Advertisement

IMPORTANT SAFETY INSTRUCTIONS

WARNING: Failure to observe these instructions can cause
WARNING: Fire or explosion hazard.
NEVER operate this machine in an
explosive atmosphere (grain dust,
flammable liquids or fumes, etc.).
INTENDED USE
This machine is intended for commercial use,
scrubbing floors in an indoor environment. NSS does
not recommend using these machines for any other
purpose.
FOR SAFETY
• ALWAYS read and understand all instructions
before operating or servicing machine.
• ALWAYS use this machine ONLY as described in
this manual.
• NEVER attempt to operate this machine unless you
have been trained in its operation.
• NEVER allow an untrained person to operate this
machine.
• NEVER attempt to operate this machine if it is not
working properly or has been damaged in any
manner.
• NEVER disconnect or modify any switches or
safety devices (circuit breaker).
• NEVER drop or insert any object into any machine
opening.
• NEVER operate this machine with any air opening
blocked. Keep all air openings free of dust, lint,
hair, etc.
• NEVER pick up anything that is burning or
smoking, such as cigarettes, matches or hot ashes.
• NEVER spray this machine with water or any
liquids.
• NEVER allow the vacuum motor or battery
charging plug to get wet or a short may occur.
• NEVER operate this machine when the battery
charger is plugged in.
• NEVER operate this machine with the side skirt
removed.
• NEVER allow this machine to be used as a toy.
Close attention is necessary when used by or near
children.
ALL REPAIR SERVICE MUST BE PERFORMED BY AN NSS AUTHORIZED DISTRIBUTOR /
SERVICE STATION USING ONLY NSS ORIGINAL EQUIPMENT PARTS.
OPERATION MANUAL
CHAMP 3529 RB
personal injury to machine operator or bystanders.
SAVE THESE INSTRUCTIONS
WARNING: Fire or explosion hazard.
NEVER attempt to pick up flammable
or combustible materials or use such
materials in tanks.
• ALWAYS wear clean tennis shoes or "non-slip"
shoes. Leather soled shoes will be extremely
slippery when wet.
• ALWAYS keep face, fingers, hair or any other body
part or loose clothing away from any machine
opening or moving part (revolving brush, pad
driver, or vacuum motor).
• ALWAYS turn the machine off when attaching
pads or brushes.
• ALWAYS remove keys when this machine is left
unattended.
• NEVER turn on machine unless sitting in the
operators seat.
• NEVER climb on machine when it is turned on.
• NEVER use machine to transport passengers other
than the operator.
• ALWAYS be sure that the ramp is secured to the
vehicle before attempting to load / unload.
• ALWAYS use extreme caution when operating the
machine on a ramp or loading / unloading this
machine into or out of a truck / trailer. Use
extreme caution if the ramp is wet, oily, or covered
with cleaning chemicals.
• NEVER stop or turn the machine on a ramp or
incline.
• NEVER attempt to climb a grade or operate this
machine on a ramp or incline of more than 8
degrees.
• NEVER park or store the machine near a dock, on
ramps, near a furnace, boiler, open flame, or other
high heat source.
• NEVER allow this machine to freeze.
• NEVER expose the machine to rain, snow, or
extreme temperatures.
• NEVER store any items on the machine.
• ALWAYS store this machine indoors in a dry, cool
area.

Advertisement

Table of Contents
loading
Need help?

Need help?

Do you have a question about the CHAMP 3529 RB and is the answer not in the manual?

Questions and answers

Subscribe to Our Youtube Channel

Summary of Contents for NSS Enterprises CHAMP 3529 RB

  • Page 1: Important Safety Instructions

    OPERATION MANUAL CHAMP 3529 RB IMPORTANT SAFETY INSTRUCTIONS WARNING: Failure to observe these instructions can cause personal injury to machine operator or bystanders. WARNING: Fire or explosion hazard. WARNING: Fire or explosion hazard. NEVER operate this machine in an NEVER attempt to pick up flammable...
  • Page 2 IMPORTANT SAFETY INSTRUCTIONS BATTERY POWERED EQUIPMENT WITH ON BOARD CHARGERS WARNING: Failure to observe these instructions can cause personal injury to machine operator or bystanders. Read and understand all No smoking, open Poison. Causes Contains acid. instructions before installing flames, or sparks while severe burns.
  • Page 3: Noise And Vibration

    LCD Display Screen - brightly lit to work in all NOISE AND VIBRATION lighting situations. NOISE Traction Speed Switch - 3 Positions: Sound pressure level at Operator 70 dB(A) • Down is high speed. position • Center is medium speed. VIBRATION •...
  • Page 4 THE DISPLAY SCREENS There are many symbols that can be displayed on the LCD. Therefore, the LCD Push Button can be used to toggle between pre-defined screens (see Control Panel for Details). Screen 1 Screen 2 Screen 3...
  • Page 5: Machine Operation

    Install a Brush: MACHINE OPERATION • Pull pin and open skirt. • Raise the brush motor into the transport position. General Information • Align the lugs of the brush with the notches of the The CHAMP 3529 is very maneuverable and is designed to clean as you drive the machine.
  • Page 6: Machine Maintenance

    MACHINE MAINTENANCE Battery Charger Operating instructions Daily Maintenance 1. Connect charger power cord to a properly grounded • Recharge the batteries when indicated by the outlet. When using an extension cord, avoid Battery Discharge Indicator. excessive voltage drop and extended charge times •...
  • Page 7: Maintenance Instructions

    Check or change the charging algorithm Maintenance Instructions a. Disconnect the positive connector from battery 1. For flooded lead-acid batteries, regularly check pack. Apply AC power and after an up/down flash water levels of each battery cell after charging and of the LEDs, the algorithm # will display for 11 add water as required to level specified by battery seconds.
  • Page 8 TRIO+: Scrubber System Diagnostic Codes Scrubber System Faults External to TRIO+ Code Fault Description Corrective Action 0810 Throttle fault-1.0 For all Throttle Diagnostic Codes: 0811 Throttle max wiper difference error. 1- Check the throttle wiring for shorts or opens. Repair or replace as necessary.
  • Page 9 2C00 Low battery error. Battery Charge too low. Recharge battery. 2C01 Low battery error 2. Battery Charge too low. Recharge battery. 2C02 Soft battery lockout occurred. Battery Charge too low. Recharge battery. 2C03 Soft battery lockout 2 occurred. Battery Charge too low. Recharge battery. 2F01 Tiller displaced error.
  • Page 10 Possible Internal TRIO+ Faults Code Code Code Code Corrective Action 0003 1800 3104 3603 For All Internal TRIO + Diagnostic Codes: 0100 1802 3105 3608 1 - Turn Off Key switch and disconnect batteries. 0204 1B20 3200 3609 2 - Wait 1 minute. 0705 1B21 3201...
  • Page 11: Troubleshooting

    TROUBLE SHOOTING PROBLEM CAUSE SOLUTION No Solution Flow. The solution valve is closed. Open the solution valve. Water solenoid valve not open. Charge the battery. Obstruction in the solution hose. Remove the obstruction. Solution valve or cable damaged. Repair / replace the valve cable. Solution tank is empty.
  • Page 12 ® Enterprises, Inc. 3115 Frenchmens Road, Toledo, Ohio 43607 PHONE (419) 531-2121 FAX (419) 531-3761 NSS ® Enterprises, Inc. European Distribution Centre Unit II, Pinfold Trading Estate * 55 Nottingham Road STAPLEFORD, NOTTINGHAM NG9 8AD ENGLAND U.K. PHONE: (44) 0115 939 1568 * FAX: (44) 0115 949 0615 CHAMP 3529 Operation Manual - 9097634 Orig.

Table of Contents