Lubrication Recommendations; Engine Oil - Polaris RANGER XP 900 Owner's Manual

MAINTENANCE

Lubrication Recommendations

Check and lubricate all components at the intervals outlined in the Periodic Maintenance
Chart beginning on page 63, or more often under severe use, such as wet or dusty conditions.
Items not listed in the chart should be lubricated at the general lubrication interval.
Item

Engine Oil

Brake Fluid
Main Gearcase Oil
(Transmission)
Front Gearcase Oil
Front Prop Shaft Yoke
Front Control Arm Pivot
Bushings
Rear Control Arm Pivot
Bushings
Rear Stabilizer Bar
Bushings
Engine Oil
Always check and change the engine oil at the intervals outlined in the Periodic Maintenance
Chart beginning on page 63. Always change the oil filter whenever changing oil.
WARNING! Vehicle operation with insufficient, deteriorated, or contaminated engine oil will cause
accelerated wear and may result in engine seizure, accident, and injury. Always perform the
maintenance procedures as outlined in the Periodic Maintenance Chart.
Oil Recommendations
POLARIS recommends the use of POLARIS PS-4 5W-50 4-Cycle Oil or a similar oil. Refer
to the specifications section beginning on page 94 for capacities. See page 98 for the part
numbers of POLARIS products.
NOTICE: Mixing brands or using a non-recommended oil may cause serious engine damage. Always
use the recommended oil. Never substitute or mix oil brands.
Always check and change the oil at the intervals outlined in the Periodic Maintenance Chart
beginning on page 63. Always use the recommended engine oil.
66
Lube
PS-4 5W-50 4-Cycle Oil
DOT 4 Brake Fluid
AGL Gearcase Lubricant &
Transmission Fluid
Demand Drive Fluid
U-Joint Grease
All Season Grease or grease
conforming to NLGI No. 2
Method
Add to proper level on dipstick. See page
67.
Maintain level between fill lines. See page
80.
See page 69.
See pages 69-70.
Locate fittings and grease (3 pumps
maximum).
Grease 3 fittings on each side of the
vehicle.
Grease 4 fittings on each side of the
vehicle.
Grease one fitting on each side of the
vehicle.