Table of Contents
Advertisement
TABLE OF CONTENTS
Installation Cautions ................................................................................................................................. 3
Freestanding Installations ......................................................................................................................... 4
Positioning the Unit .................................................................................................................................. 4
Chimney Installation ................................................................................................................................ 5
Door Removal .......................................................................................................................................... 6
Wiring ....................................................................................................................................................... 6
Connecting Gas Line ................................................................................................................................ 7
Minimum/Maximum Gas Supply Pressure .............................................................................................. 7
Wall Thermostat Instructions ................................................................................................................... 7
Log Installation ......................................................................................................................................... 8
Lighting and Shutdown ............................................................................................................................8
High Altitude Orifice Chart .................................................................................................................... 10
Alcove Installation.................................................................................................................................. 11
Pre-Fab Fireplace Insert Installation ....................................................................................................... 12
Lighting Instructions .............................................................................................................................. 13
Masonry Insert Installation ..................................................................................................................... 14
Cleaning and Maintenance Requirements .............................................................................................. 15
Trouble Shooting .................................................................................................................................... 16
Replacement Parts .................................................................................................................................. 18
Warranty ................................................................................................................................................. 19
1
Advertisement
Table of Contents
Related Manuals for New Buck Corporation 61TV
Summary of Contents for New Buck Corporation 61TV
-
Page 1: Table Of Contents
TABLE OF CONTENTS Installation Cautions ..........................3 Freestanding Installations ......................... 4 Positioning the Unit ..........................4 Chimney Installation ..........................5 Door Removal ............................6 Wiring ............................... 6 Connecting Gas Line ..........................7 Minimum/Maximum Gas Supply Pressure ....................7 Wall Thermostat Instructions ........................7 Log Installation ............................ -
Page 3: Installation Cautions
GAS FIRED VENTED ROOM HEATER MODEL 61 INSTALLATION INSTRUCTIONS IMPORTANT: READ THIS MANUAL BEFORE INSTALLING AND USING THIS GAS HEATER. Installation and/or repair of this unit should only be done by a qualified installer. This appliance has been tested to and complies with ANSI Z21.11.1(1991) and CGA 1 - 2.1 - M86 with 1989 updates “Gas Fired Vented Room Heaters”, CAN/CGA - 2.17 - M91 “Gas Fired Appliances For Use At High Altitudes”. -
Page 4: Freestanding Installations
FREESTANDING INSTALLATION POSITIONING THE UNIT 1. Determine the exact position of your gas heater. If possible place the heater in such a manner that the piping will be placed between two wall studs so additional framing is not necessary. Also, try to place unit where flue pipe exit is between two ceiling joists. -
Page 5: Chimney Installation
INSTALLING THE CHIMNEY SYSTEM WARNING: THIS GAS APPLIANCE MUST NOT BE CONNECTED TO A CHIMNEY FLUE SERVING ANOTHER TYPE OF APPLIANCE. Class "B" - 4" (101 mm) flue vent is required for this unit. Follow the vent pipe manufac- turer’s instruction or NFPA 54 (ANSI Z223.1 1988) for proper installation. Also see Figure 2 for minimum clearances to roof. -
Page 6: Door Removal
REMOVING THE DOOR 1. Facing heater, the door latch is located on the right side just behind the door edge. 2. Release the door latch. Swing door all the way to the left. 3. Grasp top of door with both hands and raise up. D) WIRING - ROOM AIR BLOWER (See Figure 3) 1. -
Page 7: Connecting Gas Line
CONNECTING THE GAS LINE CAUTION: INSTALLATION OF THE GAS LINE MUST ONLY BE DONE BY A QUALI- FIED PERSON IN ACCORDANCE WITH LOCAL BUILDING CODES. 1. Connect gas line. An accessible shutoff valve must be installed up stream from the unit. NOTE: Do not run the incoming gas line in a manner that would obstruct the operation or removal of the fan. -
Page 8: Log Installation
PREPARING LOG KIT 1. Open the cartons containing the Burner Base and the logs. Inside one of the cartons you will find the Burner Base. The logs are boxed separately and numbered as follows: Front (1) Rear Right Side Top (3) Left Side Top WARNING: POSITIONING OF THE LOGS IS VERY CRITICAL. - Page 9 NOTE: The appliance and its individual shutoff valve must be disconnected from the gas supply piping system during any pressure testing of the system at test pressures in excess of 1/2 psi (3.5 kPa). The appliance must be isolated from the gas supply piping system by closing its individual manual shutoff valve during any pressure testing of the gas supply piping system...
-
Page 10: High Altitude Orifice Chart
LP Gas 51 Retrofits Nat. Gas 35 LP Gas 51 Model 19 Nat. Gas 37 LP Gas 53 Model 30, Nat. Gas 38 32,34,329, LP Gas 52 36,42,logs Model 1127, Nat. Gas 42 327, LP Gas 54 NEW BUCK CORPORATION... -
Page 11: Alcove Installation
ALCOVE INSTALLATION Figure 6 IMPORTANT: 1. Caution: Read entire manual before installing unit. 2. For clearances see Figure 6. 3. For installation information see page 3-8. FOR YOUR SAFETY: What To Do If You Smell Gas ♦ Do not try to light any appliance. ♦... -
Page 12: Pre-Fab Fireplace Insert Installation
PRE-FAB FIREPLACE INSERT INSTALLATION MANTEL AND/ OR SUPPORTS COMBUSTIBLE PROJECTING MORE THAN 3/4” Figure 7 IMPORTANT: READ ENTIRE MANUAL BEFORE ATTEMPTING TO INSTALL THESE UNITS. 1. For clearance see Figure 7. 2. Failure to follow instructions will result in improper burning of unit and voids all warranties and liability of manufacturer. -
Page 13: Lighting Instructions
FOR YOUR SAFETY, READ BEFORE LIGHTING WARNING: IF YOU DO NOT FOLLOW THESE INSTRUCTIONS EXACTLY, A FIRE EXPLOSION RESULT CAUSING PROPERTY DAMAGE, PERSONAL INJURY OR LOSS OF LIFE. ♦ A. This appliance has a pilot which must be lighted If you cannot reach your gas supplier, call your local by hand. -
Page 14: Masonry Insert Installation
MASONRY INSERT INSTALLATION MANTEL AND/ OR SUPPORTS COMBUSTIBLE PROJECTING MORE THAN 3/4” Figure 8 IMPORTANT: 1. Caution: Read entire manual before installing unit. 2. For clearance see Figure 8. 3. Masonry insert must be installed as follows: 4. All heaters must be vented with 4" (101mm) pipe from top of unit to entire height of exiting chimney. -
Page 15: Cleaning And Maintenance Requirements
MAINTENANCE REQUIREMENTS 1. This appliance should be inspected at least once a year by a professional service person. NOTE: Installation and repair should be done by a qualified service person. The appliance should be inspected before use and at least annually by a qualified service person. -
Page 16: Trouble Shooting
TROUBLE SHOOTING GUIDE The regulator board includes the following items: regulator, generator, pilot, Piezo, electrode, rocker switch, burner, orifice and orifice holder. If any of these items are defective, replacement of the entire board would be easier and would not void the warranty. - Page 17 SOLUTION PROBLEM CAUSE 1. Relight pilot 4. Burner won’t light 1. Pilot not lit 2. Turn valve to “ON” 2. Regulator valve turned on 3. Press bottom of switch 3. Rocker switch exposing the “Red” or turned on “ON” indicator 4.
-
Page 18: Replacement Parts
REPLACEMENT PARTS PART PART NUMBER AUTO/MANUAL Switch PE0815-2243 Fan Motor PE SBR084 Rheostat PE BC204 Power Cord PE 400240 Thermostat PE 400132 Male Terminal PESX 428 Female Terminal PESX 425 Regulator - Hi/Low PE711 REG (Specify gas type) Pilot PE 5SHL-1 Thermopile PECP2 AUTO/OFF/MANUAL Switch... -
Page 19: Warranty
NEW BUCK CORPORATION (NBC) “LIMITED FIVE YEAR WARRANTY” FOR THE BUCK STOVE AND RELATED PRODUCTS PLEASE READ THIS WARRANTY CAREFULLY This warranty covers your new heating unit, so long as it is owned by the original purchaser, including optional and standard accessories purchased at the same time, subject to terms, limitations, and conditions herein set out. - Page 20 Some states do not allow the exclusion of incidental or consequential damages, so the above exclusion may not apply to you. (D) All warranty repairs under this warranty must be performed by an authorized Buck Stove service representative. Repairs attempted repairs anyone other...
- Page 21 GAS -FIRED VENTED ROOM HEATERS MODEL 61TV INSTALLATION MANUAL NEW BUCK CORPORATION WARNING: Improper installation, adjustment, alteration,service or maintenance can cause injury property damage. Refer to this manual. For assistance or additional information consult a qualified installer, service agency, or the gas supplier.