Eastman Outdoors 37211 Instruction And Safety Manual

Hide thumbs

Table Of Contents

Table of Contents

Quick Links

If you smell gas:

1. Shut off gas to the appliance.

2. Extinguish any open flame.

3. If odor continues, keep away from the

appliance and immediately call your fire

department.

Failure to follow these instructions could

result in fire or explosion which could cause

property damage, personal injury or death.

1. Never operate this appliance unattended.

2. Never operate this appliance within 10 ft

(3 m) of any structure, combustible

material or other gas cylinder.

3. Never operate this appliance within 25 ft

(7.5m) of any flammable liquid.

4. Do not fill cooking vessel beyond

maximum fill line.

5. Never allow oil or grease to get hotter

than 400ºF or 200ºC. If the temperature

exceeds 400ºF (200ºC) or if oil begins to

smoke, immediately turn the burner or gas

supply OFF.

6. Heated liquids remain at scalding

temperatures long after the cooking

process. Never touch cooking appliance

until liquids have cooled to 115ºF (45ºC) or

less.

7. If a fire should occur, keep away from the

appliance and immediately call your fire

department. Do not attempt to extinguish

an oil or grease fire with water.

Failure to follow these instructions could

result in fire, explosion or burn hazard,

which could cause property damage,

personal injury or death.

OUTDOOR USE ONLY / NEVER LEAVE UNATTENDED

DANGER

Outdoor Gourmet Cooking Set

Instruction and Safety Manual

WARNING AND SAFETY

INFORMATION; ASSEMBLY AND

OPERATING INSTRUCTIONS;

MAINTENANCE & COOKING

INSTRUCTIONS FOR:

Outdoor Gourmet

Baby Kahuna Burner with Adjustable &

Removable Legs Model 90315

Portable Kahuna™ XL Burner

For a Safe Cooking Experience,

Follow All Instructions and Safety

Warnings in this Instruction

Manual

This Instruction Manual contains

important information necessary for the

proper assembly and safe use of the

appliance.

Read and Follow all Warnings and

Instructions before assembling and

using the appliance.

Follow all warnings and instructions

when using the appliance.

KEEP THIS MANUAL FOR FUTURE

REFERENCE. The installer must leave the

instructions with the consumer.

Approximate assembly time is 10 minutes.

18" Carbon Steel

Wok Kit Model 37503

18" Carbon Steel

Wok Kit Model 37211

Model 90411

Page 1 of 18

Table of Contents

Summary of Contents for Eastman Outdoors 37211

Page 1 Outdoor Gourmet 18” Carbon Steel Wok Kit Model 37211 Failure to follow these instructions could result in fire or explosion which could cause Baby Kahuna Burner with Adjustable & property damage, personal injury or death.
Page 2: Warnings
LP gas connections for leaks. Do NOT use the appliance if there is a leak. Contact Eastman Outdoors at 1-800-241-4833 on how to obtain and replace the parts.
Page 3: Table Of Contents
Do not tamper with or attempt repairs on the burner body, frame, valves, regulator hose assembly, or LP • tank. Repair should be done by a qualified service person. Please contact Eastman Outdoors at 1-800-241- 4833 for assistance. Do NOT loosen or disconnect any gas fitting while the appliance is in use.
Page 4: Burner Parts Diagram
Step 1 ASSEMBLY Burner Parts Diagram QTY PARTS LIST 1. Burner Body 2. Legs 3. Burner Element 4. Burner Grate 5. Burner Orifice/Regulator Hose Assembly 6. Burner Housing Bolt 7. Air Shutter 8. Shutter Spring 9. Short Square Bolts 10.Flat Washer 11.
Page 5: Regulator Hose Assembly
The high pressure regulator and hose assembly supplied must be • used. Replacement high pressure regulators assemblies must be those specified by Eastman Outdoors. One adjustable wrench is needed when attaching the hose to the appliance. OUTDOOR USE ONLY / NEVER LEAVE UNATTENDED...
Page 6: Leg Adjustment
Place the shutter spring (8) onto burner orifice/regulator hose assembly (5) by sliding the small end of the shutter spring onto the burner orifice/regulator hose assembly (figure 7). Fig. 7 Set the air shutter (#7) onto the burner element (#3) by placing it on the casting (figure 8).
Page 7: Connecting The Lp Gas Tank
with Acme/Type 1/QCC1 Safety Valves). These can be quickly identified because the valves have external threads. LP gas is flammable, explosive under pressure, colorless, tasteless and heavier than air. It pools in low areas. LP gas is naturally odorless, but a distinctive odor has been added by the LP gas supplier for your protection. LP gas can cause skin to freeze on contact.
Page 8: Leak Testing
LP tank by turning LP valve clockwise. The regulator control valve is faulty, do not use and call Eastman Outdoors Customer Service Department at 1-800-241-4833 for replacement. If no gas passes through the regulator control valve, proceed to next step.
Page 9: Maintenance Before Every Use
Immediately turn off both the LP tank valve and regulator control valve. Tighten the connections and repeat test. If the leak cannot be stopped, contact Eastman Outdoors Customer Service Department at 1-800-241-4833. DO NOT USE THE BURNER.
Page 10: Lighting
Close regulator control valve by turning valve clockwise until tight. Start propane gas flow from LP tank by slowly turning the LP valve two complete turns counter-clockwise. Place a lit match (Eastman Outdoors strongly recommends using a long-stem match or lighter) under the burner up through the hole in the center of the burner element (figure 27).
Page 11: Shut Off
resets the safety valve in the LP tank if the valves are opened too quickly. Repeat the lighting procedure making sure to open both valves slowly. When burner is lit, turn regulator control valve to regulate flame intensity. Turn valve counter- clockwise to increase flame.
Page 12: Lighting And Placing Cooking Vessel On Burner
Before each use, place tip of the thermometer into a pot of boiling water to check that it registers approximately 212ºF +/- 20ºF (100ºC +/- 10ºC). If it does not function properly, contact Eastman Outdoors at 1-800-241-4833 to obtain a replacement thermometer before using the appliance. Do not fry without a thermometer or with a faulty thermometer.
Page 13: Cooking Food
As food is slowly lowered into hot cooking oil, oil will begin to boil which can cause splattering. Wear cooking gloves/mitts, eye protection, shoes, and long sleeved shirt when inserting or removing food from cooking vessel. Always turn burner off when removing food from cooking vessel. Once cooking oil/grease/water reaches cooking temperature, slowly and gently partially insert the completely thawed and towel dried food into the cooking vessel, and then remove it from oil/grease.
Page 14: Leg Removal
Place dust cap on cylinder valve outlet whenever the cylinder is not in use. Only install the type of dust cap on the cylinder valve outlet that is provided with the cylinder valve. Other types of caps or plugs may result in leakage of propane. LP tank must be stored in an upright position outdoors, out of the reach of children and must not be stored in a building, garage, or any other enclosed area.
Page 15: Fish/Hot Pot Assembly Instructions
Burner does not ignite in 3 to 5 seconds or burner ignites and has a low flame intensity? Turn regulator control valve off and turn LP tank valve off. Check to make sure the LP tank is not empty. Wait five minutes for gas fumes to dissipate. Do not attempt to re-light if you smell gas. Disconnect the QCC1 fitting and reconnect it to LP tank.
Page 16: Frying Fish Of Chicken Wings
Wok and food are extremely hot! Step 9 Frying Fish or Chicken Wings Eastman Outdoors Fish-Fry/Hot pot and Eastman Outdoors Burner can fry up to 2 pounds of fish or chicken wings at one time.
Page 17: Warranty Information
MERCHANTABILITY AND FITNESS FOR A PARTICULAR PURPOSE, SHALL APPLY TO THE PRODUCT. Eastman Outdoors shall not in any event be liable for any incidental or consequential damages, either in the breach of this warranty or any other reason, resulting from the use of this...
Page 18: Outdoor Use Only / Never Leave Unattended
Eastman Outdoors will not be held liable for any losses due to negligent operation on the part of the user. Eastman Outdoors will not be obligated to repair or replace equipment that has been altered or used other than in accordance with the manufacturer’s operating instructions.

This manual is also suitable for:

37503 90315 90411 37225 37212 37502 ... Show all