Table Of Contents; Packaging; Introduction; General.information - Lennox Hearth Products MONTEBELLO LSM40MP-2 Installation Instructions Manual

TABLE OF CONTENTS

Packaging..........................................Page. 2
Introduction.......................................Page. 2
General.Information...........................Page. 2
Massachusetts.and.New.York
....Requirements. . ...............................Page. 4
Cold.Climate.Insulation......................Page. 5
Manufactured.Home.Requirements...Page. 5
Location.............................................Page. 5
Vent.Termination.Clearances.. . ...........Page. 6
Minimum.Clearances.to.Combustibles.Page. 8
Detailed.Installation.Steps. . ................Page. 9
Typical.Installation.Sequence.............Page. 9
Step.1.. Framing. . ..............................Page. 9
Fireplace.and.Framing.Specifications...Page. 10
Step.2.. Routing.Gas.Line.................Page. 11
Proper.Sizing.of.Gas.Line. . .................Page. 11
Step.3.. Install.the.Vent.System........Page. 12
Vertical.Termination.Systems. . ...........Page. 13
Vent.Section.Length.Chart.................Page. 13
Vertical.Vent.Tables.and.Figures. . .......Page. 16
Horizontal.Termination.System..........Page. 17
Horizontal.Vent.Tables.and.Figures....Page. 19
Step.4.. Field.Wiring. . ........................Page. 21
Step.5.. Removing.Glass.Door
....Frame.Assembly............................Page. 22
Step.6.. Connecting.Gas.Line............Page. 22
Step.7.. Checking.Appliance.
....Operation.......................................Page. 23
Step.8.. Installing.Logs.and.Panels...Page. 24
Step.9.. Installing.Glass.Door.. . .........Page. 26
Step.10.. Burner.Adjustments.............Page. 26
Finishing.Requirements.....................Page. 28
Step 11. Attaching Safety in
Operation Warnings ............... Page 29
Installation.Accessories.....................Page. 30
Gas Conversion Kits .................. Page 31
This.manual.is.part.of.a.set.of.two.supporting.
this. product.. . Refer. to. manual. 875,027M. for.
Care.and.Operation.information..
Please read and understand these
instructions before beginning your
installation.
2

PACKAGING

The..assembled.vented.gas.fireplace.is.pack-
aged.with:
1.-. one.envelope.located.in.the.firebox.contain-
ing.the.literature.package,.which.consists.of.
the.care.and.operation.manual,.installation.
instructions,. safety. in. operation. warning.
labels.and.warranty.
2-. one.bag.of.glowing.embers.and.volcanic.
stone
3.-. one.of.the.following.brick.liner.kits:
. a...Brick.Liner.Kit,.Rustic
. b...Brick.Liner.Kit,.Herringbone
. c...Brick.Liner.Kit,.Old.Cottage
. d...Brick.Liner.Kit,.Black.
. e...Brick.Liner.Kit,.Red.Rustic
. f...Brick.Liner.Kit,.Red.Herringbone
4.-. one.of.the.following.log.sets:
. a...Birch.Log.set
. b...Oak.Log.set
5.-. pull.screen
6.-. door.modesty.shield

INTRODUCTION

The.Millivolt.appliances.are.designed.to.operate.
on.natural.or.propane.gas.and.have.a.millivolt.
gas.control.valve.with.piezo.ignition.system.
The. Electronic. appliances. are. designed. to.
operate.on.natural.or.propane.gas.and.have.a.
electronic.intermittent.pilot.ignition.system...No.
external.electrical.power.is.required.to.operate.
these.units..
These.vented.gas.fireplaces.are.sealed.com-
bustion.gas.fireplaces.designed.for.residential.
applications..
Use Only These Approved Vent Components.
-.These..fireplaces..are..designed,..tested..and. .
listed..for..operation..and..installation..with,. .
the. . following. . (8". inner. and. 11". outer). vent. .
components..only:
•. Secure Vent™..Direct..Vent..System..Compo-
nents. manufactured. by. Security. Chimneys.
International.
These.approved.vent.system.components.are.
labeled. for. identification.. . DO. NOT. use. any.
other. manufacturer's. vent. components. with.
these.appliances.
GENERAL INFORMATION
WARNING
Young children should be care-
fully supervised when they are
in the same room as the appli-
ance. Toddlers, young children
and others may be susceptible
to accidental contact burns. A
physical barrier is recommended
if there are at risk individuals in
the house. To restrict access to
a fireplace or stove, install an
adjustable safety gate to keep
toddlers, young children and
other at risk individuals out of
the room and away from hot
surfaces.
AVERTISSEMENT
Les jeunes enfants devraient être
surveillés étroitement lorsqu'ils
se trouvent dans la même pièce
que l'appareil. Les tout petits,
les jeunes enfants ou les adultes
peuvent subir des brûlures s'ils
viennent en contact avec la sur-
face chaude. Il est recommandé
d'installer une barrière physique
si des personnes à risques habi-
tent la maison. Pour empêcher
l'accès à un foyer ou à un poêle,
installez une barrière de sécu-
rité; cette mesure empêchera les
tout petits, les jeunes enfants et
toute autre personne à risque
d'avoir accès à la pièce et aux
surfaces chaudes.
Children and adults should be alerted to the
hazards of high surface temperature and
should stay away to avoid burns or clothing
ignition.
Les enfants et les adultes devraient être infor-
més des dangers que posent les températures
de surface élevées et se tenir à distance afin
d'éviter des brûlures ou que leurs vêtements
ne s'enflamment.
DO NOT ATTEMPT TO ALTER OR MODIFY
THE CONSTRUCTION OF THE APPLIANCE OR
ITS COMPONENTS. ANY MODIFICATION OR
ALTERATION MAY VOID THE WARRANTY,
CERTIFICATION AND LISTINGS OF THIS
UNIT.