Table Of Contents - Quadra-Fire CB1200MI-MBK Owner's Manual Installation And Operation

R
Safety Alert Key:
• DANGER! Indicates a hazardous situation which, if not avoided will result in death or serious injury.
• WARNING! Indicates a hazardous situation which, if not avoided could result in death or serious injury.
• CAUTION! Indicates a hazardous situation which, if not avoided, could result in minor or moderate injury.
• NOTICE: Indicates practices which may cause damage to the fi replace or to property.
Section 1: Listing and Code Approvals
A. Appliance Certifi cations ......................4
B. Mobile Home Approved ......................4
C. Glass Specifi cations ............................4
D. Electrical Rating ..................................4
E. BTU & Effi ciency Specifi cations ..........4
Section 2: Getting Started
A. Design, Installation & Location
Considerations ....................................5
B. Locating Your Appliance & Chimney ..6
C. Thermostat Location ...........................6
D. Draft ....................................................6
E. Negative Pressure ..............................6
B. Fire Safety ..........................................7
C. Tools & Supplies Needed ...................7
D. Inspect Appliance, Components
and Pre-Check List .............................7
Section 3: Dimensions & Clearances
A. Appliance Dimensions ........................8
B. Clearances to Combustibles
As A Built-In, UL and ULC ..................9
C. Clearances to Combustibles,
Masonry & Zero Clearance .................10
D. Minimum Opening for Factory
Built Fireplace .....................................10
E. Masonry Minimum Opening ................10
F. Floor Protection ..................................10
G. Calculating Alternate Floor
Protection Material ..............................11
H. Prefabricated Metal Chimney .............11
I. Removing Floor of Factory Built
Fireplace .............................................12
J. Altering Factory-Built Fireplace ...........12
Section 4: Vent Information
Chimney & Exhaust Connections
A.
B. Venting Termination Requirements ....13
C. Equivalent Feet of Pipe.......................14
D. Pipe Selection Chart ...........................14
Section 5: Venting Systems
A. Full Reline with Outside Air-Horizontal 15
B. Full Reline with Outside Air-Vertical ....16
November 22, 2011

TABLE OF CONTENTS

Section 6: Mobile Home
Section 7: Appliance Set-Up
Section 8: Operating Instructions
Section 9: Troubleshooting
Section 10
Section 12: Reference Material
3
........1
7014-188C
CB1200-I Pellet Insert
..................................17
A. Rear Shroud Installation .....................18-19
B. Outside Air Kit .....................................20
C. Adjustable Hopper Option...................20
D. Grille Installation .................................20
E. Adjustable Hearth Support..................21
F. Panel & Trim .......................................22-23
G. Brick Set Installation ...........................24
H. Brick Clip Installation ...........................24
I. Log Set Placement ..............................25
J. Thermostat Installation ........................25
A. Fuel Size, Material & Storage .............26
B. General Operation Information ...........27
C. Before Your First Fire .........................27
D. Starting Your First Fire ........................27
E. Fire Characteristics .............................28
F. Feed Rate Adjustment .......................28
G. Ignition Cycles ....................................28
H. Frequently Asked Questions...............29
............................31-32
Maintaining & Servicing Appliance
:
A. Proper Shutdown Procedure ...............33
B. Quick Reference Maintanence Chart ..33
C. General Maintenance & Cleaning .......33-36
D. High Ash Content Maintenance ..........37
E. Glass Replacement .............................38
F. Igniter Replacement ............................39
G. Baffl e Removal ....................................39
A. Component Functions.........................40-41
B. Component Locations .........................42
C. Exploded Drawings .............................43
D. Service Parts & Accessories...............44-48
E. Service & Maintenance Log ................49
E. Warranty Policy ...................................50-51
F. Contact Information ............................52
Page 3