Kx32x4Bit,TSOP,86P,400MIL,7nS,3.3V,10%,PLASTIC,0to+70C,2mA,CMOS,TR 1203-001448 IC808 IC-SWITCH VOL. REG. 2596,TO-263,5P,-,PLASTIC,4.750 1203-001448 IC815 IC-SWITCH VOL. REG. 2596,TO-263,5P,-,PLASTIC,4.750 1203-001448 IC816 IC-SWITCH VOL. REG. 2596,TO-263,5P,-,PLASTIC,4.750 1203-001465 IC804 IC-POSI.ADJUST REG. 317,TO-263,3P,-,PLASTIC,1.2/37 1203-001465 IC806 IC-POSI.ADJUST REG. 317,TO-263,3P,-,PLASTIC,1.2/37 1203-001465 IC807 IC-POSI.ADJUST REG. 317,TO-263,3P,-,PLASTIC,1.2/37 1203-001488 IC810 IC-POSI.FIXED REG. 7805,T0-252,3P,-,PLASTIC,4.8/5 1203-001488 IC811...
  • Page 27 2007-000070 R745 R-CHIP 0ohm,5%,1/16W,DA,TP,1608 2007-000070 R746 R-CHIP 0ohm,5%,1/16W,DA,TP,1608 2007-000070 R747 R-CHIP 0ohm,5%,1/16W,DA,TP,1608 2007-000070 R748 R-CHIP 0ohm,5%,1/16W,DA,TP,1608 2007-000070 R749 R-CHIP 0ohm,5%,1/16W,DA,TP,1608 2007-000070 R750 R-CHIP 0ohm,5%,1/16W,DA,TP,1608 2007-000070 R751 R-CHIP 0ohm,5%,1/16W,DA,TP,1608 2007-000070 R752 R-CHIP 0ohm,5%,1/16W,DA,TP,1608 2007-000070 R753 R-CHIP 0ohm,5%,1/16W,DA,TP,1608 2007-000070 R754 R-CHIP 0ohm,5%,1/16W,DA,TP,1608 2007-000070 R755 R-CHIP...
  • Page 28 2007-000071 R523 R-CHIP 22ohm,5%,1/16W,DA,TP,1608 2007-000071 R525 R-CHIP 22ohm,5%,1/16W,DA,TP,1608 2007-000071 R537 R-CHIP 22ohm,5%,1/16W,DA,TP,1608 2007-000071 R538 R-CHIP 22ohm,5%,1/16W,DA,TP,1608 2007-000071 R539 R-CHIP 22ohm,5%,1/16W,DA,TP,1608 2007-000071 R540 R-CHIP 22ohm,5%,1/16W,DA,TP,1608 2007-000071 R541 R-CHIP 22ohm,5%,1/16W,DA,TP,1608 2007-000071 R542 R-CHIP 22ohm,5%,1/16W,DA,TP,1608 2007-000071 R544 R-CHIP 22ohm,5%,1/16W,DA,TP,1608 2007-000071 R545 R-CHIP 22ohm,5%,1/16W,DA,TP,1608 2007-000071 R548 R-CHIP...
  • Page 29 2007-000074 R212 R-CHIP 100ohm,5%,1/16W,DA,TP,1608 2007-000074 R217 R-CHIP 100ohm,5%,1/16W,DA,TP,1608 2007-000074 R219 R-CHIP 100ohm,5%,1/16W,DA,TP,1608 2007-000074 R234 R-CHIP 100ohm,5%,1/16W,DA,TP,1608 2007-000074 R239 R-CHIP 100ohm,5%,1/16W,DA,TP,1608 2007-000074 R241 R-CHIP 100ohm,5%,1/16W,DA,TP,1608 2007-000074 R245 R-CHIP 100ohm,5%,1/16W,DA,TP,1608 2007-000074 R304 R-CHIP 100ohm,5%,1/16W,DA,TP,1608 2007-000074 R305 R-CHIP 100ohm,5%,1/16W,DA,TP,1608 2007-000074 R306 R-CHIP 100ohm,5%,1/16W,DA,TP,1608 2007-000074 R307 R-CHIP...
  • Page 30 2007-000075 R421 R-CHIP 220ohm,5%,1/16W,DA,TP,1608 2007-000076 R313 R-CHIP 330ohm,5%,1/16W,DA,TP,1608 2007-000076 R318 R-CHIP 330ohm,5%,1/16W,DA,TP,1608 2007-000077 R327 R-CHIP 470ohm,5%,1/16W,DA,TP,1608 2007-000077 R377 R-CHIP 470ohm,5%,1/16W,DA,TP,1608 2007-000077 R812 R-CHIP 470ohm,5%,1/16W,DA,TP,1608 2007-000077 R815 R-CHIP 470ohm,5%,1/16W,DA,TP,1608 2007-000077 R821 R-CHIP 470ohm,5%,1/16W,DA,TP,1608 2007-000077 R822 R-CHIP 470ohm,5%,1/16W,DA,TP,1608 2007-000077 R823 R-CHIP 470ohm,5%,1/16W,DA,TP,1608 2007-000077 R824 R-CHIP...
  • Page 31 2007-000084 R367 R-CHIP 4.7Kohm,5%,1/16W,DA,TP,1608 2007-000084 R400 R-CHIP 4.7Kohm,5%,1/16W,DA,TP,1608 2007-000084 R406 R-CHIP 4.7Kohm,5%,1/16W,DA,TP,1608 2007-000084 R407 R-CHIP 4.7Kohm,5%,1/16W,DA,TP,1608 2007-000084 R408 R-CHIP 4.7Kohm,5%,1/16W,DA,TP,1608 2007-000084 R409 R-CHIP 4.7Kohm,5%,1/16W,DA,TP,1608 2007-000084 R410 R-CHIP 4.7Kohm,5%,1/16W,DA,TP,1608 2007-000084 R411 R-CHIP 4.7Kohm,5%,1/16W,DA,TP,1608 2007-000084 R412 R-CHIP 4.7Kohm,5%,1/16W,DA,TP,1608 2007-000084 R413 R-CHIP 4.7Kohm,5%,1/16W,DA,TP,1608 2007-000084 R425 R-CHIP...
  • Page 32 2007-000090 R504 R-CHIP 10KOHM,5%,1/16W,DA,TP,1608 2007-000090 R506 R-CHIP 10KOHM,5%,1/16W,DA,TP,1608 2007-000090 R507 R-CHIP 10KOHM,5%,1/16W,DA,TP,1608 2007-000090 R600 R-CHIP 10KOHM,5%,1/16W,DA,TP,1608 2007-000090 R601 R-CHIP 10KOHM,5%,1/16W,DA,TP,1608 2007-000090 R603 R-CHIP 10KOHM,5%,1/16W,DA,TP,1608 2007-000090 R605 R-CHIP 10KOHM,5%,1/16W,DA,TP,1608 2007-000090 R606 R-CHIP 10KOHM,5%,1/16W,DA,TP,1608 2007-000090 R704 R-CHIP 10KOHM,5%,1/16W,DA,TP,1608 2007-000090 R706 R-CHIP 10KOHM,5%,1/16W,DA,TP,1608 2007-000090 R707 R-CHIP...
  • Page 33 2007-001167 R126 R-CHIP 75ohm,5%,1/16W,DA,TP,1608 2007-001167 R127 R-CHIP 75ohm,5%,1/16W,DA,TP,1608 2007-001167 R128 R-CHIP 75ohm,5%,1/16W,DA,TP,1608 2007-001167 R223 R-CHIP 75ohm,5%,1/16W,DA,TP,1608 2007-001167 R224 R-CHIP 75ohm,5%,1/16W,DA,TP,1608 2007-001167 R225 R-CHIP 75ohm,5%,1/16W,DA,TP,1608 2007-001167 R310 R-CHIP 75ohm,5%,1/16W,DA,TP,1608 2007-001167 R311 R-CHIP 75ohm,5%,1/16W,DA,TP,1608 2007-001167 R312 R-CHIP 75ohm,5%,1/16W,DA,TP,1608 2007-001167 R321 R-CHIP 75ohm,5%,1/16W,DA,TP,1608 2007-001167 R322 R-CHIP...
  • Page 34 2011-000002 RA502 R-NETWORK 22ohm,5%,63mW,L,CHIP,8P,TP 2011-000002 RA503 R-NETWORK 22ohm,5%,63mW,L,CHIP,8P,TP 2011-000002 RA504 R-NETWORK 22ohm,5%,63mW,L,CHIP,8P,TP 2011-000002 RA600 R-NETWORK 22ohm,5%,63mW,L,CHIP,8P,TP 2011-000002 RA601 R-NETWORK 22ohm,5%,63mW,L,CHIP,8P,TP 2011-000002 RA602 R-NETWORK 22ohm,5%,63mW,L,CHIP,8P,TP 2011-000002 RA603 R-NETWORK 22ohm,5%,63mW,L,CHIP,8P,TP 2011-000002 RA604 R-NETWORK 22ohm,5%,63mW,L,CHIP,8P,TP 2011-000002 RA605 R-NETWORK 22ohm,5%,63mW,L,CHIP,8P,TP 2011-000002 RA606 R-NETWORK 22ohm,5%,63mW,L,CHIP,8P,TP 2011-000002 RA607 R-NETWORK...
  • Page 35 2203-000189 C179 C-CERAMIC,CHIP 100nF,+80-20%,25V,Y5V,TP,1608, 2203-000189 C183 C-CERAMIC,CHIP 100nF,+80-20%,25V,Y5V,TP,1608, 2203-000189 C184 C-CERAMIC,CHIP 100nF,+80-20%,25V,Y5V,TP,1608, 2203-000189 C185 C-CERAMIC,CHIP 100nF,+80-20%,25V,Y5V,TP,1608, 2203-000189 C186 C-CERAMIC,CHIP 100nF,+80-20%,25V,Y5V,TP,1608, 2203-000189 C187 C-CERAMIC,CHIP 100nF,+80-20%,25V,Y5V,TP,1608, 2203-000189 C188 C-CERAMIC,CHIP 100nF,+80-20%,25V,Y5V,TP,1608, 2203-000189 C189 C-CERAMIC,CHIP 100nF,+80-20%,25V,Y5V,TP,1608, 2203-000189 C191 C-CERAMIC,CHIP 100nF,+80-20%,25V,Y5V,TP,1608, 2203-000189 C192 C-CERAMIC,CHIP 100nF,+80-20%,25V,Y5V,TP,1608, 2203-000189 C193 C-CERAMIC,CHIP...
  • Page 36 2203-000189 C285 C-CERAMIC,CHIP 100nF,+80-20%,25V,Y5V,TP,1608, 2203-000189 C286 C-CERAMIC,CHIP 100nF,+80-20%,25V,Y5V,TP,1608, 2203-000189 C287 C-CERAMIC,CHIP 100nF,+80-20%,25V,Y5V,TP,1608, 2203-000189 C288 C-CERAMIC,CHIP 100nF,+80-20%,25V,Y5V,TP,1608, 2203-000189 C289 C-CERAMIC,CHIP 100nF,+80-20%,25V,Y5V,TP,1608, 2203-000189 C290 C-CERAMIC,CHIP 100nF,+80-20%,25V,Y5V,TP,1608, 2203-000189 C291 C-CERAMIC,CHIP 100nF,+80-20%,25V,Y5V,TP,1608, 2203-000189 C292 C-CERAMIC,CHIP 100nF,+80-20%,25V,Y5V,TP,1608, 2203-000189 C293 C-CERAMIC,CHIP 100nF,+80-20%,25V,Y5V,TP,1608, 2203-000189 C294 C-CERAMIC,CHIP 100nF,+80-20%,25V,Y5V,TP,1608, 2203-000189 C295 C-CERAMIC,CHIP...
  • Page 37 2203-000189 C528 C-CERAMIC,CHIP 100nF,+80-20%,25V,Y5V,TP,1608, 2203-000189 C529 C-CERAMIC,CHIP 100nF,+80-20%,25V,Y5V,TP,1608, 2203-000189 C530 C-CERAMIC,CHIP 100nF,+80-20%,25V,Y5V,TP,1608, 2203-000189 C531 C-CERAMIC,CHIP 100nF,+80-20%,25V,Y5V,TP,1608, 2203-000189 C532 C-CERAMIC,CHIP 100nF,+80-20%,25V,Y5V,TP,1608, 2203-000189 C533 C-CERAMIC,CHIP 100nF,+80-20%,25V,Y5V,TP,1608, 2203-000189 C534 C-CERAMIC,CHIP 100nF,+80-20%,25V,Y5V,TP,1608, 2203-000189 C535 C-CERAMIC,CHIP 100nF,+80-20%,25V,Y5V,TP,1608, 2203-000189 C537 C-CERAMIC,CHIP 100nF,+80-20%,25V,Y5V,TP,1608, 2203-000189 C538 C-CERAMIC,CHIP 100nF,+80-20%,25V,Y5V,TP,1608, 2203-000189 C539 C-CERAMIC,CHIP...
  • Page 38 2203-000189 C633 C-CERAMIC,CHIP 100nF,+80-20%,25V,Y5V,TP,1608, 2203-000189 C634 C-CERAMIC,CHIP 100nF,+80-20%,25V,Y5V,TP,1608, 2203-000189 C635 C-CERAMIC,CHIP 100nF,+80-20%,25V,Y5V,TP,1608, 2203-000189 C636 C-CERAMIC,CHIP 100nF,+80-20%,25V,Y5V,TP,1608, 2203-000189 C637 C-CERAMIC,CHIP 100nF,+80-20%,25V,Y5V,TP,1608, 2203-000189 C638 C-CERAMIC,CHIP 100nF,+80-20%,25V,Y5V,TP,1608, 2203-000189 C641 C-CERAMIC,CHIP 100nF,+80-20%,25V,Y5V,TP,1608, 2203-000189 C642 C-CERAMIC,CHIP 100nF,+80-20%,25V,Y5V,TP,1608, 2203-000189 C643 C-CERAMIC,CHIP 100nF,+80-20%,25V,Y5V,TP,1608, 2203-000189 C647 C-CERAMIC,CHIP 100nF,+80-20%,25V,Y5V,TP,1608, 2203-000189 C648 C-CERAMIC,CHIP...
  • Page 39 2203-000189 C826 C-CERAMIC,CHIP 100nF,+80-20%,25V,Y5V,TP,1608, 2203-000189 C828 C-CERAMIC,CHIP 100nF,+80-20%,25V,Y5V,TP,1608, 2203-000189 C833 C-CERAMIC,CHIP 100nF,+80-20%,25V,Y5V,TP,1608, 2203-000189 C842 C-CERAMIC,CHIP 100nF,+80-20%,25V,Y5V,TP,1608, 2203-000189 C844 C-CERAMIC,CHIP 100nF,+80-20%,25V,Y5V,TP,1608, 2203-000189 C920 C-CERAMIC,CHIP 100nF,+80-20%,25V,Y5V,TP,1608, 2203-000189 C921 C-CERAMIC,CHIP 100nF,+80-20%,25V,Y5V,TP,1608, 2203-000189 C922 C-CERAMIC,CHIP 100nF,+80-20%,25V,Y5V,TP,1608, 2203-000189 C923 C-CERAMIC,CHIP 100nF,+80-20%,25V,Y5V,TP,1608, 2203-000236 C254 C-CERAMIC,CHIP 0.1nF,5%,50V,NP0,TP,1608 2203-000236 C310 C-CERAMIC,CHIP...
  • Page 40 2203-000440 C339 C-CERAMIC,CHIP 1nF,10%,50V,X7R,TP,1608,- 2203-000440 C340 C-CERAMIC,CHIP 1nF,10%,50V,X7R,TP,1608,- 2203-000440 C500 C-CERAMIC,CHIP 1nF,10%,50V,X7R,TP,1608,- 2203-000440 C501 C-CERAMIC,CHIP 1nF,10%,50V,X7R,TP,1608,- 2203-000440 C502 C-CERAMIC,CHIP 1nF,10%,50V,X7R,TP,1608,- 2203-000440 C503 C-CERAMIC,CHIP 1nF,10%,50V,X7R,TP,1608,- 2203-000440 C504 C-CERAMIC,CHIP 1nF,10%,50V,X7R,TP,1608,- 2203-000440 C505 C-CERAMIC,CHIP 1nF,10%,50V,X7R,TP,1608,- 2203-000440 C506 C-CERAMIC,CHIP 1nF,10%,50V,X7R,TP,1608,- 2203-000440 C507 C-CERAMIC,CHIP 1nF,10%,50V,X7R,TP,1608,- 2203-000440 C508 C-CERAMIC,CHIP...
  • Page 41 2203-000903 C240 C-CERAMIC,CHIP 0.0047nF,0.25pF,50V,NP0,TP,1608 2203-000903 C241 C-CERAMIC,CHIP 0.0047nF,0.25pF,50V,NP0,TP,1608 2203-000903 C242 C-CERAMIC,CHIP 0.0047nF,0.25pF,50V,NP0,TP,1608 2203-000903 C265 C-CERAMIC,CHIP 0.0047nF,0.25pF,50V,NP0,TP,1608 2203-000903 C266 C-CERAMIC,CHIP 0.0047nF,0.25pF,50V,NP0,TP,1608 2203-000903 C267 C-CERAMIC,CHIP 0.0047nF,0.25pF,50V,NP0,TP,1608 2203-000903 C313 C-CERAMIC,CHIP 0.0047nF,0.25pF,50V,NP0,TP,1608 2203-000903 C314 C-CERAMIC,CHIP 0.0047nF,0.25pF,50V,NP0,TP,1608 2203-000972 C152 C-CERAMIC,CHIP 47nF,10%,16V,X7R,TP,1608 2203-000972 C237 C-CERAMIC,CHIP 47nF,10%,16V,X7R,TP,1608 2203-000972 C238 C-CERAMIC,CHIP...
  • Page 42 2203-005005 C147 C-CERAMIC,CHIP 100nF,10%,16V,X7R,TP,1608 2203-005005 C180 C-CERAMIC,CHIP 100nF,10%,16V,X7R,TP,1608 2203-005065 C246 C-CERAMIC,CHIP 1000nF,+80-20%,10V,Y5V,TP,1608 2203-005065 C253 C-CERAMIC,CHIP 1000nF,+80-20%,10V,Y5V,TP,1608 2203-005065 C255 C-CERAMIC,CHIP 1000nF,+80-20%,10V,Y5V,TP,1608 2203-005065 C303 C-CERAMIC,CHIP 1000nF,+80-20%,10V,Y5V,TP,1608 2203-005065 C304 C-CERAMIC,CHIP 1000nF,+80-20%,10V,Y5V,TP,1608 2203-005065 C571 C-CERAMIC,CHIP 1000nF,+80-20%,10V,Y5V,TP,1608 2203-005065 C572 C-CERAMIC,CHIP 1000nF,+80-20%,10V,Y5V,TP,1608 2203-005065 C573 C-CERAMIC,CHIP 1000nF,+80-20%,10V,Y5V,TP,1608 2203-005065 C574 C-CERAMIC,CHIP...
  • Page 43 2402-000176 C150 C-AL,SMD 10uF,20%,16V,GP,TP,4.3x4.3x5.4 2402-000176 C151 C-AL,SMD 10uF,20%,16V,GP,TP,4.3x4.3x5.4 2402-000176 C309 C-AL,SMD 10uF,20%,16V,GP,TP,4.3x4.3x5.4 2402-000176 C322 C-AL,SMD 10uF,20%,16V,GP,TP,4.3x4.3x5.4 2402-000176 C336 C-AL,SMD 10uF,20%,16V,GP,TP,4.3x4.3x5.4 2402-000176 C354 C-AL,SMD 10uF,20%,16V,GP,TP,4.3x4.3x5.4 2402-000176 C358 C-AL,SMD 10uF,20%,16V,GP,TP,4.3x4.3x5.4 2402-000176 C375 C-AL,SMD 10uF,20%,16V,GP,TP,4.3x4.3x5.4 2402-000209 C197 C-AL,SMD 22uF,20%,16V,WT,TP,5.3x5.3mm,1 2402-000209 C522 C-AL,SMD 22uF,20%,16V,WT,TP,5.3x5.3mm,1 2402-000209 C523 C-AL,SMD...
  • Page 44 2409-001035 C274 C-ORGANIC 10uF,20%,10V,LZ,TP,5.4x4.3x4.3mm,1 2409-001035 C566 C-ORGANIC 10uF,20%,10V,LZ,TP,5.4x4.3x4.3mm,1 2409-001035 C640 C-ORGANIC 10uF,20%,10V,LZ,TP,5.4x4.3x4.3mm,1 2409-001035 C815 C-ORGANIC 10uF,20%,10V,LZ,TP,5.4x4.3x4.3mm,1 2409-001035 C823 C-ORGANIC 10uF,20%,10V,LZ,TP,5.4x4.3x4.3mm,1 2409-001035 C824 C-ORGANIC 10uF,20%,10V,LZ,TP,5.4x4.3x4.3mm,1 2409-001035 C831 C-ORGANIC 10uF,20%,10V,LZ,TP,5.4x4.3x4.3mm,1 2503-001018 CA200 C-NETWORK 15PFX4,10%,50V,- 2503-001018 CA201 C-NETWORK 15PFX4,10%,50V,- 2503-001018 CA202 C-NETWORK 15PFX4,10%,50V,- 2503-001018 CA203 C-NETWORK...
  • Page 45 2703-001778 L104 INDUCTOR-SMD 3.3UH,20%,3.2X2.5X2.2MM 2703-001778 L107 INDUCTOR-SMD 3.3UH,20%,3.2X2.5X2.2MM 2703-001778 L108 INDUCTOR-SMD 3.3UH,20%,3.2X2.5X2.2MM 2703-001778 L400 INDUCTOR-SMD 3.3UH,20%,3.2X2.5X2.2MM 2801-003667 X400 CRYSTAL-SMD 14.3182MHZ,50PPM,28-AAN,16,50OHM,TP 2801-003773 X302 CRYSTAL-SMD 12MHZ,30PPM,28-AAN,20PF,50OHM,TP 2801-003843 X101 CRYSTAL-SMD 18.432MHz,30ppm,28-AAN,20pF,50ohm,TP 2801-004004 X301 CRYSTAL-SMD 20.25MHz,20ppm,28-AAN,13pF,25ohm,TP 2901-001114 FT102 FILTER-EMI SMD 25VDC,2.0ADC,-,100nF,3.2x1.6x1 2901-001114 FT103 FILTER-EMI SMD 25VDC,2.0ADC,-,100nF,3.2x1.6x1 2901-001114 FT104...
  • Page 46 2901-001114 FT700 FILTER-EMI SMD 25VDC,2.0ADC,-,100nF,3.2x1.6x1 2901-001114 FT701 FILTER-EMI SMD 25VDC,2.0ADC,-,100nF,3.2x1.6x1 2901-001114 FT702 FILTER-EMI SMD 25VDC,2.0ADC,-,100nF,3.2x1.6x1 2901-001114 FT703 FILTER-EMI SMD 25VDC,2.0ADC,-,100nF,3.2x1.6x1 2901-001114 FT815 FILTER-EMI SMD 25VDC,2.0ADC,-,100nF,3.2x1.6x1 3301-001145 FT101 CORE-FERRITE BEAD AB,4.5x1.6x1.6mm,-,- 3301-001145 FT800 CORE-FERRITE BEAD AB,4.5x1.6x1.6mm,-,- 3301-001145 FT801 CORE-FERRITE BEAD AB,4.5x1.6x1.6mm,-,- 3301-001145 FT802 CORE-FERRITE BEAD...
  • Page 47 CBF SIGNAL -,2000MM,-,-,UL2851#28,- BH39-10339H CBF POWER CORD DET,H05VV-F,250V/10,16A,BLK,25 BH69-30348D BAG-PE LDPE,T0.05,W240*L356,Y,-,CMG73 BN39-00115A CBF SIGNAL NL5MO,15P/15P,2990,1830MM,UL2990,BLACK,D-SUB/MALE,-,-,- BN59-00228A REMOCON -,TM71,RUBENS,37,GR20,BLUE,PAL,-,-,-,- BN68-00169E MANUAL USERS LW24R15W,SAMSUNG,E/F/G/NE/IT/SP/P,EDC,MIMOJO80G BN69-00054B BOX-ACCESSORY PC24PB,CB SW-1,YEL,KSD-21,45,300,230,-,- BN80-00001A WRENCH RU24AS,SCM,M8,5,WHT,L80 BN92-00619K ASSY LABEL LW24R15WX/XEC AA68-50502A LABEL-CONFORMATION W/P100(G),CTV,ITALY,170x110,BL BN68-00241B LABEL RATING RU24AS,EDC,PE,T0.05,65,79,-,-,PE NATURE,-,-...

  • Page 48: Block Diagram

    CONFIDENTIAL 8 Block Diagram RS21A*/RS24A*...
  • Page 49 CONFIDENTIAL 8 Block Diagrams Memo RS21A*/RS24A*...

  • Page 50: Wiring Diagram

    CONFIDENTIAL 9 Wiring Diagram CN702 CN102 LINE_OUT SROUT SROUT CN103 CN700 SCL4 SCR4 LINE_L LINE_R LINE-OUT CN301 VID_DATA VOLO+ VOL- QSS_IF CHK_TVNER EXIT +5V_TVNER MENU BUZZER VID_SCLK AUTO +33V_T +5V_TUNER SOURCE RF_CVBS CN302 CN800 CN101 RS21A*/RS24A*...
  • Page 51 CONFIDENTIAL 9 Schematic Diagrams Memo RS21A*/RS24A*...

  • Page 52: Schematic Diagrams

    CONFIDENTIAL 10 Schematic Diagrams 10-1 RUBENS_PAL_Top Parts Schematic Diagram RS21A*/RS24A* 10-1...
  • Page 53 CONFIDENTIAL 10 Schematic Diagrams 10-2 RUBENS_PAL_Micom Parts Schematic Diagram +5V_M Configuration Data +3.3V_A +5V_M +5V_M +5V_M +5V_M +5V_M +5V_M AUDIO +3.3V_A +5V_M +5V_M +3.3V_A +3.3V_A +5V_M +5V_M +3.3V_A +5V_M +3.3V_A 10-2 RS21A*/RS24A*...
  • Page 54 CONFIDENTIAL 10 Schematic Diagrams RS21A*/RS24A* 10-3...
  • Page 55 CONFIDENTIAL 10 Schematic Diagrams 10-3 RUBENS_PAL_ADC Parts Schematic Diagram +3.3V_P1 +3.3V_ADC1 +3.3V_ADC1 +3.3V_AD1 +3.3V_P1 +5V_ADC +5V_ADC +5V_IN +5V_IN +5V_IN +3.3V_B +3.3V_AD1 VSYNCB +3.3V_P1 +3.3V_ADC1 +3.3V_P1 +3.3V_SYNC PAR(0:7) MC_DATA PAG(0:7) MC_SCLK HSYNC_PLL VSYNC_SS +3.3V_ADC1 OECH2 PAB(0:7) RED_IN GREEN_IN BLUE_IN ADCCLK1 +5V_SYNC +3.3V_B +3.3V_AD2 +3.3V_P2...
  • Page 56 CONFIDENTIAL 10 Schematic Diagrams RS21A*/RS24A* 10-5...
  • Page 57 CONFIDENTIAL 10 Schematic Diagrams 10-4 RUBENS_PAL_Video Parts Schematic Diagram +3.3V_LVDS +5V_M +5V_TUNER +5V_M +3.3V_LVDS +5V_DEC VID_ONB MC_SCLK MC_DATA +3.3V_LVDS +5V_DEC +5V_DEC1 +5V_DEC1 +5V_DEC1 +3.3V_LVDS +3.3V_TTX +3.3V_TTX +5V_TUNER +3.3V_LVDS +3.3V_TTX +3.3V_TTX +5V_DEC +5V_TUNER TTX_SW 10-6 RS21A*/RS24A*...
  • Page 58 CONFIDENTIAL 10 Schematic Diagrams RS21A*/RS24A* 10-7...
  • Page 59 CONFIDENTIAL 10 Schematic Diagrams 10-5 RUBENS_PAL_Audio Parts Schematic Diagram +14V_MAIN +5V_DEC MSP_INT 10-8 RS21A*/RS24A*...
  • Page 60 CONFIDENTIAL 10 Schematic Diagrams RS21A*/RS24A* 10-9...
  • Page 61 CONFIDENTIAL 10 Schematic Diagrams 10-6 RUBENS_PAL_J200_PC Part Schematic Diagram +3.3V_B +3.3V_B +2.5V_PC FT500 FT501 SGM32F1E104-2A SGM32F1E104-2A FT502 SGM32F1E104-2A PC_2.5V C522 22uF 22uF,20%,16V,WT,TP,5.3x5.3mm,1 C-AL,SMD C500 C501 C502 C503 C504 C505 C506 C507 C508 C509 C510 C511 C512 C513 C514 C515 C516 C517 C518 C519...
  • Page 62 CONFIDENTIAL 10 Schematic Diagrams RS21A*/RS24A* 10-11...
  • Page 63 CONFIDENTIAL 10 Schematic Diagrams 10-7 RUBENS_PAL_V_Backend Parts Schematic Diagram +A2.5V_FLI 10-12 RS21A*/RS24A*...
  • Page 64 CONFIDENTIAL 10 Schematic Diagrams RS21A*/RS24A* 10-13...
  • Page 65 CONFIDENTIAL 10 Schematic Diagrams 10-8 RUBENS_PAL_J200_VID Parts Schematic Diagram +2.5V_VID +3.3V_A FT601 FT600 SGM32F1E104-2A SGM32F1E104-2A VID_2.5V C622 C639 22uF 22uF C600 C601 C602 C603 C604 C605 C606 C607 C608 C609 C610 C611 C612 C613 C614 C615 C616 C617 C618 C619 C620 C621 C623...
  • Page 66 CONFIDENTIAL 10 Schematic Diagrams RS21A*/RS24A* 10-15...
  • Page 67 CONFIDENTIAL 10 Schematic Diagrams 10-9 RUBENS_PAL_LVDS Parts Schematic Diagram +5V_P +3.3V_LVDS +5V_P +3.3V_LVDS MC_DATA MC_SCLK BL_EN +3.3V_LVDS +14V_INV +3.3V_LVDS +5V_PNL 10-16 RS21A*/RS24A*...
  • Page 68 CONFIDENTIAL 10 Schematic Diagrams 10-10 RUBENS_PAL_POWER Parts Schematic Diagram +3.3V_B +3.3V_LVDS +5V_P +5V_P +3.3V_A +2.5V_VID +A2.5V_VID +5V_IN +2.5V_PC +A2.5V_PC +2.5V_FLI +A2.5V_FLI +5V_IN +5V_P +3.3V_SYNC +5V_SYNC +5V_SYNC +5V_DEC +5V_DEC1 +5V_TUNER +5V_ADC +5V_P RS21A*/RS24A* 10-17...
  • Page 69 CONFIDENTIAL 10 Schematic Diagrams 10-18 RS21A*/RS24A*...
  • Page 70 Samsung Electronics Co.,Ltd. 416, Maetan-3Dong, Paldal-Gu, Suwon City, Kyungki-Do, Korea. Printed in Korea P/N : BN81-00022C-00 http://www.samsungmonitor.com (SyncMaster Worldwide) http://www.samsung-monitor.com (SyncMaster USA) http://www.sec.co.kr/monitor (Korea)

This manual is also suitable for:

Rs24a series

Table of Contents