Summary of Contents for Ladan 18
- Page 1 Ladan Wood gasification boiler Instruction for use, installation and assembly of boiler.
-
Page 2: General Description
General description: We are introducing you the ecological wood gasification boiler of the output 18, 25, 40, 60, 80kW. The hot-water boiler is designed for heating of apartment, family house, guest house, smaller industrial workshop and similar object The boiler is designed for burning of wood only. -
Page 3: Technical Parameters
Technical parameters: Type of boiler LADAN Boiler output Feed hopper capacity 370x570, 370x570, 270x570 270x570 Door dimension /h-w/ 270x450 270x450 270x450 Prescribed chimney draught Test overpreassure Max. working overpressure Boiler weight Diameter of flue connection 1490 1490 Boiler height 1280... -
Page 4: Protection Of Boiler Against Overheating
Protection of Boiler against overheating. ATTENTION: According to the EN 303-5 standard the Safety cooling circuit against the boiler overheating must not be used for other purposes than to protect boiler against overheating. - Page 5 1. Drain valve Danfoss - BVTS, ¾“ 2. Submersible case with temperature-sensitive element 3. Safety cooling heat exchanger 4. Drain to sump 5. Boiler 6. Inlet of cold water Valve Danfoss – BVTS is on the outlet of the cooling circuit of which sensor is placed at the side part of a boiler and protects the boiler against overheating.
- Page 6 Dimension scheme: Boiler sketch...
-
Page 8: Boiler Operation
Boiler operation: Before making fire it is necessary: - familiarize with the attendance of electronic boiler regulation - check water pressure in the central heating system - check if the boiler is connected to the mains Making fire in the boiler - set the heating temperature - select the fan speed - through the upper door insert paper, chips, small pieces of wood and to the rest of feeding... - Page 9 After removing a fan and air inlet cover we can see the two tubes that lead air into the nozzle and to two holes at the upper door. These holes should be cleaned with a small brush and vacuum cleaner. Turn on the fan and check by hand the clearness of air. Put the cover of air inlet and fan back.
-
Page 10: Problems Solution
Problems solution Defect Cause/Remedy - Clean up air inlet system Boiler has a lower output as it was - Clean up blades of fan a new one - Use dry wood - Insufficient quantity of primary air Afterclosing the flue shutter the boiler - Clean up the primary air inlet burns for a while and then smoke - Check the shutter opening behind the fan... - Page 11 Scheme of boiler Ladan 25 kW: 1. Electronic regulation 14. Thermometer 2. Upper door 15. Thermal fuse / emergency thermostat / 3. Pull rod of chimney shutter 16. Water output socket 4. Loading chamber 17. Upper back cover 5. Conduit of primary air 18.
- Page 12 Picture of thermal sensor and emergency thermostat: 1. Upper metal sheet of the boiler 2. Socket of outlet water 2“ 3. Temperature sensor 4. Emergency thermostat /in case the temperature is higher than 110 °C the fan turns off /...
- Page 13 Scheme of loading chamber: Length of chamber is 590-1000 mm Loading chamber...
- Page 14 Assembly regulations Basic connection scheme of boiler Ladan into the central heating system The boiler should be connected into the central heating system of which the capacity is appropriate to the boiler output. The boiler must be connected to the flue by the shortest way. Other appliances must not be attached to the same flue.
-
Page 15: Installation Instruction
Attendance instructions: The boiler can be operated only by person who is older than 18 years old, mentally and healthy capable and familiarized with the Manual for operation. During boiler operation it is necessary to check impeccable boiler state. -
Page 16: Certificate Of Warranty
Certificate of warranty Type of boiler ................LADAN Production number ..............Checked by : ................Sell-by-date: ..........................Stamp and signature Instructions for customers and conditions of guarantee: - Producer is not responsible for damage during transportation of the product.