Table of Contents
Advertisement
WARNING
Improper installation, adjustment, alteration,
service or maintenance can cause property
damage, injury or death, and could cause
exposure to substances which have been
determined by various state agencies to cause
cancer, birth defects or other reproductive
harm. Read the installation, operating and
maintenance instructions thoroughly before
installing or servicing this equipment.
IMPORTANT
The use of this manual is specifically intended
for a qualified installation and service agency.
A qualified installation and service agency must
perform all installation and service of these
appliances.
PLEASE BE SURE TO LEAVE IT WITH THE OWNER WHEN YOU LEAVE THE JOB.
INSTALLATION AND SERVICE MANUAL
THIS MANUAL IS THE PROPERTY OF THE OWNER.
electric unit heaters
FOR YOUR SAFETY
The use and storage of gasoline or other
flammable vapors and liquids in open containers
in the vicinity of this appliance is hazardous.
Inspection on Arrival
1. Inspect unit upon arrival. In case of damage, report it
immediately to transportation company and your local
Modine sales representative.
2. Check rating plate on unit to verify that power supply and
motor specification requirements meets available electric
power at the point of installation.
3. Inspect unit upon arrival for conformance with description of
product ordered (including specifications where applicable).
General Information
Installation and wiring of these electric unit heaters must
conform to all applicable local codes and the National Electric
Code. Wiring of these electric unit heaters should only be
performed by a qualified electrician.
Table of Contents
General Information ................................................................... 1
Special Precautions / Important Information.............................. 2
SI (Metric) Conversion Factors ................................................. 2
Unit Location ............................................................................. 3
Unit Mounting ............................................................................ 3
Installation ................................................................................. 4
Electrical Connections .......................................................... 4
Operation ................................................................................... 5
Operating Sequence ............................................................. 5
Dimensional Data ..................................................................... .6
Performance Data ..................................................................... 6
Motor Specifications .................................................................. 6
General Maintenance & Troubleshooting. ................................. 7
Warranty .....................................................................Back Page
2-525.3
5H75690
January, 2013
model HER
Advertisement
Table of Contents
Related Manuals for Modine Manufacturing HER
Summary of Contents for Modine Manufacturing HER
- Page 1 2-525.3 5H75690 January, 2013 INSTALLATION AND SERVICE MANUAL electric unit heaters model HER FOR YOUR SAFETY The use and storage of gasoline or other flammable vapors and liquids in open containers in the vicinity of this appliance is hazardous. Inspection on Arrival 1.
-
Page 2: Si (Metric) Conversion Factors
"W.C. factory-approved service replacement parts. A complete replacement parts list may be obtained by contacting Modine Manufacturing Company. Refer to the rating plate on the appliance for complete appliance model number, serial number, and company address. Any substitution of parts or controls not approved by the factory will be at the owner's risk. -
Page 3: Unit Location
2. Do not install appliance outdoors. Wall-Mounting Bracket For easier installation of Model HER electric unit heaters, where In locating units, consider general space-heating requirements ceiling suspension is not feasible, a wall-mounting bracket kit is of the area. Unit heaters should be located so they discharge available. -
Page 4: Installation
INSTALLATION Electrical Connections 4. Make sure all multi-voltage components (motors, transformers, etc.) are wired in accordance with the power supply voltage. WARNING 5. The power supply to the unit must be protected with a fused or circuit breaker switch. 6. The power supply must be within 5% of the voltage rating and 1. -
Page 5: Operation
OPERATION Initial Start-Up Figure 5.1 - Exposed Side of Electric Unit Heater 1. Set thermostat above room temperature. 2. Turn on power to the unit. 3. Adjust the air deflector blades for desired heat distribution. All horizontal blades should be kept open a minimum of 45° as measured from vertical. -
Page 6: Performance Data
DIMENSIONAL / PERFORMANCE DATA Figure 6.1 - Dimensions (inches) Table 6.1 - Outline Dimensions (inches) Model Size (2) MOUNTING HOLES Dimension 50 - 75 100 - 150 200 - 250 MINUMUM CLEARANCES, 3/8"-16 N.C. TAP 12" TO SIDES AND TOP, 16-7/8 16-7/8 18-7/8... -
Page 7: General Maintenance & Troubleshooting
Such component must be replaced. replacement parts list may be obtained by contacting Modine Manufacturing Company. Refer to the rating plate NOTE: To check most of the Possible Remedies in the on the unit for complete unit substitution of parts or controls trouble-shooting guide listed in Table 7.1, refer to the... - Page 8 Burners High Intensity Infrared Units Sheet Metal Parts All Products As Modine Manufacturing Company has a continuous product improvement program, it reserves the right to change design and specifications without notice. Commercial Products Group Modine Manufacturing Company 1500 DeKoven Avenue Racine, WI 53403 Phone: 1.800.828.4328 (HEAT)
Need help?
Do you have a question about the HER and is the answer not in the manual?
Questions and answers