Relocate the unit if necessary. 9. Keep children away from the unit while it is being repaired. 10. Be sure to clean the unit and its surrounding area. Fig. 1-3 No Kids Nearby! Fig. 1-4 Clean the Unit Samsung Electronics...
Page 3
Precautions Notice : The symbol of model name Type Model Name AW07P1HBA AW09P1HAA AW07P1HEA AW09P1HBA AW09P1HDA AW09P1HEA AW12P1HAA AWT12P1HBA AW12P1HBA AWT12P1HEA AW12P1HDA AW12P1HEA Samsung Electronics...
2. Product Specifications 2-1 Table Unit of Item AW07P1HBA AW07P1HEA AW09P1HAA AW09P1HBA AW09P1HDA AW09P1HEA Measure Type WINDOW Dimensions: 500 x 355 x 458 (Width x Height x Depth) Voltage Volt 220V ~ 220 - 240V~ 115V~ 220V~ 200 - 220V~...
Page 5
50 / 370 40/ 450 30 / 450 Compressor Capacitor µF / VAC 25 / 370 35 / 450 30 / 450 Fan Motor Capacitor µF / VAC 3.5/450 Fan Speed 900/860/800 Thermo Control THERMISTOR Air Swing MODEL 50SM16 Samsung Electronics...
Page 6
2-2 Dimensions 2-2-1 Main Unit (Unit : mm) Front view Side view Type Samsung Electronics...
(obtain a clearance of at least one meter). • Do not use the air conditioner in the following environments : greasy areas (including areas near machines), or marine areas. Contact your local dealer for advice. Samsung Electronics...
Level 10 : Cool air will be ceased below 14.4~17.4˚ contact, which provides the source of electric power to the compressor. The room temperature will fall and the cycle will repeat. Samsung Electronics...
Page 9
Use the ventilation switch to exhaust stale air. • Open position : The air inside the room circulates while the outdoor air is introduced inside. • Closed position : The air inside the room circulates while the outdoor air is not introduced inside. Samsung Electronics Samsung Electronics...
Perform soldering function Problem? Fill system with nitrogen gas Check for leakage Leakage? Corrective action Check refrigerant oil level Release nitrogen gas? Low oil level? Evacuate system Add oil as necessary Recharge system Pinch and braze filling tube Samsung Electronics...
4. When the refrigerant is replaced ..add 30cc oil. 5. After vacuum is completed, the oil is filled through the high pressure side. 6. In the event of a refrigerant leak, generally it is not necessary to add oil. (Unless the oil has leaked significantly.) Samsung Electronics...
Ass'y Cabinet 1. Remove the screws on both sides of the cabinet to disconnect the cabinet and frame. 2. Pull the handle on the front side of the bottom, and remove the unit from the cabinet. Samsung Electronics...
Page 13
1.Remove for screws on the left front and top side of the evaporator. Plate - Evap Casing 1. Lift up the evaporator, and remove the tray drain. 2.Remove the screw on the front side of plate evap casing and lift up the plate evap casing. Samsung Electronics...
Page 14
Part name Procedures Remarks 1.Remove the screws on the cond and lift up the cond. 1.Remove four screws on the partition and the earth wire earth. 2.Move the motor to ward the conderser.
Page 15
1. Remove the screws on both sides of the cabinet to disconnect the cabinet and frame. 2. Pull the handle on the front side of the bottom, and remove the unit from the cabinet. Plate reinf 1.Remove 4 screws,on the partition and case cond . Samsung Electronics...
Page 16
1.Remove for screws on the left front and top side of the evaporator. Plate - Evap Casing 1. Lift up the evaporator, and remove the tray drain. 2.Remove the screw on the front side of plate evap casing and lift up the plate evap casing. Samsung Electronics...
Page 17
1. Remove four hexagon nuts on the base Motor pan and partition. 2. Move the motor - assembly toward the condenser, and lift up the motor - assembly from the frame. 3. Remove four hexagon nuts on the supporter-motor. Samsung Electronics...
(2) The hex. nut is loose (not loose or broken). (3) The parts are broken 3) Check bearing noise of the motor. (4) Motor is faulty 4) Check the compressor noise against. (5) Compressor is faulty that of other compressors. Samsung Electronics...
7. Exploded View and Parts List 7-1 Main unit(Type”A”) You can search for the updated part code number through the ITSELF. URL : http://itself.sec.samsung.co.kr Samsung Electronics...
10. Wiring Diagram Code No : DB68-02132A AW***"1"*** DIAGRAM-ELECTRIC This Document can not be used without Samsung's authorization. Samsung Electronics...