Intellihot i201X Operation Manual
  1. Manuals
  2. Brands
  3. Intellihot Manuals
  4. Boiler
  5. Combi i201X*
  6. Operation manual

Intellihot i201X Operation Manual

Hide thumbs Also See for i201X:
Table of Contents

Advertisement

Quick Links

See also: Troubleshooting Manual , Technical Manual
Smart. Efficient. Endless
Operation
Manual
Model: i201X
i251X
Intellihot Direct Vent Boiler/ Combination Water
heater. This product complies with ANSI Z21.13-
(2010) / CSA 4.9 Low Pressure Boiler and with
ANSIZ21.10.3 (2011) / CSA 4.3 Gas Water Heater. For
use as potable water heating and space heating.
WARNING
If the information in these instructions is not followed
exactly, a fire or explosion could result causing
property damage, personal injury, or death.
— Do not store or use gasoline or other flammable
vapors and liquids in the vicinity of this or any
other appliance.
WHAT TO DO IF YOU SMELL GAS
Do not try to light any appliance.
•
Do not touch any electrical switch; do not use
•
any phone in your building.
Immediately call your gas supplier from a
•
neighbor's phone. Follow the gas supplier's
instructions.
If you cannot reach your gas supplier, call the
•
fire department.
— Installation and service must be performed by
a qualified installer, service agency, or the gas
supplier.
Certified to
NSF/ANSI 372
AVERTISSEMENT
Assurez-vous de bien suivre les instructions données
dans cette notice pour réduire au minimum le
risque d'incendie ou d'explosion ou pour éviter tout
dommage matériel, toute blessure ou la mort.
— Ne pas entreposer ni utiliser d'essence ou
ni d'autres vapeurs ou liquides inflammables
à proximité de cet appareil ou de tout autre
appareil.
QUE FAIRE SI VOUS SENTEZ UNE ODEUR DE GAZ
•
Ne pas tenter d'allumer d'appareil.
•
Ne touchez à aucun interrupteur; ne pas vous
servir
des
téléphones
se
le bâtiment.
Appelez immédiatement votre fournisseur de gaz
•
depuis un voisin. Suivez les instructions
du fournisseur.
Si vous ne pouvez rejoindre le fournisseur,
•
appelez le service des incendies.
— L'installation et l'entretien doivent être assurés
par un installateur ou un service d'entretien
qualifié ou par le fournisseur de gaz.
To avoid product damage, personal injury, or
even possible death, carefully read, understand,
and follow all the instructions in the Installation
and Operation manuals before installing this
product. Improper installation, adjustment, alteration, or
maintenance can cause injury, loss of life, and/or property
damage. This water heater should be installed and
serviced by a qualified technician. The lack of proper
service can result in a dangerous condition.
trouvant
dans
This manual contains safety information, installation
instructions, and maintenance procedures. It must be left
with the homeowner or placed near the water heater in
a noncombustible place. The customer should retain this
manual for future reference.
if
o x
k B
d t
o
n e
p a
e c
t e
ro
e r
a s
z p
C h
g a
)
n v
e G
te
i a
u
e c
C o
a n
e rt
d ir
o p
n v
ti o
n
P r
c o
s i
la
s e
n ti
c a
v e
la
à
t o
e r
n é
c h
n ta
*
C o
o n
s ta
)
s i
n e
in
p a
q u
e
e r
n v
p ro
a ti
g a
z
m
C o
s
to
G a
a u
a u
c e
d
a u
e l
e
r p
la
e -e
F i
a n
s u
u ff
o p
n *
h a
P r
io
S
v e
rs
(C
T )
H
e r
E N
o n
a t
(C
0 0
I T
G A
E M
P a
)
U L
W
H e
e t
9 ,0
2 k
S E
1 9
E
e r
U R
e s
l)
0
U S
P r
re
,0 0
2 .6
)
a t
É R
IE
n a
tu
. (
P a
z
2 0
R
E C
N T
y
a s
g a
6 k
F O
A V
L
W
L 'I
o r
u r
.C
s
À
c t
l G
p o
W
P a
)
N
N
0 .7
E T
A T
IO
o u
T IO
r a
in
e
.5
. (
4 k
R A
F a
u s
1 0
IS
n e
L A
t u
e n
.C
E S
U T
IL
A L
N a
2 .7
t a
S T
g e
W
. (
P R
U R
la
P O
a n
IN
é g
3 .0
)
R
.
(R
.C
P a
Y
E
s t
O U
. .
0 0
)
W
4 k
T U
S IN
(P
P a
O R
D 'U
I n
L Y
9 ,0
.0
. .
0 k
1 1
0 3
C T
G E
S
i c
O N
1 9
( 1
)
a t
0
3 .2
P a
L A
. .
.
,0 0
)
s i
F A
É G
N
. (
P a
0 p
3 k
)
N A
É R
o m
T IO
. .
. .
2 0
.C
0 k
1 5
1 0
P H
P R
u t
L A
i (
3 L
L
. .
u m
.
W
2 .0
)
R E
t A
A L
. .
.0
P a
p s
. .
1 3
. (
0 0
T U
S T
p s
im
0 k
1 5
( 1
N A
e n
a x
.C
m
. .
u m
. .
W
2 .0
P H
Z
- V
IN
5 A
r M
. (
.9 4
G A
O R
: .
im
. .
8 .0
)
c t
z ,
/h
P a
5 G
/ 0
D O
t u
in
.C
r e
0 H
a z)
r M
. .
. .
W
4 k
2 6
)
D i
e g
: B
9 8
%
.9 4
m
IN
, 6
. .
8 .0
0 3
/ 0
p p
e d
t)
u /h
. .
n
R
o lt
y p
e n
B t
( 1
)
t o
9 8
%
2 0
ti o
F O
e m
. .
. .
. .
s i
P a
U p
e ra
.
0 V
s
(T
s s
'à
a n
O p
re
e t
G a
. .
) :
0 p
3 k
)
q u
)
d u
n
d e
1 2
C la
. .
P H
u s
t h
p m
d
c e
ti o
o f
le
t s
1 5
1 0
(J
0 p
a n
ll a
d u
re
e r
e :
. .
e n
i (
3 L
s s
e 2
n
p ro
c é
p e
n tr
L e
ti o
n
s ta
u r
m
.
p s
0 0
s d
ll a
io
'i n
p ro
T y
g
(E
s s
. .
s t
. .
s ta
v e
rs
l d
1 5
( 1
o in
u e
r la
a t
in
r e
e :
d ju
. .
(M
In
o n
a n
o u
)
P H
.9 4
r to
r c
m
t p
t R
s P
u m
u r
r a
))
.
e fe
l fo
u
e n
ts
. .
. .
5 G
/ 0
u a
r a
p u
G a
a x
im
s s
f o
e n
*R
re
e m
r e
e (
m
. .
2 6
)
a n
fé
n n
In
le t
e m
)
s te
. .
%
.9 4
m
m
e ré
ti o
iv é
s P
u m
u r
9 8
/ 0
p p
n c
n .)
s s
r a
ju
. .
. .
. .
(S
io
In
'a rr
G a
im
o u
t o
%
2 0
d e
fo
e rs
u m
z d
in
r e
. .
. .
9 8
n v
g a
le t
e m
(p
. .
U p
'à
c o
R
iv é
s P
u m
q u
a n
)
K E
x im
d e
. .
. .
. .
u s
t h
p m
n
In
'a rr
G a
im
:
(J
0 p
M a
io
z d
e m
in
r e
. .
s s
T IC
)
s s
u m
g a
le t
s u
. .
. .
e 2
T L
re
iv é
L e
s d
L S
t E
(P
im
d e
'a rr
e s
. .
a n
n
In
:
. .
o in
o ll
M in
io
u m
z d
P r
r e
. .
E T
s s
g a
. .
. .
(M
(C
re
d e
e r
s u
. .
(P
im
a t
)
e s
. .
n
u m
r :
M in
s s
io
W
im
P r
. .
ic t)
a x
. .
t o
is tr
re
u m
m
e r
a c
. .
(P
a u
a t
)
. .
t D
d 'e
u m
y F
e n
x im
W
im
. .
m
M a
n
in
e n
t)
r g
.2 )
g e
s s
io
u m
m
g :
e )
. .
4 6
n a
a u
m
n e
q u
M a
re
d 'e
t in
u v
re
é ti
11
(P
im
c o
/ : E
. .
R u
le
ty
M in
n
R a
e rg
a li
b le
s s
io
re
c y
é n
. .
ic t
Q u
r y
d e
u r
is tr
s ti
re
v e
u e
ie n
te
t A
ir
b u
(P
ti q
a c
. .
t D
a s
o n
c o
ri s
fi c
/ F
e n
m
c ti
r :
E f
u e
m
C o
C o
ti o
n
R e
c té
g e
th
s
tr u
u c
b e
a ra
a l
iq
n a
o u
c e
m
n s
e rm
n s
:
M a
a n
F ro
s tr
)
(C
m
"S
s )
C o
o n
b le
u m
e r
it é
th
ty
d u
a r
e c
s ti
io
a li
6 .2
u m
'u n
b u
)
T h
a c
is s
x )
Q u
1 4
C le
im
l N
ff ic
ir
t 1
in
(D
c o
m
c m
ri e
)
m
N O
t A
m
r i a
(E
x E
d e
a s
e n
u m
ts
5 .2
s é
n s
C o
m
e n
s
(1
)
S e
d e
g le
im
e m
b le
c .
N O
is s
io
u th
rè
a g
m
s ti
s )
6 in
m
é ro
S o
u
M in
é g
F ro
b le
m
u m
s In
-0 1
m
t a
b u
s ti
5 .8
0 5
(É
to
e n
(D
o m
b u
(N
n t
é m
(1
)
g ie
-0 0
u a
o m
in
c m
B L
u rs
rm
n -C
n -c
)
lo
fo
N o
n o
m
5 /8
n o
T -L
(P
o n
m
5 .2
(c
e s
0 .8
(1
)
c h
IG
(D
m
(5
)
6 in
m
T e
m
0 .8
2 in
m
)
n
5 .8
(5
c m
e e
G r
S t
.
1
(1
2 in
0 .4
4 0
)
o t
5
)
in
c m
(3
a in
6 1
7 0
m
a u
5 /8
in
- 1
.c o
e -e
5 .2
1 2
ll ih
. M
o t
)
t e
, IL
3 5
r
u ff
(1
m
m
a te
h a
6 in
m
In
W
r g
) 8
ll ih
.c o
h e
)
2 .7
0 0
b u
t e
u c
a u
)
2 9
7 7
o t
o f
s d
r
-e
(1
c m
le s
( 8
in
ff e
ll ih
T o
p
s u
a te
a u
in
0 .4
G a
e :
@
e s
h e
1 /2
f o
t e
c h
)
(3
o n
.i n
(D
o f
a u
: in
c k
d u
r
in
P h
w w
a te
e -e
1 2
a il
B a
re
h e
u ff
rr iè
E m
: w
o f
h a
(A
n t
u c
e b
F ro
n td
e t
W
v a
)
ô té
b in
)
(A
c a
o n
e (C
o f
a ti
li s
S id
tt o
m
n a
c a
B o
ô té
(C

Advertisement

Table of Contents
loading
Need help?

Need help?

Do you have a question about the i201X and is the answer not in the manual?

Questions and answers

Related Manuals for Intellihot i201X

Summary of Contents for Intellihot i201X

  • Page 1: Operation Manual

    Smart. Efficient. Endless Operation Manual Model: i201X i251X Intellihot Direct Vent Boiler/ Combination Water heater. This product complies with ANSI Z21.13- (2010) / CSA 4.9 Low Pressure Boiler and with e rt d ir ti o ANSIZ21.10.3 (2011) / CSA 4.3 Gas Water Heater. For n ti à...

  • Page 3: Table Of Contents

    Table of Contents 1. General Information Items Shipped With Water Heater ....4 Contact Information......4 Serial Number Plate Locations .

  • Page 4: General Information

    T IS Front (Avantdu Side of heater chauffe-eau) (Côté) 1/2 in 12 in (12.7 (30.4 12 in Intellihot W. Main Green IL 61401 Technologies Recovery (Pression (Caractéristique Rating: Effi ciency de recouvrement) . . . / : Energy énergétique) .

  • Page 5: Safety Signal Words

    2. Safety DANGER Safety Signal Words A. This water heater does not have a pilot. It is equipped DANGER with an ignition device which automatically lights the burner. Do not try to light the burner manually. Indicates an imminently hazardous situation which, if not avoided, will result in death or serious injury.
  • Page 6 CAUTION Make sure you know the location of the gas shut-off valve and how to operate it. Immediately close the gas shut-off valve if the water heater is subjected to fire, overheating, flood, physical damage, or any other damaging condition that might affect the operation of the unit.

  • Page 7: Operation

    3. Operation A) LCD screen Control Panel The LCD display screen shows all information about the operating functions of the water heater. B) Arrow keys Press the UP or DOWN arrows to adjust the value of the selected feature, such as time or water temperature. C) Enter button To return to the Main or Home screen.

  • Page 8: Turning Water Heater On And Off

    4. Press the Up/Down arrows to set the correct hour. When Turning Water Heater ON and OFF setting the hour, make sure you have correctly advanced the time to either the AM or PM hour setting. 1. When plugging in, the unit will show the four digit software version.

  • Page 9: Setting Space Heating Temperature

    Actual Outside Air Temperature (if connected) Setting Space Heating Temperature toAt and the actual outside air temperature, such as 65°F. Press and hold the Orange button. On the right-hand side If -- is shown, this parameter is unavailable or sensor is not of the display the current temperature setting of the supply connected..

  • Page 10: Error Screen

    Recirculation Temperature trEC and the actual temperature of recirculation, such as 110°F. Flue Temperature FLUE and the actual temperature of flue, such as 110°F. Error Screen If an error occurs, the display will indicate an error code; E1, E3, E7, etc. The flashing triangle will also appear in the upper left corner of the display to indicate a potential problem with the unit.

  • Page 11: Programming

    4. Programming Modes of Operation The Modes of Operation screens provide set up screens and additional information on the water heater. There are five Mode of Operation screens which are used by the technician during installation or maintenance of the water heater. 4.1.1 Standard Modes 1.
  • Page 12 4.2.2 Performance History 4.2.3 Setting Instant Hot Water Times The Performance History mode allows the This mode is used to set the times when the unit technician to view ignition cycles, number of ON will supply instant hot water. times, and cumulative water flow. The displayed results are for all the water heater modules combined within the unit.
  • Page 13 4.2.4 Diagnostic Code and Error Log Selection 4.2.5 Blower Ramp Selection This screen provides the technician with Diagnostic When exhaust harmonics are observed, i.e. Codes and Errors recorded as the water heater resonance at low fire, adjust the water heater using operates.
  • Page 14 4.2.6 Fuel Type Verification 4.2.7 Flue Pipe Selection (PVC or CPVC) The Fuel Type mode screen shows the selected fuel Changing this setting can only be done when the type; natural gas (factory preset) or Propane. Flame ON icon is not displayed. Operation with natural gas is factory preset.

  • Page 15: Maintenance

    5. Maintenance Cleaning the Inlet Water Strainer Draining the Water Heater All the water heaters are equipped with a sediment strainer CAUTION on the inlet water connection. Initially, this strainer should be inspected and cleaned every Hot water can cause burns to the skin. The water three months to establish a cleaning schedule.

  • Page 16: Filling The Water Heater

    Filling the Water Heater 1. Open the water outlet supply valve. Slowly open the water inlet supply valve. 2. Open the hot water faucet that is located farthest away from the water heater. Once a steady stream of water flows and all the air is purged from the system, close the hot water faucet.

  • Page 17: Troubleshooting

    6. Troubleshooting Error Code Chart Blower Speed Fault • Blower noisy / impeller jammed. • Inspect blower / impeller. Clean and remove any obstructions. • Disconnected signal wire. • Check PWN signal. Check for loose wires / pins, and repair. •...
  • Page 18 Temperature Sensor • Unplugged connectors • Check connectors and ensure they are securely Open Circuit connected • Check for nicked or broken sensor wiring or • Faulty sensor wiring connectors. Also check for corroded or wet connectors • Measure resistance of sensor at connector (18 Kohm •...

  • Page 19: Wiring Diagram Chart

    Wiring Diagram Chart Troubleshooting...

  • Page 20: Operational Diagram

    Operational Diagram Program time or Thermostat IH-156 Troubleshooting...

  • Page 21: Serviceable Parts

    7. Serviceable Parts Electrical Components DESCRIPTION ITEM NO. PART NUMBER DISPLAY IGT-SPR0004 CONTROLLER IGT-SPR0002 IGT-SPR0005 IGNITER MODULE Serviceable Parts...

  • Page 22: Blower, Gas Valve, And Exhaust

    Blower, Gas Valve, and Exhaust DESCRIPTION ITEM NO. PART NUMBER i2 0 /i250 FLUE PIPE ASSEMBLY (PP) IGT-SPR0017 GAS INLET ASSEMBLY IGT-SPR0016 BLOWER KIT IGT-SPR0008 GAS VALVE KIT IGT-SPR0011 Serviceable Parts...

  • Page 23: Water Lines And Fittings

    Water Lines and Fittings DESCRIPTION ITEM NO. PART NUMBER IGT-SPR0036 SMALL TEE IGT-SPR0018 WATER INLET FITTING (3/4" NPT) IGT-SPR0024 HEAT EXCHANGER INLET TOP TUBE IGT-SPR0023 BY PASS TUBE IGT-SPR0003 FLOW SENSOR KIT IGT-SPR0025 HEAT EXCHANGER INLET BOTTOM TUBE IGT-SPR0026 HEAT EXTANGER OUTLET TOP TUBE BUFFER IGT-SPR0028 TANK TO DRAIN PORT TUBE IGT-SPR0027...

  • Page 24: Ignition Components

    Ignition Components DESCRIPTION ITEM NO. PART NUMBER ELECTRODE KIT IGT-SPR0006 IGNITER MODULE IGT-SPR0005 Serviceable Parts...

  • Page 25: Multiple Units

    1. Disconnect the power from all the units in the system. unit. WARNING SHOCK HAZARD Before making any adjustments or connections inside the water heater cabinet, make sure the power is disconnected. Unplug the water and/or turn the circuit breaker OFF. IN-61 i201X-i251X Multiple Units...
  • Page 26 Enter button for three seconds to save this setting and return to the main display screen. Repeat the above steps and set each unit to a different number. For example, the next unit would be 02, the third unit would be 03, and so on. i201X-i251X Multiple Units...

  • Page 27: Warranty

    This warranty is limited to repairs or replacement of parts, maximum contaminant levels (40 CFR part 143.3), as shown at Intellihot’s option that are proven to be defective under in the table. Intellihot will warrant the heat exchanger coil normal use and connected only to potable water systems.
  • Page 28 Intellihot shall not be liable for indirect, special, incidental, consequential, or other similar damages, including lost profits, arising from or relating to the unit.

  • Page 29: Product Warranty Card

    10. Product Warranty Card To activate your warranty, please fill out the information in the form below and mail to the following address: Warranty Registration Intellihot Green Technologies, Inc. 2900 W. Main Street Galesburg, IL 61401 Model: __________________ Serial Numbers (up to 4):...
  • Page 32 d to p an p ro g az rt i d ir n ve ti o n ti à n é n ta s ta s io a ti r pl e -e F ie u ff 9 ,0 .6 2 R IE ,0 0 T É...

This manual is also suitable for:

I251x

Table of Contents