Maytag MDG50PCC Installation Manual
Maytag MDG50PCC Installation Manual

Maytag MDG50PCC Installation Manual

50 lb single pocket / phase 7 / coin
Hide thumbs Also See for MDG50PCC:

Advertisement

MDG50PCC Installation Manual
50 lb Single Pocket / Phase 7 / Coin
WARNING: For your safety the information
in this manual must be followed to
minimize the risk of fire or explosion and
to prevent property damage, personal
injury or death.
— Do not store or use gasoline or other
flammable vapors and liquids in the
vicinity of this or any other appliance.
— WHAT TO DO IF YOU SMELL GAS:
Do not try to light any appliance.
Do not touch any electrical switch;
do not use any phone in your
building.
Clear the room, building or area of
all occupants.
Immediately call your gas supplier
from a neighbor's phone. Follow
the gas supplier's instructions.
If you cannot reach your gas
supplier, call the fire department.
— Installation and service must be
performed by a qualified installer, service
agency or the gas supplier.
AVERTISSEMENT: Assurez-vous de bien
suivre les instructions données dans cette
notice pour réduire au minimum le risque
d'incendie ou d'explosion ou pour éviter
tout dommage matériel, toute blessure ou
la mort.
—Ne pas entreposer ni utiliser d'essence
ni d'autres vapeurs ou liquides
inflammables à proximité de cet
appareil ou de tout autre appareil.
—QUE FAIRE SI VOUS SENTEZ UNE
ODEUR DE GAZ:
Ne pas tenter d'allumer d'appareils.
Ne touchez à aucun interrupteur. Ne
pas vous servir des téléphones se
trouvant dans le bâtiment.
Évacuez la pièce, le bâtiment ou la
zone.
Appelez immédiatement votre
fournisseur de gaz depuis un voisin.
Suivez les instructions du fournisseur.
Si vous ne pouvez rejoindre le
fournisseur de gaz, appelez le service
des incendies.
—L'installation et l'entretien doivent être
assurés par un installateur ou un
service d'entretien qualifié ou par le
fournisseur de gaz.
RETAIN THESE
INSTRUCTIONS IN A
SAFE PLACE FOR
FUTURE REFERENCE
Part No. 113198-5

Advertisement

Table of Contents
loading

Summary of Contents for Maytag MDG50PCC

  • Page 1 MDG50PCC Installation Manual 50 lb Single Pocket / Phase 7 / Coin WARNING: For your safety the information in this manual must be followed to minimize the risk of fire or explosion and to prevent property damage, personal injury or death.
  • Page 2 POUR VOTRE SÉCURITÉ Ne pas entreposer ni utiliser d’essence ni d’autres vapeurs ou liquides inflammables à proximité de cet appareil ou de tout autre appareil. IMPORTANT For your convenience, log the following information: Maytag Co. Benton Harbor, MI 1-800-662-3587 MDG50PCC...
  • Page 3: For Your Safety

    State of California Proposition 65 Warnings: WARNING: This product contains a chemical known to the State of California to cause cancer. WARNING: This product contains a chemical known to the State of California to cause birth defects or other reproductive harm. YOU MUST DISCONNECT AND LOCK OUT THE ELECTRIC SUPPLY AND THE GAS SUPPLY OR THE STEAM SUPPLY BEFORE ANY COVERS OR GUARDS ARE REMOVED FROM THE MACHINE TO ALLOW ACCESS FOR CLEANING,...
  • Page 4 WARNING The dryer must never be operated with any of the back guards, outer tops, or service panels removed. PERSONAL INJURY OR FIRE COULD RESULT. WARNING DRYER MUST NEVER BE OPERATED WITHOUT THE LINT FILTER/SCREEN IN PLACE, EVEN IF AN EXTERNAL LINT COLLECTION SYSTEM IS USED. IMPORTANT PLEASE OBSERVE ALL SAFETY PRECAUTIONS displayed on the equipment and/or specified in the installation manual included with the dryer.
  • Page 5: Table Of Contents

    SECTION I SAFETY PRECAUTIONS ... 2 SECTION II SPECIFICATIONS ... 4 SECTION III INSTALLATION PROCEDURES ... 6 A. Unpacking/Setting Up ... 6 B. Location Requirements ... 6 C. Dryer Enclosure Requirements ... 7 D. Fresh Air Supply Requirements ... 8 E.
  • Page 6: Safety Precautions

    4. Installation and service must be performed by a qualified installer, service agency, or gas supplier. 5. Dryers must be exhausted to the outdoors. 6. Although Maytag produces a very versatile dryer, there are some articles that, due to fabric composition or cleaning method, should not be dried in it.
  • Page 7 ACCESS FOR CLEANING, ADJUSTING, INSTALLATION, OR TESTING OF ANY EQUIPMENT PER OSHA (Occupational Safety and Health Administration) STANDARDS. IMPORTANT: Dryer must be installed in a location/environment, which the ambient temperature remains between 40° F (4.44° C) and 130° F (54.44° C). 113198 - 5 Maytag Co.
  • Page 8: Specifications

    32-3/4” 37-1/2” 3/4 hp 21-1/2” 18.3 cu ft 120v 1ø 60 Hz 651 lbs 700 lbs 150,000 Btu/hr 750 cfm Maytag Co. 22.7 kg 83.2 cm 95.3 cm 0.560 kW 54.61 cm 0.518 cu m 10/20 24/26 295.3 kg 317.7 kg...
  • Page 9 SPECIFICATIONS – GAS ONLY NOTE: Manufacturer reserves the right to make changes in specifications at any time without notice or obligation. 113198 - 5 Maytag Co.
  • Page 10: Installation Procedures

    IMPORTANT: “The dryer must be installed on noncombustible floors only.” 2. The dryer must not be installed or stored in an area where it will be exposed to water and/or weather. 3. The dryer is for use in noncombustible locations. SECTION III Maytag Co. 113198 - 5...
  • Page 11: Dryer Enclosure Requirements

    NOTE: With the exception of the floor, clearances shown are for combustible construction. X = 12-inch (30.48 cm) minimum, 24-inches (60.96 cm) is suggested for ease of maintenance. * 1-inch (2.54 cm) maximum for electric dryers. 113198 - 5 Maytag Co.
  • Page 12: Fresh Air Supply Requirements

    Make-up air that is contaminated by dry cleaning solvent fumes will result in irreparable damage to the motors and other dryer components. NOTE: Component failure due to dry cleaning solvent fumes will VOID THE WARRANTY. Maytag Co. 113198 - 5...
  • Page 13: Exhaust Requirements

    NOTE: As per the National Fuel Gas Code, “Exhaust ducts for type 2 clothes dryers shall be constructed of sheet metal or other noncombustible material. Such ducts shall be equivalent in strength and corrosion resistance to ducts made of galvanized sheet steel not less than 26 gauge (0.0195-inches [0.50 mm]) thick.” 113198 - 5 Maytag Co.
  • Page 14 40 feet (12.19 meters). This calculation compensates for the use of a maximum of three (3) elbows including the two (2) elbows creating the 180° (turned downward) outside outlet. Illus. B Maytag Co. JEV 04/12/02 113198 - 5...
  • Page 15 IMPORTANT: No more than four (4) dryers maximum should be connected to one (1) main common duct. Refer to the illustrations below for Multiple Dryer Horizontal Venting and Vertical Venting examples/ illustrations. HORIZONTAL VENTING Illus. C VERTICAL VENTING Illus. D 113198 - 5 Maytag Co.
  • Page 16: Electrical Information

    For others, calculate/verify correct breaker size according to appliance amp draw rating and type of breaker used. SERVICE PHASE VOLTAGE APPROX. WIRE AMP DRAW SERVICE 60 Hz 50 Hz 1ø 12.0 Maytag Co. CIRCUIT BREAKER — 9/23/08 113198 - 5...
  • Page 17 In both cases, a strain relief must be installed where the wiring enters the dryer. Single-Phase (1ø) Wiring Connections/Hookup The electrical input connections on ALL single-phase (1ø) gas dryers are made into the rear service box located at the upper left area of the dryer. 113198 - 5 Maytag Co.
  • Page 18: Gas Information

    The dryer must be connected to the type of heat/gas indicated on the dryer data label. If this information does not agree with the type of gas available, DO NOT operate the dryer. Contact the dealer who sold the dryer or contact the Maytag Co. FOR 110V APPLICATIONS...
  • Page 19 The adjustment or conversion of dryers in the field for elevations over 2,000 feet (610 meters) is made by changing each burner orifice. If this conversion is necessary, contact the dealer who sold the dryer or contact the Maytag Co. 2. Technical Gas Data a.
  • Page 20 An in-line pressure regulator must be installed in the gas supply line (header) if the (natural) gas pressure exceeds 12.0 inches (29.9 mb) of water column (W.C.) pressure. (Refer to the illustrations above.) Maytag Co. 113198 - 5...
  • Page 21: Preparation For Operation/Start-Up

    9. Rotate the basket (tumbler/drum) by hand to be sure it moves freely. 10. Check basket (tumbler) bearing setscrews to ensure that they are ALL tight. 11. Check vent is connected to the dryer and is exhausted to the outdoors. 113198 - 5 Maytag Co.
  • Page 22: Preoperational Tests

    30-seconds). If heat does activate, make the necessary adjustments to the sail switch. 5. Make a complete operational check of ALL operating controls. NOTE: If computer program changes are required, refer to the computer programming section of the manual supplied with the dryer. Maytag Co. 113198 - 5...
  • Page 23: Preoperational Instructions

    1. Discontinue power to the dryer either at the external disconnect switch or the circuit breaker. 2. Discontinue the gas supply: a. SHUT OFF external gas supply shutoff valve. b. SHUT OFF internal gas supply shutoff valve located in the gas valve burner area. 113198 - 5 BASKET (TUMBLER) COATING Maytag Co.
  • Page 24: Service/Parts Information

    Replacement parts should be purchased from the dealer from whom the Maytag equipment was purchased. If the dealer cannot be contacted or is unknown, contact the Maytag Co. for a dealer in your area. NOTE: When ordering replacement parts from the Maytag dealer or the Maytag Co. be sure to give them the correct model number and serial number so that your parts order can be processed in an expeditious manner.
  • Page 25: Warranty Information

    NOTE: Be sure to include the installation date when returning the warranty card(s). B. WARRANTY For a copy of the manufacturer’s commercial warranty covering your particular dryer(s), contact the Maytag dealer from whom you purchased the equipment and request a dryer warranty form. If the dealer cannot be contacted or is unknown, warranty information can be obtained from the Maytag Co.
  • Page 26: Routine Maintenance

    Maximum operating efficiency is dependent upon proper airflow. The accumulation of lint can restrict this airflow. If the guidelines in this section are met, a Maytag dryer will provide many years of efficient, trouble free, and most importantly safe operation.
  • Page 27: Adjustments

    DO NOT have a grease fitting. Provisions are made in the bearing housing for the addition of a grease fitting, which can be obtained elsewhere, or from the Maytag dealer by ordering kit P/N 882159 (includes two [2] fittings).
  • Page 28: Lint Drawer Removal

    To remove the lint drawer from the dryer pull drawer out approximately halfway. Rotate/move lint drawer stop hinge (refer to the illustration below) downward and pull the drawer out. IMPORTANT: After replacing the lint drawer back into the dryer, be sure to rotate/move hinge back to the upward stop position. Maytag Co. 113198 - 5...
  • Page 29: Data Label Information

    DATA LABEL INFORMATION When contacting the Maytag dealer certain information is required to ensure proper service/parts information. This information is on the data label affixed to the left side panel area behind the top control (access) door. When contacting the Maytag Co. please have the model number and serial number available.
  • Page 30: Procedure For Functional Check Of Replacement Components

    Start the drying cycle by pressing any temperature selection keys (HI, MED, or LO). c. Verify that the applicable indicator lights on the microprocessor controller (computer) board are lit. (Refer to the illustration below.) SECTION VIII Maytag Co. 113198 - 5...
  • Page 31 “LOCKOUT” (a red L.E.D. diagnostic indicator will flash). An unlit red L.E.D. diagnostic indicator indicates normal operation. A lit green L.E.D. diagnostic indicator indicates dryer controller is calling for heat and that ALL interlocks have been satisfied. 113198 - 5 Maytag Co.
  • Page 32: Manual Reset Burner Hi-Limit Instructions

    3-seconds to clear the fault. The open burner hi-limit must be reset “manually” prior to the start of the next cycle. WARNING: Discontinue power to dryer before attempting to reset hi-limit. Maytag Co. 113198 - 5...
  • Page 33 Notes _____________________________________________________________________________________________________________________ ___________________________________________________________________________________________________________________________ ___________________________________________________________________________________________________________________________ ___________________________________________________________________________________________________________________________ ___________________________________________________________________________________________________________________________ ___________________________________________________________________________________________________________________________ ___________________________________________________________________________________________________________________________ ___________________________________________________________________________________________________________________________ ___________________________________________________________________________________________________________________________ ___________________________________________________________________________________________________________________________ ___________________________________________________________________________________________________________________________ ___________________________________________________________________________________________________________________________ ___________________________________________________________________________________________________________________________ ___________________________________________________________________________________________________________________________ ___________________________________________________________________________________________________________________________ ___________________________________________________________________________________________________________________________ ___________________________________________________________________________________________________________________________ ___________________________________________________________________________________________________________________________ ___________________________________________________________________________________________________________________________ ___________________________________________________________________________________________________________________________ ___________________________________________________________________________________________________________________________ ___________________________________________________________________________________________________________________________ ___________________________________________________________________________________________________________________________ ___________________________________________________________________________________________________________________________ ___________________________________________________________________________________________________________________________ ___________________________________________________________________________________________________________________________ ___________________________________________________________________________________________________________________________ ___________________________________________________________________________________________________________________________ ___________________________________________________________________________________________________________________________ 113198 - 5 Maytag Co.
  • Page 34 Part No. 113198 5 - 09/24/08 - 0...

Table of Contents